What 304 owners told NHTSA about the 2017 Jeep Wrangler 4-door 4xe

The airbag light is on. The clocksprin is the failure and is very expensive at the dealer.

NHTSA ODI 11545536

2017 Jeep Wrangler Unlimited with 44,000 rear brake calipers sticking and burning smell. Had brake pads and calipers replaced on all 4 wheels. At approx 60K miles, rear brakes were sticking and smoking. Right brakes wearing unevenly compared to the left side, both front and rear. Caliper seals are leaking. Replaced 4 brake hoses, Calipers and Pads AGAIN. At 70K miles rear brakes locked up and caused a fire on the rear passenger wheel which created unsafe driving conditions with 2 small children on board. I had to stop on the side of a 2 lane road with small shoulder, quickly evacuate the children onto the shoulder of the road and extinguish the fire using an on-board suppression device. We then had to wait for towing assistance on the side of the road for 90 minutes. Brakes, Hoses, Calipers replaced all around. Again.

NHTSA ODI 11543370

The airbag clockspring is defective. I know other years have a recall on the defective part. The cost of labor and the cost of the part is too expensive. I consider this a safety issue and feel like it should be under a recall like the previous model years.

NHTSA ODI 11542345

Airbag light continually goes off and on with alerting beep and light

NHTSA ODI 11541169

2017 Jeep Wrangler, approx 46k miles, driven gently (only highway and city), well-maintained. Problems with Brake Calipers seizing. Back Driver calipers/lines/pad/etc replaced. ABS and brakes jammed last week. Front and Back Passenger calipers, rotors, brake fluid lines and brake pads advised by mechanic. Brakes temping 550 - unreadable (temp gun wouldn't register) Mechanic recommends unsafe to drive because brakes could seize and cause sudden stop and/or accident Dealer says too bad, normal wear and tear. This is our family's 10th Jeep, and NOTHING has happened like this before. Seems like a safety issue perhaps that Jeep should be addressing rather than putting on the consumer (who will no longer purchase Jeeps)

NHTSA ODI 11539082

A check engine light came on and when diagnosed it was the Electronic Vacumn Pump which runs the braking system. I see there is a TSB from FCA (Fiat Chrysler Automobiles) about this problem.. Case Number: S1805000006 Release Date: 02/24/2020 Symptom/Vehicle Issue: ESC Light Illuminated. DTC C1252-92 VACUUM PUMP CONTROL CIRCUIT And Or P258B ELECTRONIC VACUUM PUMP PERFORMANCE Discussion: If ABS has C1252-92 Active or Stored do not replace the brake system module (ABS). PCM may also have set P258B-00. The faults are pointing to vacuum pump system having an issue maintaining vacuum levels. Please check the vacuum pump operation, fusing, wiring, and connector for proper functionality. Poor connections, spread pins, damaged connectors are possible causes. Perform the diagnostic for the DTC P258B regardless if it is set or not, since it is more compressive of a test than C1252-92. In addition when checking Vacuum lines, please ensure to check Vacuum hoses and check valves between the engine intake, booster and vacuum pump. Because the check valves only allow flow of air on one direction, each vacuum circuit must be checked separately to make sure there are no leaks, kinks or damages. Please refer to the correct vacuum diagram. For KL vehicles: inspect ALL under hood grounds for connection and contact issues. My Jeep is at the Ford Dealership I work at at this time. Didn't want to drive any farther than I had to at this time.

NHTSA ODI 11539006

Front driver side brake caliper was sticking on right after I bought the car at approximately 86000 miles! I found an article about there being updated hoses right after my car was manufactured. The updated hoses are on the front brakes. Of course I read this article after assuming it was the caliper cause I couldn't squeeze the caliper piston in. I replaced it, with the same results! After I replaced the hose, its fine now. So I cut the hose in sections to found out where the hose was pinched, and its where the hose is crimped in a metal bracket that bolts to the axle. I have a picture of the part of the hose, I cannot see through tiny 3" section or stick a pin through it! I'm assuming the bracket rusted and pinched that section off.

NHTSA ODI 11538460

Jeep caught on fire on the interstate. 17 year old boy had to pull over and escape vehicle. Vehicle left the side of the road even after being in park and brake. Vehicle continued unmanned on interstate into oncoming traffic engulfed in flames. It has not been confirmed by a dealer. Vehicle was inspected by State Farm. NO warnings given prior to incident.

NHTSA ODI 11536634

Fuel overfill due to improper design of the filling tube. Caused fuel to spill onto vehicle, bumper and ground. Fire hazard high.

NHTSA ODI 11536486

The contact's brother owned a 2017 Jeep Wrangler. The contact stated that while her brother was driving at an undisclosed speed, another vehicle crashed into his driver's side, causing his vehicle to crash into a tree. The contact's brother had no account of what happened the day of the crash. No air bags were deployed upon impact. The contact's brother sustained injuries to his face, was unable to walk, and was transported to the hospital for medical treatment. A police report was filed. The vehicle was towed to a tow yard, where it was deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was unavailable.

NHTSA ODI 11533496

The contact owns a 2017 Jeep Wrangler. The contact stated that on various occasions while driving at various speeds, the air bag warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the air bag needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 110,000.

NHTSA ODI 11530603

Shortly, after returning home, I was cleaning out my jeep, including my glove box. There is no catch behind the glove box and things fall out the back of the glovebox to the floor particularly get stuck underneath the center dashboard console directly adjacent to the glove box. I had some face masks from Covid that fell out the back of the glove box, and landed underneath the hidden in area of the console between the steering column in the glove box. I reached behind the plastic cover to retrieve the masks and burned my hand on some very hot metal. It was so hot. If I would not have found the masks that fell in there, they would’ve surely started an interior fire in the jeep while I was driving or in my garage. This is very dangerous, my husband also burned himself when he checked on another day when I showed him. This is a serious fire hazard and they need to either completely close off that gap at the glove box or close it off directly below the dashboard where all the controls are for heating and cooling and radio.

NHTSA ODI 11529688

My Jeep has been experiencing what is called the “death wobble”. When I get over 50mph, it starts to shake real bad feeling as though my tires are about to come off.

NHTSA ODI 11525156

Engine light came on stating cylinder #4 miss fire. After taking it in, the mechanic said that they can repair the head but it will most likely be an issue again in another 30k or it will be another cylinder. They said it is still causing the air to leak. This Jeep only has 51k miles and is in mint condition. After further research, Jeep had previously recalled this same issue on Jeeps a little older than 2017.

NHTSA ODI 11524448

While on the highway, cruising at 65 mph, the electronic stability control warning light started flashing and the brakes started to be applied automatically and almost caused an accident and rollover. No trouble codes are shown or captured and dealership can not reproduce the issue. However it has happened more than 5 times and only while on the highway at cruising speeds.

NHTSA ODI 11524104

The vehicle has 55,000 miles on it. BOTH brake calipers were stuck and grabbing. A complete front end redo for brakes & calipers at very low mileage. When braking to stop, it was all over the road and unpredictable.

NHTSA ODI 11523403

Chrysler has a recall for 2017 jeeps, fuel sending component, campaign #16V84900, but does not include this vin. However, the component is defective from manufacturer in this vehicle. How do I get this vin to be included in recall?

NHTSA ODI 11521589

Clockspring needs to be replaced. I have had this happen twice in my Jeep Wrangler RHD that I previously owned. There is a recall for models through 2016, but mine is a 2017.

NHTSA ODI 11518524

Check engine light flashing then steady all of a sudden. Oil leaks

NHTSA ODI 11514961

Transmission went out at 86k miles, all maintenance has been kept up with. Jeep broke down while driving, pouring transmission fluid in road, losing all power and unable to go forward or reverse. Problem has been confirmed by service center. Jeep has not yet been inspected by manufacturer, no warnings at all.

NHTSA ODI 11512709

2017 Jeep wrangler with 40,000 miles. Passenger Side Impact - No Air Bags. 1. the Safety restraint system. The Vehicle is now repaired and yes I'd like the EDR record examined for deployment criteria. Threshold, side safeing, Algorithm, etc. 2. My safety was at risk, No air bags deployed, I suffered bruising and I hit my head on the driver side window. 3. No, the Restraint Control Module/EDR record was not investigated. 4. No, the system was not indicating any air bag tell tale lights and was functioning normal. Heading North on ..., traveling 40 - 45 MPH, was broadsided by a vehicle traveling West on ... @ 30 MPH . My airbags did not deploy.

NHTSA ODI 11506945

Faulty torque converter causes vehicle to stall.

NHTSA ODI 11506793

Vehicle stalls when going into reverse mainly during first start of the day, but has happened throughout the day as well. Many people in online wrangler forums are attributing this to a faulty torque converter. No symptoms prior to this failure but it’s affecting many jeeps with low mileage like mine.

NHTSA ODI 11506795

I smell oil burning as I drive then found oil on the garage floor. Found the oil adaptor (Oil filter housing) worped causing oil to drip out and onto the hot exhaust. Oil on heat is a safety issue and should be addressed.

NHTSA ODI 11506358

Heater core constantly “clogs” and no longer blows hot air on drivers side of the vehicle. Either through the defroster vents or floor vents, this makes it difficult to defrost the drivers side windshield or side window (can’t see side mirror!). Jeep wants me to spend &3500 to replace entire system!!!

NHTSA ODI 11506034