What 822 owners told NHTSA about the 2019 Chevrolet Silverado Ld 1500

Key keeps getting stuck when I put it in park and turn off truck! It’s off and on park but it won’t release the key! This happens every day!

NHTSA ODI 11677404

What component or system failed or malfunctioned, and is it available for inspection upon request? The ECU/Power train failed/ Yes the vehicle is available for inspection. The vehicle's check engine light & traction light came on & the dash displayed multiple warning messages including reduced engine power & service ECS. How was your safety or the safety of others put at risk? I was traveling on the Interstate at 65 MPH in traffic in the far left passing lane. Engine power was reduced & I had to safely navigate the vehicle through traffic & multiple lanes to safely get the vehicle to the shoulder of the interstate & avoid causing any accidents. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the problem was confirmed by my local Chevrolet dealer. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It was inspected by my local Chevrolet dealer. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No there was not. The issue was attributed to a known manufacturing flaw on my vehicle. The wiring harness to the ECU was chaffed caused by rubbing on the frame, ECU bracket and/or A arm which in turn caused the issue. GM published a repair bulletin on this issue as well as the NHTSA.

NHTSA ODI 11674862

Truck goes into limp mode several times… fuses pop when it does..it does it when I drive or hit any slight bump

NHTSA ODI 11674410

I went to drive my truck and it would start but I got a “ service power steering no assist “, service rear vision camera, service trailer brake system. Then it wouldn’t start and got the “ lost communication with fuel pump control module, back up camera was flashing in and out and license plate lights would flash with turn signal on.

NHTSA ODI 11671476

I have a 2019 Chevrolet Silverado 1500 LTZ. 5.3 Ecotrac 8 transmission with 89,000 miles. I bought it used and have had it 12 months, but only drove it 9 before it malfunctioned causing severe electrical & mechanical problems. I was driving the truck when the EPB, service engine, stabilitrac, ECBM warning lights came on, also driving over 43 miles an hour could cause a crash due brake failure This caused the emissions. transmission, & throttle to shut down Truck would not shift out of low gear. It would shift to park but did not recognize it was in park which kept the accessory on running down the battery, the tail gate would not open, and the information system shut down. I got sick and was in the hospital for 5 weeks, the truck was vandalized. The body repair shop took it to the chevrolet dealership in long beach to have it inspected. I did not tell them the vehicle had malfunctioned, throwing code U0101 and another code. I wanted the dealer to find the problem, the truck had not been driven since it was parked from the malfunction. All they came back with was I had a burnt cylinder and would be 9000 to fix due to maintenance, we maintained this truck changing the oil every 3000 miles with Castoroil synthetic oil, regularly checking and maintaining transmission, brake , all-fluids. Supposedly they ran a diagnostic, if they did they would have found these warnings and that main code U0101 would have showed up. When it happened Onstar ran the diagnostic and told me to take it immediately to a dealership. That dash should have lit up like a christmas tree that’s how many light were going off. The dealership never said a thing about these lights. Now i’ve read where Chevy had a problem with the EPB and only put them on this model from 2019 to 2022 because of this. I found on other sites recalls that included what happened to my truck, but not in your web sight. There was major design and manufacturing flaw with this model and year. I’ve read complaints on this.

NHTSA ODI 11670125

The vehicle began knocking on the freeway and experienced a loss of power. It caused warning lights for the Electronic Traction Control and parking break system to light up.

NHTSA ODI 11666741

Getting a Shift to park message on dash screen also getting radio to be unresponsive (like the screen is frozen) also puts a message of no information detected

NHTSA ODI 11664073

It’s been draining the battery every couple of days,sometimes the screen won’t turn off it just stays on but black it won’t even play the radio the tailgate won’t open most of the time the dashboard is been over heating it gets extremely hot I tough it was just Texas weather but on winter days was hotter than normal when I put it in park it won’t it keeps beeping and showing a message to put packing on sometimes you can hear a very thin noise coming from the dashboard ..transmission vibrates over 50-60 mph

NHTSA ODI 11664130

I bought a this car and the car started giving me issues, Engine wasn’t working properly, brakes were not working well, they gave me problem even I thought maybe the need to be changed, the suspension was off in a way that I feel uncomfortable driving the car and besides that, has electrical problems sometimes the radio and the panel went off out of nowhere and the car just have 40,000 miles.

NHTSA ODI 11659848

Vehicle has been at dealership multiple times for the same issues and the cant figure it out. Constantly p303 codes. On highway doing 65-70 and truck starts to shutter and drop speed swerving down to about 40mph on highway in traffic. Have to pull to shoulder and restart Vehicle.

NHTSA ODI 11653976

Tailgate keeps coming down on its own while driving and parked.

NHTSA ODI 11653251

In 2024, I had the transmission replaced due it leaking transmission fluid. The transmission is sealed and there is no way to add fluid. This created an internal problem for the transmission. In January 2025, the engine made a loud pop noise and began performing horribly. My wife and I were on the interstate in a major city and surrounded by traffic. I drove it to the side of the interstate, immediately, and turned it off. I had to call someone to tow me back home(2 hours away) and my wife missed a very important doctor's appointment. Upon inspection, I found failed valve lifters, camshaft, pushrod and valve lifter tray. I managed to get everything replaced and the truck ran fine. March 2025, as I was driving on the highway, the truck stopped running. A message came on the dash screen saying, "Shift to Neutral and restart". I did and nothing happened. I had it towed to a shop. They told me it was a fuse block that was blown and the starter blew so they replaced them. It had struggled to start a couple of times and since I knew it had a new battery, a starter and fuse block made sense. I picked the truck up and in less than 24 hours, it happened again. It stopped running as I was driving and would not restart. The shop has checked GM tech forums and found where someone said to check if the motor would turn over manually. They have tried and failed. They, then, took the oil filter off and found metal shavings in the oil. Their diagnosis is that the engine bearing has seized and is causing the problems. My main issue is safety. My wife and I could have been seriously injured or killed and could have injured or killed someone else when the incident happened on the interstate. The same could've happened with just me in the vehicle or with our children. There were no warning lamps, messages or any symptoms whatsoever before January 2025 for the engine. The truck doesn't even have 100,000 miles on it and I have kept up all of the maintenance.

NHTSA ODI 11649523

backup camera comes on when brakes are applied. Very dangerous at night time while driving as bright backup camera displayed on screen hinders your vision to see the road.

NHTSA ODI 11647318

Vehicle is showing the GM "SHIFT TO PARK" error code on the dash board, when turning the engine off.

NHTSA ODI 11644893

When the engine turns on the ESC light come up and start beeping. While driving the light goes off and later on while driving it appears that ESC is off after 1-2 minutes its says ESC is on again.

NHTSA ODI 11643615

I noticed up on start up a warning light comes on & display says brake system failure 62 MPH then goes away. I have been reading numerous other reviews online that they are experiencing the same issue. 2nd problem is when I bought the vehicle I noticed numerous oil spots on the tailgate, I asked a GM representative & they said it was road grime, but I noticed the rear pinon is leaking, so it's been leaking since I bought the truck & the dealership either doesn't know it's a known issue or they didn't want to come out & say it.

NHTSA ODI 11642824

My DIC showed a message of Shift to Park. This has prevented me from turning my truck off. I have been stranded on a couple of occasions until finally I was able to push the Stop/Start button to turn my truck off. Also has prevented me from locking my truck at times. The fact that I can't turn my truck is a real safety problem and also creates the possibility of it rolling down hill. Being stranded is the worst part and if I can't turn my truck off at some point the battery is going to go dead. There are several bulletins out on at least 5-6 GM cars with this problem - #19-NA-206 and 04-00-89-053 from engineering. I finally to feel safe I had to go to my local Chevy store and get it fixed costing me 563.24 plus tax. I need to be reimbursed for this as GM has been aware of this problem since 2018.

NHTSA ODI 11640610

I purchased this vehicle after my first 2019 chevrolet silverado trail boss's BCM dealined the vehicle after owning it 32 days. The vehicle with VIN [XXX] has had multiple engine failures causing the vehicle to be deadlined at the dealership for in excess of sixty days. The transmission is now failing as well. I am on my 2nd engine failure issue and the dealership refuses to acknowledge the problem. While under engine failure my vehicle would misfire causing the engine to stall and buck around like a wild horse. The electrical system on this vehicle is a complete catastrophe. The windows refuse to roll up once in the down position more often than not, the tailgate intermittently drops and closes on its own, the notifications on the dash always indicate the tailgate is down even when it is in the upright position, the lane change assist and parking detection intermittently work causing faulty detection when backing in/out of parking and changing lanes on the highway endangering the public, and all while these issues persist the "check engine" light never illuminates. Even when my truck had to be towed into the dealership the check engine light never came on. I have had this vehicle sine 43000 miles and now have 115000 miles and every oil change i have done(I am a shop owner and technician) has had metal shavings in the drained oil that has got past the filter due to the IMPROPER engine repair done by BEAVER CHEVROLET when my engine failed the last time. It is best practice to drain all the oil, remove engine from vehicle and replace the oil pump and pickup after cleaning the engine internally while disassembled to ensure no metal contaminants are inside the engine. Chevrolet simply replaces the broken components and doesn't do the proper procedure when an internal component fails, call any machine shop in any city across america and ask what the procedure is when a camshaft or bearing fails in a motor is. It is 100% not what chevrolet did for me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11639505

I own a 2019 Chevrolet Silverado 1500 LT Trail Boss that exhibits strange and persistent issues. A recurring engine code appears P0499, clears itself, and then reappears without consistent resolution. This affects the remote starter as the engine light will be engaged. Additionally, several service warnings flash momentarily and disappear, including: •Service Trailer Brake System •Brake System Failure – Top Speed Limited to 62 or 43 MPH •Parking Sensor Unavailable These warnings occur without warning and vanish too quickly to document fully. Despite multiple visits to the dealership, technicians have been unable to replicate or resolve the problem. This unpredictable behavior creates safety concerns, particularly regarding brake system reliability and sensor functionality. I and many others experiencing these same issues are concerned about a potential electrical or sensor issue impacting vehicle performance and safety.

NHTSA ODI 11635899

Wires were improperly installed during assembly, on truck and rubs on a frame which chafes, which causes the protective covering to get rubbed off causing a short circuit on my wiring harness which causes the "check engine light" to stay on constantly. This is a factory mistake yet they want to charge me for the fix. I also have come to know this is getting too common on Chevy Silverado 1500 and GMC Sierras. GM needs to correct their factory defect for free. This chafing can happen in three different areas on the trucks. These shorted wires can cause failure of the fuel pumps and leave you on the road when the engine shuts down. GM knows about these problems but has not acted on this problem. they never mentioned or noted the wiring problem on my repair summary, Oct. 23, 24, when they were replacing the torque converter. They showed it to me, but never made note of it. They are going to work on it Monday 12/9/24, I will talk of, who's going to cover the cost of this after it's repaired.

NHTSA ODI 11629529

Twice the vehicle has malfunction at high rates of speed no brakes no steering and almost caused serious injury to myself and young son the second occurrence I record the last 15 seconds safely to have proof of exactly the speed of disengaged control. For this very reason. Vehicle has been at dealership since 10/28 I’ve had to rent a car 1700.00 and more than 30+ days no diagnostic or response to purchase this defective vehicle with number of same occurrence of brake electric emissions and transmission malfunction.

NHTSA ODI 11629294

Transmission problems in 8l90. Needs valve body. Torque convert and few others. Lost communication with power steering control module. Most control to body co trol module. Rear right and left speed sensor correlation.

NHTSA ODI 11622147

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while at a complete stop, the Auto START/STOP function engaged, and the engine shut off as needed. The contact stated that while depressing the accelerator pedal to resume driving, the vehicle started rolling backward. The contact shifted to park(P), turned off and restarted the vehicle. The contact stated upon shifting to drive(D), the failure persisted. The check engine warning light was illuminated. The vehicle was towed to the residence. The contact stated while starting the vehicle the following day, the steering wheel seized. The check engine warning light, the traction control warning light, the parking warning light, and other unknown warning lights were illuminated. The messages "Battery Saver Mode", "Service Charging System" and other unknown messages were displayed. The dealer was notified of the failure and advised the contact to tow the vehicle to their location for diagnostic testing. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 84,000.

NHTSA ODI 11615906

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while her husband was making a right turn from a complete stop at approximately 10 MPH, the vehicle lost power steering functionality. The message "Trailer Brake" and another message indicating a power steering failure were displayed. The contact stated that her husband pulled to the side of the road, turned off and restarted the vehicle; however, the failure persisted. The contact's husband was able to drive to the residence by using physical strength to maneuver the steering wheel. The dealer was notified of the failure and informed the contact that the failure could be related to a corroded ground strap. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 55,000.

NHTSA ODI 11597892

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that the tailgate emergency release button located inside the cabin was inoperable. Additionally, the contact stated that while pressing the button on the tailgate to open or close the tailgate, the tailgate would slightly open or be closed. The contact stated that the tailgate required to be pushed manually to open as needed or to be closed securely. The vehicle was taken to the dealer, where the tailgate motor was replaced; however, the failure recurred. The vehicle was taken back to the dealer where the contact was informed that the tailgate motor needed to be lubricated. The motor was lubricated; however, the failure persisted. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 10,000.

NHTSA ODI 11598004