May 22, 2026Engine
I am reporting a serious safety defect in my 2019 Mercedes-Benz GLS450. My vehicle experienced low oil pressure warnings and engine warning lights, which were diagnosed as a faulty oil pump solenoid valve. The repair required removing major engine components, resulting in a cost of $5,000 that I paid personally. It is important to note that Mercedes-Benz updated the valve design in the following model year, indicating that the company was aware of a defect in the original design. This demonstrates that the failure is recurring and not isolated, creating a serious safety risk—low oil pressure can lead to catastrophic engine failure while driving, endangering the driver and passengers. I request that NHTSA: Document this as a potential safety defect. Investigate the prevalence of this issue. Consider initiating a recall or safety notice for affected GLS450 vehicles.
NHTSA ODI 11739507
Dec 4, 2024Engine
While driving my car the check engine light comes on. The code is P06DA (OIL PUMP SOLENOID OPEN CIRCUIT - ELECTRICAL ISSUE). Dealer states repair is $5000!!! Car is not able to pass inspection due to the check engine light.
NHTSA ODI 11628945
Sep 9, 2024Engine
9/9/24 after 5pm I'm driving my car and the check engine light came one. I have a small autel handy scanner always in my car. I checked it right away and gives me the code P06DA (OIL PUM SOLENOID OPEN CIRCUIT - ELECTRICAL ISSUE). I stop on the side for a quick check, no knocking noise from the engine and runs good. I checked on the website (Mercedes forums) and a lot of people had the same problem (lemon???). Most of them talking that thanks God the solenoid stuck on full open (higher pressure oil) so there's no damage to the engine. Repair cost around $5000!!!!! That problem must be taken seriously from Mercedes! Thank you
NHTSA ODI 11613641
Dec 11, 2019EngineElectrical system
DRIVING ON FREEWAY AT ̃75MPH TOWARD 202 W ARIZONA FREEWAY, DASHBOARD SHOWED A "ENGINE MALFUNCTION + 48 V BATTERY SEE OPERATOR'S MANUAL:. 1 MINUTE LATER ANOTHER ERROR ON SCREEN SAYING, COOLANT OFF TURN ENGINE OFF. THEN THE CAR LOST THE POWER IN THE MIDDLE LANE OFF FREEWAY. LUCKILY NO CARS BEHIND US. CAR IN SERVICE AT MERCEDES DEALER IN CHANDLER AZ
NHTSA ODI 11288497