What 822 owners told NHTSA about the 2019 Chevrolet Silverado Ld 1500

GM says my Vin was not part of the recalls, The Vin wasn't the problem,It was the Transmission!!! letter I sent to GM : Transmission Failure on 2019 Chevrolet Silverado 1500 LT Dear General Motors Customer Assistance, I am writing to formally express my concern regarding the complete failure of the 8L90 transmission in my 2019 Chevrolet Silverado 1500 LT. I have been a loyal Chevrolet customer and have always trusted GM vehicles for their reliability and performance. However, the recent catastrophic failure of my transmission—resulting in both internal and external damage—has left me extremely disappointed and financially burdened. This vehicle, equipped with the 8-speed 8L90 transmission, began exhibiting harsh shifting, delayed acceleration, and shuddering well before the failure. Despite regular maintenance and proper care, the transmission ultimately failed and "blew up" both internally and externally, rendering the vehicle undrivable and in need of complete transmission replacement. Upon further research, I discovered that numerous owners of 2015–2019 GM vehicles with the 8L90 transmission have reported similar issues, and multiple class-action lawsuits have been filed citing systemic defects in this transmission design. Though no recall has been officially issued, the volume of complaints and the existence of internal Technical Service Bulletins (such as TSB 16-NA-019) suggest GM is aware of the ongoing problems associated with this transmission. Given these circumstances, I am requesting that General Motors stand behind its product and assist with the full cost of replacing the failed transmission. I am prepared to provide documentation including service records, a technician’s report on the failure, and photos of the damage if needed. Please let me know how GM intends to proceed with this request. I would appreciate a prompt and fair resolution to this matter. Sincerely, [XXX] VIN # [XXX] Current Mileage: 114850 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11678994

Transmission is shifting and shaking and vibration funny whines when driving and hard shifts makes clunking noises when shifting or down shifting. Engine ticks very loud and loses power

NHTSA ODI 11679087

GM refuses to cover catalytic converter recall 20V-005 despite matching VIN/build criteria. Failure occurred at 88k, but dealer refused service at the time. I'm now driving it at 108k. Private garage confirmed it's critically plugged.

NHTSA ODI 11679211

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the vehicle jerked and vibrated while shifting into gear. The check engine warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in an Extended Warranty coverage related to the failure. The failure mileage was 200.

NHTSA ODI 11678140

On 7/2/25, I was driving my 2019 Chevy Silverado on the highway and felt like there was a slight loss of power. I then noticed the Service parking brake, service ESC and the check engine light came on. I was going up a hill and had to move over to the far right lane and drive very slowly on the highway because of the engine problem. I was able to get off the highway without incident. I immediately took the truck to the Chevrolet dealer where I purchased it since it was very close. The dealership later inspected the truck and found the lifters had seized and caused damage to the camshaft. They said I would need a new engine at a cost of around $15,000. There were no warning signs or problems to indicate I was going to have an engine failure. The instrument warning lights came on when the engine problem occurred.

NHTSA ODI 11678379

The vehicle was being driven to work when the engine lost power and several warning lights started cycling. The vehicle started shaking badly. The truck had 62,735 miles and was regularly serviced. We took it to Christian Brothers Automotive in Lubbock, TX. where they were able to find that that lifters failed causing $7,000.00 in damage. The shop that made the repairs said it is a common and known issue.

NHTSA ODI 11678385

Key keeps getting stuck when I put it in park and turn off truck! It’s off and on park but it won’t release the key! This happens every day!

NHTSA ODI 11677404

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while idling, the vehicle made an abnormal ticking sound, and several unknown warning lights were illuminated. The contact was able to pull to the shoulder of the roadway. The vehicle was towed to an independent mechanic to be diagnosed, but no diagnostic trouble codes were retrieved, and the cause of the failure could not be determined. The mechanic advised the contact to tow the vehicle to a dealer. The vehicle was then towed to a dealer, where the vehicle was diagnosed with defective engine lifters and a defective camshaft. The contact related the failure to NHTSA Action Number: PE25001(Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall, and a case was filed. The manufacturer agreed to partially cover the cost of the repair. The vehicle was repaired. The manufacturer also referred the contact to the NHTSA Hotline to file a vehicle safety complaint. The failure mileage was approximately 63,000.

NHTSA ODI 11677163

I have a 2019 Chevrolet Silverado 1500 LT and I am having issues with the transmission bucking, hesitating, slipping. I am also having issues with the variable timing system. The variable timing system started acting up last year and when I took it to the dealer they replaced it and I was charged over $400 for it to be repaired. It happened again the beginning of this year and I took it back to the dealer. They told me the oil was dirty and suggested an oil change to fix the issue. I had the oil change done and now I am having the same problem again and have already had the oil changed. I need help since I am paying for a vehicle that is sitting in my driveway not being able to be used. There are 6 codes that have popped up including the variable timing system, cylinder 4 misfire, brake system, and I'm not exactly sure what the other ones are.

NHTSA ODI 11676707

Driving on highway leaving Virginia going around 70 all of a sudden truck starts making clicking and clacking sound all warning signals came on dash truck slows down to 20-25 miles pulled off highway checked fluid levels returned back to highway could only drive 45-50 an hour to Augusta Ga upon inspection at dealership was told either the lifters and camshaft were bad no prior problems

NHTSA ODI 11676513

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, there was an abnormal knocking sound coming from the vehicle with several unknown warning lights illuminated. The vehicle was taken to the dealer where the contact was informed that the failure was an internal engine failure; however, the vehicle was not officially diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 116,500.

NHTSA ODI 11675647

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. The contact was able to pull over to the side of the road. The contact inspected the vehicle and found an oil leak on the ground. The vehicle was towed to the dealer where it was diagnosed and determined that the engine oil cooler lines had ruptured and failed. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The manufacturer assisted with the cost of the repair. The failure mileage was approximately 95,000.

NHTSA ODI 11675474

What component or system failed or malfunctioned, and is it available for inspection upon request? The ECU/Power train failed/ Yes the vehicle is available for inspection. The vehicle's check engine light & traction light came on & the dash displayed multiple warning messages including reduced engine power & service ECS. How was your safety or the safety of others put at risk? I was traveling on the Interstate at 65 MPH in traffic in the far left passing lane. Engine power was reduced & I had to safely navigate the vehicle through traffic & multiple lanes to safely get the vehicle to the shoulder of the interstate & avoid causing any accidents. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the problem was confirmed by my local Chevrolet dealer. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It was inspected by my local Chevrolet dealer. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No there was not. The issue was attributed to a known manufacturing flaw on my vehicle. The wiring harness to the ECU was chaffed caused by rubbing on the frame, ECU bracket and/or A arm which in turn caused the issue. GM published a repair bulletin on this issue as well as the NHTSA.

NHTSA ODI 11674862

Truck goes into limp mode several times… fuses pop when it does..it does it when I drive or hit any slight bump

NHTSA ODI 11674410

The contact owned a 2019 Chevrolet Silverado 1500. The contact stated while driving at approximately 55 MPH, there was an abnormal rattling sound coming from the engine compartment. The contact stated that the vehicle was losing motive power. The contact stated no warning light was illuminated. The contact pulled over and turned off the vehicle; however, when the vehicle was restarted, the vehicle failed to exceed 10 MPH while driving to an independent mechanic. The mechanic diagnosed the vehicle and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 120,000.

NHTSA ODI 11673437

abrupt shifts when approaching a red light or stop and sometimes rough shifting.

NHTSA ODI 11673123

I am experiencing the exact details of N192272400 Rear Wheels Lock At Low Speed but for some reason my VIN isn’t associated with the recall! This is highly dangerous. It could cause a serious accident seen that I live on a main road. I don’t know where the vehicle locks up the rear brakes if I go over 5 miles an hour at random times. I believe 100% that it is exactly what is described in that recall which is a defective TCM that has a short circuit. Another issue that I have with his truck out of nowhere is a short circuit in my rear defroster that was sparking and smoking when I used it.

NHTSA ODI 11672653

Started truck Lights came on and warnings popped up on 5/13/2025 Service ESC Service Trailer Brake System Engine Power Reduced ABS Light Started truck lights came on and warnings popped up on 7/10/2025 Service ESC Service Trailer Brake System Engine Power Reduced ABS light

NHTSA ODI 11672704

TSB PIP5776. 87000 miles failed. dealer quote ($9,000) to repair lifter and bent camshaft. Gm said they aren't helping and my next step is get a attorney. Mention 10% “goodwill” offer and lifter collapse + bent cam

NHTSA ODI 11672609

The transmission does not shift smoothly. It actually will lurch forward after a stop at a sign or traffic light. It hesitates upon acceleration. I find it unerving and possibly dangerous. It was fixed by the dealer on October 22, 2024 and was good for 6 months but has started to do the same thing again.

NHTSA ODI 11671871

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated there was an abnormal ticking sound coming from the engine compartment. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed the vehicle and determined that the engine had failed due to defective camshaft phasers. The contact was informed that the engine needed to be rebuilt. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 108,000.

NHTSA ODI 11671883

I went to drive my truck and it would start but I got a “ service power steering no assist “, service rear vision camera, service trailer brake system. Then it wouldn’t start and got the “ lost communication with fuel pump control module, back up camera was flashing in and out and license plate lights would flash with turn signal on.

NHTSA ODI 11671476

During acceleration my vehicle had a whinning noise coming from near the transmission. It will buck and then when slowing down to a stop it bucks like being hit in the rear by another vehicle. It also shudders and makes the reduce engine power light come on.

NHTSA ODI 11671011

Bought my truck with 29,000 miles on it. Was making a noise in rear tire. Took it in and it was the break calilper. Dealership wanted $1500 to replace it a week after I bought it. Stated that it was not covered. After a week of arguing, they did not charge me for it. Around 40,000 miles, every once in a while, it would feel like I was being rear ended when I came to a stop. It was not often, but around 55,000 miles, was more frequent. I took it to the dealershp at 62,000 miles and they said that it was a torque converter and would not be covered. Fixed it at a shop $2700. Lifter and Cam in the UP of michigan $5000. Oil lines at 110,000 $700. Torque converter again at 130000, and now lifter and camshaft again at 145,000 miles. I feel that GM should back their product. I had a 95 Chevy Silverado that I sold with 360,000 miles and never had any issues except fot transmission at 250,000 which is expected. I have all receipts showing proof

NHTSA ODI 11670774

Driving on interstate when "Service ESC" and "Service ABS" warning came on in cluster, with flashing CEL light. Near total loss of power and loud noise from under hood. Exited the interstate immediately and turned off engine. Had towed to dealer for diagnosis. Dealer states failed lifter in right bank and possible camshaft replacement needed as well, to the tune of $4600-$10100 pre tax repair cost. 2019 Silverado RST with 84,000 miles purchased Certified Pre-Owned and CPO warranty expired April 2025.

NHTSA ODI 11670605