What 123 owners told NHTSA about the 2015 Volkswagen Golf R

The chrome plastic trim coating on the START/STOP button and also the steering wheel have peeled and are razor sharp. I cut myself badly on both pieces on my right fore fingertip and middle ring finger. I try to avoid placing my hand accross the horn of the steering wheel since this happened, but the trim there is very dangerously sharp. There is a recall on the same trim on 2017 cars (Service Action 34L9), but the VW dealer told me there was not on my vehicle.

NHTSA ODI 11669266

I brought my 2015 Volkswagen (with only 50,000 miles) to Island Volkswagen in NY for a fuel system recall repair. Before this, the car had no fuel smell, no leaks, and was driving normally. Immediately after the recall work, I began smelling fuel. The dealership told me the fuel line is leaking and needs to be replaced. I never had this issue before, and it’s clearly related to the repair they performed. I’m now being told I must pay $550 out of pocket for something I believe was caused by their handling of the fuel system during the recall. This is a serious safety concern. If I drive this car and something goes wrong, it could result in a fire. I believe this issue deserves review, especially if other drivers experience similar problems after this recall.

NHTSA ODI 11653103

The contact owns a 2015 Volkswagen Golf. The contact stated while driving at an undisclosed speed, the fuel gauge level dropped quickly, and there was an abnormal fuel odor before the vehicle shutoff in the middle of the roadway. The contact stated that the check engine warning light was illuminated. The contact exited the vehicle and push the vehicle to the side of the road. The contact stated that while checking underneath the vehicle, the contact became aware of a fuel leak. The vehicle was towed to an independent mechanic to be diagnosed. The independent mechanic confirmed the fuel leak and referred the contact to the dealer for assistance with the repair. The vehicle was not yet repaired. The contact referenced NHTSA Campaign Number: 24V110000 (FUEL SYSTEM, GASOLINE) as a possible cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 111,000.

NHTSA ODI 11626162

When I turn on the ignition it says on the screen Starting system fault please service the vehicle.

NHTSA ODI 11621842

I was driving to my grandparents house and once i got to the house there was gasoline dripping from the back of car, from the area of the tank. "61821 SE VERIFICO UNIDAD CON LIQUEO DE GASOLINA , SE VERIFICO Y SE ENCONTRO CHARCOL CANISTER LLENO DE GASOLINA , SE HIZO TEST PLAN Y SE ENCONTRO VALVULA INTERNA DEL TANQUE DE LA GASOLINA TRANCADA Y ESTO OCASIONANDO LIQUEO DE GASOLINA , SE REMOVIO Y SE INSTALO TANQUE DE GASOLINA NUEVO Y CANISTER DE LOS GASES NUEVO Y VALVULA N80 NUEVA Y SE LIMPIARON TODAS LAS LINES DEL SISTEMA , SE HIZO TEST Y NO PRESENTO LIQUEO DE GASOLINA" - Mecanic

NHTSA ODI 11609559

Vehicle had recall for "leaking fuel fire risk" Strong smell of fuel inside car. Manufacturer recall #20UF NHTSA recall 24V110 There has not been a fix yet available. Dealer (Team Volkswagen Merrillville IN) replaced the Jet fuel pump. Problem continued, VW engineering said bring the car back and replace the entire fuel tank. Completed. Problem returned 2 weeks later (XXX). While driving home from work noticed extremely strong fuel odor in car. Pulled off in a store parking lot, someone ran up and told me my car was leaking fuel. Gas was literally pouring out, I lost 1/4 tank of fuel on way home. The fuel was leaking under hood, under fuel tank area and under the rear passenger seat. I had the car towed to the dealer. Volkswagen does not have an actual fix for the problem. I should be given a replacement car due to Volkswagen being unable to correct this serious safety issue. What should I do, I am afraid to take the car back. I have videos and several pictures but unable to upload onto this website. Call [XXX] Crown Point Indiana INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11604416

The contact owns a 2015 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while refueling the vehicle, there was fuel leaking from the vehicle, making it impossible to fill the fuel tank. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 73,780. VIN tool confirms parts not available.

NHTSA ODI 11600861

The hood release doesn’t work and cannot access anything in the engine bay. No oil changes until the hood can be opened. Clear recall due to the danger of not being able to open. The handle inside the car broke by attempting to open the hood.

NHTSA ODI 11599200

The contact owns a 2015 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was made aware of the issue and informed the contact that a second notice would be mailed when parts became available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11585517

Thermostat/water pump housing leaking coolant at 20,000 miles. No damage to vehicle that caused this, seems to be a common issue with VW Golfs. The repair is out of pocket and the dealership which sold me the car only a year ago is quoting $1600.

NHTSA ODI 11577119

The contact owns a 2015 Volkswagen Golf. The contact stated that while driving at an undisclosed speed, the stick shift was inoperable. The vehicle was taken to the dealer where it was diagnosed with a failed rear axle and coil springs. The contact was informed that the rear axle and coil springs needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 50,000.

NHTSA ODI 11577150

Leaking sunroof !!!!!!!

NHTSA ODI 11575002

There is a crack and leak in my sunroof. I have not done anything to my car that would result in the crack. Based on Reddit searches, this is a frequent problem for VW owners. Autobody shops do not want to touch my sunroof or fix it because they do not have success fixing sunroofs.

NHTSA ODI 11573889

I smelled a strong odor coming from the heater that turned out to be burnt plastic and wiring associated with the auxiliary heater. This is an obvious fire/ smoke hazard that could have been deadly if other nearby components caught fire.

NHTSA ODI 11556818

Thermostat housing and water pump are leaking coolant. It is available for inspection. It can cause my engine to overheat and/or fail while being used. It has been confirmed by a dealership. It has not been inspected by the police, manufacturer, or insurance company. There have been occasional reports of low coolant, and the coolant drains significantly faster than expected especially in cold weather (e.g. needing to fill coolant every 7 days). It was first repaired in 2019, and has since failed again.

NHTSA ODI 11549044

While normally driving on the street, I noticed that the car started to overheat and could hear the radiator working to keep the heat level normal. I stopped and did not notice any leaks and added coolant to the car after I left it cool for about 3 hours. The problem went away but i still took it to the dealership and i was told it might be the head gasket of the engine or thermostat/waterpump, a $4000 repair. Was advised to just sell the car. VW should address this issue as it has been a long issue now

NHTSA ODI 11541025

Driving on thruway at 65 when the left rear coil spring broke. There was a loud bang and pieces of the spring exited out onto the highway where several vehicles ran over them before they bounced off the road.

NHTSA ODI 11532637

I was putting gas and it started shooting out gas from the tank fuel. I had filled up 2 gallons and the entire two gallons ended up on the floor of the gas station. I took the car to an old Volkswagen specialist and he suggested I get an evap system smoke test to determine what the problem is. I did the test and it came back as a faulty evap canister. That the evap vent valve is stuck closed and purge is allowing fuel into the canister. So I bought an oem canister and replaced the old one. For one day the car drove fine with no issue putting gas or any leaks. The next day I noticed the smell of gas and saw that it was leaking gas from behind the rear wheel. I took it to a local mechanic and the car leaked the remaining 60 miles of gas on the floor. Also the new canister is filled with gas again.

NHTSA ODI 11526988

Over the last two months, I've had over 30 incidences where the car will either randomly shift extremely hard into a gear or will hesitate, stutter, lose power while accelerating. Some of the shifts have been so hard that they've thrown me forward. Some of the losses of power are extremely dangerous as I'm accelerating at highway speeds. I have a full log of at least 30 of these incidents (and detailed as best I could) and they are attached. I picked May 11th because that was the hardest shift/loss of power which caused me the greatest harm. I've been able to reproduce the errors in drive, sport, and Tiptronic mode. The errors occur in all gears, but are most common in 2nd and 3rd (although the higher gears are involved as well), which leads me to believe it's not the transmission, yet the mechatronics unit or something outside of the transmission and engine itself. The troubling issue here is that the car is recording absolutely zero fault codes for diagnosis; that is, the car is shifting, stuttering, hesitating randomly and erratically and no diagnostics are being provided to resolve the issue. Technicians are able to guess what the issue is, but cannot give a guarantee what the problem is without the fault codes. This is the greatest safety concern, but luckily no crashes so far. I was interested to learn that there was a recall on the same model by the Australian government related to the pressure accumulator and I'd like to see if this could be the issue, since I'm experiencing the same symptoms as those described in the recall: https://www.vehiclerecalls.gov.au/recalls/rec-005369. The contact stated that the loss of power issue still persists. The contact stated the issue is a faulty crank trigger.

NHTSA ODI 11525100

Discovered several inches of water in the spare tire boot area. The entire back seat was also soaked through. Water appears to be leaking into the car from rear pressure vents behind the bumper or from another undetermined source, posing risks including black mold and damage to the spare tire.

NHTSA ODI 11515575

Left rear coil spring failed and is not available for inspection. The car was difficult to control when the spring failed which put driver safety at risk. The car was brought to an independent service center and confirmed that the failure was a left rear coil spring which required replacing both the left and right rear coil springs. The component was not inspected by the manufacturer. There were no warning signs or symptoms of the problem prior to failure. The car suddenly start making a loud noise in the rear left section of the vehicle while driving.

NHTSA ODI 11515691

The frame and track of the sun roof has developed a crack. It is available for inspection upon request. Because the frame/track developed a crack in the structural material, I can hear it rattling when I drive, which tells me it is loose. A loose sun roof structural system is not good, as driving on a freeway / highway at a higher speed could possibly cause the sun roof to become detached and fly off of the vehicle, or dislodge enough to distract the driver. Another secondary problem that has happened because of this loose, cracked sun roof track/frame, is that water has now been leaking into the car (possibly causing mold and condensation which has fogged up the windshield while driving) and slippery conditions all over the track/frame. This water drips through the overhead electrical panel, the headliner and down into the speakers. This can cause an electrical shortage in the vehicle, or shock. Water dripping into the car while driving on a rainy day on the freeway, can cause major distraction to the driver in dangerous conditions. The vehicle and sun roof issue have been inspected by the VW dealer, auto shop, and insurance. The VW dealer did tell me they have this issue often for these same models (they were fixing one as i was talking to them) and I have seen lawsuits online for this same issue. The car has never warned me about this issue, there are no warning lamps or messages pertaining to this. Nothing has ever severely impacted the car to cause this problem (It has never been in an accident). Please note, I have not used / opened / activated / operated this sun roof since this issue began back in December 2021. Car Insurance has offered to pay for a new headliner, but not for sun roof repair. The lifetime warranty has declined to pay for the repair because water has been involved (even though water is a secondary issue to the initial issue of a crack developing in the sun roof track/frame under normal dry warm conditions).

NHTSA ODI 11514261

Clock spring issue in VW golf’s should re reinvestigated. These are failing on these cars and companies are not looking into fixes or warranty help for these devices that should last. It’s shortsighted for consumers to continue to deal with this issue.

NHTSA ODI 11508805

The contact owns a 2015 Volkswagen Golf. The contact noticed that the fuel pump would frequent stop while fueling the vehicle. The contact then stated that while his vehicle was being driven by a valet, fuel began to pour out of the fuel tank while on an incline. The valet attendant managed to drive the vehicle down a decline which stopped the leak. Despite the failure, the contact was able to drive the vehicle home. The vehicle was then driven to a dealer where a diagnostic test was performed. The dealer informed the contact that the suction pump, seal, and emission filter needed to be replaced. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine and Engine Cooling) however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed him that the vehicle was no longer under warranty. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 115,000.

NHTSA ODI 11495757

Loss of coolant due to cheap plastic housing leads to damage to the thermostat and water pump. Researching the forums on this issue has shown that it's a common problem with the vehicle that Volkswagen hasn't addressed.

NHTSA ODI 11495289