What 334 owners told NHTSA about the 2021 Ford Mustang Mach-e Bev Bev

Front Camera Fault & Pre-Collision Assist Not Available Error messages since August 2022 around the time after a recall for windshield reglue.

NHTSA ODI 11503102

* On October 16th, 2022, at about 7:00 pm, I was driving my 2021 Ford Mach-E GT when we began to change lanes (we were in the left lane heading East) as the vehicle in front of us slowed down to make a left-hand turn. There was a car behind us and two vehicles in the right lane (two-lane road in each direction) that were a few car lengths behind us as we began to change into that lane. When I turned on my signal and turned the steering wheel, I pressed the gas pedal to accelerate to get around the car in front of me to keep my distance from the vehicles in the lane I was transitioning into. Unfortunately, when I pressed the gas pedal, we experienced complete vehicle failure. I had no steering, brakes, or acceleration. Within a short time (30-45 minutes), we had no power as the lights on the vehicle, and all electrically powered devices and components were entirely out. This made it very difficult to tow the car as it is all-wheel drive, and we could not put it in Neutral to pull the vehicle. As this happened, five cars were in the area, and several had to swerve and fly off the road onto the dirt shoulder. We barely missed the car in front of us, and the car behind us had to lock up its breaks not to hit us. Our car gradually slowed down and cost off the road about 50 yards or so after losing power, as it was very difficult to get the vehicle to steer; it took everything I had to turn the wheel to get it off the road. We put on the emergency blinkers, but the vehicle lights flashed erratically inside and outside the car. We had over a dozen warnings flash on our dashboard about vehicle failure. The speakers in the car were making a thumping sound on their own as the car was flashing headlights, brake lights, and flashers on their own and very sporadically. It was like a disco club in the car as all the lights were flashing on and of at a rapid rate. The other cars stoppe and were very angry at us as the screamed at us that we almost caused an accident.

NHTSA ODI 11493140

I keep receiving a fault for the front camera which seems to be a very common occurrence amongst Mach-e owners lately. After receiving this message, the cruise control abruptly kicks off. All functions of the cruise control do not work in this instance…adaptive, speed keeping, lane control, etc. This fault happens about once every couple of minutes while driving. When I’m using cruise control in ‘one-pedal’ drive mode and this fault occurs, the vehicle immediately starts braking. This happened one time as I was entering a narrow bridge in Solomons, MD, and a car behind me nearly rear ended me.

NHTSA ODI 11490513

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that while her husband was driving slowly into the garage and the vehicle suddenly experienced unintended acceleration and crashed into the home and went through to the bedroom, causing damages to the vehicle and the home. No warning lights were illuminated. The vehicle was taken to a local dealer for an unrelated recall repair and the contact made the mechanic aware of the failure. The mechanic confirmed that there was no related recall on the VIN. The vehicle was not diagnosed. The contact was concerned about the safety of driving the vehicle and was referred to the manufacturer for guidance. The contact filed a claim with the insurance provider and the vehicle, and the home was repaired. The manufacturer was made aware of the failure and a case number was provided. The approximate failure mileage was 2,335.

NHTSA ODI 11490334

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that while her mom was driving, the vehicle accelerated without warning. The electrical system was inoperable. While the contact was driving at low speed in a parking lot approaching a stop sign, the vehicle accelerated. The brake pedal was applied but the vehicle continued to drive and crashed into a Toyota 4 Runner. The air bag deployed and impacted the driver in the face and she sustained knee injuries and cuts on her stomach and blood in her stool. A police report was filed. There were no reported fires. The vehicle was towed to an independent collision center. The vehicle was taken previously to the local dealer where the hardware was updated and a reboot was completed. The vehicle was repaired but the failure persisted. The manufacturer was not contacted. The failure mileage was unknown. The VIN was not available.

NHTSA ODI 11490039

The HVBJB subassembly in ALL Ford Mach-e vehicles has known defects with 'under-designed' main contactors that are known to fail under normal charging and driving conditions as outlined in current open Ford recall notice for my vehicle 22s41. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, and power brakes... and failure of other 12v systems due to failure to charge the 12v battery properly after contactors are damaged. Less catastrophic results can include failure to start; which can 'strand' driver's and passengers in remote areas, bad weather conditions, as well as cause loss of use for weeks due to delays in replacement parts and local Dealerships needing equipment and training to effect removal/replacement of faulty unit with a new HVBJB having re-designed 'beefier' components.​ ​ My complaint is that Ford's recall notice 22s41 is a software-only attempt to prevent future damage, and does not require removal of the part(s) which are KNOWN TO FAIL to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially 'stranding me' in unsafe conditions unable to re-start my vehicle.​ ​ I would like to see NHTSA strengthen the Ford recall to include both improved software AND removal/replacement of the HVBJB sub-assembly with the new 'beefier' parts.

NHTSA ODI 11475000

When placed in drive the car takes off on its own without the acceleration pedal being touched. The passenger locks only work with key fob unlock button being pressed and the passenger side doesn't recognize the Fob for easy entry. The adaptive cruise control warning comes on constantly. The handas free parking never worked since i got the car in July 2021.

NHTSA ODI 11474017

The contact owns a 2021 Ford Mach-E. The contact stated while reversing from his driveway, he shifted into drive and depressed the accelerator pedal. However, the vehicle accelerated at high speed independently. There was no warning light illuminated. The contact continued to drive. The contact stated that the failure reoccurred the following day. The contact stated while his wife was exiting the carwash and making a left turn with a passenger in the front passenger seat, she shifted from neutral into drive and depressed the accelerator pedal. The vehicle accelerated at high speed independently and crashed into the block wall. The air bags deployed. The contact's wife sought medical assistance and was informed that she had sustained a fractured rib on the left side of her body, pain on the shoulders, and pain in the rib cage. The passenger occupying the front passenger's seat sustained pain all over her body and a bruised rib and she sought medical assistance. A police report was filed. The vehicle was towed to a tow lot where it was totaled. The dealer was not notified of the failure. The manufacturer was notified of the failure. The contact became aware of NHTSA Campaign Number: 22V333000 (Vehicle Speed Control, Power Train), which he associated with the failure. The failure mileage was approximately 18,000.

NHTSA ODI 11466999

On approximately March 20, 2022, I was driving my Mach E vehicle. I pulled into a driveway and parked my vehicle. Upon exiting my vehicle, my vehicle began accelerating forward up the inclined driveway. It then struck a parked vehicle and came to a stop. The car accelerated uninetentionally which is in alignment with the current recall. Additionally, the advanced emergency braking did not work as the brakes did not deploy and the car only went back to rest after I re-entered the car post-accident.

NHTSA ODI 11466177

While driving around a curve, my car lost all power and went completely dark. I didn't have brakes, steering, lights or any other functions. My car was completely bricked. This happened before daylight and I didn't have emergency flashers to notify other drivers I was stopped on the side of the road. After waiting for 6 hours for a tow truck, I went and tried to find the problem myself. I found a loose connection. It was the main power feed supplying the fuse box. Once I tightened it up, I was able to start and drive the car. I've attached a picture of the connection I tightened.

NHTSA ODI 11462003

AS I WAS DRIVING DOWN THE ROAD (IN MOTION / CITY STREET) AT 30 MILES PER HOUR IN MY BRAND NEW (4 WEEK OLD / 2200 MILES) ALL ELECTRIC FORD MACH E, THE DISPLAY FLASHED MULTIPLE WARNING LIGHTS THAT CAME TOO QUICKLY TO DECIPHER, AND THEN THE CAR WENT DEAD. I WAS ABLE TO PULL OFF THE ROAD AND COME TO A STOP. AT THIS POINT THE CAR WAS COMPLETELY DEAD. EVEN THE HAZARD LIGHTS WOULDN'T WORK WHICH MADE THE SITUATION DANGEROUS SINCE THE CARS BEHIND ME COULD NOT TELL THAT THERE WAS A PROBLEM.

NHTSA ODI 11415152