What 307 owners told NHTSA about the 2016 Jeep Grand Cherokee Trackhawk

Car shut down without warning while i was driving in traffic. Car locked it shelf out and was not drivable. Had to have it towed to local Jeep Dealer. They looked into it and determined that the alternator failed and fried a fuse block as well. the Repair cost just over $1500. There is a recall out for Grand Cherokee's from 2012 to 2014 for the same issue. P60 / NHTsA 14v634. I know my jeep is a 2016 but i feel like this is the same issue.

NHTSA ODI 11533245

Since purchased new, vehicle frequently loses acceleration, at varying vehicle speeds and will not exceed engine idle and has happened several times when crossing oncoming speeding traffic and is hard to avoid dangerous collision. To get the engine to accelerate again, operator must stop the vehicle, put the can in park, shut the engine off then restart. Most of the times, it is hard to find a spot in the traffic to go through the above maneuver creating a very dangerous situation as it has happened in the HOV lane of freeways during high speed and crowded traffic, no place to pull over.

NHTSA ODI 11528612

Terrible band aid like fix of the software “update” truck runs awful, .The fuel pump recall has me worried about safety concerns, the transmission tune feels unsafe for new drivers and the big , loss of value, and lack of reliability it took 2 months for a recall. I am a disabled combat veteran on a fixed income I can not afford such maintenance and the lack of reliability

NHTSA ODI 11527295

Please see attached further information as to complaint recently filed, NHTSA ID # 11525685

NHTSA ODI 11526397

Similar to https://static.nhtsa.gov/odi/tsbs/2019/MC-10170403-9999.pdf NUMBER: 23-036-19 GROUP: 23 - Body DATE: December 18, 2019 SUBJECT: Leather Instrument Panel (IP) Cover Delaminating - X81 Warranty Extension This issue still exists in newer years. Including my 2016 Jeep Overland High Altitude. Recall should be extended to include 2016 model years. There are plenty of similar complaints online. Jeep has not improved the quality or design on this defect.

NHTSA ODI 11526039

The contact owns a 2016 Jeep Grand Cherokee. The contact stated that while the vehicle was receiving tire maintenance service, the contact was informed that all 20 lug nuts were swollen. The contact took the vehicle to the local dealer, where it was diagnosed and determined that all 20 lug nuts needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 104,000. The contact replaced all of the swollen lug nuts at their own expense.

NHTSA ODI 11525676

On 4/14/2023 while getting tire rotation and other general maintenance done on my 2016 Jeep, I was informed by service Tec that my lug nuts on my Jeep were swollen and soon will not be able to remove or break, causing issues like tire rotation and general maintenance impossible and high risk of cracking and breaking. This would cause the Jeep to lose its stability, at a higher speed, wheel could come off. This could cause serious damage/injury or death if this happened. I went to local Chrysler dealer in Turnersville and spoke with parts department. They stated each lug bolt cost $18.00 each. I need 20 to replace defective ones. Chrysler parts rep suggested I call Chrysler customer service who he believes would send replacement bolts as these are steel and should not swell at all. I did call and open a complaint with Chrysler recently this month, June. I was just informed by Chrysler customer service that they deem this a warranty issue and not a safety issue and refuse to remedy or replace the defective lug bolts. I’m asking for your assistance in this situation to help replace the defective lug bolts via Chrysler before a serious accident or injury happens. I think it’s totally unacceptable that replacing these defective lug bolts cost $18.00 each and I’m being told to pay this , total cost is $360 for 20 lug bolts that are defective original Chrysler parts

NHTSA ODI 11525685

Lug nuts on tires have swelled up and expanded causing inability to get tire to come off with emergency lug wrench that comes with the vehicle. This poses a risk for driver if they come across a flat tire as they will be left stranded. Still have yet to find a mechanic that has been able to get my tire off.

NHTSA ODI 11523812

Dear Sir or Madam, I want to file this complaint regarding an authorised JEEP Dealership and Service in Kyiv, Ukraine (Stolychne Highway, 90, 03045), which refuses to repair my Recall 22V-406 on my 2016 JEEP Grand Cherokee Overland. According to that I'm not able to use my car until it will be maintained and mentioned above Safety Recall will be completed because it may cause a car accident on the road or highway without my fault and this can seriously affect my, my family’s and others people health. I hope you can make a right influence on this authorised JEEP Dealership and Service to make sure this unpleasant situation will not happen again with me or any other client. Looking forward to answer from you.

NHTSA ODI 11523380

I noticed a fire from under the hood, half of my car burnt down. I had been parked at home for about five minutes when I noticed a fire.

NHTSA ODI 11523507

******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE IT IS REQUESTED BY THE CONSUMER THAT THEY WISH TO HAVE IT REMOVED*DJR ******* DELETE VOQ *******

NHTSA ODI 11523232

Water pump issue. While driving, the thermometer gauge suddenly went to "H", check engine light came on, no smoke seen and the car suddenly stopped. Coolant confirmed in the tank. The incident happened without warning and was frightening. The car was towed by AAA road service to Olathe jeep dealership and awaiting additional diagnostics. Please advise on the recalls. FCA/Mopar acknowledges issues with water pumps and head gasket issues related to leaks. Please advise.

NHTSA ODI 11521324

On May 8th, Son driving Jeep to work and the thermometer gauge suddenly went to "H" check engine light came on, no smoke seen but the the car stopped suddenly. There was coolant in the tank.This incident happened without warning and was quite frightening. Had the car towed by AAA to Jeep dealership in Olathe Ks. Now awaiting diagnostics. It's been a day and a half and the dealership is unsure of what is going on. please help/advise.

NHTSA ODI 11521249

The contact owns a 2016 Jeep Grand Cherokee. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. The contact stated that there are multiple recalls open but they are not getting fixed. The issue could potentially cause a fire yet the parts may not be available until March 2024.

NHTSA ODI 11517842

There has been a recall since last year, with no parts. In Feb my car broke down stopped running due to this recall. I had it towed to a dealership and no parts. Now its been sitting there for months and I have no car to drive. The dealership said they cant help, call Crysler. I contacted them and was told so sorry we WONT pay for a rental car. Now what am I going to do? I have to work and cant afford all these costs. Anything you can do to help?

NHTSA ODI 11517643

The car has a good battery but won’t start. A click is made the radio turns on but the car won’t start. We have changed the starter and also the file pump. Failed 2 times

NHTSA ODI 11516078

I have a transmission fluid leak that can cause a fire. I have noticed there was recalls for a cooler hose in 2021. Can that be possible it is a similar issue ?

NHTSA ODI 11514015

(2) FAILURES; (1) failure of the engine oil filter assembly (BECAUSE IT WAS PLASTIC). No warning whatsoever, only caught because I noticed oil leak. turns out the filter assembly cracked, pump at least 3 quarts of oil into radiator. COULD HAVE BEEN A CATASTOPHIC FAILURE AT HIGHWAY SPEED - ENGINE WOULD HAVE LOCKED UP. - Cost to repair:$1,477.39 Mileage 128,766 (2) failure of multiple rocker arms, only symptom was flashing check engine light under heavy acceleration. NO OTHER WARNINGS. engine effectively stops functioning correctly. Stopping car, turn off and restart- NO CHECK ENGINE LIGHT. COULD HAVE BEEN CATASTROPHIC IF OCCURS DURING PASSING, ESPECIALLY ON MINOR ROADS. Cost to repair: $2,479.75 Mileage: 142,724 BOTH ARE CAUSE BY DEFECTIVE PARTS INSTALLED IN/ON ENGINE. RECALL FOR THESE ISSUES IS NOT ONLY WARRANTED, BUT DEMANDED.

NHTSA ODI 11512660

The contact owns a 2016 Jeep Grand Cherokee. The contact stated that while slowing down and coming to a stop, the vehicle stalled. There were rats detected in the vehicle that chewed the interior wires. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who stated that the wires were damaged. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. VIN tool confirms parts not available. The failure mileage was approximately 157,000.

NHTSA ODI 11508977

The headrest on the driver's side popped open when I was driving. I had backed out of my driveway and had changed to drive and as I did the headrest popped open. It hit me in the back of my head. Luckily I was driving slow and I could pull over to find out what happen and discovered that the headrest popped open. In trying to find out what was going on with the headrest I discovered a small piece of plastic that came out of the headrest. I am unable to reset the headrest due to this broken piece of plastic. I am glad that I wasn't driving at a faster speed as the bump from the headrest may have caused me to put on the breaks or change lanes as a result of the hit on my head.

NHTSA ODI 11505928

Over a 3 year time span my 2016 Jeep Grand Cherokee has on multiple occasions had an extremely rough idle, has a hard time accelerating and car drives extremely rough and bumpy. I’ve taken it to multiple different auto shops and all they ever do is change spark plugs OR they just don’t know what’s wrong. No engine light illuminated and no codes. Spark plugs changed March 2020, august 2020, January 2021 and now January 2023 I’m having this problem again and the shop says they don’t think it’s spark plugs . I just want this resolved. This cannot be safe!

NHTSA ODI 11502704

The headlight lenses are hazing on the inside. I have turned this defect in for warranty repair and repair was denied. I contacted Jeep and I was told since it was denied there is nothing more they can do. The hazing on the inside of the lese is defusing the lights and visibility is drastically reduced at night. I have researched this issue and what I find out is the haze is caused by the heat of the BiXenon HID is burning the inside of the headlight lense.

NHTSA ODI 11500952

Vehicle is currently at a Jeep dealership for the 8th time with another Brake Concern. Brakes repetitively seize causing brakes to rapidly overheat, smoke emitting from the wheel, about to catch fire. Two Dealerships have failed to "duplicate the concern" until I get it there with the wheel about to catch on fire. Initially the drive side rear was the problem, 2 months after having the car returned to me, the passenger side rear began doing the same thing. I have contacted Jeep Customer Care and my concerns over the safety of the vehicle have been dismissed, they stated "this is not a known issue, if you have any other questions or concerns please contact us again". There have been no warning lights from the vehicle, it will be operating fine one trip, and the next trip you will stop after a short drive a cloud of smoke will be coming from the wheel, and the smell of burning brakes. As the brake continues to heat up while you are driving, the vehicle will begin to violently shake and vibrate.

NHTSA ODI 11499672

The contact owns a 2016 Jeep Grand Cherokee. The contact stated that while driving at approximately 60 MPH, the driver's head restraint exploded, which caused him to sustain a whiplash injury. No warning lights were illuminated. The vehicle was taken to a local dealer; however, the parts for the repair were on backorder. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 96,000.

NHTSA ODI 11492133

The contact owns a 2016 Jeep Grand Cherokee. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that there was a leak in the evap system. The mechanic replaced the Evaporative System Integrity Module (ESIM). The manufacturer was made aware of the failure. The failure mileage was 63,635.

NHTSA ODI 11490987