What 202 owners told NHTSA about the 2014 Ram 3500

The contact owns a 2014 Ram 3500. The contact stated that while the contact's husband was driving at an undisclosed speed, the driver's side rear outer tire detached. The vehicle was driven to the shoulder of the road. The contact's husband inspected the vehicle and noticed that only one stud was attached to the wheel, and the wheel was tilted sideways. The vehicle was towed to an independent mechanic, where it was repaired; however, the failure reoccurred. The vehicle was towed to the independent mechanic, who informed the contact that the driver's and passenger's side rear outer tire studs had detached. The vehicle was repaired; however, the failure persisted. The vehicle was towed to an independent mechanic, where the contact was informed that the passenger's side rear outer tire studs had detached again. The vehicle was repaired; however, the contact stated that the rear axle, rims, and rear tire hubs were also damaged. The vehicle was driven to the residence. The contact stated that the failures occurred while hauling horses. The contact referenced an unknown recall with a similar failure description, stating that the vehicle was taken to the dealer three years ago for the recall repair, but the vehicle was only inspected and no repairs were completed. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to take the vehicle to the dealer for inspection. The failure mileage was approximately 120,000.

NHTSA ODI 11748722

Norcold N641.3FL refrigerator (serial #XXX) installed in an Arctic Fox truck camper caught fire on June 2, 2026 due to cooling unit failure. This model is subject to a known Norcold fire risk recall. The unit had not been repaired under the recall. I extinguished the fire myself. I have photographic evidence and have reported the incident to Thetford/Norcold at [XXX] . Norcold LLC filed for Chapter 11 bankruptcy in November 2025 with over 10,500 similar fire-related claims. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11741544

the recall number is 14V-635 or P65\n\nsays electric defect causes fires from heater Year: 2014\nMake: RAM\nModel: 3500\nTrim: N/A\nSeries: N/A

NHTSA ODI 11725649

We were traveling on a highway doing 70mph and the whole truck started to shake really badly. My husband could not steer the vehicle safely, nor could he brake without losing control. He had to slow down until the shaking stopped. When we got back on the road, the vehicle did the same thing three times. This is known issue with Dodge, yet they don't have a fix for it. They call it the "death rattle"

NHTSA ODI 11662921

ABS is not working and no part is available. Towing an RV without trailer brakes is dangerous. The ABS malfunctions at random and we never know when this will happen. ABS control deactivates traction control, as well as trailer breaks, and effects transmission functions as well.

NHTSA ODI 11647288

The heater core in this model with the Cummins motor and of those around the same year plug constantly. I have to flush mine every couple of weeks in cold weather otherwise it will not keep moister off of the inside windows including the windshield as it just blows frigid air. A complete repair is $2,400+ and it will continue to plug even after the repair. It's common to need to frequently pull off of the highway and wipe down the inside glass to keep the windows clear.

NHTSA ODI 11636002

The contact owns a 2014 Ram 3500. The contact stated that while driving 50 MPH, the Electronic Stability Control (ESC) and brake assist warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed that the ABS module had failed and needed to be replaced; however, the part was not available. The dealer informed the contact that the ABS module was under engineering review and there was no estimated availability date for availability. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 63,000.

NHTSA ODI 11624079

The contact owns a 2014 Ram 3500. The contact stated while driving 65 MPH, the "no turbo signal" warning light illuminated, and the vehicle shifted into LIMP Mode. The contact stated that the vehicle slowed to approximately 20 MPH on the highway. The contact pulled over and turned the vehicle off and detached the positive and negative battery terminals. The contact stated that he touched the ends of the cables and reconnected the terminals to the battery and was able to return to normal vehicle functionality. The contact stated that the failure was intermittent but occurred at various speeds. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the turbo actuators needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 116,000.

NHTSA ODI 11612734

The contact owns a 2014 Ram 3500. The contact stated that while operating the vehicle at highway speeds, the steering wheel felt loose, and the steering was unstable, causing the vehicle to become difficult to control. The vehicle was taken to the local dealer who diagnosed that the outboard steering linkage jam nut had become loosened. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V021000 (Steering). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 139,000.

NHTSA ODI 11580109

The V06 Drag Link recall of welding the adjuster doesn't allow a complete front end alignment to be done correctly. If you have had the adjuster welded, you cannot re-center the steering wheel with the adjustments that have been provided by the manufacture. This itself presents a safety issue with the steering wheel now being off centered! I have not had the welding done and have been trying to get the drag link replaced since it has become loose again! Independent repair shops won't touch a RAM truck that has been welded or not do to liability. The replacement parts are now in stock and they should be replaced since the way that RAM says to now do an alignment only allow toe and camber but not re-centering of your steering wheel. I have confirmed that with RAM service. Ram Cares has not helped in this matter. Have a previous Request #1273536 with NHTSA. This is a major safety issue for myself and others on the road. Thank you for your time.

NHTSA ODI 11579928

The contact owns a 2014 Dodge Ram 3500. The contact stated that while driving at an undisclosed speed, the integrated brake controller was activated, however, the vehicle failed to brake as intended. The contact stated that when the brake controller was activated, the trailer trailer brake was inoperable. The contact stated that the failure had been persistent since the vehicle was purchased in 2019. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 10,000.

NHTSA ODI 11578468

this was a recall and all parts broke again . called dealer december 18 2023 and they have no idea what to do .

NHTSA ODI 11560718

My service abs light comes on and off, which makes cruise control inoperable and rear park sensors inoperable. This also makes putting into 4x4 impossible unless I turn off the truck, switch to 4x4, and start it before the sensor kicks off. I’m worried about the abs mainly. I contacted my dealer and they said it’s a common issue but the part is almost $1k and backordordered for months. How is this not a recall or safety issue?

NHTSA ODI 11556897

There was the V06 Drag Link recall which was to weld the drag link solid with no adjustment. I had it inspected on 3 May 19 where they found the nuts not properly torqued. I told them not to weld on the truck as this would cause extra expense to me when having any future work done on the truck. Had contacted Ram Cares to get a replacement drag link installed now that a replacement part is available. That didn't happen as the appointment that I had through Ram Cares couldn't happen without DM notes. There is clucking in the steering again like before and I'm sure it has loosened up again. I confirmed with independent repair shops that they would either not touch it do to welding or charge me additional cost to remove the weld and wouldn't re-weld do to liability. If Ram was willing to supply lifetime alignments for the truck, then no problem. The welding goes against how it's supposed to be fixed. I could be subject to a DOT inspection and truck impounded if there is welding on steering components. I know it's a discretionary rule, But could cost me time, money and other expenses for something that there is the correct replacement part available to fix the manufacture error. Thank you for you time.

NHTSA ODI 11555240

Turbocharger actuator failure. Recognized as known issue for vehicles manufactured one year later (2015). All replacement cost covered by manufacturer and warranty extended. The replacement part for the 2014 RAM 3500 turbocharger actuator is MOPAR part 68481772AA and the replacement part for the 2015 RAM 3500 turbocharger actuator is MOPAR part 68481772AA (identical part numbers). Similarly, the turbocharger installation kits for both model years are identical. Multiple online complaints noted about failures in 2014 model years. I incurred $3000 expense to replace. Two detailed letters sent to manufacturer with no response or acknowledgement of receipt.

NHTSA ODI 11555342

I HAVE 27 OPEN RECALLS, the steering wheel knuckle just keeps getting looser, nothing on the column will tighten, my wipers short out , I was sold a Omission deleted truck with documentation the day of purchase it was omission deleted, I was never told this vehicle was unsafe, The manufacture wants me to pay hundreds of dollars out of pocket for them to see if it maybe safe enough . Both Chysler, and the certified dealership of ford refuse to take any accountability or action

NHTSA ODI 11553257

I was towing my 4 horse lq trailer from Ohio back to Illinois and without warning my whole wheel flew off. Left me stranded for days not to mention the accident I had to avoid when it happened

NHTSA ODI 11552242

1. HCU and ABS. Yes available for inspection. 2. Faulty braking, faulty fuse control, faulty anti skid, electronics began random operations such as radio, gauges flashing and wipers working. 3.Yes. Dealer said bad HCU and ABS. Currently with dealer due to no part availability. 4. No. Dealership inspected. 5. Yes, in June 2022 the service 4wd light came on periodically when driving but when we got it into service it was working fine. July 2023 the lights began flashing, wipers going, warning lights flashing then no lights and the truck died. Had to have it towed to dealer.

NHTSA ODI 11537551

The contact owns a 2014 Ram 3500. The contact stated that while driving at approximately 50 MPH, the rear wheel studs failed. The wheels were stuck underneath the vehicle. The contact was able to pull over to the shoulder and noticed the wheel was bent. The vehicle was towed to the local dealer where it was diagnosed that the front and rear wheel studs needed to be replaced. The vehicle was repaired but the failure recurred. The vehicle was taken back to the local dealer where it was diagnosed that all thirty-two-wheel studs needed to be replaced. The vehicle was repaired but the failure persisted. While driving approximately 50 MPH, in the middle lane, the rear end of the vehicle swayed, and he noticed the tire behind the vehicle. The passenger’s side rear studs fractured, and the wheel detached and struck the median and crossed the highway. There were no reported injuries. The vehicle was towed to the dealer again but was not diagnosed or repaired. The manufacturer was contacted and informed him about the warranty, but no additional assistance was provided. The failure mileage was approximately 298,712.

NHTSA ODI 11523392

ABS light, traction control, cruise control and the 4 wheel drive will not work. Part is on back order and was told November then January and now it’s August. I have a camper that I pull with this truck.

NHTSA ODI 11512262

The Turbo Actuator failed while driving on a two-lane highway without a shoulder to safely pull over. The truck lost power down to a maximum speed of 10mph until I could safely pull off of the highway. The problem has been diagnosed with a OBD2 scanner. No other inspections by police or insurance. The MIL did not turn on until the vehicle was pulled off of the highway and at a stop.

NHTSA ODI 11496786

- Steering linkage jam broke while driving. Not sure if available truck is at dealership - I was unable to steer the vehicle while driving. I could have died and killed multiple people if a car crash had occurred - Dealer has acknowledged they inspected the part but did not perform the recall as it was not cracked. This is not the remedy listed on the NHTSA. - No warning lamps or symptoms

NHTSA ODI 11488068

The contact owns a 2014 Ram 3500. The contact stated while driving 75 MPH, the steering wheel was consistently turning to the left independently. There was no warning light illuminated. The contact veered to the side of the road. The contact stated that upon inspecting the vehicle, he noticed that the front driver’s side wheel was dislocated and turned to the left. The contact stated that upon wiggling the wheel to relocate into the normal position, he noticed that the front track bar bracket had started to detach from the frame. The contact stated that as he readjusted the front wheel, the front track bar bracket was pushed closer to the frame. The vehicle was towed to the residence. The vehicle was then towed to the dealer where it was diagnosed that front track bar bracket needed to be replaced or the entire frame needed to be replaced. The manufacturer was notified of the failure and informed the contact that the vehicle could be repaired under NHTSA Campaign Number: 15V541000 (Steering) however, the dealer advised the contact that the manufacturer denied the request to cover the repair. The vehicle was not repaired. The failure mileage was approximately 300,000.

NHTSA ODI 11486878

The contact owns a 2014 Ram 3500. The contact stated that while towing a trailer filled with horses, the bed had detached from the cab as she pulled into her driveway. When the contact unhooked the trailer, she discovered a 6-inch gap had formed between the cab and the bed of the vehicle. She also discovered cracks on driver’s and passenger’s side frame of the vehicle. The contact called the dealer and was informed that her vehicle was no longer under warranty. No further assistance was provided. The contact then called her insurance provider and was able to drive the vehicle to an independent mechanic for repair. The mechanic replaced the frame and had both sides of the frame steel plated. The manufacturer had yet to be notified of the failure. The vehicle had been repaired. The failure mileage was approximately 80,000.

NHTSA ODI 11458042

The contact owns a 2014 RAM 3500. The contact stated that while driving at 35 MPH, the front end of the vehicle started shaking uncontrollably. There were no warning lights illuminated. The contact stated that as he released the accelerator pedal, the brake exhaust turbo engaged, then he depressed the brake pedal. The contact veered to the side of the road, inspected the vehicle, and noticed that the front support track bar bracket was fractured at the A-frame. The contact became aware that the VIN was included in NHTSA Campaign Number: 15V541000 (Steering) before he owned the vehicle; however, the recall repair was not completed at that time because the vehicle had been lifted. The contact stated that the recall repair had been marked as complete though it was not. The manufacturer was notified of the failure and advised the contact that the recall history showed that a reinforcement bracket was not installed over the front track bar bracket; therefore, the recall was not completed. The contact stated that he used a strap and tied the front end of the vehicle and then drove to the dealer that was 1.2 miles away. The dealer diagnosed that the front support track bar bracket was fractured. The dealer informed the contact that the recall repair could not be complete because the previous owner had lifted the vehicle. The dealer submitted a report to the manufacturer stating the recall repair for NHTSA Campaign Number: 15V541000 (Steering) was incomplete because the vehicle had been lifted. The manufacturer updated the recall repair from "Completed" to "Inspected" in the vehicle recall history. The contact drove the vehicle to his hotel. The vehicle was towed to the contact's residence in Florida. The contact stated that the recall repair was not completed on Power Wagon vehicles or vehicles that were lifted by the owners. The vehicle was not repaired. The failure mileage was approximately 60,000.

NHTSA ODI 11446334