What 405 owners told NHTSA about the 2019 GMC Sierra Limited 1500

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving approximately 45 MPH, the message "Battery Saver Alert" was displayed on the instrument cluster. The contact stated that the battery gauge was reading 9V on the 12V battery. The vehicle was driven to a dealer. The dealer diagnosed the vehicle and determined that a battery tender was needed. The contact asked the dealer to check the 12-Volt battery which was replaced 2 years prior by the same dealer. The dealer diagnosed the vehicle and determined that the alternator needed to be replaced. The contact was later informed that the battery fuse also needed to be replaced. The vehicle was repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 19V888000 (Electrical System); however, the VIN was not included in the recall. The failure mileage was 43,742.

NHTSA ODI 11678824

My 2019 GMC Sierra Denali shut off suddenly while I was stopped in traffic. The engine died, the steering wheel locked, and the dashboard displayed warning messages including “ESC,” “power,” and another I didn’t catch. The truck would not restart despite attempts. The check engine light is now on. This happened without warning, and I had no prior mechanical issues. The vehicle is well maintained, garage-kept, and recently received a full service including oil change, brake work, and 75K-mile recommended service. I fear this is related to a known issue affecting other GMC engines under investigation for sudden power loss.

NHTSA ODI 11665652

Ok I know my vin don't go under the 10 recalls for 2019 gmc sierra limited 1500 rwd, but my truck has the same problem with the brake module has those recalls I feel like gmc might have used different parts for the other recall but used the same brake module for my truck cause I have that same problem has the recall. It's obviously a issue that needs to be look in and my brake module should be fixed by gmc

NHTSA ODI 11661191

I’m contacting you regarding my 2019 GMC Sierra 1500 with the 5.3L V8 engine. The vehicle is currently experiencing a cylinder 8 misfire (code P0308), accompanied by engine backfiring, ticking noise, and exhaust fumes inside the cabin. Additionally, the ESC (Electronic Stability Control) warning light is on, and performance is noticeably affected. To date, I have: •Replaced all spark plugs and fuel injectors •Verified proper ignition coil function •Had an oil change on September 23, 2024, during which I reported early concerns about engine performance (shortly after the powertrain warranty expired) •Had a transmission flush on March 17, 2025, in an attempt to resolve continued drivability issues Despite these efforts, the issue persists. Given the known issues with AFM lifters and camshaft wear on this engine, I suspect a mechanical failure related to that system.

NHTSA ODI 11659222

Just purchased this vehicle, at 84000 miles had engine failure and electrical issues while traveling down interstate with my family. Lost power steering and all warning lights popped up. Safely exited busy interstate -- avoided major accident. This engine should have been included in the recent GMC recall - After a diagnostic $7000.00 plus to fix. UNSAFE ENGINE ISSUE!! Please help the consumer!!

NHTSA ODI 11658622

Rear sliding glass window is leaking water around the exterior frame. This is addressed in TSB 18-NA-383 but not covered under any warranty. My rear seats and carpet are becoming wet. I am concerned about the possibility of mold and an electrical short/fire resulting from water intrusion. There are many reports and discussions on the internet regarding this issue. Full window replacement estimated at $1300. Patchwork repair with caulk is estimated at $600 with no guarantees of success. I would expect GMC to cover the replacement of the rear glass in kind and remedy any other damage to my vehicle due to water intrusion into the cabin area.

NHTSA ODI 11657067

WHILE TURNING INTO A BUISNESS FROM A HIGHWAY, THE LOW FUEL WARNING CAME ON EVEN THOUGH I HAD JUST FILLED THE TANK. UPON LEAVING THE BUISNESS, I STARTED THE TRUCK AND PUT IT INTO REVERSE AND THE ENGING STALLED. RESTARTED THE TRUCK AND PUT IT INTO REVERSE AGAIN AND IT STALLED AGAIN. RESTARTED AND TRIED GOING FORWARD AND IT RAN FINE. ABOUT 1 MILE DOWN THE ROAD THE LOW FUEL WARNING CAME ON AGAIN AND THE ENGINE STALLED WHILE TRAVELING APPROXIMATELY 35 MPH. AT THIS POINT I REALIZED THAT THE DOORS HAD UNLOCKED AND THE INSTRUMENT CLUSTER GAUGES KEPT SWEEPING UP AND DOWN. I TRIED TO RESTART THE ENGINE BUT IT WOULD NOT TURN OVER. IT ACTED LIKE THE BATTERY WAS DEAD. AFTER WATING SEVERAL SECONDS, I TRIED AGAIN AND THE ENGINE RESTARTED. I NOTED THE BATTERY VOLTAGE IN THE INSTRUMENT CLUSTER AND IT WAS NORMAL. NO WARNING LIGHTS ON IN THE INSTRUMENT CLUSTER. NO DTCS PRESENT WHEN CHECKED WITH A GENERIC SCAN TOOL. MY SAFETY WAS PUT AT RISK BECAUSE THE ENGINE STALLED WHILE DRIVING IN TRAFFIC. I HAVE NOT TAKEN IT TO THE DEALER YET AS THEY ARE NOT OPEN TODAY AND I WANTED TO REPORT THIS WHILE ALL THE DETAILS WERE FRESH ON MY MIND.

NHTSA ODI 11655587

I had engine failure two weeks after a schedule maintenance that included a tune up. When the engine failed all the components made the vehicle impossible to operate much less bring to a stop safely. I had to get the vehicle towed to the dealer. The dealer confirmed that the engine (6.2 V8) has a known documented issue. The vehicle is at my dealer with the engine being disassembled. There weren't any warnings as I stayed on the maintenance schedule that the dealer mapped out since my purchase. The problem began [XXX]. After researching the issue I found this online. That is how I found your web site. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11655350

Transmission keeps skipping missing gears and hard shifting, as well as jolting forward. When attempting to switch lanes vehicle transmission skips. When being placed from Park to drive or any other gear vehicle transmission hard shifts. Vehicle radio and screen shut off intermittently every 30 to 45 minutes. Vehicle screen goes blank and black and resets itself after 30 to 45 minutes.

NHTSA ODI 11654048

When going to shut off vehicle, when you push the push start button the engine will turn off but the radio and all the instrument panel, gauge lights, and dinging noise are still on. It states on the screen to shift to park. The vehicle is in park and even sometimes has the parking brake on. It can stay on from 1 minute to numerous minutes, which is only running my battery and other things down on my truck. This has happened daily.

NHTSA ODI 11651176

While attempting to accelerate to get onto the expressway with no warning, the vehicle went into limp mode. Traction control, front end warning collision, auto/stop start functionality was all disabled and the engine light warning light on came on. The vehicle locked out and reduced acceleration. An attempt to pull over and turn the vehicle off for a few seconds was made. Once restarted, the vehicle continued running on limp mode at reduced speeds with the same indicators mentioned still disabled and locked out.

NHTSA ODI 11647668

Lifters in engine failed at beginning of March 2025 and destroyed inside of engine. Transmission failed in summer of 2024 and had to be replaced

NHTSA ODI 11647758

While driving at 65 mph on a freeway, the engine failed and cracked a rod with fresh oil and all maintenance done regularly. Truck brakes would not work after engine failure. Truck was fully disabled and I was stranded on freeway @ 90,000 miles. Lights on exterior of the vehicle were dim after engine failed

NHTSA ODI 11643283

Complete engine failure. Absolutely insane. All lights on dash, engine seized while driving!!!!!!!!!!!!!! Unbelievable that GMC keeps making us fix issues and pay for it! They won't cover the cost. This has been happening too much and putting my family at risk!

NHTSA ODI 11638654

The contact owned a 2019 GMC Sierra 1500. The contact stated that while driving 25 MPH, there was an abnormal sound coming from the rear of the vehicle before the vehicle jerked forward. There was no warning light illuminated. The contact was able to pull over on the side of the road. The contact also stated that the radio would turn on, but there was no image on the screen. The contact took the vehicle to the dealer; however, no cause for the failure was found. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle was no longer covered under an undisclosed Customer Satisfaction Program. The contact stated that the abnormal sounds and failure persisted, and the manufacturer was contacted again. The vehicle was taken to the dealer and was diagnosed with a misfire and that the brake lights needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 42,000.

NHTSA ODI 11637323

When accelerating it will over rev and then slip and then punch foward I had a diagnostic did and the sensor in the Transmission aren't working properly and then when just driving my etrak also randomly went out and I can no longer active cruise controll

NHTSA ODI 11632000

At around 28,000 miles the truck started having intermittent electrical issues. The head unit will show a blue screen. Safty systems will automatically disable. Camera system failures. Even though the truck is a 2019 model it only has around 31,000 miles on it and is now out of warranty and I can’t afford to have the dealership chase electric issues. GMC should be ashamed of putting out such an unreliable vehicle.

NHTSA ODI 11627824

Rear window leaks as also reported by GM when truck was manufactured (GM Service Bulletin 18-NA-383). Water from leaking rear window gets into the electronics used for safety systems as well as rear camera and eventually disables safety systems.

NHTSA ODI 11615958

While driving the vehicle caught engine fire later exploding within seconds.

NHTSA ODI 11615204

2019 GMC Sierra 1500 SLT. Truck would not start on several occassions. By playing with brake, shift, and steering wheel truck would start again., Also would show warning notices, last one being {engine oil low-add oil}, even right after I just had the oil changed. This last time it would not start I paid to have my mechanic come to me to check it out. He tested a lot and thought it might be the starter so I then had to pay to have it flat-bedded to their garage. What he finally found was a BUNCH of wires worn through in a major wiring harness. It was caused by the wiring harness being next to the steering knuckle and the steering was wearing through the wires exposing bare wires. The mechanic and I see this as a major safety concern and a possible fire hazard. He has told me others have had similer problems . I believe this should definitly be a safety recall for these vehicles. My mechanic states that a new wiring harness olone is about $1500.00 plus a LOT of labor to install it. I do not believe that I should have to pay for a defect in GMC building this truck I have a picture of this mess of wires if you can help me with this. Don't know how to upload the photo I have but would gladly send it to you, Please respond back to this. Thank You Dennis Dorn

NHTSA ODI 11598350

GMC of Vacaville California sold me a 2019 GMC Sierra that has a know back window leak issues. I was told by service worker GMC of Vacaville California sold me a 2019 GMC Sierra that has a know back window leak issues. I was told by service worker Brent Lewis/405 that is a common issue and GMC is aware of this issue that the vehicle was brought in before for this same issue prior from [XXX] but was not taken care of. I purchased this vehicle on [XXX] along with a 5k extend warranty that I was told is a bumper to bumper warranty. Come to find out it does not cover a manufacturer defected back window installation. My concern is that they are aware of these issues and water sitting on the inside of the cab due to a leak causes black mold and could cause serious illness to myself and my children. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11583349

There is an issue with the drivers door locking mechanism. Something between the electrical and the mechanical components that lock and unlocks the door keeps breaking. So far you can always unlock the door manually by pulling the door handle but it sporadically will not lock or unlock by the remote or push button. Also it doesn’t always lock when put into drive like the rest of the doors do.

NHTSA ODI 11574398

Complete system failure while driving. Lost control of vehicle, no breaks. Had it brought to dealership. Lifter failure and bent rod, top engine failure which caused everything to malfunction. Vehicle has 88K miles on it. This is a defect. We had taken it in for the ticking problem in the past and they did nothing for us. Everything is documented. We are afraid that bottom half of engine was compromised. Do not feel safe driving this vehicle anymore. I do not want it to blow or lose control of vehicle again. This is a known issue and must be addressed. There was a service bulletin put out for my engine and there is an exact part by part that needs to be replaced, however GM is unwilling to listen to us at this time. Please look into this because this will happen to more and more consumers. This is very scary. What is the cost of a life?

NHTSA ODI 11574417

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 45 MPH, the service brakes were inoperable, and the vehicle experienced phantom braking. The vehicle came to a complete stop on the highway. The vehicle was towed to an independent mechanic however, the failure could not be duplicated. The contact called and made the dealer aware of the failure. The contact stated that the failure was intermittent. Additionally, the speed odometer was inoperable. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 70,000.

NHTSA ODI 11557941

There is a water leak coming into the back cab of my 2019 GMC Sierra. My truck smells horrible the dealership can't find the leak. It smells very moldy and very concern for my children riding in the back breathing the unsafe air.

NHTSA ODI 11554368