What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

When I put the car in park and try to turn the car off the Shift Park message comes on preventing me from cutting the car completely off. I put in back in drive or reverse then back in park it still dings and shows the message. I takes a number of repeating these steps for it to stop and turn off and this is happening every time I'm trying to turn the car off.

NHTSA ODI 11668474

The contact owns a 2016 Chevrolet Malibu. The contact stated that while shifting into park(P), the vehicle failed to recognize that the transmission was in park(P). The contact had to manipulate and maneuver the gear shifter several times before the vehicle recognized that the gear shifter was in park(P). The message to "Shift-to Park" was illuminated. While receiving a routine oil change, the vehicle failed to start. The mechanic charged the battery; however, the vehicle failed to start. The vehicle was inspected, and it was determined that the was experiencing the "Shift to Park" failure. The contact found information of NHTSA Campaign Number: 16V502000 (Electrical System, Power Train); and linked the failure to the recall. The dealer was contacted and confirmed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 72,000.

NHTSA ODI 11667071

Stability track warning randomly appears while driving and spontaneously causes total brake failure and the brakes fail to slow or stop vehicle. It has newer brakes but it’s very dangerous to drive. Currently being sent to Chevrolet dealership

NHTSA ODI 11666586

I am filing a complaint regarding ongoing and worsening issues with my Chevrolet vehicle, which appear to point to broader defects involving the engine and electrical systems. Months ago, while driving, the car suddenly lost power and displayed "Engine Power Reduced." I had to keep using it due to work needs. Over time, it hesitated more during acceleration and felt increasingly unsafe. When I finally brought it to a Chevrolet service center, I was told the issue involved the pistons. The vehicle also regularly shows a "Shift to Park" warning even when the gear is in Park, raising concerns about the transmission's reliability. The power loss continues, especially when going uphill — again triggering the "Engine Power Reduced" alert and dropping the speed to no more than 35 MPH. A diagnostic showed a P0302 code for a cylinder 2 misfire. The radio head unit, already replaced once under warranty, failed again after just 9 months. Prior to the worsening idle and gear issues, I also received network-related codes involving the ECM and transmission computers. Although I’ve replaced the alternator, the car still shows "Service Electric System" warnings, suggesting ongoing electrical problems. I also noticed GM’s N182195660 campaign involving predictive monitoring for Stochastic Pre-Ignition (SPI) on SCP platforms. My car has the 2.0L turbo engine, and I’m concerned it may be experiencing SPI or coolant intrusion issues affecting overall performance and system integrity. I’m requesting that Chevrolet investigate these problems thoroughly and determine whether my vehicle qualifies for recall, extended warranty, or defect coverage. These issues are persistent, serious, and deserve immediate attention. Thank you for your time. I hope to see resolution soon.

NHTSA ODI 11663745

Shift to park message and park not fully engaging. This caused the vehicle to roll back when parked on an incline.

NHTSA ODI 11663473

Took my car to Chevy dealership to diagnose my car, as it was rough idling, causing hesitation, and knocking... all while the check engine light was on. They showed me two codes my car was giving from the check engine light. They said he would look further into it. They told me I needed a tune up, though I had gotten a tune up 4 months prior. They fixed some things and charged me over $4,000. The day I drove off the lot, the problems were still present. On my way home going about 50 mph, my car slowed down and the engine reduced power illuminated. I kept driving because I needed a car for work. The car continued to decline and acted like it didn't want to accelerate when pressing the gas. I finally took it back into chevy, and they told me it was my pistons. I'm 90% sure there is a defect that they won't tell me about, or the won't fix. I've had the car 2 years. Now the car won't run.

NHTSA ODI 11659468

To whom it may concern, I am writing to formally report a recurring safety-related issue with my 2016 Chevrolet Malibu. The vehicle consistently displays a “Shift to Park” warning message, even when the gear selector is properly in the Park position. This malfunction prevents the car from turning off completely and poses a serious safety and reliability concern. This issue first occurred while the vehicle was under warranty, and the dealership performed a repair. However, the problem has returned, and my warranty has since expired. Despite the previous fix, the issue continues to persist. This malfunction is widely documented among other 2016–2019 Chevy Malibu owners and appears to stem from a design or manufacturing flaw in the shifter assembly or park switch. I am concerned that this defect could: Prevent the vehicle from being securely parked. Lead to battery drain due to the vehicle not shutting off. Pose a risk if the driver believes the car is in park when it is not. I am requesting that Chevrolet consider this a safety defect and either recall the affected vehicles or offer extended coverage for repairs. I also ask that NHTSA investigate this issue further as it compromises the safety, reliability, and proper functioning of the vehicle. Thank you for your attention to this matter. I would appreciate any assistance or updates regarding how this issue will be addressed. Vehicle Info: 2016 Chevrolet Malibu E2 Year: 2016 Make: Chevrolet Model: Malibu Mileage: 60,000 VIN: ALREADY INSERT Previous repair date(s): 02/21/2020 Sincerely, [XXX] [XXX] [XXX] Toledo, Ohio INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11656608

Vehicle will display on dashboard “Shift to park” while the vehicle is placed in “P”. The engine will turn off, but the power remains on until the battery is disconnected from the vehicle. Codes have been verified by the Chevrolet dealership.

NHTSA ODI 11654899

MY SHIFT TO PARK LIGHT IS COMING ON

NHTSA ODI 11649401

I had my vehicle for about 2 years. I noticed that after I went over a certain amount of mileage, my car went into an engine power reduce mode. With the engine power reduce mode my vehicle could only go 25 mph. This was happening to me when I was driving on major highways, etc.. I would have to pull over and stop the vehicle because after certain amount of time it also would tell me oil pressure low to stop engine. I took it to the Chevy dealership to have it looked at. I got the runaround with trying to figure out exactly what the issue was. They kept telling me that it was something else I spent over $1600 in repairs due to them, telling me that they found the issue and corrected it. After about another week or two, The same issue happened, engine power reduced stop engine oil pressure low. The most dangerous part about it is again I’m driving on interstates heading to work, etc. and the car is slows down on the interstate not allowing me to go over 25 mph again having to pull over on the interstate to give the car a break, crank it back up and get to a safe location. After having multiple mechanics look at it, still unable to fix. It started to get worse where once it pops up engine power reduce, oil pressure low stop engine, the car started jerking & shaking really bad. The only way to stop this from happening is to again shut the car down. I can’t keep shutting the car down in the middle of the interstate and on major roads. I took the vehicle to the Chevy dealership first they couldn’t find the issue. They said it was another issue that wasn’t even the issue so I paid over $1600 for nothing. I took it to Rick Hendrick, who couldn’t find an issue and all they could tell me was to trade it in. This vehicle issue needs to be recalled. My bf is now having the exact same issue that my car was having & after researching, others are as well. Same year, same model, just a different color. This vehicle needs to be recalled for this ongoing safety issue ASAP!

NHTSA ODI 11635330

The check engine light came on and we brought it to the shop where they said the code is for the electronic brake system modulator. It is also causing the ABS to malfunction and be hypersensitive. There is a recall for the same make/model/year of vehicle, except the month before her car was manufactured. I believe this is a safety issue that needs to be looked into and that her car should also be a part of this recall. We purchased the car in mid November and the engine light showed up a couple weeks later. I contacted GM who said to contact this site to request further investigation for safety risks.

NHTSA ODI 11635349

I am writing to formally lodge a complaint regarding an ongoing issue I have encountered with my 2016 Chevrolet Malibu. Recently, I experienced a significant problem with the vehicle’s trunk and rear seat release mechanism, which has made it impossible for me to access the trunk or fold down the rear seats. The specific issues I am facing are as follows: Trunk Latch Stuck: The trunk latch has become stuck, and I am unable to open the trunk manually or with the remote key fob. The latch mechanism appears to be malfunctioning, and it will not unlatch when attempting to open it. Remote Key Fob Failure: The remote key fob, which is typically used to release the trunk, no longer works, making it impossible to access the trunk from outside the vehicle. Seat Release Mechanism: Additionally, the release button for folding down the rear seats is also not functioning, and I cannot lower the seats from inside the cabin. Typically, this release mechanism can be accessed from the trunk; however, due to the trunk being inaccessible, I am unable to release the seats, which is an urgent issue. This situation is highly inconvenient and concerning, as I rely on the trunk and rear seats for storage and daily functionality. The inability to access the trunk or fold down the seats creates a major safety and usability issue, especially in situations where I need access to the trunk in emergencies. I kindly request that this issue be investigated and resolved as soon as possible. Ideally, I would like to have the trunk latch mechanism repaired and the seat release system fixed so that I can safely and reliably use my vehicle. Please let me know how we can proceed to address this matter, whether through an inspection, repair, or replacement of the defective components. Thank you for your prompt attention to this complaint. I look forward to your swift response and resolution to ensure that my vehicle remains functional and accessible.

NHTSA ODI 11634960

The car has a seat belt electrical problem it makes sound once in a while indicating for the driver to put their seat belt on. Also there is issues with the brake sensor. The #1 issue is the Transmission Accumulator Pressure Pipe, when it breaks all your transmission oil pours out from the bottom of the vehicle. The part is about $20 but if not installed right you will think that your transmission is dead but it's not.

NHTSA ODI 11629477

I experienced a check engine light and a "reduced engine power" message in the middle of traffic in the stromy rain. I was driving 35 to 40 mph before vehicle slowed to almost a stop and when pressed gas pedal it excel slowly creeped to less than 30 MPH THANKFUL I wasn't rear-ended.Pulled into nearest Autozone part store and diagnostic scan showed the P2138 code. DC severity, sensor, and accelerator pedal position - see photos attached. Waited with engine off for approx over 30 minutes then started vehicle , engine lght off and proceeded to my destination excell with no issues.This has happened several times since purchase of vehicle began 2019. Throttle body repairs, ECM replacements and harness repairs later still reoccurring documented at dealships and repair shops. This is a serious and costly hazard.

NHTSA ODI 11615368

There’s a warning on the display that says ‘shift to park’ while the vehicle is already in park. This is causing the battery to drain/die and needs jumpstart everyday. Battery was tested and does not need to be replaced. I’m surprised this hasn’t been recalled yet. Online search ‘Chevy Malibu shift to park’ shows this is a common problem. Here’s a YouTube link that includes comments to prove this further. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11611028

The electrical chip in my EBCM has a malfunction and the brakes will grab and grind at random times. Also at the time electronic stability control will mess up increasing the risk of a crash. Other malibu vehicles with the same year have had a recall on these parts. Mine however was not included but has the same malfunctioning part.

NHTSA ODI 11607420

“Shift to park” intermittently indicated when vehicle is in park. Power will not shut off while indicated. Was repaired twice but has returned

NHTSA ODI 11604866

On may 23,2024 I was on a very busy highway going 66. All of a sudden my 2016 malibu lt aburtely slowed to 27 miles an hour and two warnings lights came on 1 -engine power is reduced 2 - speed reduced to 27 I barely avoided getting hit by two semi trucks, as well as a car. The car is available for inspection on request. An independent service person confirmed it was indeed a defective electron control and acceleration peddle position sensor. How very irresponsible of you not to put out a recall on the 2016-2018 models knowing very well of the many class action law suits that have arrived from this issue. I probably can guarantee none of you own a Malibu. How very incredious it is that you put people lives in danger knowing that there was issues with the problem. Unbelievable. I almost got killed because of the lack of responsibility because you dint make a recall.

NHTSA ODI 11590824

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, the vehicle independently engine seized and the check engine warning light illuminated. In addition, the contact stated that the battery would not stay charged. The vehicle was taken to an independent mechanic where it was diagnosed with a no-start dead battery. The vehicle was not repaired. The contact was informed of TSB 16-NA-209 in which the failure description was similar to that of the contact's vehicle. The contact was advised to take the vehicle to the dealer for repair. The dealer was contacted and made aware of the failure and the vehicle had a scheduled service appointment. The manufacturer was not made aware of the failure. The failure mileage was approximately 176,000.

NHTSA ODI 11590140

My car was started shaking really bad and the stabili trak sensor came on. My engine had to be replaced in February 2023. My car was at 66K miles. I rarely drove it. I worked from home for 3 years due to the pandemic. I purchased the car with about 12K miles. I was on my way home and my car just shut off. I could not get it to start at all. The stabili trak light came on. This was in January 2024 with 75K miles. The tow truck driver told me he had picked up multiple Chevrolets experiencing this same issue. It took the dealership almost two months to figure out that the crank sensor needed to be replaced.

NHTSA ODI 11585903

The contact owns a 2016 Chevrolet Malibu. The contact stated that while attempting to park the vehicle, an alarm sounded and the message "Shift to Park" was displayed. After turning off and restarting the vehicle, the vehicle operated as needed. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 16V502000 (Electrical System, Power Train). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. No assistance was provided. The failure mileage was 40,000.

NHTSA ODI 11583543

I'm adding to a complaint where I have found recall problems in the past on the model and the problem is still there the car shows the car is in park but it shows action is required shift the car to park and it's already in park I have a video I can't upload it.i purchased the car august 2023 for 28000 with a extended warranty that isn't right Hopefully someone will investigate.

NHTSA ODI 11583172

I bought this car August 2013 and I have been constantly having issues with it I contacted the BBB they showed them a check off list of the problem I was having to quiet them I was having rear in issues that they claim they did a full exspection of the vehicle which isn't true they tried to give me excuses now the car shows it's in part but it's saying action is required the car isn't in parking made a video on my phone so they can't make a excuse this should be a recall because I have read reviews with people having the same problem not once but two times after the first repair and it's not fair to the consumer someone need to investigate the dealerships.I can't get my video to upload I do have a short video on my cell phone

NHTSA ODI 11581998

When the auto shutdown feature on the car turns off the engine at a stop light; stop sign; or other reason, sometimes the cars entire electrical system shuts down. This happened twice to me. Once at a stoplight and once when freeway traffic came to a sudden stop. You cannot open the electrical trunk to get hazard lights or jumper cables; cannot get the car out of gear or out of park to move it safely out of traffic; cannot turn car hazard lights on; or even unlock a door that is locked. On freeway incident, I was in the middle of 3 lanes and traffic quickly got back up to ~60 mph. Fortunately, I was able to get out of the car and a few hundred feet away in case someone hit my car. This happened during the day and I cannot imagine how someone would see a stalled vehicle in the middle of the freeway in the dark with enough time to stop. My battery was brand new and in perfect order. The dealership said it is a known issue and they no longer sell cars with this auto shutoff feature.

NHTSA ODI 11578294

I am very upset right because I purchased this Chevy Malibu 2016 from Vroom. It was fine at first and then things start to go downhill. For starters my tire light came on first only a week after having the car, then the shift into was appearing on the dashboard as well as the engine light. Then my husband spent almost 2000 on the brakes because the car was making this horrible sound and I almost couldn't stop the car because the pedal was stuck and would not push down. Thank God no one was hurt. Then my car just shut off twice one day at a busy intersection, it went completely dead with my children in the car. This is a ongoing issue. Now I had a diagnostic test ran on my vehicle and it was said I needed a new motor only after having the car for only a year. This car is very dangerous and I wish they would take it off the market, because it will also reduce your speed while driving out of nowhere. Chevrolet should be responsible for all problems before they are aware of these issues!

NHTSA ODI 11571862