What 451 owners told NHTSA about the 2019 Ford Ecosport

I own a 2019 Ford EcoSport, VIN [XXX] , which is subject to recall 23S64 / 23V905 (Engine Oil Pump Belt and Tensioner Replacement - Final Repair). I was informed of this recall in June 2024, yet Ford has advised there is currently no available remedy. This is a serious safety concern. Under 49 U.S.C. Chapter 301 and the National Traffic and Motor Vehicle Safety Act, manufacturers must correct safety defects within a reasonable time and at no cost. Ford's failure to provide a repair, replacement, or refund is a violation of these obligations. I request NHTSA's urgent attention to compel Ford to resolve this recall promptly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11679895

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that he contacted several unknown local dealers for a year and eight months, and it was confirmed that the recall parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11678463

Recall anounced for vehicle early 2024. Remedy still not available. Check Engine light comes on, noticeable loss of fuel pressure at times.

NHTSA ODI 11676577

The contact owns a 2019 Ford EcoSport. The contact stated that while driving at various speeds, the vehicle jerked abnormally while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with transmission failure. The vehicle was serviced under warranty, and the transmission was replaced. Despite the transmission replacement, the failure persisted and became more frequent. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 15,000.

NHTSA ODI 11676608

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11675375

Engine oil pump belt tension

NHTSA ODI 11674990

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 75-80 MPH, the “Low Oil” warning light illuminated, and there was a sudden loss of power. The contact was able to drive 5 MPH to the nearest exit, and located a local oil service shop, where a mechanic inspected the vehicle and determined that the engine had failed. The vehicle was towed from the mechanic to the dealer, who confirmed that parts for the recall repair were not yet available. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 51,000. VIN tool confirms parts not available.

NHTSA ODI 11674475

I have had the same issue with my Ecosport since 04/2022 and have taken it to the ford dealership and been in contact with ford corporate multiple times. In March 2023 I had to replace the engine because it finally completely froze up and was told it was do to the oil pump tensioner. This was the fifth time I had taken it in. The check engine light came back on as soon as I left the dealership, I was told it just needed to reset. It started having issues again in August 2023 and every time I took it in it has been dismissed. I have spent thousands of dollars on repairs for this SUV. Today the check engine light came back on and it smells like smoke if you try to drive it, along with it being very slow to pick up speed and making the same odd noise as before the motor locked up the last time. I contacted ford and made another appointment today to get it checked. I also contacted ford customer service and was told that there is nothing they can do that I will once again be responsible for the cost of all repairs because the recall is not completely in place. This vehicle is not fixable or safe to drive. Ford informed me that the vehicle is now to old for them to be responsible for the fact that the car is not fixable despite the fact that they have been trying to fix it and charging me thousands of dollars while I am still paying on it. And knowing it was unsafe

NHTSA ODI 11672578

Was driving down highway when I lost power and it started whistling and a warning sounded said low oil pressure so I pulled over and had to be towed home. When I received my recall letter I took it to my local ford dealer In Covington indiana and they told me they couldn't get the parts but would contact me when they came and they neverdid. So I called them back after this happened and they said they couldn't get these parts sent to them that I would have to find a bigger dealership. Now I have to pay for a tow to Lebanon Indiana they can't get it in until July 23rd for diagnosis and no loaner. So I am without answers or a vehicle for almost a month...

NHTSA ODI 11671433

I am filing a complaint regarding Ford Recall 23S64 on my 2019 Ford EcoSport. My vehicle is showing a solid red low oil pressure warning, which Ford’s own documents state can result in engine failure while driving. I contacted my Ford dealership, and they confirmed I am part of the recall but told me to keep driving the vehicle until the engine fails, even though this clearly poses a serious safety risk to myself and others on the road. They also said it would be 3 weeks before I can receive a loaner vehicle. I then called Ford’s official customer service number (800‑392‑3673) and was met with dismissive and rude behavior. My concerns about the safety of operating a vehicle with an active engine defect were not taken seriously. I explained that I rely on this car for income and have no safe alternative right now. I’m being told to knowingly drive a car with a known oil pump defect that could result in sudden engine seizure, while Ford delays parts and offers no timely solution. This creates a serious safety issue for me and for others on the road. I am requesting that NHTSA investigate this further and that Ford be required to take urgent action to provide safe alternatives to affected drivers before their engines fail.

NHTSA ODI 11671159

Before 58000 miles my 2019 Ford EcoSport began experiencing serious drivetrain issues. The car grinds when going uphill, shakes and shudders when accelerating, and the RPMs surge up and down erratically. A certified Ford dealer diagnosed it as a transmission-related problem, (torque converter which I understand to be an issue with these cars)and Ford has only offered partial financial assistance (45%) for a $3,000 repair. These symptoms pose a potential safety issue, especially while merging, climbing hills, or accelerating in traffic. Additionally, the infotainment system failed—backup camera and USB ports stopped working—raising more concerns about overall electrical system reliability. This transmission failure occurred far too early for normal wear and raises serious concerns about possible manufacturing defects. This should not be happening this soon and no engine lights came on or anything.

NHTSA ODI 11670794

Waiting 3 years for recall repair

NHTSA ODI 11670357

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11668933

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11668712

What component or system failed or malfunctioned, and is it available for inspection upon request? The issue appears to be related to the powertrain system, specifically the belt tension or transmission shifting components. A “Powertrain Malfunction / Reduced Power” warning message appeared through the FordPass app, and I have also been experiencing jerking or hesitation when applying pressure to the gas pedal, particularly during gear shifts. The vehicle is available for inspection upon request. ⸻ How was your safety or the safety of others put at risk? The unexpected jerking and reduction in power while driving could pose a serious safety risk, especially when merging onto highways or changing lanes, where smooth acceleration is critical. This behavior could result in a loss of control or increase the likelihood of a rear-end collision in traffic. ⸻ Has the problem been reproduced or confirmed by a dealer or independent service center? An independent mechanic has reviewed the issue and suspects that it may be related to the previously reported belt tension recall, although my specific vehicle VIN was not included in that recall group. The mechanic observed the jerking and powertrain alert and recommended further inspection. ⸻ Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. I am currently in the process of filing this report and seeking guidance from the manufacturer to determine the next steps for inspection and resolution. ⸻ Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. The “Powertrain Malfunction / Reduced Power” message appeared via the FordPass app. Prior to the alert, I had noticed intermittent jerking and hesitation during acceleration, which became more noticeable within the last few weeks leading up to the warning

NHTSA ODI 11667514

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11666029

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11665331

Engine failed one me [XXX] it sat in my drive until it made its way to Sarasota Ford on July 9, 2024. I have no been able to drive this car at all for about 2 years now. (July 9th, 2024 - 5/2025) When driving the car it goes from 40mph to 9mph in the middle of traffic putting not only mi life in danger but others. I have compiled to the motor company about how dangerous this car is. My car has had about 3 engines and still has the same problem the recall was put out for. I was told that after so many times of them trying to fix the car and it’s still Not working they have to replace are car by putting us in the same year or newer year make and model but ford doesn’t want to do so they just want to keep replacing and installing engines that obviously has the recall problem. My car has recently got repossessed due prolonged non-use. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11663853

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving approximately 65 MPH, the message "Powertrain Failure" was displayed on the instrument cluster. The contact stated that the vehicle was losing motive power. The contact pulled over to the side of the road; however, while depressing the accelerator pedal, the vehicle failed to exceed 3 MPH. The contact had the vehicle towed to two dealers. The first dealer diagnosed the vehicle and informed the contact that cylinder #2 had failed, and advised the contact to take the vehicle to the dealer where the vehicle was purchased. The contact had taken the vehicle to the second dealer who was unable to diagnose the vehicle. The vehicle was not repaired. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

NHTSA ODI 11663442

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11662052

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving 40 MPH, the message "Low Engine Oil Pressure" was displayed, and the vehicle lost motive power. The contact immediately pulled over and had the vehicle towed to a local dealer to be diagnosed. The dealer linked the failure to NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The vehicle was not repaired. The approximate failure mileage was 62,000. VIN tool confirms parts not available.

NHTSA ODI 11662205

The contact owns a 2019 Ford EcoSport. The contact stated that while driving at undisclosed speeds, the vehicle was slow to respond. Additionally, the contact stated that the vehicle was hesitating while starting. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was taken to the local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The failure mileage was approximately 82,630. VIN tool confirms parts not available.

NHTSA ODI 11661194

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11660882

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11660598

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11660373