What 689 owners told NHTSA about the 2018 Chevrolet Malibu Eco

I put the car in park and got a message shift to park. I then wasn’t able to shut my car off. The car is only 6 years old! This should not be happening!!!

NHTSA ODI 11568116

On Jan 22,2024 while driving on the interstate the speed was unexpectedly instantly reduced, the car would not accelerate over 60 mph and the service engine light came on, the car was safely driven off the highway then towed to the dealership. My safety as well as the safety of other drivers on the highway was at risk when the car suddenly decreased to 60 mph from 75 mph which could have caused a collision. The inspection at the dealership confirmed that the issue was the intercooler for turbo found moisture/oil frozen in charge air cooler causing restriction in induction system, and the part design has been updated to help prevent the issue from happening again. My issue is that if the part has been updated that means that GM is aware of the issue and should be responsible for the cost of the part or there should have been a recall on the part. The consumer should not have to be responsible for the cost of the part or the repair to the vehicle. It is unknown if the part was inspected by an insurance representative but it was inspected by the dealership where the car was purchased. There were no prior warnings, lights or lamps occurring before the date of the incident. I feel like Gm should cover the cost of the repair, the total cost should no fall on the consumer and the vehicle manufacturer should take responsibility for the defective part.

NHTSA ODI 11567903

Check Engine Light constantly comes on . Pedal position sensor is faulty. engine power reduced pops up

NHTSA ODI 11565871

The car's Reduced Engine Power light comes on and the engine drops power. It just happens at any time while driving. I've had oil changes done, engine cleanings done but nothing changes.

NHTSA ODI 11565589

The Vehicle wobbled when at 70 MPH. I have new tires but the wobble won't stop. I have visited a mechanical specialist was refer to this site. Also, the Radio Display touch screen is not working.

NHTSA ODI 11564919

While driving on highway, check engine light came on as well as message saying "Engine power reduced". Car immediately decelerated on the highway and brakes pedal became rock hard and unable to press.

NHTSA ODI 11564692

I was driving my car and my entire car’s dashboard went out and the cars speed dropped I tried braking but they kept slipping. It was a very scary event for me as I was driving on highway 59 when this happened to me. The TCM is s a problem for this vehicle please recall this issue.

NHTSA ODI 11562988

The contact owns a 2018 Chevrolet Malibu. The contact stated while driving approximately 65 MHP, the message "Engine Power Reduced" was displayed and the vehicle decelerated to 30 MPH. The contact stated that the speed would no longer exceed 30 MPH. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The contact stated that the failure had also previously occurred but after taking the vehicle to the local dealer no cause of the failure was found. The failure mileage was 110,653.

NHTSA ODI 11561528

Vehicle will not stay started will stop when ever even while driving. I haven’t driven the car in 8 months because it’s not safe.

NHTSA ODI 11561300

The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed and exiting a ramp to get on to a major highway, the vehicle failed to accelerate as needed. The contact stated she depressed the accelerator pedal, and the vehicle failed to respond. The contact stated that the engine power reduced warning light was illuminated, and the vehicle decelerated and was almost rear-ended by an oncoming vehicle. The contact stated that the failure had been consistent for several weeks. The vehicle was previously taken to an independent mechanic and the contact was informed that the failure could be caused due to a failed unknown sensor. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 167,000.

NHTSA ODI 11559451

I have an ongoing issue with the shifter not communicating to the ECU that it is in park. I put the car into park, dash board shows in P (park) and transmission is in park (ie won't move forward with brake released) and when I go to turn the car off I get message that car is not in Park. To remedy this I have to smack the back of the shifter forward sometimes 5-15 times and from light to moderately hard pressure to get the ECU/sensor to realize it's in Park. The shifter was replaced by a Chevy dealer 2-3 years ago but the problem started again. I believe there needs to be a recall due to the same issue ongoing [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11558519

Transmission Surge Accumulator System Performance. The car fails to accelerate once it comes to a complete stop, traffic lights, etc. The car will rev up to 5000 RPMs but will not reach 10 mph. This causes problems when driving and I was almost hit on several occasions (more than 8 times) on my drive home to be safe again. The car was taken to the dealership and was reported to have been fixed, after paying a $100 deductible, but only ran properly for one day. Again, I was almost hit 5 times while driving back home, after the repair was made. The check engine light came on after the car presented issues, as I was out running errands, the car was losing power and was not performing well. About 20 minutes after the initial issue, the check engine light came on. I took the car to Auto Zone where they were able to run the diagnostic that came back with the code, P171D Transmission Surge Accumulator System Performance. This took place twice in one week, with the dealership fixing the issue on Tuesday and it failing again on Saturday (after the car sat idle for 3 days, while I was on vacation).

NHTSA ODI 11556792

The contact owns a 2018 Chevrolet Malibu. The contact stated that a "shift to park turn the vehicle off" message was displayed while the vehicle was in the park position. While driving at unknown speeds, the vehicle stalled. The steering wheel was tight. After slowing down, the driver depressed the start/stop button, and the vehicle shut off and restarted. The vehicle was randomly shut down. After waiting, the vehicle restarted. While depressing the brake pedal, there was an abnormal, unidentifiable noise detected, and the vehicle came to a sudden halt. While driving at 55 mph, the vehicle suddenly stopped, and she hit her head on the steering wheel but medical attention was not provided. The vehicle was pulsating while driving. There was a sound of water going through the vehicle. The vehicle was slow to accelerate and then moved violently. All the instrument warning lights were illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not diagnosed or reported. The vehicle was taken to another dealer, Capital Chevrolet, at 9820 Capital Blvd., Wake Forest, NC 27587, where it was diagnosed that the vehicle was not safe to be on the road. The oil throttle body and vacuum pump needed to be replaced. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 20V668000 ( Power Train), and NHTSA Campaign Number: 19V642000 (Electrical System Fuel System, Gasoline, Engine). The manufacturer was not contacted. The failure mileage was approximately 50,000.

NHTSA ODI 11555469

The contact owns a 2018 Chevrolet Malibu. The contact stated while driving approximately 60 MPH, the braking system failed, and the brake pedal became firm while depressed. The "Engine Power Reduced" message was displayed, and the vehicle went into LIMP Mode, causing the vehicle to decelerate. The vehicle was later towed to the local dealer who diagnosed the vehicle and determined that the braking system vacuum booster pump had failed and needed to be replaced, along with the camshaft and crank case which were damaged during the failure. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 107,000

NHTSA ODI 11555493

Vacuum Booster Pump failed while driving on the highway with my girlfriend and her small child in the car and this common problem for this specific Chevrolet motor and endangered our lives significantly. Over 500 complaints on NHTSA website. No recalls to date. $4,000 damage. Filed official complaint and requested that Chevrolet cover the costs.

NHTSA ODI 11555491

My car will stall in the middle of driving will say it is not in drive, the power steering is reduced, and I cannot use the brakes properly. This is a safety issue. As I drive on interstates and highways on my commutes.

NHTSA ODI 11554537

Mass air flow sensor has been replaced 3 times. Keeps going bad causing hiccups and hesitation. Very dangerous at times

NHTSA ODI 11553338

Service Stabilitrak warning will pop up on my dash. The car loses power. Push on the gas and it sputters. Had it serviced by GMC 2 years ago and now it is happening again. More frequent in colder weather. There are thousands of reddit posts about this same issue from other 2018 Chevy Malibu owners. GMC refuses to acknowledge it is a quality or performance issue on their end.

NHTSA ODI 11552855

While driving, my car’s dash suddenly showed a warning message that state “engine power reduced”. I was driving around 45mph at the time of the incident.

NHTSA ODI 11552366

I was driving the vehicle on a busy road and a message came up on the display above the steering column saying Engine Power Reduced. I went to brake and was unable to push the pedal in as it was extremely stiff. There were vehicles around me and I tried to use both feet and stand on the brakes and was able to get a little bit of movement but the car still didn't slow down. I had my significant other and brother-in-law in the car and we were all horrified we were going to get into an accident. I turned the hazard lights on and was able to steer to avoid hitting several vehicles and when traffic finally cleared I was able to get over and off the road into a gas station that was uphill and allowed us to slow down and finally stop because I put the vehicle in neutral tried the parking brake which got us to a complete stop and shut the vehicle off. There had been no previous issues with the brakes or messages such as the one that came up right before this issue occurred. The vehicle had to be towed and the repair shop told me the cam driven vacuum pump failed which caused the brake booster to not function. When this failure occurred, it damaged the intake and exhaust camshafts, crankshaft, and several other components. The cooling system and oil to be flushed out as I was told there was metal debris from the damaged parts caused by the vacuum pump failure in the fluids which had been all completely flushed and changed including cooling system, transmission fluid, and oil change The total cost of repairs as a result of the vacuum pump failure setting off a Domino effect of damage was $3536.40.

NHTSA ODI 11552160

Engine power reduced

NHTSA ODI 11551622

My turbo failed while I was on a very busy highway, causing me from going 70mph to 35mph in a matter of seconds and almost being hit. This put my life and my friends life at risk since we were in the left lane. Now that I’ve been fighting with the dealership ti help make this right they found a GM warranty that fixed and updated electrical sensors. We fixed that first because at the time we thought that was what it was. My turbo gave out again up in the mountains almost killing me and my friend a second time on a busy road. We made it to a parking lot and called a tow truck. Now the stabiltrak is showing up and the car refuses to start, it makes a whooshing sound and doesn’t start completely. (There is fuel, oil, etc). I was sold an unsafe vehicle and now I’m stuck paying 500$ a month for a car that’s unsafe and refuses to work even when it’s been fixed. The dealership is refusing to help me, I’m at a loss. I still owe 18k and I can’t have an in working car sitting in my apartment complex, it will get towed and cost me more money.. I need help. I was sold a car that almost killed me twice and no one seems to care.

NHTSA ODI 11551208

Just now car drove rought made it home to shutting down shift to park message came on I was not on the first recall list

NHTSA ODI 11550822

Just now coming home my car made noises when I parked it said shift to park Friday GM said I'm to repair the problem with my studies it's gm hidden defects I was not on the first recall I seen on goggle NHTSA please help me with this car problems and please help 513 complaints as well on the 2018 Chevy Malibu breakdowns

NHTSA ODI 11550719

Wanted to shut off just now at the stop intersection and when I got home shift to park message came on

NHTSA ODI 11550169