What 20 owners told NHTSA about the 2020 Mercedes-benz E-class Wagon

The AC compressor failed in traffic causing the engine to lock up and not restart.

NHTSA ODI 11720104

The Engine Electrical harness is completely corroded after only 50,000 miles requiring a 4k+ repair. Oil leaking from the camshaft sensor pushed it way all throughout harness. There are no warnings as it will only be noticeable after doing routine maintenance OUTSIDE of the manufactures warranty. While driving you may lose complete power or slight power loss due to engine misfiring and low system voltage. Warranty company has denied my claim saying that it looks as if the car was in an accident with water damage but the car is pristine and accident free. This is happening to all Mercedes with magnetic camshaft solenoids after doing routine spark plugs. Any movement of the wires will cause damage to the corrosion and then electrical problems. This happened before with previous generations and they recalled the engine to put extensions between the sensors and harness. Unfortunately they did not do a recall for this generation even though the same problem is apparent!

NHTSA ODI 11672020

Over the last couple of days, my car has displayed the "Engine Warning" message intermittently. I took this to the dealership for inspection and received the following fault code: P06DA00 - Inoperative Oil Pump Valve. For a car with low mileage, this could potentially be a car issue. The estimated total cost for labor and parts is over $5k. I think there are more cars affected.

NHTSA ODI 11666806

There was smoke coming from from the engine compartment and spontaneous fire started while the car was at a stop light. The car was totally damaged. The car has less than 15000 miles driven. It is still under warranty. Information was sent to Mercedes-Benz USA with a certified mail and immediately via email from the dealership. Also was reported where the vehicle was stored if they wanted to investigate the engine. Benz USA just wanted me to fill out their standard report form. The towing company also told me that they had to tow another Benz not long ago from engine fire.

NHTSA ODI 11616110

While driving on the highway the engine shut down and I needed to pull over and restart the car. The engine would restart but then stalled several more times while driving. No check engine lights were on before the vehicle stalled and upon restarting the car no check engine lights turned on. I have it at the dealership currently but they can't look at it until December because of their backlog of repairs.

NHTSA ODI 11490562

On October 2, 2021, car caught fire in the engine compartment while car was turned off under carport of home. Car mileage was 18,000. The car was serviced by Mercedes of Marin and driven approximately 25 miles after the service when incident occurred. No warning lamps or messages appeared. Fire damage to carport and garage of house and fence and gate. Allstate, the insurance carrier is performing a fire inspection of the vehicle.

NHTSA ODI 11437940