What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

SINCE I BOUGHT THIS CAR NEW IN 2016 I HAVE HAD TO REPLACE THE VCM 4 TIMES. NOTHING SEEMED TO FIX THE PROBLEM. THE STOP/START NEVER WORKED RIGHT. THREE TIMES OVER THE LAST MONTH, AFTER VARIOUS REPAIRS AT THE DEALERSHIP, THE CAR HAS COMPLETELY STOPPED WHILE DRIVING AND WOULD NOT START AGAIN. THE DOORS UNLOCKED AND LOCKED, VEHICLE JUMPED 3 TIMES, ALL KINDS OF WARNING LIGHTS AND MESSAGES ON THE DASH....THEN NOTHING BUT A DEAD CAR IN THE MIDDLE OF THE ROAD ON A SUNNY DRY DAY. I COULD'VE BEEN THE CAUSE OF ACCIDENTS WHILE STOPPED IN THE ROADWAY AND MANY PEOPLE COULD'VE BEEN SERIOUSLY INJURED. THE CAR WAS FIXED THE FOURTH TIME YESTERDAY AND THE MECHANIC TOOK IT OUT TO TEST BEFORE RETURNING THE VEHICLE TO ME. IT DIED ON HIM AGAIN AND HAD TO BE TOWED BACK TO THE SERVICE CENTER. SERIOUS SAFETY HAZARD AND THE CERTIFIED GM TECHS CAN'T FIGURE OUT WHAT'S WRONG. P3055 AND P3056 ARE THE ERROR CODES THAT COME UP EVERY TIME. NEW BATTERY, NEW VCM, NEW WIRING HARNESS....EACH TIME THE PROBLEM GOT WORSE UNTIL IT COMPLETELY STOPPED RUNNING. NO RECALL AND THE CAR IS OUT OF WARRANTY SO CHEVY IS NOT WILLING TO HELP AT ALL.

NHTSA ODI 11244609

EGINE POWER REDUCED LIGHT. THE CAR WONT GO OVER 20-30MPH. BRAKES MALFUNCTION CAUSING A SMALL FENDER BENDER. ITS HARD TO START WONT STAY RUNNING. IT EVEN LOST POWER ON THE HWY A FEW TIMES BEFORE THE WRECK.

NHTSA ODI 11243558

TAKATA RECALL- MY CAR IS DECREASING SPEED, SWITCHING GEARS WHILE DRIVING, MY CAR KEEPS TELLING ME TO 'SHIFT TO PARK' WHILE THE CAR IS ALREADY PARKED AND NOT CUTTING OFF. THE CAR KEEPS DROPPING TO ZERO ON MY DASH BOARD WHILE I'M DRIVING AND SHAKING WHILE I'M DRIVING. MY SENSOR SYSTEM KEEPS FLASHING 'STABILITALK' AND 'STEERING POWER SERVICE, REDUCED SPEED'

NHTSA ODI 11243803

UPON STOPPING AND SHIFTING THE TRANSMISSION INTO PARK, THE INSTRUMENT DISPLAY GIVES A "SHIFT TO PARK" WARNING AND WHEN THE "STOP / START" BUTTON IS PUSHED TO SHUT OFF THE ENGINE, THE ENGINE STOPS, BUT THE ELECTRICAL SYSTEM REMAINS ENERGIZED. THE PROBLEM IS INTERMITTENT AND IT OFTEN TAKES SEVERAL ATTEMPTS TO REMEDY BY RE-STARTING THE ENGINE, SHIFTING INTO GEAR, SHIFTING BACK TO PARK, THEN HITTING THE "STOP / START" BUTTON AGAIN BEFORE IT WORKS CORRECTLY. BASED ON FEEDBACK FROM THIS AND OTHER SITES, THIS APPEARS TO BE A COMMON PROBLEM AND MY LOCAL DEALER HAS QUOTED ME APPROXIMATELY $500 TO REPLACE THE TRANSMISSION CONTROL ASSEMBLY. GM HAS ALSO ISSUED A TECHNICAL SERVICE BULLETIN, NO. 18-NA-297, WHICH RECOGNIZES THIS PROBLEM. THE CAR HAS 27,000 MILES ON IT AND IS 3 MONTHS OUT OF WARRANTY. THIS IS UNACCEPTABLE FROM A 100 YEAR OLD CAR COMPANY THAT THE GOVERNMENT BAILED OUT JUST 10 YEARS AGO.

NHTSA ODI 11243342

ON JUNE 30, 2019, I WAS DRIVING MY CHEVROLET MALIBU HYBRID HOME ON THE FREEWAY WHEN SUDDENLY THE ENGINE LOST POWER AND STALLED. THE SERVICE ENGINE SOON LIGHT TURNED ON AND A MESSAGE ON THE DASHBOARD SAID 'SHIFT TO PARK'. I COASTED TO THE NEXT EXIT AND STOPPED ON THE SIDE OF A STREET. I PRESSED THE OFF BUTTON AND SHIFTED TO PARK. I TRIED TO TURN ON THE CAR AND IT WOULDN'T EVEN CRANK THE ENGINE. I CALLED AAA AND AFTER 10 TO 15 MINUTES THE SERVICE ENGINE SOON LIGHT TURNED OFF. I TRIED AGAIN TO START THE CAR AND IT TURNED ON. I CANCELED AAA AND DROVE THE CAR HOME. AFTER A COUPLE OF DAYS, I DECIDED TO SCAN THE TROUBLE CODES IN THE CAR WITH MY CODE SCANNER. THE REPORT SAID FOUR CONFIRMED TROUBLE CODES, NO PERMANENT TROUBLE CODES, NO PENDING TROUBLE CODES, NO BODY CONTROL MODULE TROUBLE CODES, 1 TELEMATICS TROUBLE CODES, NO HUMAN MACHINE INTERFACE MODULE TROUBLE CODES, AND FOUR ELECTRONIC BRAKE CONTROL MODULE TROUBLE CODES. I SAVED THE REPORT AND RESET THE TROUBLE CODES. COPY OF THE REPORT ATTACHED. THEN ON JULY 2, 2019, I WAS DRIVING ON THE CITY STREET AND THE CAR STALLED AGAIN WITH THE SAME MESSAGE TO SHIFT TO PARK. I COASTED TO THE SIDE OF THE ROAD AND PRESSED THE OFF BUTTON AND SHIFTED TO PARK. I TRIED TO START THE CAR AND IT DID START AND I DROVE IT HOME. NEXT DAY I SCANNED THE TROUBLE CODES AGAIN. THE REPORT SAID NO CONFIRMED TROUBLE CODES, NO PERMANENT TROUBLE CODES, NO PENDING TROUBLE CODES, 2 BODY CONTROL MODULE TROUBLE CODES, 3 FRONT CAMERA ACTIVE SAFETY TROUBLE CODES, 3 TRANSFER CASE CONTROL MODULE TROUBLE CODES, AND 1 ELECTRONIC BRAKE CONTROL MODULE TROUBLE CODES. I SAVED THE REPORT, COPY ATTACHED. NEXT DAY I TOOK THE CAR TO THE DEALER FOR TROUBLE SHOOTING, AND REPAIR UNDER WARRANTY.

NHTSA ODI 11243134

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. WHILE PARKING, THE START/STOP BUTTON WAS PRESSED AND FAILED TO TURN OFF THE VEHICLE. IN ADDITION, THE "PARK TO SHIFT" WARNING MESSAGE WAS DISPLAYED ON THE INSTRUMENT PANEL. THE CONTACT HAD TO SHIFT GEARS AND BACK INTO PARK IN ORDER TO TURN OFF THE VEHICLE. THE CONTACT CALLED MCKENNEY CHEVROLET CADILLAC BUICK GMC (LOCATED AT 831 S MAIN ST, LOWELL, NC 28098, (855) 757-1635) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 41,000.

NHTSA ODI 11242488

I COULD BE DRIVING DOWN THE ROAD AND IT'LL SAY ENGINE POWER REDUCED. IF I PRESS THE GAS, IT'LL SLOW DOWN. WHEN I PUT MY CAR IN PARK, AND TURN IT OFF IT'LL SAY SHIFT TO PARK.

NHTSA ODI 11242169

DASH SAYS TO SHIFT TO PARK WHEN SHUTTING CAR OFF, EVEN THOUGH IT'S ALREADY IN PARK

NHTSA ODI 11242174

I WAS DRIVING NORTHBOUND ON I-435 WHEN AVOIDING AN ACCIDENT. I PRESSED MY BRAKE AS HARD AS I COULD. MY VEHICLE DID NOT STOP SO TO AVOID CAUSING A SERIOUS ACCIDENT I WENT OFF ROAD IN THE CENTER OF THE TWO HIGHWAYS. AFTER HITTING THE GUARDRAIL TO STOP MY VEHICLE FROM FALLING INBETWEEN THE OVERPASS. MY AIRBAGS DID NOT DEPLOY . I FEEL SOME CONCERN AFTER HAVING MY BREAKS CHECKED AND TOLD THEY WERE GOOD. THEN IF I'M AT STOP AND I RELEASE THE BREAK FOR MY CAR TO START BACK UP. I GIVE IT A SECOND AND THEN PRESS THE PEDDLE IT DOES NOT MOVE WHICH HAS ALMOST CAUSED ME TO HOLD UP TRAFFIC OR ALMOST BEING HIT WHEN VEHICLES WERE AT SAFE DISTANCES.

NHTSA ODI 11241542

IN DECEMBER OF 2018 ON A ROAD TRIP, MY BRAKES FAILED; I LITERALLY HAD TO SLAM ON THE BRAKES TO GET THE CAR TO STOP. THIS HAPPENED ON THE PENNSYLVANIA TURNPIKE, WITH MYSELF, MY MOTHER AND MY 5 YEAR OLD DAUGHTER IN THE CAR. YOU CAN IMAGINE THE FEAR I FELT AT THAT TIME. THANKFULLY, I WAS ABLE TO MERGE ONTO THE SHOULDER OF THE ROAD AND WAIT FOR A TOW TRUCK. MY CAR WAS TAKEN TO A CHEVROLET DEALERSHIP IN HARRISBURG, PA AND IT TOOK THEM A WEEK TO REPLACE THE VACUUM PUMP. JULY 2019 I NOTICE THAT MY ENGINE LIGHT IS ON AND THERE IS A MESSAGE ON MY DASHBOARD THAT STATES 'REDUCED ENGINE POWER.' I IMMEDIATELY MADE AN APPOINTMENT FOR SERVICE AT THE DEALERSHIP THAT I INITIALLY PURCHASED THE CAR FROM. MY CAR HAS BEEN THERE SINCE TUESDAY, JULY 23, 2019 AND THEY TELL ME THAT THE 'ANTI-LOCK BRAKE' SYSTEM HAS FAILED AND THEY ARE STILL TRYING TO PINPOINT WHY THE ENGINE LIGHT IS ON. THE DEALERSHIP SUGGESTED THAT WE TAKE THE CAR HOME AND BRING IT ON ANOTHER DAY, BUT AGAIN, LEAVING THE DEALERSHIP, THE BRAKE PEDAL BECAME STIFF AND WE COULD NOT APPLY PRESSURE TO IT! THEY HAVE SINCE REPLACED THE VACUUM PUMP AGAIN.

NHTSA ODI 11241016

THIS HAS HAPPEN TO ME MULTIPLE TIMES WITH THE MOST RECENT ONE BEING TODAY. THE CAR WOULD BE AT A RED LIGHT WHEN ALL OF A SUDDEN THE WHOLE CAR WOULD SHUT IT SELF OFF THEN RESTART AGAIN SHORTLY AFTER TURNING OFF. THEN A MESSAGE WOULD POP UP ON THE LCD SCREEN SAYING SOMETHING ALONG THE LINES OF. 'POWER STEERING ASSIST REDUCED' THE MESSAGE WOULD DISAPPEAR SO FAST THAT IT DOESN'T EVEN GIVE ME A CHANCE TO FULLY READ IT.

NHTSA ODI 11241207

WHEN I TURN OFF MY CAR. THE MESSAGE SHIFT TO PARK POPS UP AND I HAVE TO KEEP TURNING ON AND OFF THE CAR UNTIL THE MESSAGE " SHIFT TO PARK" DISAPPEARS. IF I LEAVE IT LIKE THAT THE RADIO TURNS ON REALLY LOUD. MY CAR IS NOT EVEN 3 YEARS OLD. THIS STARTED ABOUT A MONTH AGO AND IT WENT AWAY FOR A FEW DAYS AND IT CAME BACK AGAIN.

NHTSA ODI 11240649

ENGINE FAILURE. MY CAR WENT COMPLETELY OUT WHILE DRIVING HOME. THE STABIKITRAK POP ON, ENGINE LIGHT POP ON, BRAKES LOCKED UP MAKING IT HARD FOR ME TO STOP THE CAR IN TRAFFIC. I HOPE THEY ARE PLANNING ON DOING SOMETHING ABOUT THIS BECAUSE I SHOULDN'T HAVE TO BE AFRAID FOR MY LIFE. THIS CAR IS DEFINITELY NOT SAFE.

NHTSA ODI 11235317

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. WHILE DRIVING 65 MPH, THE STABILITY CONTROL AND STEERING ASSIST REDUCED WARNING INDICATORS ILLUMINATED. THE VEHICLE THEN SHUT DOWN COMPLETELY. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 80,000.

NHTSA ODI 11234760

WHEN IS THIS GOING TO BE A RECALL FOR THIS SHIFT TO PARK IN THE MALIBU. THIS CAUSES THE BATTERY TO DIE SO BOTH PARTS HAVE TO BE REPLACED. CHEVY HAS SEVERAL COMPLAINTS ABOUT THE SHIFT TO PARK. I CAN SPEND UP TO 10 MINUTES TRYING TO GET THAT MESSAGE OFF. I AM VERY DISAPPOINTED THAT THE DEALERS KNOW THIS IS AN ONGOING ISSUE FOR THE 2016 MALIBU BUT NOTHING IS BEING DONE. I HAVE FILED A COMPLAINT! I WILL ALSO BE GOING TO THE MEDIA WITH THIS.

NHTSA ODI 11234838

WHEN SHIFTER WAS PLACED INTO PARK IN A PUBLIC PARKING LOT, THE VEHICLE DISPLAYED A "SHIFT TO PARK" ERROR AND WOULD NOT TURN OFF. THE ISSUE CONTINUED DESPITE TWO DEALER REPAIR ATTEMPTS. I HAVE BEEN UNABLE TO SHUT OFF THE VEHICLE IN MY GARAGE, IN MY DRIVEWAY, AND AT NUMEROUS PUBLIC PARKING LOTS. LATER, THE VEHICLE SMACKED THE BRAKES WITHOUT DRIVER INPUT WHILE I WAS DRIVING ON THE HIGHWAY AND DISPLAYED A "STABILITRAK" ERROR. WHEN I PULLED INTO A PARKING LOT AND SHIFTED TO PARK, IT AGAIN DISPLAYED THE "SHIFT TO PARK" ERROR AND WOULD NOT TURN OFF. EVENTUALLY I WAS ABLE TO TURN OFF THE VEHICLE. WHEN I RESTARTED IT, IT DISPLAYED "STABILITRAK" ERROR AND "POWER STEERING" ERROR. I DISABLED THE STABILITRAK SYSTEM IN ORDER TO GET BACK ON THE ROAD BECAUSE I WAS IN A REMOTE AREA WITH NO PLACE TO GET THE CAR FIXED. WHILE DRIVING, THE VEHICLE WOULD TURN THE STABILITRAK SYSTEM BACK ON AND SMACK THE BRAKES. A FEW SECONDS LATER, THE SPEEDOMETER AND TACHOMETER DROPPED TO ZERO WHILE THE VEHICLE WAS STILL MOVING ON THE HIGHWAY, AND THE CLIMATE CONTROL SYSTEM STOPPED WORKING. THIS ISSUE CONTINUED TO REPEAT ITSELF WHILE I WAS DRIVING THE VEHICLE TO THE DEALERSHIP FOR REPAIR.

NHTSA ODI 11233450

WHEN SHIFTER WAS PLACED INTO PARK IN A PUBLIC PARKING LOT, THE VEHICLE DISPLAYED A "SHIFT TO PARK" ERROR AND WOULD NOT TURN OFF. THE ISSUE CONTINUED DESPITE TWO DEALER REPAIR ATTEMPTS. I HAVE BEEN UNABLE TO SHUT OFF THE VEHICLE IN MY GARAGE, IN MY DRIVEWAY, AND AT NUMEROUS PUBLIC PARKING LOTS. LATER, THE VEHICLE SMACKED THE BRAKES WITHOUT DRIVER INPUT WHILE I WAS DRIVING ON THE HIGHWAY AND DISPLAYED A "STABILITRAK" ERROR. WHEN I PULLED INTO A PARKING LOT AND SHIFTED TO PARK, IT AGAIN DISPLAYED THE "SHIFT TO PARK" ERROR AND WOULD NOT TURN OFF. EVENTUALLY I WAS ABLE TO TURN OFF THE VEHICLE. WHEN I RESTARTED IT, IT DISPLAYED "STABILITRAK" ERROR AND "POWER STEERING" ERROR. I DISABLED THE STABILITRAK SYSTEM IN ORDER TO GET BACK ON THE ROAD BECAUSE I WAS IN A REMOTE AREA WITH NO PLACE TO GET THE CAR FIXED. WHILE DRIVING, THE VEHICLE WOULD TURN THE STABILITRAK SYSTEM BACK ON AND SMACK THE BRAKES. A FEW SECONDS LATER, THE SPEEDOMETER AND TACHOMETER DROPPED TO ZERO WHILE THE VEHICLE WAS STILL MOVING ON THE HIGHWAY, AND THE CLIMATE CONTROL SYSTEM STOPPED WORKING. THIS ISSUE CONTINUED TO REPEAT ITSELF WHILE I WAS DRIVING THE VEHICLE TO THE DEALERSHIP FOR REPAIR.

NHTSA ODI 11233452

AT 63K MILES, THE PISTON CRACKED AND THE ENGINE NEEDS TO BE REPLACED. THERE WAS A RECALL ON THIS SAME EXACT ISSUE, WHERE CHEVY DECIDED TO RETARD THE TIMING SO THIS WOULD FIX THE ISSUE. OBVIOUSLY, THIS DID NOT FIX THE ISSUE AND NOW THE ENGINE NEEDS TO BE REPLACED. I CONTACTED GM AS THIS IS A MANUFACTURERS DEFECT AND BECAUSE THE CAR IS OUT OF THE POWERTRAIN WARRANTY, THEY ARE ONLY WILLING TO PAY 40% OF THE TOTAL COST TO REPLACE THE ENGINE. ONLY 3K MILES OUT OF WARRANTY? MANUFACTURERS DEFECT AND I HAVE TO SPILL ALMOST $5K TO FIX THE VEHICLE, WHEN THEY KNEW THEY HAD A PROBLEM? THIS IS NOT FAIR OR CORRECT. THE CONSUMER NEEDS REPRESENTATION AND CHEVY NEEDS TO PUT OUT A RECALL TO ALL OF THESE VEHICLES AND STAND BEHIND THEIR LOYAL CUSTOMERS. THIS IS THE 8TH GM VEHICLE I HAVE OWNED IN MY LIFETIME.

NHTSA ODI 11232984

I WAS DRIVING ON THE FREEWAY AT A SPEED OF 60 AND ALL OF A SUDDEN A MESSAGE POPS UP SAYING REDUCED SPEED AND THEN IT AUTOMATICALLY WENT DOWN TO 20MPH THEN ENGINE SHUT OFF IN THE MIDDLE OF THE FREEWAY LUCKILY I DIDNT GET HIT. THIS COULD OF CAUSED ME A HORRIBLE ACCIDENT

NHTSA ODI 11232175

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU EQUIPPED WITH CONTINENTAL CONTI PRO CONTACT TIRES, SIZE: 245/40/R19 (NA). THE CONTACT STATED THAT THERE WAS EVIDENCE OF TIRE BUBBLES ON THE SIDEWALLS OF THE FRONT PASSENGER AND REAR DRIVER'S SIDE TIRES. THE TIRE MANUFACTURER WAS NOT NOTIFIED. THE TIRES WERE ORIGINAL EQUIPMENT. TIM LALLY CHEVROLET (LOCATED AT 24999 MILES RD, WARRENSVILLE HEIGHTS, OH 44128, (440) 359-8781) WAS INFORMED OF THE FAILURE VIA PHONE. THE APPROXIMATE TIRE AND VEHICLE FAILURE MILEAGE WAS 67,000.

NHTSA ODI 11232467

VEHICLE WAS PARKED ON AN INCLINED DRIVEWAY. THE CAR WAS RAINED ON FOR 2 CONSTITUTIVE DAYS. THE 3RD BRAKE LIGHT ASSEMBLY JUST ABOVE THE REAR LEAKED INTO THE ROOF OF THE CARE AND THE TRUNK. THE LEAK WAS EXTREMELY FAST AND CAUSED A POOL ABOUT 1/2 AN INCH DEEP TO BUILD UP IN THE SPARE TIRE STORAGE COMPARTMENT OF THE TRUNK. THE LEAK CAUSED DAMAGE TO THE ROOF PANEL ON THE INTERIOR OF THE CAR WITH SIGNIFICANT WATER MARKS, AND COMPLETELY SOAKED THE TRUNK AS MENTIONED BEFORE WITH THE POOL OF WATER. THE CAR WAS PURCHASE NEW AND HAS NEVER BEEN INVOLVED IN ANY MOTOR VEHICLE ACCIDENT OR COLLISION OF ANY TYPE. THE TECHNICIAN THAT REPAIRED THE LEAK SHOWED THE LEAK WAS CAUSED BY A LOOSE NUT ON THE 3RD BRAKE LIGHT ASSEMBLY JUST ABOVE THE REAR WINDOW. I HAVE ATTACHED THE INVOICE FROM THE REPAIR SHOP THAT FIXED THE LEAK. THE MANUFACTURER REFUSED TO SERVICE OR INVESTIGATE THE SOURCE OF THE LEAK BECAUSE THE VEHICLE WAS OUT OF WARRANTY DUE TO MILEAGE. THE CARE WAS STATIONARY AND PARKED UNDER A RAINSTORM WHEN THE DAMAGES WERE NOTICED. AS FAR AS I CAN TELL THERE IS NO ELECTRICAL DAMAGE HOWEVER THE PROXIMITY TO THE 3RD BRAKE LIGHT WARRANTS THE REPORT OF ELECTRICAL DAMAGE. BODY DAMAGE IS DUE TO WATER DAMAGE TO THE FLOOR MATS OF THE TRUNK, HEADREST IN THE PASSENGER AREA OF THE CAR, AND WATER DAMAGE TO THE ROOF OF THE VEHICLE. THE DAMAGE WAS FOUND ON SATURDAY JULY 6TH, 2019. THE REPAIRS WERE PERFORMED ON TUESDAY JULY 9TH, 2019.

NHTSA ODI 11230455

THE VEHICLE UNEXPECTEDLY GOES INTO REDUCED ENGINE POWER MODE WHILE DRIVING. THE ACCELERATOR PEDAL WAS REPLACED. THE ISSUE CONTINUED AFTER IT WAS REPAIRED. IT CREATES A DANGEROUS SITUATION BECAUSE IT HAPPENS AS I'M DRIVING THE CAR.

NHTSA ODI 11229777

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. WHILE DRIVING 55 MPH, THE INSTRUMENT PANEL DISPLAYED "YOUR POWER SLOWING DOWN" AND THE VEHICLE DECELERATED TO 20 MPH. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY; HOWEVER, THE FAILURE RECURRED THREE TIMES TWO MILES DOWN THE ROAD. THE VEHICLE WAS TAKEN TO DUVALL CHEVROLET (LOCATED AT 464 US-441, CLAYTON, GA 30525, (877) 818-7723) WHERE IT WAS DIAGNOSED THAT THE ACCELERATOR PEDAL SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED CASE NUMBER: 9-5339020905. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

NHTSA ODI 11229219

MY 2016 MALIBU HAS INTERMITTENTLY NOT TURNED OFF WHEN HITTING THE STOP BUTTON AND THE ERROR MESSAGE "SHIFT TO PARK" WAS COMING UP. THE CAR WAS IN PARK. I AM ABLE TO TAKE MY FOOT OFF THE BRAKE WITH NO MOVEMENT OF THE VEHICLE. THIS HAS INCREASED TO WHERE I HAVE TO TURN THE CAR ON AND OFF MULTIPLE TIMES AND EVENTUALLY IT ALLOWS THE CAR TO TURN OFF. WHEN I CALLED THE DEALERSHIP TO EXPLAIN THE SITUATION THEY INFORMED ME THAT THE SHIFTER WAS BAD. HE STATED THAT HE KNEW THAT WAS THE PROBLEM BECAUSE IT WAS THE 8TH ONE THEY HAD REPLACED OVER THE PAST COUPLE OF WEEKS. I DO NOT LIVE IN A LARGE METRO AREA SO 8 IS A PRETTY HIGH NUMBER FOR THE POPULATION. I RESEARCHED ONLINE AND NOTICED THAT MULTIPLE COMPLAINTS FOR THE 2016-2017 MALIBU AND VOLTS OVER THE SAME ISSUE.

NHTSA ODI 11229298

WHEN PLACING THE CAR IN PARK TO SHUT OFF THE VEHICLE, A MESSAGE APPEARS STATING "ACTION REQUIRED" "SHIFT TO PARK." THE CAR IS IN PARK. SHIFTING IN AND OUT OF PARK DOES NOT SOLVE THE ISSUE. THIS INTERMITTENT PROBLEM OCCURRED OVER ABOUT 3 MONTHS. HAVE TO TURN OFF LIGHTS MANUALLY OR THEY WON'T GO OFF. DASH LIGHT REMAIN ON LONGER THAN USUAL. CAR BATTERY FINALLY DIED. REPLACED THE BATTERY/ PROBLEM PERSISTS. WHEN GETTING OUT OF CAR AND CLOSING DOORS, HORN HONKS 3 TIMES. REMOTE NOT DETECTED WHEN GETTING IN CAR AGAIN TO GO SOMEWHERE. PROBLEM STARTED SHORTLY AFTER WARRANTY EXPIRED. TOOK TO DEALER, COURTESY CHEVROLET. WAS TOLD WHILE THE PROBLEM WAS NOT "COMMON" IT WAS A "KNOWN" ISSUE. NEVER SUGGESTED THIS WAS SOMETHING TO LOOK AT ANY OTHER TIME THE CAR WAS IN FOR SERVICE. HAD TO REPLACE THE SHIFT GEAR. COST $450 INITIALLY, BUT AFTER COMPLAINING, THEY TOOK OFF ABOUT $100. WAS TOLD THAT THIS IS NOT COVERED BY POWER TRAIN WARRANTY EVEN THOUGH NHTSA DEFINES POWER TRAIN AS INCLUDING "SHIFT LEVER/GEAR CONTROL AND INDICATOR DEVICES." THERE IS A TSB OUT ON THIS PROBLEM AND MANY NHTSA COMPLAINTS AS WELL AS CHEVROLET MESSAGE BOARDS. CAR HAS ONLY 16,000 MILES ON IT.

NHTSA ODI 11228301