What 68 owners told NHTSA about the 2019 Kia Sportage Phev

The engine locked up about a year ago, and since we didn’t technically have a recall we didn’t know what to do. It was able to drive again after we had a technician work on it, but now it’s not driving anymore. It shakes hard when it’s idling and driving. We have waited over 2 weeks to be diagnosed with the problem. We have had to spend $1300 on rental cars because we can’t get a loaner until diagnosed. The car is not safe to drive and puts our lives at risk to drive it. We were lucky it didn’t start shaking while we were driving on a major highway, but it did still happen while driving and was terrifying. The car is at Williams Kia now, in Elmira NY. They still haven’t diagnosed the problem. The check engine light is on.

NHTSA ODI 11748112

The vehicle is experiencing excessive engine oil consumption. The engine was found by the dealership to be low by 3 quarts of oil after about 1000 miles during an oil consumption test, indicating abnormal oil loss. The suspected failure involves internal engine components, possibly piston rings, allowing oil to enter the combustion chamber and burn. This condition creates a safety risk because the engine can become critically low on oil, without warning, potentially leading to engine damage, loss of power, or engine failure while driving. The problem has been reproduced and documented by the dealership during oil consumption testing. However, there are inconsistencies in the dealership’s reporting, as later documentation stated that no oil consumption was found despite earlier records showing excessive oil loss. This vehicle has been inspected multiple times by an authorized dealership and is currently part of an open case with the manufacture. The vehicle was also held at the dealership for approximately three weeks without clear documentation of work performed. There were minimal warnings indicators prior to the issue. The vehicle showed rough engine performance, which was consistent with oil fouling the spark plugs. No clear warning light reliably indicated the severity of the oil loss before the condition was discovered during testing.

NHTSA ODI 11726557

This complaint is in reference to my vehicle which is involved with Federal Class Action Lawsuits and the fact that my engine was defective from the day it was built. My engine was consuming oil at a rate of 1 quart every 361.1 miles driven. I was advised to not put oil in it and drive it until it blows up. This would have put myself, my family, friends, or any other passengers or bystanders at risk. Kia is denying my claim solely on a non rod bearing failure.

NHTSA ODI 11709880

My check engine light started blinking and the car was stalling out. I have now parked the car in my driveway. I bought the car October, 2024

NHTSA ODI 11697043

Severe oil consumption issue at 100k miles. Same issue seen on kia class action lawsuit for GDI engines. No leaks present, after 800 miles from oil change, no oil seen on dip stick.

NHTSA ODI 11695393

Engine went out at 150,000 miles.

NHTSA ODI 11691396

The contact owns a 2019 Kia Sportage. The contact stated that while the vehicle was in for maintenance, the contact was informed that there was no oil in the engine. The contact stated that the oil warning light had only illuminated once. The vehicle was taken to the dealer, where the first oil consumption test was performed. The dealer added oil to the vehicle. The contact checked the oil level every two weeks and noticed that the engine was consuming an excessive amount of engine oil. The contact was adding several quarts of oil every two weeks. The vehicle had several oil consumption tests performed by the dealer. The contact was informed that less than a quart of oil was lost. However, while the vehicle was at the dealer, all the oil had leaked out of the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but did not offer any assistance. However, a claim was filed. The failure mileage was approximately 70,000.

NHTSA ODI 11690970

My oil consumption is approximately 1.5 quarts every 200 miles. I get my oil changed every month and every other week I need to top off. When my oil, is low there is no indication on the dash. I have to preform inspections on my car on a daily basis. Now, my car will randomly not start. I replaced the battery and changed the spark plugs.

NHTSA ODI 11687052

My engine has been burning through oil very fast, it is only 6 years old. I have to put oil in it approx 3 times before another oil change is due. My mechanic suggested I see if there were any recalls but there are none. I have no lights on or any other issues.

NHTSA ODI 11679543

The I started noticing my oil light was coming on after only few hundred miles. After every oil change a week or 2 later I would need oil. Took it to a several mechanics and no leaks founds they all said the GDI engines are known for consuming high amounts of oil. I called Kia and they admitted they know about the problem but will do nothing about it

NHTSA ODI 11664071

The car started stalling anf an engine light came on

NHTSA ODI 11649966

Oil consumption issues that kia is not taking responsibility for

NHTSA ODI 11647567

The car continues to burn oil and have to put oil in it although not time for oil change. I took the vehicle to dealership several times because whenever I get gas it won’t let me start it right away or stutters after getting gas. Whenever the car is in park or idle it’s making a knocking noise and shaking really bad. The check engine light keeps going off and on but this most recent time it is not on. Initially i was advised they could only diagnose when check engine light on but that’s the issue because light does not stay on. I was on the freeway going about 70mph the car started declining in speed so had to hurry and pull over. Pulled over and turned off the car then it took several times to start back up. Vehicle currently at dealership waiting for more info but said it’s something related to the engine misfire.

NHTSA ODI 11643278

Vehicle was throwing codes P2196 O2 sensor stuck rich, P0290 post catalyst fuel trim lean, P01720 system too rich, P016B closed loop air/fuel ratio control at limit. Brought to local dealership where they did an inspection and could not find any major issue that, in their words, “would affect drivability”. Recommended I start using premium fuel and in the future consider a fuel system cleaning. 9 days later while driving my engine starting knocking, check engine light was on and flashing, then my car died. Towed vehicle to the dealership where the assessed and found there to be no compression and stated the pistons looked “melted”. They could not give me a reason as to why, or why none of this was caught at my $100 service inspection 9 days prior. They stated I needed an engine replacement at $6700 due to failed pistons. They would not do any type of diagnostic or testing to rule out a known issue with the Theta II engine recall. They stated they did not have to do any further diagnostic since they found my pistons to be melted. Local mechanic of mine not affiliated with the dealership, assessed the engine and components, stated he did not see any abnormalities outside of normal wear and tear but did recommend I have the dealership tear into the engine since they are “Kia Experts” and know the engines. Kia dealership stated they filed a claim with corporate and it was denied. Kia corporate stated my dealership sent report stating engine failure reason is outside of scope for recall. Kia dealership refused providing me denial in writing. Sent me photo of correspondence with tech line which was a total of 3 messages. Vehicle had been at dealership since November 16th.

NHTSA ODI 11630646

The contact owns a 2019 Kia Sportage. The contact stated that on several occasions the vehicle failed to start. The contact stated that the vehicle occasionally stalled while driving. Additionally, the contact stated while driving 55 MPH, the vehicle unintendedly decelerated to 30 MPH. The contact pulled over to the side of the road and attempted to restart the vehicle however, the vehicle failed to restart. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the engine was faulty and needed to be replaced. The contact received a secondary diagnostic test from an independent mechanic and was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 160,000.

NHTSA ODI 11629690

The vehicle just suddenly stopped without any warning or anything. No warning lights came on until after the engine had almost completely stopped in the middle of the road. Vehicle is also using oil without any warning light coming on at all and vehicle is out of oil. That is a problem with both things. Suddenly stopping can cause me to be in an accident. This is not safe at all and should be the manufacturer responsible to repair this issue.

NHTSA ODI 11620419

The contact owned a 2019 Kia Sportage. The contact stated while driving 40 MPH, the vehicle started overheating and smoke started emitting smoke from the hood. No warning lights were illuminated. No injuries were reported. The vehicle was destroyed leaving only the framing. The fire department arrived on the scene and extinguished the fire. A fire department report was filed. A police report was not filed. The manufacturer was notified of the failure and the vehicle was inspected; however, the inspector did not find a defect in the vehicle. The vehicle was also inspected by the fire department who determined that the cause was in the rear passenger window. The failure mileage was unknown.

NHTSA ODI 11617339

1) Vehicle is burning oil and engine is overheating quite fast. 2)Vehicle has stalled or shut off on its own during use 3) Kia dealership refused to address the specific issue due to car being out of warranty because of the mileage. They also wanted to run different tests not directly associated with the issue; Wants to do trial and error which is only creating a humongous bill for the customer. 4) Insurance was contacted and currently awaiting instruction at the present time this form is completed on September 14, 2024 11:35 AM MST 5)No warning lamps or messages appeared. Only found out about initial issue when vehicle was taken in for yearly inspection in accordance to state laws for Tag renewal at a local Pep Boys. The mechanic informed me that my vehicle had an engine recall, the vehicle is burning oil drastically, and that the vehicle will need a new engine. After this and Kia refusing to do anything, all my vehicle issues became worse(April 2024-Present). I must put oil every 1k miles now presently. I revisited Oil Changers multiple times for a top off before it was even time for an oil change. The mechanic also made it so my oil would burn slower but it did not work.

NHTSA ODI 11614592

On my way driving to pick up my kids my vehicles check engine light started flashing and went into limp mode. It wouldn't go above 15 mph. The oil lamp started to flash. I had to ease it out of traffic and park the vehicle. I proceeded to check the oil and the dip stick was completely dry. I had to walk to the nearest autozone purchase 5 quarts of oil, walk back to the vehicle and put it into it. I then had to bring it home. I ran a diagnostic test and it was putting out a P1326 code. The car is not drivable. I had to have it towed to the dealership and they currently have it and I am awaiting further details.

NHTSA ODI 11613488

The contact owns a 2019 Kia Sportage. The contact stated that on several occasions while driving at various speeds, the vehicle jerked abnormally. The contact stated that the accelerator pedal was depressed, and the vehicle lost motive power. Additionally, on several occasions while in reverse, there was a loud noise coming from the engine compartment. The check engine warning light was illuminated. The vehicle was towed to a dealer five times; however, the failure could not be replicated. The contact stated that on another occasion the vehicle was towed to an independent mechanic where an unknown code was retrieved. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

NHTSA ODI 11593887

The contact owns a 2019 Kia Sportage. The contact stated while driving 45 MPH, the electrical and mechanical systems became inoperable. The headlights, signal, and hazard lights became inoperable. The contact pulled over, placed the vehicle in park, and turned the vehicle off. After restarting the vehicle, an abnormal ticking sound was coming from the vehicle. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the radiator needed to be replaced and the tie rod had excessive play. The dealer denied repairing the vehicle due to sludge in the engine. The vehicle was not repaired. The manufacturer was notified, but no assistance was provided. The failure mileage was approximately 75,490.

NHTSA ODI 11583756

Fully maintained services with my 2019 Kia Sportage with my local Kia dealership. I am a sales rep and use my car daily. I have 155k miles on my car. My car was needing oil changes about every 2500 miles because it was burning so much oil. Yesterday, 2/08,I turned on my car during my work day and while ideling my car in park, my engine light came on. The car immediately started to shake uncontrollably. No other indication prior to the shaking of the car did I think something was wrong. Again I get services done frequently to my car. I took it to Kia immediately. They diagnosed that in cylinder 2 one of my intake valves was broken. This is not covered under the recall already put in place or with the extended warranty with the software update. According to my Kia Dealership, the current recall for an engine replacement is only for the under rod bearing. The dealership wants $7300 for a completely new engine. I have never had a car that has ever had an engine go. Nor have heard of one having the engine fail within the first 5 years. I have looked online and many people have complained about this exact same problem and Kia says they can’t do anything for us. I do not have current documentation because my car is still at Kia. I am trying to figure out what to do before I drive it off the lot.

NHTSA ODI 11571139

Complained since buying car noise in motor was told it was fine on dec 7th car broke down 200 miles from home was told it was the rod bearings that was under recall

NHTSA ODI 11559055

I have been fighting with Cronin Kia over my engine that needs replaced due to a known problem with the GDI engine. This vehicle is burning so much oil and I have reported the problem. I was told to perform oil consumption tests, which I have been compliant with. The problem is that on 11/16/23, I had to go to an oil change company due to my engine having no oil, yet again. I called Cronin Kia and was told that since I put oil in the car, I have to start all over again. I hadn't even gone the 1,000 miles that they requested me to do. I called the dealership and the service manager, Josh Hopkins, told me he could not help me even though I had photos. I then called the Kia corporate office number and spoke to Angel and was told that I should have let my engine blow up on the road and have it towed to the dealership. This would have caused an accident and they told me they didn't care that is what I needed to do. I feel this is so unacceptable and needs to be reported to you. This could cause a major accident and I have a daughter wo has special needs and I need to drive a safe vehicle and telling me to take the chance of an accident is so scary. I would really appreciate any help you can offer. [XXX] (formerly [XXX] ). [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11556695

The contact owns a 2019 Kia Sportage. The contact stated that while driving at an undisclosed speed, she heard an unusual ticking sound coming from the engine. The vehicle was taken to the dealer where it was diagnosed with tow hitch wiring harness deficiency. The contact was informed that the tow hitch wiring harness needed to be replaced. The vehicle was not repaired. The contact had received an interim recall notification in November 2022. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches) in July 2023. The contact stated that the vehicle was stolen in April 2023 for a short while. The manufacturer was made aware of the failure but provided no assistance. The manufacturer offered to cover half the cost of the repair. The approximate failure mileage was 40,000.

NHTSA ODI 11542854