What 689 owners told NHTSA about the 2018 Chevrolet Malibu Eco

The contact owns a 2018 Chevrolet Malibu. The contact stated that while his daughter was driving and stopped at a traffic light, while depressing the accelerator pedal, the vehicle failed to respond, and the vehicle lost automotive power. The contact stated that five minutes after restarting the vehicle, the vehicle operated as intended. A dealer was contacted. The vehicle was taken to dealer, where it was diagnosed that the engine control module needed to be replaced. The contact stated that the failure had occurred on several occasions. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 19V642000 (ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE, ENGINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 75,000.

NHTSA ODI 11733336

The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, a fuel odor was detected, and the vehicle failed to accelerate above 30 MPH. The check engine warning light was illuminated. Additionally, the rearview camera intermittently failed to display while reversing, and the vehicle made an abnormal clicking sound. Upon inspection, the contact discovered a fuel leak beneath the engine. The vehicle was towed to the residence, where an independent mechanic determined that the fuel line needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 130,000.

NHTSA ODI 11732427

The contact owns a 2018 Chevrolet Malibu. The contact stated that there was an oil leak coming from the engine. While driving at an undisclosed speed, the message "Engine Power Reduced" and "Service Stabili-trak" were displayed. Occasionally, the automatic emergency braking activated unexpectedly, and while the vehicle was stopped, the vehicle shuddered abnormally. The vehicle also decelerated and stalled occasionally. Additionally, the volume on the radio was stuck, the steering wheel command controls failed to operate as needed, and the air compressor was recently replaced. The contact associated the failures with NHTSA Campaign Number: 20V668000 (POWER TRAIN), 19V642000(ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE, ENGINE), 18V400000(AIR BAGS), and 18V358000(FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recalls. The vehicle was taken to the dealer where it was diagnosed with air compressor failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 150,842.

NHTSA ODI 11730437

In 2020, I received multiple red recall notices in the mail regarding a safety issue. I scheduled an appointment with a Chevrolet dealership in Los Angeles and have a voicemail confirming the appointment. At the time, I did not follow through with ensuring the repair was fully completed, which I take responsibility for. However, the vehicle has continued to experience the same dangerous symptoms. My vehicle continues to display sudden “Engine Power Reduced” warnings while driving at freeway speeds. The car abruptly slows down and limits acceleration, forcing me to pull over and turn the vehicle off and back on to reset it. During these events, the steering wheel becomes extremely difficult to turn, creating a dangerous situation, particularly at high speeds. The vehicle also appears to have ongoing issues with the push-button start/stop system. Although I did not pursue the issue further at the time, I am now seeking to have it properly addressed because the safety risk remains and another family member is currently driving the vehicle. When I recently attempted to verify the recall status, both the Chevrolet website and other sources show no open recalls. However, the symptoms persist exactly as before, I cannot find the little red notices that were sent but I do have a voicemail from someone at Chevy confirming the appointment that I made because of the recall notices. This issue presents a serious safety hazard due to sudden loss of engine power and steering assist on highways. I respectfully request investigation into whether the recall was improperly marked as completed. Furthermore, can you provide me with the full recall and service history on my VIN including closed recalls and warranty repairs? I know recalls do not expire so I’m confused as to why no one wants to help me now. I appreciate your time.

NHTSA ODI 11721889

The vehicle shut off in the middle of the street. I had to get it jumped to start again. There was a fuel leak. Car is still smelling like fuel after getting it repaired. The vehicle doesn't alert if your close to a car or anything

NHTSA ODI 11711621

After diagnostic troubleshooting from DTCs on a check engine light, it was discovered that the brake vacuum pump connected to the engine was completely nonfunctional. Previous symptoms included stiff brake, loss of brake power at random brake periods which could have cause and accident with other drivers, and finally malfunctioning sensors attributed to the exhaust system. This also led the vehicle to be unable to pass state regulated Emissions testing because of the inability to maintain proper emissions levels. Brake Vacuum pump that was removed from vehicle to inspect and diagnose is still available for inspection. Recent findings show that Chevrolet/GM is aware of the issue in their vehicles but refuses to address or replace faulty brake vacuum pumps. It is a common problem amongst 2013-2022 Chevrolet Malibus. Vehicle that is in question was inspected by a certified mechanic shop with failed emissions test. Solid check engine light appeared once the brake had become harder to push and stop the car. OBD scans show DTC codes that were pertaining to MAF and MAP malfunctions in readouts and communications to the ECM. After further inspection, the ABS module had been acting as "backup" for hydrolic brakes system that had zero vacuum to power the brake booster, this could have caused the engine to stall, longer than normal stopping distances (stronger risk of rear ending other drivers), and multiple components and sensors to fail, requiring them to also be replaced.

NHTSA ODI 11701025

The contact owns a 2018 Chevrolet Malibu. The contact stated that there was a strong fuel odor coming from the vehicle. The contact stated that the engine was difficult to turn over. The TPMS warning light was illuminated. The vehicle was taken to an independent mechanic who determined that the fuel injectors were leaking. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 123,074.

NHTSA ODI 11699741

Every so often I get an indication of engine power reduced, but every time I go in to get it checked it's off. I have recently just learned through research online that the issue is caused by a certain condition that gives false reading to the electronics. I have contacted GM and GM financial about the recalls on my cars of the same year. I have not been in a wreck but I have had the issue of engine reduced power in the middle of traffic. Cox Chevrolet in Bradenton has turn me away about the issue GM financial is giving me the runaround neither one mention anything about a recall instead I get a estimate $400 /$808.50/1900.41 all to fix ECM as I told the mechanic I was driving with no problem through the day me and the kids at the park when it was time to leave the car sounded like it just didn't have no gas. We was stuck tell 10:45 we waited two hours for the tow truck. I have OnStar and get monthly reports on my car. When the check engine light comes on OnStar has no indication that's why I believe it is the same ECM. I was told by Chevrolet Maher service manager of St Pete to get my car off their lot as I said before I got a estimate of 400 that went up to 800 and all I did was ask why

NHTSA ODI 11692209

Purchased a car for financing from Barret Motors and 2300 Lakeview PKWY, Rowlett, TX and as soon as I drove it off the lot on [XXX] the engine light popped on. I immediately called and was told to just take it to Chevy/GMC for servicing but was not told why, but just because the engine light was on I was told to go. I couldn’t take an appointment asap because I just started a new job which they also knew. The car has had a recall since 09-06-19 for an engine control module. Which is a serious issue and this car never had it completed and sold me a car with possible engine issue and did not inform there’s a recall on the vehicle for almost 5 years now. I took the car to get serviced at Chevy for the recall on 09/09/2025 and now I am facing multiple issues with the car from it not being done years ago. The recall was N192221960 and it’s major so to sell a car before getting the properly service and I have been financing the vehicle for a year now. Never not once late and I am now being told there’s nothing can be done. I have photos of the car having the engine light pop on the same day u financed this vehicle. Barret knew a serious engine problem was effecting this car for 5 years and still deciding to sell it to me for financing on [XXX]. I need immediate assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11691347

The contact owns a 2018 Chevrolet Malibu. The contact stated that the vehicle failed to start. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed with a failure of the battery and fuel pump. The contact was informed that the ground wire and fuel tank needed to be replaced. The dealer informed the contact about a recall on the malfunctioning ECM. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 50,206.

NHTSA ODI 11676993

The contact owns a 2018 Chevrolet Malibu. The contact stated while driving 35 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. Additionally, there was an abnormal fuel odor coming from the engine and entered the vehicle through the A/C vents. No warning lights were illuminated. The contact pulled over to the side of the road. The contact exited the vehicle and upon inspecting the exterior of the vehicle, the contact noticed gasoline leaking on the ground. The contact drove the vehicle to the residence. An independent mechanic stopped by the residence and inspected the vehicle. The contact was advised that the fuel injectors and another unknown part had failed. The vehicle was not repaired. Upon investigation, the contact related the failure to NHTSA Campaign Number: 18V358000 (FUEL SYSTEM, GASOLINE). The manufacturer was not notified of the failure. The contact parked the vehicle and the vehicle was no longer driven due to the safety concern. The failure mileage was approximately 100,000.

NHTSA ODI 11675625

I have searched the prior recalls and I’m having the same problem that were said to be fixed. I would like the car check again for the recalls that said to be fixed and checked for all reacalls . The car turns of unexpected without warning . At random times the low power mode is always on and when I push down in the pedal it doesn’t respond well at all . I have invested countless money into fixing issues with this car .

NHTSA ODI 11666973

On [XXX] while driving at highway speed on [XXX] in Columbia SC vehicle lost power and shut down. Was able to move to emergency lane. Car would not start. Called AAA for tow back to Chevrolet dealer in York SC. Dealer performed diagnostic test and found fuel pump driver control module had failed. Part was replaced and car returned to service. Car mileage at time of failure 70,949 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11654757

I was going about 75 mph on the express way with one lane open due to construction. My car started losing power.I heard the chime and upon the dashboard were the words power reduced. My car slowed down in a matter of seconds to around 45 mph. A 18 wheeler was trailing behind me. I quickly jumped in the emergency lane to my right and took the next exit while riding the emergency lane. I shut the car off at the gas station, sat there for about 10 minutes, restarting my car helped temporarily. I was 3 hours away from home and had to drive back unknowingly if I will make it or not. I reached out to Chevrolet and was told to bring it in and leave it but they had no loaner cars for anyone at that time. I have replaced 2 sensors and now my start /stop has quit working. I spoke with 5 visitors at Chevrolet and we all were having the same issues. This is something ongoing according to my research on this particular vehicle and should be recalled asap.

NHTSA ODI 11651650

The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The “Engine Power Reduced” message was displayed. The contact stated that the vehicle lost motive power. While driving 70 MPH, the vehicle decelerated to 45 MPH unintendedly. The vehicle was previously repaired under NHTSA Campaign Number: 19V642000 (ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE, ENGINE). The local dealer was contacted and provided the contact with an estimate for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 186,000.

NHTSA ODI 11643630

The contact owns a 2018 Chevrolet Malibu. The contact stated that while on a trip and traveling at high altitudes, the check engine warning light was displayed on the instrument panel. The contact used a code reader which showed that the barometric pressure sensor was defective. Once the contact returned home, the mass air flow sensor was replaced. The following year while traveling in the same region at high altitude levels, the failure recurred. The contact also stated that the engine booster had started to fail due to ice accumulation in the charge air cooler (CAC), which restricted airflow. As a result of the failure, the vehicle failed to accelerate above 25 MPH. Upon investigation, the contact discovered Technical Service Bulletin No: 18-NA-069; which the contact linked to the failure. The dealer was notified of the failure, but the contact was informed that the vehicle was out of warranty. The manufacturer was also notified of the failure and referred the contact back to the dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 76,000.

NHTSA ODI 11643747

Car has "check engine light" mechanic says vapor canister vent solenoid is bad. Part number: 2282618. Also said they have been seeing this a lot on Chevy Malibus and other GM cars. Part was not available from Chevorlet for oven two months.

NHTSA ODI 11641199

Started car after acceleration, car started shaking , check engine light came on , acceleration decreased and message saying service Stabilitrak. 6 hours later started car and message no longer, check engine light off and car not shaking anymore. Chevy dealership diagnosed misfire, fuel injector needs replaced and damaged ECM.

NHTSA ODI 11635171

When parking it says shift to park even when I’m already in park. The dealer says it’s the shifter however after seeing numerous other vehicles with this issue I believe it’s electrical

NHTSA ODI 11617132

The contact owns a 2018 Chevrolet Malibu. The contact stated while driving approximately 60 MPH, the vehicle stalled. The contact stated there was no warning light illuminated. The contact stated that the vehicle was left on the side of the roadway. The contact called the dealer where the vehicle was purchased and was advised that he had to pay to have the vehicle towed. The vehicle was not taken to the dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact was aware of an open recall on the vehicle, NHTSA Campaign Number: 19V642000 (Electrical System, Fuel System, Gasoline, Engine). The failure mileage was unknown.

NHTSA ODI 11606412

car pauses after stopping at lights and stop signs and in stop-n-go traffic and won't go as soon as gas pedal is pressed. It hesitates then jerks forward once the gas is activated. Check engine warning is for stop/start transmission accumulator sensor! Cost to repair over $1300 and seems to be the same issue seen in thousands of 2018 malibu's that have been recalled??? My car does not show an active recall??? Chevy rep Andrea at 1-800-222-1020 said sorry no recall for your car and to contact you with complaint? This issue almost caused my wife to have accidents after the car lurched forward after stopping. We were also beeped at many times as cars behind us were frustrated we could not move for 10-20 seconds after stopping! [XXX] [XXX] [XXX] Car is being repaired now by Belise Chevrolet Warwick RI 877-553-0957. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11598692

Car hesitant to crank, once the Start/ stop button is pushed, the car will start, run smooth for a second or two then start to shake and putter like it’s not getting fuel and loses it power and cuts off. I have to go through this process 5/6 times before the car will stay crunk. While driving Car will out the blue say reduced engine power and acts as if it does not want to pull or it is losing power! The car also has the eco saving feature where it cuts off at every stop and there is not an option be turned off and car is hesitant to start back up after it cuts off. Car is now starting to smoke from the tailpipe. The VVT intake and exhaust solienoids have oil getting into them and the PCV valve is about to crack open. The car throws codes like rich fuel intake, something to do with the catalytic system (in which I’ve put a brand new catalytic converter on the car and it did not solve the issue) it also throws codes about a throttle and cam sensors and a few more codes.. I see where there are recalls for the (same make, model,year, and engine size) but my cars VIN is not included with the recall! Can we please get this as I need my car and need this issue fixed as soon as possible as it is dangerous for me and my 2 year to travel in this vehicle.

NHTSA ODI 11597353

The contact owns a 2018 Chevrolet Malibu. The contact stated while driving at approximately 70 MPH, the vehicle started losing motive power with an unknown engine warning light illuminated. The contact stated that the engine power was reduced. The contact depressed the accelerator pedal; however, the vehicle failed to respond. The contact stated that the vehicle decelerated to approximately 15 MPH and the vehicle stalled. The contact stated that the vehicle lost power steering and braking functionality. The contact was able to stop the vehicle. The contact attempted several times to restart the vehicle however, the vehicle was unable to be restarted. The contact stated there was an abnormally strong odor of gasoline in the cabin of the vehicle. The contact opened the hood, and the odor of gasoline was very strong. The contact looked underneath the vehicle and saw gasoline in a puddle underneath the vehicle. The contact stated that the vehicle was towed to the residence. The vehicle had not been taken to an independent mechanic or dealer. The vehicle was not diagnosed and was not repaired. The contact had not informed the manufacturer of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 19V642000 (Electrical System, Fuel System, Gasoline, Engine). The failure mileage was approximately 50,000.

NHTSA ODI 11574627

My car does not register when it is park. I cannot disable the car when this happens. I have been that my car is not in the recall that has already been issued for this issue.

NHTSA ODI 11546414

Underlying fuel pump went out

NHTSA ODI 11540052