What 194 owners told NHTSA about the 2020 Hyundai Santa Fe Phev

Crack windshield

NHTSA ODI 11474769

The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 21V00M000 (Visibility) however, the part to do the recall repair was not yet available. The dealer had been notified of the issue and confirmed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11473868

The Windshield cracked without anything striking it. The windshield is being replaced at my expense. There is wind noise coming from the area below the crack where it is attached to the vehicle.

NHTSA ODI 11473681

On May 17th, I had an oil change completed on my 2020 Hyundai Santa Fe at a Hyundai dealership. On May 18th, I was parking my Santa Fe in a parking lot with which I am very familiar. I parked in front of the building, but realized that I had not pulled up far enough to the curb. I went to pull up a couple feet and as I started to put my foot on the gas pedal, I heard the engine roar and take off. I hit the brake, but it didn't stop, and I drove through the window and into the building. I was stunned. I have been driving for 44 years, and I have never had an accident that has been my fault. I was in shock that the car would not stop. I thought there might be a recall regarding this issue, but there wasn't. A friend told me he though he read somewhere that Kia and Hyundai were having acceleration issues. I went online and I was shocked that there are so many reports of sudden unintended acceleration and my Santa Fe was one of those vehicles. I saw one website where over 60 people with Santa Fe's have had similar issues. I was very lucky that I did not injure or kill anyone. Hyundai needs to investigate these instances, before more people are injured or killed. I feel these vehicles need to be recalled immediately. I have contacted Hyundai USA and opened a case file. After the extensive repairs to my vehicle were complete, I took my car to the dealership and instructed them to replace the throttle body assembly. To NHTSA: Please grant Defect Petition DP21-003 and investigate these issues.

NHTSA ODI 11471608

The Driver's-side rear wheel came completely off the vehicle while traveling at 65 mph on Interstate 75. The vehicle violently swerved into the left lane, and then my wife was able to pull off to the right side of the road. She almost tipped over from the side of the road being on a steep incline. A couple of days before this, the vehicle was at the Hyundai dealership getting a 'Service' where they changed the oil and performed a 'safety' inspection. They did NOT perform the inspection, but lied on the form saying all systems passed. They reluctantly admitted that they didn't do the inspections. There were NO warning lights of any kind before or after the incident, which could have killed my wife.

NHTSA ODI 11470577

I have a 202 Hyundai Sante Fe. I was pulling into a parking garage parking spot, going about 3 miles per hours. Suddenly about 3 feet away from the wall (with my foot on the break) my SUV's engine suddenly race and propelled me forward into the wall. No warning lights or messages. No front- end auto breaking, I have reported it to Hyundai. I was injured from the air bag and the seat belt, my passenger was not injured. I am waiting for my SUV to be assessed by my insurance and my auto body company. I have read many articles about circumstances like these and am considering contacting an attorney.

NHTSA ODI 11465643

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while her husband was driving at an undisclosed speed, the vehicle was not able to stop immediately while the brake pedal was depressed, causing his vehicle to rear-end another vehicle. The failure recurred on a separate occasion while the contact's husband was driving, and the brakes failed to stop the vehicle from crashing into their daughter's residence. The air bags did not deploy in either collision. No injuries were sustained and no medical attention was received for either collision. No police report was filed for either collision. The contact's husband was able to drive the vehicle away from both the scenes of the collisions. The vehicle's front end was damaged; however, the vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 28,000.

NHTSA ODI 11463518

While driving down the freeway, the sunroof of my vehicle exploded. This was not caused by a foreign object, there was nothing on or near my car at the time of the incident, and upon pulling off of the roadway I was able to confirm that no foreign object had entered the vehicle. It was an explosion sound accompanied by glass falling into the vehicle, a large hole in the sunroof, and the glass on the edge of the hole appearing in an upward direction as though the force of the explosion came from inside the vehicle. The vehicle was being operated in a normal manner at the time of the incident, there was nothing to indicate any potential issue with the vehicle. The hazards associated with this incident include the potential for loss of vehicle control following the loud and unexpected explosion and the potential for injury from falling glass. The vehicle was taken directly to the Hyundai dealership where it was purchased, where service staff confirmed the upward appearance of the glass and stated that the repairs would be covered by the vehicle warranty.

NHTSA ODI 11459122

We are experiencing exactly what is listed in HYUNDAI TSB #21-BE-005H: intermittent abnormal camera image display conditions on the instrument cluster when the turn left signal is turned on or the radio screen when transmission is in reverse.

NHTSA ODI 11458051

This car just caught on fire in my fathers driveway at midnight last night...doesnt appear to be from engine compartment

NHTSA ODI 11455990

THE DRIVERS DOOR IS NOT PROPERLY ALIGNED. WHEN YOU DRIVE IT ON THE ROAD YOU CAN HEAR A HISSING SOUND OF THE AIR PENETRATING IN THE CABIN. THE DOOR APPEARS NOT TO BE CLOSED PROPERLY, THERE IS A GAP. IF YOU LOOK AT THE ALGINMENT OF THE PASSANGERS DOOR, THE DOOR IS PROPERLY ALIGNED WITH THE REST OF THE BODY OF THE SANTA FE, BUT THAT IS NOT THE CASE WITH THE DRIVERS DOOR. I AM PLANNING CONTACTING HYUNDAI DIRECTLY, BECAUSE IF THEY MAINTAIN QUALITY CONTROLS, THIS CAR DID NOT PASSED THAT TEST. DURING 2021I DID NOT DRIVE THE CAR ON THE ROAD, BUT LATELY I TOOK 4 TRIPS TO SC, AND ON THE ROAD THE HIZZING SOUND IS NOTICIBLE.

NHTSA ODI 11451751

The tires has a big noise like, it sounds like bum bum bum bum bum, and I bought this car brand new, I went To the dealer and they said there is not warranty for tires, that’s not good, because the noise still there.

NHTSA ODI 11451475

Blind Spot System randomly fails to detect vehicle on right side, I have videos of failure. Dealer unable to find problem cause, contacted Hyundai customer service, waiting for response.

NHTSA ODI 11449004

This is the 2nd 2020 Santa Fe that this has occurred on as well as a 2019 Santa Fe that we formally owned within the last 2 years. The windshield does not take rock hits well. On all three vehicles a rock strike on the windshield not only left a large star impact, but the crack from the impact reaches all the way to the roof pillar. The crack is long. I believe the windshield glass is substandard and needs to be looked into closer as being a possible safety risk. Replacing the windshield and camera recalibration is expensive.

NHTSA ODI 11435774

This is the 1st of two 2020 Santa Fe's that this has occurred on as well as a 2019 Santa Fe that we formally owned within the last 2 years. The windshield does not take rock hits well. On all three vehicles a rock strike on the windshield not only left a large star impact, but the crack from the impact reaches all the way to the roof pillar. The crack is long. I believe the windshield glass is substandard and needs to be looked into closer as being a possible safety risk. Replacing the windshield and camera recalibration is expensive.

NHTSA ODI 11435776

While driving on the highway, the front pane of the panoramic sunroof spontaneously shattered. No contact from a foreign object was observed or heard prior to the breakage. The roof was closed, thus our family avoided any glass showering down into our cabin, but this would have been catastrophic had it happened with the roof open. This problem has happened to prior year models of the Santa Fe. Hyundai dealership has agreed to repair the broken sunroof at no cost, however, does not admit fault with the manufacture of the glass.

NHTSA ODI 11432467

Failed tire in question: Tire failed immediately when apparent road hazard occurred on a major freeway. Exited freeway and located a area where I was able to pull over. After changing said tire (Kumho 235.60/R18) I attempted to inspect tire and found the steel belt failed (punctured). Upon further investigation I observed that the steel belt has covered with less than as less than a 1/6th inch of rubber thereby exposing the belt for a potential failure. At this point the mileage said tire was 7700. As of yet the tire warranty has not been confirmed. This tire was delivered on a new 2020Hyundai Santa Fe limited.

NHTSA ODI 11432499

The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving 70 MPH, the contact heard a loud explosion. The contact felt the wind coming from the sunroof. The contact pulled over to the side of the road and saw that the glass sunroof had exploded and shattered. The contact stated that no object had struck the sunroof to cause it to explode. The contact was able to continue driving to her destination. The contact took the vehicle to a local dealer to have the vehicle inspected however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.

NHTSA ODI 11432191

The air conditioner quits working after a few minutes if the temperature is over 80 degrees. This has happened multiple times, at least 6 times. I took the car into Hyundai dealer and they said they could fine nothing wrong with it. As soon as we got it back from the dealer it happened again. Heat stroke was our only safety concern. No warning light has ever come on to report this breakdown.

NHTSA ODI 11425754

The Rear Occupancy alarm, a Safety Feature, goes off commanded usually at night with the vehicle locked and unoccupied. Dealer is unable to find a fix and has no way to prevent further occurrences. They recommend disabling the system, removing this system from the safety features of this vehicle.

NHTSA ODI 11419697

The driver rear tire may be leaking air and the pressure monitoring system shows the pressure is 27-28. The car was brought brand new from Hyundai of Torrance, CA on 20 Jan 2020 and as of this date, 23 May 2021, the mileage is 2,007 miles. I have taken the car into the dealership twice about the tire (second time was on 20 May 2021) and they keep saying they don't fix tires and it may have a slow leak. I find this unacceptable and I feel like I'm being taken advantage of (I'm a senior citizen). I plan on driving to another state and I want to ensure the safety of myself and passengers. Just now, I checked the pressure monitoring system and the light is not on. At this point, I don't know if it's tire issue or the electronic system issue. Unfortunately, I don't have any documentation, but perhaps the Hyundai dealership have something on their service database/computer.

NHTSA ODI 11418228

NEW 2020 SANTAFE TOOK DELIVERY ON JANUARY 4TH, 2021, WITH LESS THAN 5000 MILES ON MARCH 21ST THE VEHICLE REFUSE TO START AFTER IT WAS STARTED AND SHUT OFF WHILE WE WERE SITTING IN A PARKING LOT. WHILE ATTEMPTING TO START IT GETTING FORWARD COLLUSION WARNING BUT THE ENGINE WOULD NOT CRANK. TOWED TO THE LOCAL DEALER WAS TOLD THEY CANNOT DIAGNOSE THE CAR BECAUSE THEY COULD NOT READ THE ONBOARD COMPUTER, UNABLE TO SAY WHAT'S WRONG. THE CAR WAS TOWED BACK TO THE DEALER WHERE PURCHASE AND WAS TOLD IT WAS A BLOWN FUSE MAYBE LIGHTING STRIKE AND OTHER THEORIES WHAT'S WRONG. THE DEALER WOULD REPLACE THE FUSE AND COMPUTER AFTER 52 DAYS THE CARE IS STILL AT THE DEALER WAITING ON PARTS. TOTAL ELECTRICAL FAILURE WITH NO RECOURSE AT THE MOMENT, HYUNDAI MOTOR OF AMERICA CONSUMER AFFAIRS WANTS US TO SIGN A SETTLEMENT AGREEMENT TO REFUND OUR EXPENSES AND HAVE NOT FIXED OR REPLACED THE CAR. THE MANUFACTURE IS TOTALLY DRAGGING THEIR FEET AND DENYING THE CAR SUFFER A TOTAL ELECTRICAL FAILURE, WHILE THE BATTERY WAS STILL IN WORKING CONDITION ACCORDING TO AAA.

NHTSA ODI 11416261

I WAS IN A MAJOR CAR ACCIDENT AND THE CAR THAT HIT ME WAS TRAVELING ABOUT 60 MPH HIT ME IN THE REAR AND THE AIR BAG NEVER DEPLOYED, THIS IS VERY CONCERNING AND SHOULD BE LOOKED AT. I WAS STOPPED AT A RED LIGHT WHEN I GOT HIT.

NHTSA ODI 11415353

THERE ARE THREE ISSUES: 1.) IN SPORT MODE, THE TRANSMISSION WILL SOMETIMES GET STUCK/HUNG IN GEAR (MAYBE GEAR 3 OR GEAR4) AND WILL NOT SHIFT INTO THE NEXT GEAR, EVEN WHEN INCREASING SPEED. 2.) ALSO IN SPORT MODE, AFTER DRIVING FOR ABOUT 10 OR 15 MINUTES THE TRANSMISSION WILL OFTEN SLIP INTO GEAR 5, AFTER REVVING HIGH AND CAN BE HEARD REVVING, BUT IT IS NOT REFLECTED ON THE TACHOMETER, AND THEN WHEN THE GEAR CATCHES IT IS A VIOLET JERK FORWARD. 3.) LASTLY, IN ANY MORE, BUT MOST PRONOUNCED IN "SMART MODE" AFTER TAKING OUT FROM A COMPLETE STOP, AND ESPECIALLY AFTER THE ENGINE GOES INTO AUTO SHUT OFF MODE, THE TRANSMISSION WILL STUTTER AT ABOUT 3 - 5 MPH AND FEELS AS IF POWER HAS BEEN LOST FOR A FEW SECONDS. THIS IS MOST TERRIFYING WHEN MAKING A LEFT TURN INTO TRAFFIC, AS YOU NEVER KNOW IF IT WILL HAPPEN OR NOT.

NHTSA ODI 11403919

WAS DRIVING DOWN THE ROAD ABOUT 40 MPH, SLOWED DOWN TO ABOUT 10 TO 15 MPH TO MAKE A RIGHT HAND TURN WHEN THE RIGHT REAR TIRE ON MY 2020 HYUNDAI SANTA FE VIN: [XXX], EXPLODED RIPPING SEVERAL INCHES INTO THE SIDEWALL. HAD NO KNOWLEDGE OF HITTING ANYTHING ANY TIME PRIOR TO THE TIRE EXPLODING AND NOTHING IN THE ROADWAY TO CAUSE SAID DAMAGE AT THE SIGHT OF THE EXPLOSION. TEMPERATURE AT THE TIME OF THE EXPLOSION WAS ABOUT 55 DEGREES, NOT TO COLD OR TO HOT. HAD ONLY DRIVEN ABOUT 3 OR 4 MILES ON THE TIRE PRIOR TO EXPLOSION, SO HEAT WAS MOST LIKELY NOT PART OF THE PROBLEM. TIRES WERE MADE BY HANKOOK TIRES, DYNAPRO HP2, SIZE 235/65/R17 104H, DOT 15M8R RT HO 2719, WITH ABOUT 29,000 MILES ON THE TIRES, VERY LITTLE WEAR AT ALL THE TIRE, WITH AIR PRESSURE MAINTAINED AT ALL TIMES TO ABOUT 35 TO 36 PSI WHICH WAS CHECKED ALMOST DAILY. OF ALL OF MY YEARS OF DRIVING HAVE HAD FLAT TIRES, BUT NEVER HAVE I HAD A TIRE JUST EXPLODE AS IN THIS INSTANCE WITH THIS TIRE. FEEL LIKE THIS SHOULD HAVE BEEN REPORTED IN CASE OTHERS MAY HAVE EXPERIENCED ANY SIMILAR ISSUES WITH THESE TIRES. HANKOOK, DYNAPRO HP2, 235/65R17 104H, DOT 15M8R RT HO 2719. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI 11402818