What 51 owners told NHTSA about the 2020 Lexus RX 350

The rear wheel which is Lexus OEM busted and lost air when driving on the highway at highway speed on June 23, 2026. This caused an immediate hazard and a dangerous loss of vehicle control. Fortunately, I was able to safely pull over, but this failure put my life and the lives of others at serious risk. The mileage is about 45,396. The vehicle was purchased from Freeport Lexus as a pre-owned on January 20, 2026. The recording from the dashcam shows no debris on the road and the car didn't hit any object the road. I've written an email to the dealer and asked for an field inspection of the wheel.

NHTSA ODI 11746351

The panoramic sunroof has a shade, which is not closing. This causes a lot of sunlight to enter the vehicle which might be harmful to your skin and causes headaches. The repair is very expensive and there is no other way around it. I seen many owners raising concerns about the same issue happening to them, on youtube, reddit, google and other websites. This is an issue on the same model from around 2017-2022. This must be repaired by lexus, and improved so it doesn’t keep happening.

NHTSA ODI 11743718

While driving the engine stalls. It has jolted back-and-forth at times and had to be taken to a dealer. It’s still stalls when trying to slowly accelerate especially uphills. Low gas mileage barely getting 18 miles per gallon. Warning lights flickering while car stallling. It’s like it’s having a seizure. This has happened a few times.

NHTSA ODI 11740288

The hatchback window shattered without any known cause. It appeared to have been hit from inside the vehicle but no one was in or around the vehicle when it occurred. It was 82 degrees outside and the vehicle was parked in the shade. Lexus told me there were no known issues regarding the window on other Lexus vehicles.

NHTSA ODI 11729675

I own a 2020 Lexus RX 450h with approximately 129,803 miles. The check engine light came on and the vehicle stored diagnostic trouble code P0A2D, which indicates a failure of the drive motor/temperature sensor circuit that is integrated into the transmission/hybrid motor assembly. According to the Lexus dealer’s diagnosis, the temperature control sensor located on the transmission/hybrid drive unit has failed. Because Lexus designed this sensor as part of the transmission assembly, the dealer has stated the sensor cannot be replaced separately and that the only repair is to replace the entire transmission. Lexus is refusing to acknowledge this as a manufacturing defect and is requiring me, the consumer, to pay the full cost of a complete transmission replacement, estimated at approximately 9,040.03, solely due to the failure of this internal temperature sensor. This is a critical component used to monitor drive motor/transmission temperature. A malfunctioning sensor of this type can lead to improper system operation, possible overheating, loss of power, or unpredictable behavior of the hybrid drive system while the vehicle is in motion, which presents a safety risk to occupants and other road users. This failure occurred during normal use on public roads and not due to any accident, abuse, or modification. I am requesting that NHTSA investigate whether there is a design or manufacturing defect in the drive motor/transmission temperature sensor and its housing or circuitry on the 2020 Lexus RX 450h (and related Toyota/Lexus hybrid models) that forces owners to replace the entire transmission when this internal sensor fails. This appears to be an unreasonable safety‑related defect and an unreasonable repair burden on consumers.

NHTSA ODI 11723917

I am submitting this correspondence to formally report a serious safety incident involving my 2020 Lexus RX 350 and to request a thorough investigation. On Saturday, February 7, while attempting to park the vehicle, I experienced a sudden loss of control, resulting in the vehicle accelerating forward and colliding with a metal gate. The exact cause of this event is unknown. During the incident, the vehicle’s pre-collision and automatic braking system failed to engage despite an obstruction being present. Additionally, the airbags did not deploy at the time of impact. A minor child was present in the vehicle, properly secured in a child's safety seat. While no injuries occurred, the vehicle sustained extensive damage and was rendered inoperable. I would also like to note that this vehicle was subject to an airbag recall on November 29, 2025, which was serviced prior to this incident. Despite completing the recall service, the airbags failed to deploy during the accident. After the vehicle was towed, the airbags unexpectedly deployed while it was being lifted onto the tow truck using a crane, further raising concerns regarding the reliability and safety of the airbag system.

NHTSA ODI 11718294

The contact owns a 2020 Lexus RX350. The contact received notification of NHTSA Campaign Number: 23V365000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11686349

I have reached out to my dealer over the past 5 yrs and Corporate as well about the recall on my 2020 Lexus RX 350. I have since paid the car off and feel the remedy has fell on death ears. The last two services I inquired about a fix, Sterling McCall lexus in Clear Lake texas never responded back to me. I need some kind of resolution to this recall. Vehicle has 31K miles on it and the only place I can trade it in is Lexas.

NHTSA ODI 11685590

There was a recall on my car like 2 years ago. The air bag is not working. However, they didn’t fix my car and didn’t give me an estimation on this. It is not safe to drive a car without air bag.

NHTSA ODI 11682929

The contact owns a 2020 Lexus RX 450H. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11681713

The contact owns a 2020 Lexus RX-350. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts for the recall repair was not yet available. The contact had not experienced a failure.

NHTSA ODI 11677577

Tires installed by Lexus on Sept 27, 2022 are shredding and coming apart in chunks at 37,000 miles; tire is rated 60,000 miles. This is 56% of the projected life of the tire. Previous tires, same brand and size, only lasted 29,000 miles; 1/2 of the life of the tire. Current tires have good tread depth and life left if the chunks were not uniformly coming off of all tires. This condition leaves the tire vulnerable to road hazards and moderately sharp objects. Failure is clearly imminent. Dealer, upon inspection July 1, 2025, did suggest immediate replacement of the tires at normal retail prices. No warnings or alerts or other symptoms are present. There has been a slight loss of air pressure.

NHTSA ODI 11675395

This vehicle, and those of its generation, have had an active passenger airbag recall since December 2023. There has been no news on a remedy, nor any meaningful updates on progress. I am unable to transport passengers in my front seat as I am afraid for their safety and my own liability.

NHTSA ODI 11668757

I received a notice that there was a recall on my car. I received this notice on December 20, 2023. This issue still has not been addressed.

NHTSA ODI 11667822

The contact owns a 2020 Lexus RX. The contact stated while his wife and children were stopped in traffic, a vehicle had crashed into the rear of the contact's vehicle, which then caused a five-car chain reaction crash. The contact stated that none of the air bags had deployed. The contact stated that the rear end of his vehicle was crushed as well as the front end. The contact stated that the police and emergency services had arrived on the scene. The contact stated that his wife and son were transported to the hospital. The contact stated that his wife had suffered neck whiplash, cuts, and abrasions to her face, arms, and knees. The contact stated that his son also had whiplash, and had suffered a broken jaw. The contact stated that his son had cuts on his face and inside his mouth that required stitches. The police had written a report. The vehicle was towed to an impound lot and declared a total loss by his insurance provider. The manufacturer was not informed of the failure. The failure mileage was approximately 46,000.

NHTSA ODI 11662427

The contact owns a 2020 Lexus RX450H. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11661219

The contact owns a 2020 Lexus RX350. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11656116

SUNROOF EXPLODED WHILE DRIVING WHILE MY HUSBAND WAS DRIVING WITH A FRIEND. DEALERSHIP IS NOT ACKKNOWLEDGING IT SINCE THERE IS NOT A RECALL SO I WILL HAVE TO CALL LEXUS CORPORATE. I AM TAKING IT INTO THE DEALERSHIP TO BE FIXED AND DROPPING IT OFF THIS FRIDAY. INSURANCE ADJUSTER WILL BE DOING TO DEALERSHIP TO LOOK AT SINCE IT COSTS $2000 TO FIX AND I HAVE A $1000 DEDUCTIBLE :( :( NO WARNING JUST SOUNDED LIKE A BOMB OR GUNSHOT GOING OFF. MY HUSBAND HAS HAD RINGING IN THE EARS SINCE IT WAS SO LOAD AND RIGHT ABOVE HIS HEAD!!!!

NHTSA ODI 11639337

The contact owns a 2020 Lexus RX 350. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11637562

 The contact owns a 2020 Lexus RX 350. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11632620

The contact owns a 2020 Lexus RX350. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11630189

See attached document for complaint.

NHTSA ODI 11628986

The contact owns a 2020 Lexus RX350. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11626606

The contact owns a 2020 Lexus RX-350. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11620635

I was driving down the road with no one around and nothing falling or being kicked up in the air and I heard a huge crash, I had no idea what happened even after stopping at a gas station. Two days later after hearing the sound of ripping Velcro as I was driving, I opened the sunroof bc it was a nice day and glass shattered and fell all over me. I shut to sunroof cover and realized the entire time that my sunroof exploded without warning bc it was not tempered correctly. Lexus refuses to fix the manufacturer error.

NHTSA ODI 11619622