What 941 owners told NHTSA about the 2017 Hyundai Santa Fe Hybrid Hev

Bottom brake lights will not work but top high brake light works. I was stopped by police three times. They state all three brake lights must operate.

NHTSA ODI 11727182

After performing regular oil changes, and even a new fuel pump sensor, I experienced an issue. Last oil change was within the past two weeks. Driving home from the mountains, I heard a knocking sound from the engine bay. I narrowed it down to all gears above 2500RPM, increasing knocking with RPM speed. I took it easy on the engine, mostly coasting down the mountain. Suddenly during acceleration on an uphill, a pop sounded, and copious white smoke started coming from the engine bay. I pulled over despite having no power brakes but I was fortunate to be near an off ramp in a rural area. Trying to troubleshoot roadside, i noticed fluid on the tie rod, but I wasnt able to determine what kind of fluid it was. When I try to start the car, there is one single click, the engine wont even attempt to turn over. Oil, battery and check engine lights are all on. After towing, I found that the fluid leaking from the vehicle is oil. The vehicle is currently at a transmission shop, but from my research, this isnt a transmission issue but a blown rod bearing the Hyundai engines are know for. I will be contacting a dealership to see if they will at least confirm my diagnosis.

NHTSA ODI 11725726

ABS doesn't work, traction control doesn't work, while it was raining the sensor lights came on and I began to hydroplane almost causing a wreck while driving on the highway. The sensors go off and on the emergency brake won't engage while this sensor is on also. Acceleration stall pulling out in traffic. I'm scared to even drive the suv

NHTSA ODI 11682094

While driving, the vehicle lost its brakes and rolled to a stop on [XXX] at that point the vehicle compartment began to fill up with black smoke and soot and flames started to come out of vents. My daughter immediately grabbed her dog and exited from the vehicle to a safe spot away from the car. Within 10 seconds the vehicle exploded and erupted into a 20 ft fireball. If my daughter would have hesitated she could have been killed. Hyundai inspected the vehicle and found nothing conclusive except that this problem has been documented in other Incidents. The vehicle was declared to be totaled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11636163

The brakes and rotors need to be replaced every 3-6 months. They have been fixed at least 4 times under warranty. Every time I take the car in I get asked if I drove through the mountains because they are fried. This vehicle has never been in the mountains because I fear what will happen if it really were driven through the mountains. However, no excessive braking occurs to cause them to be ruined every 3-6 months. I am at the point I’m curious if automatic braking is causing it to heat up and burn them. The incident below is the last time I had them replaced. I’m currently looking to sell the vehicle because of the number of times I’ve had to go in and get them replaced.

NHTSA ODI 11632995

My complaint is the dealership that said had completed the recall on my brake systems according to both your and state records was not completed. They gave me a service notice stating the work was done. Since then the braked have continued to act up and the vehicle as a strange acceleration problem. The dealership is Don Wood Hyundai in Athens Ohio.

NHTSA ODI 11628124

The contact owns a 2017 Hyundai Santa Fe. The contact stated that while his wife was driving at undisclosed speeds, the vehicle lost automotive power and the vehicle failed to stop while depressing the brake pedal. The vehicle was allowed to decelerate and come to a stop. No warning light was illuminated. The vehicle was towed to a local dealer where it was diagnosed and determined that the alternator needed to be replaced. The vehicle was repaired. In addition, the contact stated that the engine was previously replaced and the contact was concerned that the warning lights on the instrument panel might not properly display because the check engine warning light had not illuminated during the previous failure. The manufacturer was made aware of the failure. The failure mileage was approximately 121,000.

NHTSA ODI 11619332

Complete failure of brake system. After the vehicle parked, a significant puddle of brake fluid formed under the rear axle area (mid between rear wheels. It appears that a break line failed. An internet search revealed that Canada has issued a recall regarding corrosion of brake lines on this vehicle. Extremely dangerous situation. Fortunately, the failure happened when driving in a residential neighborhood at speeds less than 25 mph.

NHTSA ODI 11587198

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11573966

When driving front right brake caliper locked up and would not release, after replacing brake pads, rotors and calipers on both front right brakes. I drove my car about a week and car brakes locked up again…I then had to have my car towed to the mechanics. Where they discovered that the ABS module was bad, this is the same part that is causing fires in many others Hyundai vehicles but somehow my car was exempt from the recall and after having issues with getting the part and having to rent a car and borrow a car for several weeks I finally got my car fixed almost $3000.00 later. Seems to me this part is a common problem for many people. Thankfully I was not in an accident due to the brake locking up, I will say I had a little fear when driving my car for several weeks after the 2 incidents.

NHTSA ODI 11554222

The oil leaks every time I brake, and car engine and brakes get hot.

NHTSA ODI 11547259

All safety lights AEB, TMPS, ABS, on. The car breaking as driven due to this issue. Reported to Hyundai Headquarters. They said it was a major safety issue but not willing to pay for repairs especially since it's a safety issue.There many reports online of people experiencing the same issue with new cars as well. Having to pay for this is not very noble of Hyundai.

NHTSA ODI 11543558

I bought this vehicle and there was a complete break down malfunction due to the ABS module system! This lack of due diligence caused both myself and my 7 year old to unwillingly enter a vehicle that put our lives at risk and a near death experience that still traumatizes my daughter until this day who refuses to enter any vehicle! This is an unfortunate mistake on your end and there is no where near enough compensation that will ever withdraw the fear from my innocent child’s eyes anytime I need to drive her to school, or basketball practice, or anywhere to run our daily errands and live a normal life! I have nothing else to add except I expect compensation for a safe vehicle and compensation necessary to help my child, my innocent child to get through this fear!

NHTSA ODI 11520592

It’s not a accident The car won’t start and brake and wheels keep locking by itself.

NHTSA ODI 11516659

The left rear brake caliper broke off and was hanging next to the wheel. The brake fluid was leaking and had leaked out. it is available for inspection. This occurred while driving home from an errand. Had it occurred earlier on a steep hill down the mountain, the results would have been catastrophic, probably resulting in loss of life. The vehicle has yet to be inspected by the manufacturer but will be soon. No warning lights just noise of caliper banging against car and loss of brakes. Event occurred close to home problem discovered there.

NHTSA ODI 11514909

My lane departure and collision warning did not work when I crashed into a car head on and totallled my vehicle. I had not yet received my recall maintenance, nor did I know about both recalls. Only the first. Not only that but lane assist did not work and the airbag did not go off. Despite totaling the car, how did they not go off?????

NHTSA ODI 11508838

The contact owns a 2017 Hyundai Santa Fe. The contact stated that upon purchasing the vehicle, she was given a notification for NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) and was informed by the dealer that the parts for the recall were available according to the NHTSA website. The dealer was notified about the recall but informed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11501331

I was accelerating on the highway and my RMPS shot the whole way up over 7,000 then bottomed out. I lost speed so I pulled over. Another car pulled over to inform me my car was on fire. I turned the car off and the fire went out. The car was towed to Blaise Alexander (dealership) in Altoona, PA. The mechanic reported that a connector rod went through the oil pan, engine block, and brake starter. He kept repeating to me "I've never seen anything like this before". He reached out to Hyundai to ask if they would cover repairs (starting at $13,790). Hyundai said no. I believe this incident was more than mechanical, and is related to the open recall. I attempted twice to have my car repaired under the recall but the dealership "didn't have the part".

NHTSA ODI 11495138

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. An unknown dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11483564

My dealer, Crain Hyundai, North Little Rock, AR, has not performed the recall notices on my 2017 Santa Fe (recall 961 Auxilary Canister Kit and recall 218 ABS system). I have taken the vehicle in three times and they say they don't have the parts. I would like to file a complaint in this regard. Michael Barron

NHTSA ODI 11479759

The rear hatch closes automatically even if somebody is under the hatch putting items in the trunk without going back up. This is dangerous especially if children are near the hatch. It also at times opens when the button on the hatch is pushed but does not close automatically. The Hyundai Dealership Alexandria (1707 Mount Vernon Avenue) was uninterested in the issue and said they would charge $370 to look at the problem. Also for the safety recall of the ABS system, the earliest appointment at the same dealership was September 7 even though this sounded like a serious recall.

NHTSA ODI 11479406

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic). However, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available. The consumer stated was finally able to make an appointment and repairs were made on 01/04/2023.

NHTSA ODI 11478970

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11476165

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated while driving 25 MPH, the vehicle stalled. The contact stated no warning light was illuminated. The contact was unable to restart the vehicle. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the rod bearings replaced. The vehicle was not repaired. The contact called a second local dealer, Pearson Hyundai (11701 Midlothian Turnpike, Richmond, VA 23113: (804) 276-0300) and made them aware of the failure. The vehicle was not repaired. The manufacturer had been informed of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 114,000.

NHTSA ODI 11475237

This last 07/08/2022, my car was for RECALL 218, in Kendall Hyundai, Miami Florida for ABS, my car never have problem before in 5 year. When I am driver for my home after work the light for warning is ON ABS line and other one too, when i go for the dealer the next Monday the dealer said me, i have to paid $ 1106.00 for the two rear sensor have problem, for each sensor is 42.00 dollar but the rate is the difference for repair my car, is unavailable for the same problem, i think about keeping my car and buying a new Hyundai Santa FE ,but i don't feel comfortable with this situation.

NHTSA ODI 11473336