What 647 owners told NHTSA about the 2015 Tesla Model S 60

The contact owns a 2015 Tesla Model S. The contact stated that the liquid crystal display was leaking from the instrument panel causing a glare while driving. The dealer was contacted and informed the contact that the instrument panel needed to be replaced at his expense. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 92,000.

NHTSA ODI 11471891

Tesla Refused honey my warranty! My car stopped charging fully. Would only charge to 23%. Took it to Tesla, they said a row of battery not functioning correctly and since the battery is under warranty until 12/2/2023 I would not be charged. But, Left car with Tesla Service on 6/7/22 for warranty battery replacement as confirmed by Tesla same day with no charge to customer per warranty item. On 6/23/22, car is but Myra Vasquez and Tesla informed that I would have to pay 1432.10 to fix and retrieve my car after which I reminded them the original reason for the service is under warranty and I should not pay anything per Tesla Service on 6/7/22. Warranty expires 12/2/2023 so I am well within my rights. Under duress and to be able to retrieve my car I had to agree to the service or would have not way to go to work or take my children to school.

NHTSA ODI 11470988

The contact owns a 2015 Tesla Model S. The contact stated that the backup camera functioned intermittently and on other occasions, the image would remain frozen on the screen. The contact also stated that the MCU Unit failed and went blank on several occasions. While driving on some occasions, the MCU Unit would reboot. In addition, the defroster and turn signal chimes failed to function. The failure had gotten progressively worse. The vehicle was taken to the dealer where the vehicle was serviced under NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting) however, the failure persisted. The service center offered the contact a special offer of $2,000 for an Entertainment System Upgrade (NVIDIA Tegra 3 to Intel Atom Processor). The contact declined and Tesla acknowledged that there was a known issue with NVIDIA Tegra 3 Processor in the MCU and that an upgrade to the NVIDIA Tegra 3 would resolve the known failure. The contact was concerned that the backup camera failure might result in a crash with another vehicle or pedestrian. The vehicle had been taken to the dealer on three separate occasions and on each occasion, the vehicle remained in their possession for approximately 2 weeks. The manufacturer was not notified of the failure. The failure mileage was 80,000.

NHTSA ODI 11467373

Rear drive unit failure Failed while driving, letters turned red and car became unresponsive. Car later became responsive between 3-10 seconds. Has occurred 5 times in a week. Dealer claims moisture to drive unit is what caused it and repair was covered under warranty except the harness attached to it, dealer charged me $599 for the harness. If seals are failing and allowing moisture to happen, which then leads vehicles to be unresponsive while driving is a huge risk. Please look into this, there are others online with the same issue

NHTSA ODI 11467049

This appears to be a common problem as seen in the forums. But suddenly my steering locks at intervals when turning. Feels like the power steering went out and is very jerky. Requires a lot of force to turn the wheel. Sticks and then is loose. Apparently cause by a steering column or Lower U-joint when exposed to salt roads in northern snow climates. Also it appears Tesla has replaced this part with a covering preventing this from rusting and filling up with dirt and grime. My car does not have this feature. Hopefully the car does not lose steering completely or fail before my next appointment on June 9th. I called roadside assistance and they said to try a reset. That didn’t work.

NHTSA ODI 11465864

The contact owns a 2015 Tesla Model S. The contact stated that upon starting the vehicle, the air bag warning illuminated. The vehicle was taken to a Tesla Service Center where it was diagnosed that the front passenger’s side knee air bag was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 102,057.

NHTSA ODI 11465762

The contact owns a 2015 Tesla Model S. The contact stated that the camera behind the rearview mirror overheated after driving for approximately 6 hours. Additionally, the other cameras became inoperable. The auto pilot lost vision of the line and drove over the line. The contact stated that the auto connection disconnected. The contact stated that after the computer cooled down the system operated as designed. The vehicle was taken to the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000. The consumer stated he resolved the issue. The problem was a faulty cable.

NHTSA ODI 11461648

The contact owns a 2015 Tesla Model S. The contact stated that while attempting to start the vehicle, the vehicle took 5 – 10 minutes to be started. The contact stated that the doors and apps were inoperable. The contact stated that there were several error messages displayed. The contact was concerned about the vehicle stalling. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 73,000. The VIN was not available.

NHTSA ODI 11459887

The contact owns a 2015 Tesla Model S. The vehicle had previously been serviced under NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lightning) however, the failure occurred after the recall was repaired. The contact stated that while driving at an 60 mph, the center display screen went black and then rebooted, causing the defroster, the rearview camera display, and the navigational system to become inoperable. The auto pilot function and other unknown warning messages were displayed. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000. When he reported the failure to Tesla, they believe a firmware update in the near future should fix this problem.

NHTSA ODI 11459567

I am from Florida and was passing through Vegas. The time was about 9:41 pm. I was on my way from Las Vegas, NV and I charged the car to 90% and was on my way to the Kingman, AZ Supercharger (Traveling on U.S. 93). The car was at 32% at the bottom of the mountain (Approx +3400ft). The cars indicators showed arrival to Kingman supercharger @ 31%. However, while reaching near the Cerbat Foothills Recreation Area (Approx +4000ft - so approx gradual 600ft climb). The car started to alert me that I needed to pull over as there is no more power. The car still showed 30% power remaining and approx 23 miles. The destination was 2.7 miles (5 min) away. The car drove for about 20 - 50ft then lost the ability to accelerate. I put my hazards on and had to cut drivers off to get over to the right shoulder (No shoulder on left) before it stopped rolling uphill. There were also no street lights (very dark) and the cell signal was very weak. I was able to call Tesla roadside who saw remotely that the car had 38% remaining power. The battery immediately started dropping quickly while talking to him. The car refused to start/go into neutral when the tow company came. We had it taken back to Vegas where it took Tesla over a month to acquire a replacement battery. I slept in the car and was not provided a loaner for months. Even had to get a job there. While waiting for the repair I discovered the cooling system had issues. Tesla won't say it but I am sure the cooling system failure led to the battery not being cooled and dying. The louvers were all broken, and the compressor needed to be replaced. I mentioned to Tesla long before I did this trip that the AC was making noises and they ignored it multiple times. I even recorded the sounds it made and played it for them. I have a video and more info than I can fit in here. Even though there is proof of past issues I still am responsible for the cost of their mistakes. In more ways than 1. I spent the holidays and my birthday stuck here.

NHTSA ODI 11459295

I was behind a car at a stop light when a SUV hit me very hard from behind, I hit the car in front of me. My face hit the steering wheel, 2 teeth came out whole, ripped from the gums, one tooth pushed up into my upper jaw. I got a laceration on my lower lip. i hit my forehead left side of my mouth and nose (very swollen, deviates to the right).

NHTSA ODI 11458352

When using auto pilot on the freeway my vehicle sometimes comes to a halting stop for no reason putting myself and passengers in great danger.

NHTSA ODI 11453023

On two or three occasions now my Model S will slow down for no apparent reason while autopilot is engaged. It's happened at speeds between 35 - 45 mph and highway speeds. Problem seems to have started after OTA updates. Car never had this problem before prior to the most recent OTA updates.

NHTSA ODI 11452661

System Failure: Adaptive speed control Safety Risk: My 2015 Tesla Model S, at highway speeds, smashed into the rear of a jacked up Ford F250 Pickup. A Head on collision at highway speeds put my wife (and dog) and I at great risk. Has the problem been reproduced or confirmed by a dealer or independent service center? I am unsure if or how Tesla is dealing with the problem of adaptable speed control failure. Has the vehicle been inspected? Yes. Dan's Paint & Autobody and USAA Insurance Company adjuster My accident happened in the southbound passing lane at mile marker 178 on I-10, south of chandler on the Gila River Community in Maricopa/Pinal County It was dark outside with heavy traffic in both southbound lanes. My software version was 2021.40.6 I had the distance between cars at the closest setting , and had the adaptive speed control set at ~75. I was attentive with both hands on the wheel, eyes forward watching traffic with my wife whom was also watching the traffic. Without warning a Ford F250 stopped hard in front of me and my adaptive speed control did not react. The few beats I gave the adaptive speed control to respond first cost me precious braking time. I did hit my abs brakes and could feel the vibration as they attempted to slow down, but it was too late. I submarined under the bumper of the truck at a very high speed. There was no warning lamps, messages at the time of the accident. There was one early symptom that I recall. There was a Tesla software update a few days before the collision. On 11/27/22 before leaving for my trip, the dash screen to the far left did not display the map which it usually does when you set the GPS to map the path. I rebooted with the steering wheel toggles, and the display returned to normal. There were no other software malfunctions that I recall prior to the adaptive speed control failure.

NHTSA ODI 11450994

When driving above 45 MPH, there is a shuddering sound that comes from the front left of the car. After taking the car in for service, I was told that "the front AFT and Fore links are bad on the car" and need replacement.

NHTSA ODI 11450044

The Navigation system stops and doesn't start. Checking on Google, I see that this has happened to many Tesla Model S owners who have an older model. This is because of a chip store card that fails after 4-6 years. On a long drive, this doesn't take us to the next super charger. This can cause the car to stop suddenly when it runs out of charge, and create risk for drivers and for other vehicles on the road too. The navigation is important on Teslas to know that one can safely complete her journey without running out of charge.

NHTSA ODI 11449716

I was driving on a street and needed to stop fast to avoid rear ending a stopped car. The control arm of my car broke. There was no debris on the road and I didn't hit anything. My car was towed to a Tesla Service center and they replaced both control arms (per the service person) and charged me only $200.

NHTSA ODI 11449836

The contact owns a 2015 Tesla Model S. The contact received notification of NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer had not been made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11448586

The current mcu is useless. Freezes and restarts. It's really slow to utilize

NHTSA ODI 11447266

No early alert before slamming on the brakes, only tapping a rear bumper on a 1999 Toyota Tundra. No damage to the Toyota but to my surprise, the insurance company said the Tesla's totaled. The airbags for the driver were deployed only, with no other passengers in the car. Quite a loud noise. I have an EDR report, not sure how to interpret it. Did not hear any warning lamps. Fortunately, both the other driver and I suffered no injuries. I would like to find out exactly what happened.

NHTSA ODI 11444605

Front right suspension lower forelink sheered apart while backing out of a parking space.

NHTSA ODI 11443494

Driver seat and passenger seat rocks when accelerating or braking. The seats can become loose in the event of impact from being loose in the housing. The problem has been inspected and acknowledged by Tesla service center and have unsuccessfully tried to repair the vehicle. The issue has not not been fixed after multiple visit to Tesla regarding the same issue.

NHTSA ODI 11442132

The car will issue a BMS_w035 warning which is connected to the battery heater failing/failed. In this case, the car may not restart, per Tesla's on-screen warning. If this occurs while driving, or in stop-and-go traffic, this could lead to a dangerous situation of not being able to remove the car from the road safely without a tow truck. From recent incidents online, this is occurring in many 2014-2016 Model S vehicles with the colder weather change.

NHTSA ODI 11442097

A recall for my main media control unit was announced in March 2021. I have STILL not received the replacement unit from Tesla. My main screen goes black while driving. I lose ability to control HVAC, navigation, music, suspension, security etc. I also am unable sometimes to drive the vehicle from standing as the car will "reboot" unexpectedly.

NHTSA ODI 11441664

While I was backing out from my car garage and turn the steering wheel, I heard a squeaking sound while applying a brake on the passenger front tire area. I stopped the car and went out to check, the front passenger tire pretty much pushed all the way back touching the wheel arch liner (see photo). I called tesla and they sent a tow truck to towed it to their service center near by. I didn't realize how wide spread the issue was until I research the problem online. I filed this complaint to solidify with other people which have the same problem.

NHTSA ODI 11441414