What 60 owners told NHTSA about the 2015 Ford Cmax Energi

IT IS ACCELERATING TO FAST AFTER LETTING FOOT OFF GAS PEDAL.

NHTSA ODI 10991067

FOR THE 5TH TIME MY VEHICLE HAS DIED DUE TO A VOLTAGE DRAW ON THE 12V BATTERY. THE VEHICLE HAS BEEN TO THE FORD SERVICE CENTER 5 TIMES THE MOST RECENT FOR 3 WEEKS AND IT STILL FAILS DUE TO A POWER ISSUE. THE VEHICLE IS UNRELIABLE DUE TO FREQUENT ELECTRICAL SYSTEM FAILURES. THE ELECTRICAL SYSTEM FAILURES STARTED ON 2/2/2017, AND CONTINUED THROUGH 3/12/2017, 3/22/2017, 4/3/2017 AND 4/26/2017

NHTSA ODI 10980962

1. ON TAKING A TRIP FROM PANAMA CITY BEACH, FL TO INDIANAPOLIS, IN THIS CMAX WAS PARKED & LOCKED IN THE NORTHWEST FLORIDA BEACHES PARKING LOT AT APPROXIMATELY 9 AM CST 2. AT APPROXIMATELY 4:30 PM EST A TELEPHONE CALL WAS RECEIVED FROM THE AIRPORT POLICE INFORMING ME THAT THE CMAX WAS IN THE PARKING LOT RUNNING WITH THE LIGHTS ON AND I WAS ASKED TO GO TO THE PARKING LOT AND TURN THE AUTOMOBILE OFF. AFTER I INFORMED THE OFFICER THAT I WAS IN INDIANA AND COULD NOT COMPLY WITH THE REQUEST, I PROCEEDED TO MAKE NUMEROUS TELEPHONE CALLS; FORD MOTOR COMPANY, GARY SMITH FORD AND OTHERS IN AN ATTEMPT TO HAVE THE CMAX TURNED OFF BUT WAS TOLD IT COULD NOT BE DONE. I THEN RETURNED OFFICER'S CALL AND ASKED THAT THEY GO TO THE PARKING LOT, BREAK THE DRIVERS WINDOW, AND PRESS THE START/STOP BUTTON TO TURN THE CMAX OFF. THE OFFICER CALLED ME BACK TO INFORM ME THAT WHEN THEY WENT TO THE LOT, THE CMAX WAS NOT RUNNING AND THE LIGHTS WERE OFF. 3. UPON RETURNING TO THE AIRPORT ON 2/8 I HAD TO USE THE KEY TO ACCESS THE CMAX SINCE THE BATTERY WAS DEAD AND THE GAS TANK WAS EMPTY. 4. A JUMPER BATTERY WAS USED AND FUEL WAS ADDED TO ENABLE THE CMAX TO RUN. 5. THIS VEHICLE HAS NUMEROUS INDICATORS, AUDIBLE AND VISUAL TO ALERT THE DRIVER IF EXITING THE VEHICLE WHILE THE CAR IS IN THE RUN MODE. THE EXIT FROM THE CMAX ON 2/2 WAS NORMAL. NOTHING WAS ON. THE LOCKING INDICATION WAS NORMAL AND NO LIGHTS WERE ON ( I KEEP THE HEADLIGHT SWITCH IN THE POSITION WHERE IF THE VEHICLE IS IN THE RUN MODE, THE LIGHTS ARE ON ). THIS PROBLEM HAD TO HAVE BEEN CAUSED BY A SIGNAL FROM AN AIRCRAFT OR A RADIO, RADAR WITH ENOUGH POWER TO BROADCAST SOME DISTANCE. 6. MY CONCERN IS THAT IF THIS TYPE IGNITION SYSTEM CAN BE TURNED ON ACCIDENTALLY, IT COULD ALSO BE TURNED OFF ACCIDENTALLY AND THAT COULD BE DISASTROUS IF THE VEHICLE TURNED OFF WHILE IN MOTION CAUSING THE DRIVER TO LOSE CONTROL.

NHTSA ODI 10954093

TL* THE CONTACT OWNS A 2015 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE DOOR FAILED TO REMAIN SECURELY LOCKED AND OPENED TWICE WITHOUT WARNING. THE DEALER WAS NOTIFIED OF THE FAILURE TWO MONTHS AGO. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THERE WAS NO MANUFACTURER RECALL TO REPAIR THE VEHICLE. THE DEALER PROVIDED NO REPAIR SOLUTION. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES), BUT THE PARTS WERE NOT AVAILABLE. THE NOTICE INDICATED THAT THE PARTS MAY BECOME AVAILABLE IN THE SECOND QUARTER OF 2017. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI 10915510

REVERSE GEAR SETTING ACTUALLY PUT THE CAR IN DRIVE AFTER STARTING THE PARKED CAR ND ATTEMPTING TO BACK OUT OFPARKING SPACE. I TRIED TURNING OFF ENGINE, AND THE SAME THING OCCURRED, THE CAR CONTINUED TO CREEP FORWARD UNTIL THE CAR MADE CONTACT WITH THE PARKING SPACE SIGN. THIS IS NOT A SMALL ISSUE AS 1) IT PROBABLY OCCURRED PREVIOUSLY WITH THE SAME MODEL IN THE SAME FLEET AND LEASER CHARGED ME UPWARD OF FIVE HUNDRED DOLLARS TO FIX VOSMETIC DAMAGE CAUSED WHILE PARALLEL PARKING AND 2) THUS COULD CAUSE BODILY INJURY HAD THE PARKING SPACE NOT BEEN BLOCKED IN FRONT. THESE CARS ARE PART OF A MEMBERSHIP BASED RENTAL FLEET, AND SHOULD BE HIGHLY MAINTAINED. AFTER CONTACTING THE EMERGENCY NUMBER OF THE FLEET LEASER, I WAS A FEW MINUTES LATER ABLE TO REENTER AND START THE CAR, AND THE REVERSE GEAR OPERATED PROPERLY. THE LEASER HAS PREVIOUSLY RAISED MY INSURANCE RATE BASED ON SMALL AMOUNTS OF DAMAGE TO A FLEET VEHICLE INCURRED WHILE PARKING. MY GUESS IS THAT THEY KNOW OF TE PROBLEM AND HAVE CHOSEN TO BLAME THE DRIVERS RATHER THAN THE MANUFACTURERS OR MAINTENANCE ENGINEERS.

NHTSA ODI 10895980

TL* THE CONTACT OWNS A 2015 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE VEHICLE WAS PARKED DURING NINETY DEGREE TEMPERATURE WEATHER WHEN IT WAS NOTICED THAT THE MOON ROOF CRACKED EXTENSIVELY. THE DEALER WAS NOTIFIED AND AT THE DEALER'S REQUEST, THE VEHICLE WAS TAKEN TO THE DEALER'S LOCATION FOR EXAMINATION. THE DEALER INFORMED THE CONTACT THAT THE CRACKS APPEARED TO BE AN IMPACT DAMAGED, STATING THAT SOMETHING MIGHT HAVE HIT THE ROOF AND THAT THE MANUFACTURER WOULD NOT BE RESPONSIBLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 4,000.

NHTSA ODI 10871820

ABOUT A MONTH AGO IN APRIL 2016, I PULLED INTO MY DRIVEWAY AND UPON PRESSING THE BRAKE PEDAL THE CAR SURGED AHEAD AND STRUCK MY GARAGE DOOR, DAMAGING IT. IN THIS INSTANCE I MOVED THE SHIFT LEVER INTO REVERSE TO STOP THE CAR. ON MAY17, 2016 AFTER PICKING UP MY GRANDSON FROM HIS SCHOOL, I EXPERIENCED A SUDDEN UNEXPLAINED ACCELERATION WITH NO DEPRESSION OF THE GAS PEDAL, AND DESPITE DEPRESSING THE BRAKE PEDAL AS HARD AS I COULD, WOULD NOT STOP UNTIL I HIT AND SEVERELY DAMAGED MY CAR AND 2 OTHER CARS, THEN WAS ONLY ABLE TO STOP THE CAR BY MOVING THE SHIFT LEVER INTO PARK. THIS WAS THE 2ND TIME I EXPERIENCED THIS PROBLEM, AND I AM VERY CONCERNED THIS CAN HAPPEN YET AGAIN AND CAUSE EVEN MORE SEVERE DAMAGE AND POSSIBLY INJURY.

NHTSA ODI 10865727

1. REAR WINDOWS OPEN 6 TO 8 INCHES UPON RETURNING TO CAR FROM STORE- HAPPENED 4 TIMES. (SITTING IN PARKING LOTS) 2. CAR ON OVERNIGHT IN GARAGE. GARAGE HAS THE GAS FURNACE AND HEATER 3. DOES NOT STEER WHEN YOU WANT IT TO./ JUST TAKES OFF ON ITS OWN/ CAUSED WRECK. SLOW LEFT TURN. WENT ALL BY ITSELF INTO THE SIDEWALK. 4. DOES NOT TURN OFF OR ON WHEN TOLD TO DO SO/ MOVES AFTER PARKED, EVEN IF FULLY BELTED IN 5. THE SYNC DOES NOT WORK AND NAVIGATION GOT ME LOST TWICE IN LA 6. HUMMING NOISES AND VIBRATION BELOW MY FEET AT SPEED (65 TO 70)

NHTSA ODI 10836817

FOUND CORROSION ON BOTH SIDE STEERING AXLES AND STEERING KNUCKLE AT 17K, TOOK IT TO SUNNYVALE FORD IN CA, THEY GAVE ME THE ANSWER WAS IT'S NORMAL CONDITIONS IT'S BARE METALS , FORD WAS LAYING TO THE CONSUMER, ALSO COOLANT SPILL OUT FROM HIGH VOLTAGE RESERVOIR, DEALERSHIP SAID THOSE ARE NORMAL CONDITIONS NO NEED TO TAKE CARE ABOUT IT ,STEERING WHEEL WAS COCK TO EITHER SIDE FORD DEALERSHIP DOES NOT ABLE TO FIXED STEERING WHEEL ON CENTER, CORROSION FOUND ON EVERY FORD VEHICLE AND IT'S NORMAL, I THINK GOVERNMENT SHOULD STEP IN AND GET A RECALL FOR THOSE ISSUED.

NHTSA ODI 10836867

I WAS MAKING A LEFT TURN. I WAS STRUCK BY A VEHICLE TRAVELING AT A HIGH RATE OF SPEED. THE IMPACT WAS TO THE FRONT PASSENGER SIDE WHEEL. MY VEHICLE WAS SPUN AROUND 45 DEGREES IN THE OPPOSITE DIRECTION AND I WAS TOSSED AROUND IN THE VEHICLE WITH MY SEAT BELT ON. THE CARS COMPUTER DETECTED AN IMPACT SERIOUS ENOUGH TO INITIATE A 911 CALL. NO AIRBAGS DEPLOYED.

NHTSA ODI 10811026