What 405 owners told NHTSA about the 2019 GMC Sierra Limited 1500

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving approximately 45 MPH, the message "Battery Saver Alert" was displayed on the instrument cluster. The contact stated that the battery gauge was reading 9V on the 12V battery. The vehicle was driven to a dealer. The dealer diagnosed the vehicle and determined that a battery tender was needed. The contact asked the dealer to check the 12-Volt battery which was replaced 2 years prior by the same dealer. The dealer diagnosed the vehicle and determined that the alternator needed to be replaced. The contact was later informed that the battery fuse also needed to be replaced. The vehicle was repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 19V888000 (Electrical System); however, the VIN was not included in the recall. The failure mileage was 43,742.

NHTSA ODI 11678824

The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at various speeds, the vehicle would intermittently hesitate upon depression of the accelerator pedal. The contact also stated that the check engine warning light had flashed on the instrument panel. The contact took the vehicle to an independent mechanic, where the mechanic informed the contact that there was a miscommunication between the engine and the transmission. Two dealers were notified of the failure, and each informed the contact that there were no recalls on the vehicle. The contact was also given a diagnostic fee to determine the cause of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI 11678853

Component/System that failed: The issue appears to originate from the transmission or drivetrain, specifically resulting in the rear wheels locking up and dragging at low speeds. It feels like something is seizing inside the drivetrain, making the truck very difficult to move. The vehicle is available for inspection upon request. How safety was put at risk: This failure presents a serious and unpredictable safety hazard. The vehicle begins locking up randomly when slowing down, such as in parking lots or residential areas. If this occurred at higher speeds or in traffic, it could easily result in a crash, loss of control, or pedestrian injury. It’s completely unreliable and unsafe to operate in this condition. Has the problem been reproduced or confirmed by a dealer or service center? The issue is part of a well-known transmission defect affecting GM’s 8-speed automatic transmissions. There are multiple class action lawsuits and thousands of consumer complaints documenting identical symptoms. GM is fully aware of the defect but has refused to issue a recall, instead allowing the time-based warranty to expire even when the mileage is still well within the 60,000-mile limit. My local GMC dealer refused to offer a loaner or goodwill repair and quoted over a week just to diagnose it despite knowing that this is a known failure point. The symptoms are consistent with the known defect GM continues to avoid addressing. Has it been inspected by the manufacturer, police, or insurance? No outside inspection has occurred yet. Given the widespread documentation of this defect and the consistency of symptoms, it should not be necessary to involve other parties. Were there any warning lamps or messages? No. There were no warning lights, messages, or alerts of any kind. The failure occurs randomly, and without any prior indication. That unpredictability makes the issue even more dangerous.

NHTSA ODI 11678916

While traveling on the freeway at freeway speeds and with the cruise control on, on 7/22/2025, my vehicle abruptly start making an odd noise, the steering wheel started to vibrate / move as if I had a flat tire. I safely existed the freeway and pulled over to investigate, there was no flat tire yet the vehicle still made the noise and experienced issues when the throttle was applied. I proceeded to call a tow truck, and have the vehicle towed from Alpine, CA to Temecula and Temecula Valley GMC. While there the dealership gave me an initial diagnosis of "Miss fire in cylinder 8". We left the vehicle, and awaited more information. The next day I received a phone call stating that they needed to do an engine teardown to completely diagnose the issue, to the tune of approx. $1,500. In the dealers words, they needed to do the teardown to determine if "They could salvage the engine, or if it had to be condemned". The following day I received another call stating that the engine needed to be completely replaced due to a collapsed cylinder. The estimate for this work is over $13,000. the truck is 6 years old with 58,XXX miles.

NHTSA ODI 11678572

Yates GMC Replaced my engine a couple of years ago under warranty and my truck has never been the same. I’ve been to the dealer multiple times. The drive, the way it operates always making cranking snapping sounds.

NHTSA ODI 11678070

Had to have transmission rebuilt found metal shavings and was shifting bad and shuttering. Vehicle Has 63,000 miles and is well maintained. Vehicle was taken to GMC but said their transmission person was on vacation for 2 weeks. Also parts dept Said they had no transmissions in stock and were back ordered. Truck was taken to AAMco and transmission was rebuilt And torque converter replaced . This is a common issue with GMC trucks.

NHTSA ODI 11677478

Power Steering failure. Loss of power steering while driving the vehicle made any turns nearly impossible. Dealership identified root cause and a problem with a grounding strap. They reported that in addition to our vehicle, another GMC Sierra 1500 had come in the same day with the same problem. Loss of power steering while driving can lead to collision. This should be a safety recall.

NHTSA ODI 11677558

On or around July 12th 2025 at low speed of 2-4 mph my rear end locked up sending everyone in the vehicle hard stop forward. The vehicle wouldn't disengage leaving me no choice but to have it towed for the second time 1st time happened exactly the same about month and a half prior. Gmc service department department claims they couldn't find anything wrong after it sat for two days in there lot after having it towed they were closed weekends and looked at it that Monday morning finding no signs of anything wrong. After picking up my vehicle I strongly feel like if at higher speeds or even environment this issue will endanger myself passengers and bystanders. I need help with resolving this safety issues asap please. Gmc hasn't been much help service department nor Gm support options.

NHTSA ODI 11676392

On 7/17/25 vehicle was taken to Star Buick/GMC in Easton PA for rear brakes and an oil change. This vehicle has 49,981 miles on it. I was told after the oil change the tech took the truck for a test drive. I was told he made it about 20 feet and the engine seized. Either the tech forgot to refill the crank case or it is another GM 6.2 disaster. Please advise as the dealer is quoting over 12K to replace engine.

NHTSA ODI 11674713

My 2019 GMC Sierra 1500 truck exhibiting all the same signs as the recent call for the same 2021 truck recall according to the dealership. This is for the L87 V8 engine. The 2021 engine was used in the 2019 trucks but again the 2019 trucks are not a part of the recall. My repair bill is upwards of $10,000 and diagnostics is upwards for $4,000 even though all are aware of the recent recall and my truck having the same engine.

NHTSA ODI 11673956

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 70 MPH, there was an abnormally loud sound coming from the engine compartment before the vehicle lost automotive power. The vehicle was towed to the local mechanic who diagnosed the vehicle with engine failure. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 126,000.

NHTSA ODI 11672516

The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving on the highway at 60 MPH, there was an abnormal knocking sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was advised that the camshaft and lifters were faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 73,000.

NHTSA ODI 11672247

Vehicle motor suddenly stopped working. Vehicle was pulled into a driveway safely then wouldn’t crank anymore.

NHTSA ODI 11672271

- 6.2 engine lost propulsion & warninng light on dash flashed about 3-5 times. After that the trucks engine completely malfunctioned. When this happened i was traveling at 70mhp on interstate I-69 when the the truck lost power to the engine, steering and power braking. The truck was inspected by a GM dealer and they found the engine had blown & with that it caused damage to the coolant system & to the catalytic converterin which all was replaced at full customer cost. Prior to the engine failure 2 other times it lost power and had a rough ilde and trouble starting . 1st time the dealer could not replacate the issue the next time found a camshaft postioning sensor was bad which was placed at customer cost.

NHTSA ODI 11670551

Truck is at the Jim Gauthier GMC dealership on Mcphillips in Winnipeg, Canada. Engine endured catastrophic failure and is currently waiting for a new engine.

NHTSA ODI 11670598

I was driving with my wife about to merge into traffic on the interstate when I had a huge power loss. It was a busy part of the interstate where I could have been ran over. There was a lot of traffic and was fortunate the Semi driver was alert and slowed down. I was not aware of any failures of this motor or received any notices from GM. After conducting research I found that this was a know issue that GM failed to report. My truck has been serviced regularly and until that point had not given any signs of a upcoming failure, I have read that GM is looking into other years such as 2019 which mine is. I have had no luck with GM customer care with the only response being I need to crunch the numbers from my claim advisor. I have the 6.2 L87 motor and know of the clip failure do to poor assembly and parts and debris getting into the motor causing the failure. I am looking to report this and request any assistance available. My first stop was the dealership, then GM customer care

NHTSA ODI 11669016

The contact owns a 2019 GMC Sierra 1500. The contact stated that the “Service Rearview Camera” message was displayed on the navigation display screen. The camera failed to activate while reversing. There were watermarks on the rear inside glass. The following day, the camera was operational. The contact was concerned about running over a pedestrian due to the camera being inoperable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 29,000.

NHTSA ODI 11668699

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 10 MPH, the vehicle made an abnormal ticking sound. The contact stated that the failure also occurred upon starting the vehicle. The vehicle was taken to the dealer, where the camshaft and lifters were replaced, and other unknown required repairs were performed. The vehicle was repaired. The contact related the failure to NHTSA Action Number: PE25001. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 52,029.

NHTSA ODI 11667353

Driving down the highway at approximately 65mph, when I accelerated to 70mph my truck began to shake violently flashing a check engine light, service parking brake light, and service ESC light, the engine began to violently shake and make a rough knocking noise Had the vehicle towed to the mechanic where I was informed that the lifter on cylinder 2 had collapsed and that it would be $12,500 to replace all 16 lifters as well as the cam shaft on my engine My safety was at risk as my truck went into a “limp” mode and essentially shut off on the side of the road, others were at risk due to my truck becoming a hazard, the tow operator was at risk having to pickup my truck on the side of a 70mph freeway The only check engine code I had was a misfire on cylinder 2 Dealership stated that it was a known issue but that my truck was outside of warranty, and not apart of recall so there was nothing they could do Had truck towed to different shop that is repairing the problem Requested that all parts be kept in case of inspection request

NHTSA ODI 11666867

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended. There was no warning light illuminated. The vehicle was driven to the shoulder of the road. The vehicle was towed to the dealer where it was diagnosed with metal shavings in the oil pan and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was made aware of the failure but no assistance was provided. The contact was advised to contact the NHTSA Hotline to report the safety failure. The failure mileage was approximately 120,000.

NHTSA ODI 11666582

My 2019 GMC Sierra Denali shut off suddenly while I was stopped in traffic. The engine died, the steering wheel locked, and the dashboard displayed warning messages including “ESC,” “power,” and another I didn’t catch. The truck would not restart despite attempts. The check engine light is now on. This happened without warning, and I had no prior mechanical issues. The vehicle is well maintained, garage-kept, and recently received a full service including oil change, brake work, and 75K-mile recommended service. I fear this is related to a known issue affecting other GMC engines under investigation for sudden power loss.

NHTSA ODI 11665652

There is a common lifter failure issue with the 5.3 V8 engine in these vehicles and local mechanics I've spoken too are very aware. The 6.2L was recalled for the same reason. GM would not honor or cover any of this as it was "out of warranty", however, I strongly feel this should be investigated.

NHTSA ODI 11665264

The engine failed and needs full replacement. Known GM issue with lifters. Engine style 6.2L. We contacted GM and they are not responsive and they provided a claim number. To repair is over 9,000$ and I still owe about 7000$ and the truck was purchased brand new. GM cannot furnish a replacement engine. The dealer showed 34 in stock when ordered. The dealer contacted us later stating GM canceled the order and they do not have an ETA when they can send an engine for the vehicle. We are paying on a vehicle that is stuck at dealer and cannot be repaired.

NHTSA ODI 11665190

I had a 2019 GMC Sierra with a 6.2L gas engine. The engine failed while I was driving on the highway at 65 mph. The truck began shaking badly, check engine light and all kinds of warning lights came on. I pulled over and drove slowly 10 miles to a GM dealer who then told me that I should not be driving the truck due to safety concerns and it could lose power and lead to an accident. I had it towed back to my home town ($500 later) to the GMC dealer where I purchased the truck. They told me the same thing, it could not be driven. GM has since recalled vehicles with this same 6.2L engine manufactured in model years 2021-2024. I believe that recall should have included my 2019 truck. I was at risk of serious injury or death due to engine failure, fortunately I did not crash. However, I lost $14,000 in value of the truck thanks to the faulty engine. I believe the recall should be expanded and I should be compensated by GM for the engine failure. I have attached the estimate for the repair.

NHTSA ODI 11664684

I am reporting a serious mechanical and safety issue with my 2019 GMC Sierra 1500 (5.3L engine). The truck began misfiring, running rough, and would frequently “jump” and shut off while driving — creating an unsafe situation on the road. We attempted several repairs to resolve the issue: •Transmission flush •Replaced the intake manifold gasket •Replaced all eight fuel injectors •Inspected all ignition coils •Replaced faulty sensors The vehicle repeatedly showed a Cylinder 8 misfire, even after these repairs. Eventually, it was diagnosed that both the lifters and camshaft are bad, and the engine now needs a full replacement. This is extremely concerning because the truck has only about 47,000 miles on it. We brought it to the dealership in September 2024, while it was still under warranty, and told them it wasn’t running right. The dealership said there was nothing wrong. Now that the warranty has expired, GM is refusing to help with any repairs. This appears to be a manufacturing defect that was not properly diagnosed while under warranty. Engine failure at such low mileage, especially with early warning signs and repeated diagnostic errors, should be investigated as a serious reliability and safety concern.

NHTSA ODI 11664474