What 334 owners told NHTSA about the 2021 Ford Mustang Mach-e Bev Bev

This is a safety issue. The front collision assist is not working. I have returned the car to the Ford Dealer (Biener Ford) several times but the dangerous issue persists. I'm not the only one. There are many complaints listed on the web and the Ford Mach E forum. Ford needs to recall their EV Ford Mach-E vehicles and fix this dangerous safety issue once and for all.

NHTSA ODI 11740320

The car gives two messages, "Front Camera Fault Service Required" and "Pre-Collision assist not available." The cruise control does not work, however, the front camera does work. I had the vehicle scan done at the Ford dealer and was told it needs a 7 hour software update, after which it may need cables replaced. I do not understand how software goes bad. I do understand something may have happened to cables but that would not be checked until they had charged me $ 1,400 for a software update. This is a safety issue and, from what I read on the Mach E forum, is not where near unique to my vehicle.

NHTSA ODI 11736423

Vehicle experienced immediate loss of motive power while in motion at 45 mph after "Stop Safely Now" alert. This is a repeat power failure. The vehicle was in service for 75+ days (Dec-Feb) for this exact defect. The Ford service center said they replaced the “battery controller” yet the issue recurred. The car previously flagged this alert while in motion 2 times prior (one on the highway going ~65mph and on another major street going roughly ~45 mph). As a Ford Reacquired Vehicle (Buyback), the failure to resolve this catastrophic electrical fault creates an extreme risk of crash and entrapment in traffic, putting myself, my family and the drivers in vicinity at significant safety risk. The car is currently at a different Ford Service Center. They have been able to reproduce the issue and are currently running diagnostics to identify a resolution.

NHTSA ODI 11719257

After recall-related software updates were performed on my 2021 Ford Mustang Mach-E, the vehicle began experiencing repeated electrical and climate control failures. The heating and defrost system stopped working, leaving the vehicle without heat and causing the windows to fog, which reduces visibility in cold weather and creates unsafe driving conditions. The vehicle has been taken to multiple authorized Ford dealerships for inspection and repair; however, the problem returned immediately after the repair. The issue was reproduced and confirmed by a second dealer. A required part is currently on back order until the end of Feburary, leaving the vehicle unrepaired for an extended period. In addition, the vehicle experienced 12-volt battery failure and slow charging after the last recall update. These issues were not present prior to the recall. There were no warning lights before the failures occurred. During severe winter weather conditions in Pennsylvania, the lack of heat and defrost made it extremely difficult and unsafe to operate the vehicle. Because of reduced visibility and freezing interior temperatures, the vehicle could not be safely driven and, due to frigid temperatures, has remained parked. I am still making monthly payments on a vehicle that cannot be reliably or safely used.

NHTSA ODI 11716499

I am requesting immediate escalation regarding my 2021 Ford Mustang Mach-E (VIN: [XXX] ), which is currently undrivable due to being stuck in “Power Accessory Active” mode. The vehicle will not enter Drive. The dealer has diagnosed DCEM / high-voltage system-related faults and stated that recall repairs cannot be completed unless I first pay approximately $3,000 to repair the “main battery.” My concern is that the symptoms and failure mode exactly match the known High-Voltage Battery Junction Box / DCEM defect described in Ford Safety Recall 23S56, including: •Vehicle unable to drive •High-voltage system refusing to close contactors •Vehicle remaining in accessory power mode •Safety-related loss of motive power While my VIN may not be currently listed as eligible for these recalls, my vehicle is exhibiting identical symptoms and failure modes associated with the following Ford safety recalls: •HV Battery Junction Box / DCEM defect (Recall 23S56) •Powertrain / Software Update (Recall 22S29) •12-Volt Battery / Door Latch Entrapment Risk (Recall 25S65) It is important to note that other Mustang Mach-E owners have reported the same recall-related failures even when their VINs were not listed for these recalls. These failures involve contactor issues, loss of motive power, and vehicles being stuck in accessory mode — identical to the symptoms my vehicle is experiencing. Given that my vehicle is experiencing a safety-related loss of motive power, Given the safety implications and known defect history, I request that this matter be reviewed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11712665

While charging my electric vehicle with this Enel X JuiceBox 40 charger, a burning plastic smell was noted. Upon examining the Enel X charger plug that was attached to my home's NEMA 14-50, it appeared partially melted and very to touch. Using a towel, the plug was removed and a small fire and sparks flew out of the NEMA outlet. The right half of the outlet's plastic shell was melted and the inner metal was charred. Same charring and melting was noted on the corresponding side of the Enel X plug. I turned the circuit breaker off and the sparks and fire subsided. Model of JuiceBox: 2JBO401RNA-PJWX-300

NHTSA ODI 11705449

Car stalled once while going to a military appt but started up 3 mins later. Car then made a noise then stalled out of nowhere on the highway at a slow speed in heavy traffic causing anxiety. vehicle then had me stranded waiting for a tow to find out it’s the HVJB .

NHTSA ODI 11693497

On [XXX], my 2021 Ford Mustang Mach-E (VIN [XXX] ) experienced a complete electrical failure related to its V12 battery system. The vehicle required roadside assistance twice during the same service call — first to jump the car to release the hood latch and again to restore enough power to unlock the doors. An elderly occupant was trapped inside until power was restored. After exiting, she became light-headed and fell; EMS responded and transported her to the hospital. This represents a serious safety defect because total electrical shutdown prevented door operation and normal egress. I am requesting investigation and possible recall review. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11692323

only incident I have had is that the dealership cannot fix the recall yet its been a week and still have not recieved anything ,or a loaner or a rental. I am in the military active duty and havent had anything

NHTSA ODI 11687282

The contact owns a 2021 Mustang Mach-E. The contact attempted to start the vehicle; however, the vehicle failed to start. The contact stated that there was no power to the vehicle. The following day, the contact attempted to enter the vehicle and was locked out. The contact was unable to open any of the doors. The contact was able to raise the hood and the trunk. The contact was unable to jumpstart the vehicle, but heard a clicking sound when the jumper cables were connected. The contact observed a spark from the negative terminal. The contact removed the 12-Volt battery and brought it to a local dealer to be tested. The contact was informed that the battery was in good working condition. The contact had the vehicle towed to a local dealer however, the vehicle was not diagnosed or repaired. The contact was aware of NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages) but was informed by the dealer that the part for the repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was informed of the failure. The failure mileage was approximately 65,000.

NHTSA ODI 11682938

The contact owns a 2021 Ford Mustang Mach E. The contact received notification of NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that his wife parked and turned off the vehicle; however, while attempting to exit the vehicle, his wife was locked inside the vehicle. The contact quickly searched for how to unlock the vehicle. The contact pushed the exterior door lock twice, and his wife was able to unlock and exit the vehicle. The contact called Ford Assistance Service, and the vehicle was jump-started and the vehicle was driven to the dealer. The dealer diagnosed the vehicle with battery failure. The contact was informed that the battery needed to be replaced. The battery was replaced. The dealer confirmed that the software update for the recall repair was not yet available. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000.

NHTSA ODI 11681322

The contact owns a 2021 Ford Mustang Mach E. The contact stated that a message was received from the Ford App to check the 12-Volt battery. The local dealer was contacted and informed the contact that a service appointment was needed to have the battery checked. Later, while parking the vehicle, the vehicle lost power and the vehicle shut off, and the instrument panel went black. During the failure, the doors remained locked and could not be unlocked from inside or outside the vehicle. The vehicle was later towed to the local dealer who determined that the 12-Volt battery had failed and needed to be replaced. The battery was replaced and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ODI 11680972

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that the safety system occasionally became inoperable. The contact stated that the cable wires were damaged and caused the dropping of the camera after traveling over a bump in the roadway, and the safety features were not available. The camera dropped five to six times per hour. The blue cruise became inoperable, and the driver assistance was inoperable. The vehicle began to pull to the side of the road. There was no audible chime detected. There was an unknown warning light illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted but declined to repair the vehicle under warranty. The failure mileage was approximately 34,000.

NHTSA ODI 11677851

Car gave me a warning to bring car to dealer, who told me I need to replace the High Voltage Battery Junction Box. This part was recalled on other models, but not my specific model, despite the cars using the same part. Dealer said it will cost $3,593 to replace and Ford customer service says there is no recall for it. Also, I intermittenly have gotten a warning that the front camera will not work for forward collision warning or cruise control. It often happens after a bump in the road, but also happens at other random times.

NHTSA ODI 11671737

My 12-volt battery died and due to my car being an Electric Vehicle there was no way for me to get inside my car without jumper cables. The safety concern was that it happened without noticed when i stepped out the car to get my [XXX] out of the back seat. Completely locking me out the car and no way to get inside. The car doesn’t have a conventional door handle and cannot open without electricity. I had to have emergency services come and break into the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11657119

Some of the driver assistance warning systems may not be operable due to multiple and frequent warning messages. Messages are: Front Camera Fault Service Required; Pre-Collision Assist Not Available; Lane Keeping System Fault Service Required. Ford is unable to correct these making it potentially unsafe. Additionally, they are not covering the attempt to fix this under the extended warranty. There are hundreds (if not thousands) of owners of the same model and year of my car, and subsequent years as well, having this issue with no resolution. There needs to be a recall.

NHTSA ODI 11656360

The contact owns a 2021 Ford Mustang Mach-E. The contact stated while the vehicle was parked, the vehicle stalled. The contact stated that several unknown warning lights were intermittently illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was towed to another dealer to be diagnosed. The contact researched and became aware of an unknown recall; however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 73,255.

NHTSA ODI 11651892

Melted High Volt Junction Box after DC Fast Charging. Car became compromised while 3 hours from home. Limiting speed and ability to recharge. This vehicle had the High Voltage Junction Box melt back in the summer of 2022. The original was replaced under Warranty. The replacement part they installed is also faulty. I do not DC Fast charge very often. Maybe 12 times in the lifespan of this car. The original recall for this issue was a Software upgrade in the summer of 2022. There appears to have been a recall for hardware in fall of 2023 but for some reason this car was not part of that recall. The part that Ford installed in July of 2022 has since been redesigned several times, but I was left with the old version and that Melted down. Please recall the faulty HVJB part installed in these cars that were impacted when the originals melted. This costs $3,000 to have them repair and is not covered by warranty any longer.

NHTSA ODI 11650559

The car was parked and will not move. The car turns on, an alert displays that to stop the car and pull over and the car is in park and will not allow you to move the dial out of park. Had to have the car towed to dealership. The 12v battery was replaced, this did not help, the car still will not allow you to put it in drive.

NHTSA ODI 11646194

The electrical system failed. Issue was it disengaged the 12 volt system as well. Vehicle seized and stopped in the middle of a high usage road with no ability to put into neutral. After speaking with Ford, they concede that there must be 12 volt battery power in order to put car in neutral. After 2 hours of blocking traffic The tow truck arrived ( was a rainy day) and within a minute hooked up a 12 volt battery and drove the vehicle off the road way. This is not acceptable and needs to be addressed. My claim number with Ford is: case [XXX]. Thank you. Feel free to contact me in any further information is needed. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11642954

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that while driving at approximately 20 MPH, the infotainment screen flipped forward and opened. The vehicle was taken to a dealer where it was diagnosed and determined the infotainment system screen needed to be replaced due to the clips malfunctioning. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 60,600.

NHTSA ODI 11642132

My vehicle is not a part of the Recall #23S56, however, my High Voltage Battery Junction Box has gone back and in need of replacement. The warranty light appeared on 2/2/25 after acceleration. I was able to make an appointment with my local Ford Dealership for today 2/4/25 and was informed of the issue.

NHTSA ODI 11640638

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that upon starting the vehicle, the "Stop Safely Now” message was displayed. There was a RED warning light illuminated. While the vehicle was being charged, the Ford app showed a charge fault error. The vehicle was undriveable. While using a diagnostic tool, it showed there was a failure with the BCM and DTC: P0AA2 and P0D10 were retrieved. The contact stated that the failure was related to NHTSA Campaign Number: 22V412000 (Electrical System); however, the VIN was not included. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was 19,000.

NHTSA ODI 11640279

My cameras will not work and the screen will be black. Anytime I reverse or come too close to an object the cameras will show, but since there is a problem with the camera wire the image is just a black screen. This is a serious safety issue that Ford has yet to address and I have notified them about it, with an image and video of the problem.

NHTSA ODI 11640304

The forward collision detection system failed first. Then the car suddenly would not move and gave a pull over immediately warning on the dash and also flashed a battery light. It was 15 degrees outside and my wife and son were stuck in the cold. Not a safe environment. This is inexcusable for a car to be driving fine on minute and to be completely inoperative the next.

NHTSA ODI 11636992