What 46 owners told NHTSA about the 2014 Mini Cooper S Clubman

The contact owns a 2014 Mini Cooper. The contact stated that the front driver's side and passenger’s side doors and windows failed to properly close. The vehicle was taken to the local mechanic who diagnosed the vehicle and determined that the failure was caused by a faulty foot well module which caused the electrical power windows to malfunction and the doors to not properly close. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 23V337000 (ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 80,000.

NHTSA ODI 11645104

Engine motor mount sheared, allowing motor to interact with and bounce directly on the frame, and stressing the other connections and components. Dealer indicated this is a very common problem for this car model and is likely a design issue, and even had another example of a sheared mount on display in order to show others with the same issue.

NHTSA ODI 11549149

The fuse box JBE module has a Quality Assurance problem with a solder connection to the NEC low pressure fuel relay. This is a known issue with BMW/Mini. The car suddenly stalls without warning. If the driver is not keen or if traffic patterns do not allow, the car can be left in very dangerous situations on the highway or in the middle of intersection. The repair for this problem is widely distributed online via blogs and YouTube, but replacement modules are $1500 (part only) and these modules are not available until at least October 2023. There are no warning lights or other warnings prior to the incident. While I am not aware of any serious injuries, it is only a matter of time before someone is t-boned at an intersections. This part MUST be immediately recalled due to the safety risk. The images below show the JBE fuse box housing as well as the PCB where the cold solder joint can be seen. I have circled the cold solder joint in the close up picture.

NHTSA ODI 11537267

The contact owns a 2014 Mini Cooper. The contact stated that while driving approximately 25 mph, there was smoke detected from the vehicle. The vehicle caught fire without warning. There were no reported injuries, air bag deployment, or crash. The fire department distinguished the fire. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to a lot. The manufacturer was not notified of the failure. The failure mileage was approximately 84,700.

NHTSA ODI 11473561

PASSENGER AIRBAG SENSOR ISSUE, I HAVE SEEN THIS REPORTED IN OTHER MINI COOPERS THAT WERE RECALLED BUT MY SPECIFIC MODEL WAS NOT. I WANT TO BE SURE ALL APPLICABLE VEHICLES ARE INCLUDED IN THE RECALL FOR THE SAFETY OF MYSELF AND OTHER MINI OWNERS. I HAVE NO AIRBAG FUNCTION RIGHT NOW AND BOTH MY DRIVER AND PASSENGER SIDE AIRBAG LIGHTS ARE ON. MY MECHANIC STATED THAT I WOULD NEED TO REPLACE THE PASSENGER SEAT SENSOR AT THE LEAST.

NHTSA ODI 11377693

FIRST GEAR POPS OUT RANDOMLY, WHEN IT'S BEGINNING TO MOVE OR AFTER IT STARTED MOVING. IT CAN GO DAYS WITHOUT HAPPENING THEN IT WILL HAPPEN MULTIPLE TIMES IN ONE DAY.

NHTSA ODI 11374754

TURBO CHARGER HAS SYSTEMATICALLY FAILED OVER THE LAST YEAR, WITH WORSENING EFFECTS. THIS CAUSES THE CAR TO AUTOMATICALLY GO INTO "LIMP MODE" AND CUTS POWER. THIS IS DANGEROUS FOR DRIVING ON THE HIGHWAY. THIS IS A COMMON COMPLAINT WITH MINI COOPERS WITH MANY, BUT NOT ALL YEARS RECALLED.

NHTSA ODI 11233525

HELLO, I AM THE ORIGINAL OWNER OF A 2014 MINI COOPER COUNTRYMAN PURCHASED NEW FROM IRVINE MINI, IRVINE CALIFORNIA, ON MY WAY HOME TO SAN DIEGO FROM THE PURCHASE THE REAR PASSENGER WINDOW STOPPED WORKING, I PULLED OVER CALLED THE DEALERSHIP AND WAS TOLD TO GO IN THE NEXT DAY FOR REPAIR, IT WAS REPAIRED THE NEXT DAY, ELECTRICAL FAILURE. 2014, NEXT WAS THE ENGINE WOULD STAY ON WHEN THE KEY WAS REMOVED, DEALERSHIP X 3 BUT THEY COULD FIND NOTHING, 2ND YEAR WAS DRIVING UPHILL CITY STREETS AND CAR LOST POWER, STARTING SMOKING, PULLED OVER AFTER RESTING CAR WAS DRIVABLE, DEALERSHIPS COULD FIND NOTHING WRONG, WE NEVER RECEIVED ANY NOTICE FROM OUR DEALERSHIP INFORMING US OF FAULTY TRANSMISSION. MY CHECK ENGINE LIGHT NEVER CAME ON BUT CAR STARTED LOSING POWER A FEW WEEKS AGO. I RECENTLY TOOK IT TO DEALER WHO TOLD ME THE TRANSMISSION HAS TO BE REPLACED, IT WASN'T A COMPUTER GLITCH AND THESE TRANSMISSIONS CANNOT BE SERVICED. WHAT DO I DO NOW?

NHTSA ODI 11231603

FOR THE PAST YEAR, ALL EXTERNAL LIGHT WIRING HAS MELTED. FIRST INSTANCE 5/24/18 BOTH LICENSE PLATE BULBS SHORTED, SECOND INSTANCE 10/26/18 DRIVERS SIDE HEADLIGHT BULB CONNECTOR INSIDE LIGHT MELTED, THIRD INSTANCE 5/21/19 PASSENGER SIDE HEADLIGHT BULB WIRING HARNESS MELTED, FOURTH INSTANCE AND CURRENT 5/30/19 RIGHT TAILLIGHT BULB WIRING MELTED.

NHTSA ODI 11210887

THERMOSTAT HOUSING FAULT CODE CAME ON WHILE DRIVING. 2014 MINI COOPER HARDTOP MODELS HAVE A RECALL. MY VIN # DOES NOT. PLEASE INVESTIGATE THIS AND INITIATE A RECALL FOR MY VIN.

NHTSA ODI 11192704

BAD SENDING UNIT ON FUEL PUMP ASSEMBLY; THIS CAUSED THE GAS LIGHTS TO STOP WORKING INSIDE THE VEHICLE WHILE DRIVING.

NHTSA ODI 11180415

I WAS DRIVING, MAKING A RIGHT TURN WHEN I HIT A ROCK ON THE ROAD WITH MY FRONT RIGHT TIRE. AFTER THIS, I WOULD HEAR A THUMPING SOUND WHILE TURNING. THEN WE LEARNED THAT THE MOUNTING KIT OF THE FRONT STRUT CRACKED; THE SERVICE DEPARTMENT AT OUR DEALERSHIP MENTIONED THAT IT'S A COMMON ISSUE AMONG MY MAKE AND MODEL OF CAR.

NHTSA ODI 11163304

DRIVETRAIN MALFUNCTION APPEAR WHILE DRIVING ON THE FREEWAY

NHTSA ODI 11151538

DRIVETRAIN MALFUNCTION WARNING - APPEARS AND REDUCES SPEED AT ANY TIME OF DRIVING - THIS COULD CAUSE SEVERE ACCIDENTS DUE TO LOSS OF POWER/PERFORMANCE. THIS WARNING IS ENGAGED AT ANYTIME W/O WARNING. SOFTWARE UPDATE FOR VEHICLE SHOULD BE FREE OF CHARGE AS THIS IMPACTS LOSS OF POWER. WHEN TAKING IT TO AUTO MECHANIC, NO CODES ARE FOUND AND NO ENGINE LIGHT OR FAULT CODE. RESEARCHING ALL F56 FORUM, SEEMS LIKE THIS HAS BEEN COMMON COMPLAINT. EVEN THOUGH THE WARNING COMES ON AND TELLS YOU TO DRIVE CAREFULLY (SLOW DOWN). YOU ARE STILL IN A HIGH DENSITY TRAFFIC OR FREEWAY THAT DOES NOT ALLOW YOU ENOUGH TIME TO PULL ON THE SIDE. THE SOFTWARE SHOULD BE AVAILABLE TO CONSUMER AS THIS IMPACTS THE SPEED OF THE CURRENT DRIVING CONDITION (WHICH IS NOT OBVIOUS TO OTHER DRIVERS). IF IT WAS A FLAT TIRE, OR SMOKE COMING OUT OF THE HOOD.. THIS IS VISIBLE. MECHANICS CANNOT FIGURE OUT THE ISSUE DUE TO A "GENERAL / NO DETAILS" TO THE SPECIFIC ISSUE. THEREFORE, THE OLDER SOFTWARE FOR THIS MODEL AND YEAR SHOULD BE CONSIDERED A RECALL FOR HAZARDOUS DRIVING. FURTHERMORE, SOFTWARE UPDATES SHOULD BE NOTIFIED TO ALL CONSUMERS AND DETAILING THE ITEMS THAT THE SOFTWARE WILL BE CHANGING. THERE IS NO COMMUNICATION OR EVEN ON THEIR WEBSITE TO SHOW UPDATES AND NEEDS FOR IT. THIS IS A PROBLEM IF IT HAS ANYTHING TO DO WITH ENGINE AND POWERTRAIN.

NHTSA ODI 11120569

MY INSURANCE HAS ASKED ME TO FILE THIS COMPLAINT AS MY VEHICLE'SAIRBAGS DEPLOYED AT AN IMPACT UNDER 5 MPH LEADING TO THE CONCLUSION THAT THE AIRBAG SENSOR IN MY CAR IS FAULTY.ON FRIDAY, JULY 6TH AT 10:15 AM I WAS DRIVING ON THE 405 N IN BUMPER TO BUMPER FREEWAY TRAFFIC, IT WAS A CLEAR DAY WITH GOOD VISIBILITY AND ROAD CONDITIONS. THE TWO VEHICLE'S INVOLVED IN THE MINOR COLLISIONWERE MY 2014 MINI COUNTRYMAN AND A 2017 INFINITY. MANYCARS WERE CUTTING OVER TO THE RIGHT TO GET ONTO THE UPCOMING 55 NORTH AND SOUTHBOUND INTERCHANGE HIGHWAY. ASI WAS MERGING TO THE LEFT A GREY CAR SPED BY TO MERGE RIGHT CAUSING ME TO MERGE BACK INTO MY LANE. HOWEVER, THE WHITE INFINITY AHEADHAD HIT THE BRAKES CAUSING ME TOTAP HER REAR BUMPER AT AN IMPACT UNDER 5 MPH. THEN THE THREE DRIVER'S SIDE AIRBAGS DEPLOYED. I IMMEDIATELY CALLED 911 AND THEY TRANSFERRED ME TO THE CHP. AFTER HANGING UP, I GOT OUT OF MY CAR AND THE OTHER DRIVER AND IEXCHANGED INFORMATION. THE OTHER DRIVER LEFT WITHIN 5 MINUTES AS HERBUMPER WAS LEFT WITH ONLY A MINOR SCRATCH, AND NO DENTS OR BUMPS.I GOT BACK IN MY VEHICLE AND WAITED FOR THE CHP. WHEN THE OFFICER ARRIVED, HE PUSHED MY CAR TO THE RIGHT SIDE OF THE ROAD. WE WAITED FOR THE AAA TOW TRUCK. NO ACCIDENT REPORT WAS TAKEN AS THERE WAS NO ACCUSATIONS OR INJURY. THE TOW TRUCK DROVE MY VEHICLE TO THE NEAREST MINI DEALERSHIP.MY INSURANCE COMPANY WANTS TO MOVE FORWARD AND FIX BOTH CARS' MINOR DAMAGE AND REPAIR MY VEHICLE'S AIRBAGS. THECOST PER AIRBAG RANGES FROM $1000 TO $2000.HOW VERY UNFORTUNATE GIVEN THE EXTREMELY MINOR DAMAGE INVOLVED.FROM WHAT I HAVE GATHERED, I'VE FOUND THAT AIRBAGSARE TO DEPLOY AT AN ABSOLUTE MINIMUM SPEED OF 10 MPH. GIVEN THE FACT THAT THE AFOREMENTIONED COLLISION OCCURRED BELOW 10 MPH, IT IS THEREFORE TO BE ASSUMED THAT SOME SORT OF ERROR OCCURRED CAUSING THE DEPLOYMENT OF MY VEHICLE'S AIRBAGS.

NHTSA ODI 11112041

THE F56 HORN IS NOT SENSITIVE, AND REQUIRES AGGRESSIVE PUSHING TO SOUND, CREATING A SAFETY HAZARD.

NHTSA ODI 11103580

OTHER MINI COPPERS FROM THIS YEAR WITH DIFFERENT MODELS HAVE BEEN RECALLED FOR AN ISSUE THAT ALLOWS THE CAR TO THE EXITED WHEN THE CAR IS NOT IN PARK. MY CAR CAN GET SHUT DOWN, THIS IS PURPOSEFULLY STOPPED LIKE AT A PARKING SPACE. WHILE STILL IN DRIVE MODE, I CAN EXIT THE CAR, THE CAR STARTS TO ROLL AWAY. THIS HAS HAPPENED TO ME NUMBERS TIMES. HAVING HAD TO JUMP BACK IN MY CAR TO STOP IT. ONCE ON A HILL AND IT ALMOST CAUSED A CRASH. SCARY. BOUGHT THE CAR IN 2015 SPRING AND THE STARTED FALL OF 2016 AND HAS CONTINUED TO HAPPEN. CAR BOOT TO BONNET WARRANTY WAS EXPIRED AT THE TIME THIS STARTED. THEY WERE CALLED THE AROUND FIRST TIME THIS HAPPENED, I WAS UNABLE TO GET MY KEY OUT OF THE IGNITION WHILE IN PARK. THEN I WAS ABLE TO GET IT OUT WHILE IN DRIVE AND NOW, I CAN OFTEN RUN MY CAR WITHOUT THE KEY IN THE IGNITION. THIS IS NOT A KEYLESS START CAR. ALL INCIDENTS TRANSPIRED ON PARKING LOTS OR PARKING SPACES ON A STREET.

NHTSA ODI 11023971

TL* THE CONTACT OWNS A 2014 MINI COOPER S. WHILE ACCELERATING FROM A STOP LIGHT, THE CONTACT'S VEHICLE CRASHED INTO THE PRECEDING VEHICLE. THE DRIVER SIDE AIR BAG DEPLOYED. THE CONTACT BLACKED OUT DUE TO THE DEPLOYMENT AND WAS NOT ABLE TO PROVIDE FURTHER DETAILS. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN AUTO BODY REPAIR SHOP WHERE THE BODY DAMAGES WERE REPAIRED, BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000.

NHTSA ODI 10957644

MY CAR WAS PARKED AND I WENT TO START IT UP IN THE MORNING TO GO TO WORK. A LIGHT CAME ON WHICH LOOKED LIKE AN AIRBAG/SEATBELT LIGHT. IN MY VEHICLE IT WAS NOT ONE OF THE REGULAR SERVICE LIGHTS THAT THEY HAVE HIGHLIGHTED IN THE MANUAL SO I CALLED THE DEALERSHIP THAT AFTERNOON. THEY MADE AN APPOINTMENT FOR ME TO BRING MY CAR IN TO BE CHECKED OUT ON 4/5/16 WHICH I DID. BEFORE I GOT THE CAR TO THE DEALERSHIP THE LIGHT HAD TURNED OFF BUT I TOOK IT IN ANYWAY. THEY SAID THEY WOULD CHECK IT OUT AND GET BACK TO ME. THE NEXT DAY THEY CALLED ME TO TELL ME THAT IT WAS AN AIRBAG ISSUE AND THEY HAD TO SPECIAL ORDER THE PARTS FROM GERMANY WHICH WOULD BE IN ON 4/22/16. LATER THAT MONTH THEY CALLED ME BACK AND ASKED ME TO BRING THE LOANER CAR THEY HAD SUPPLIED TO ME BACK BECAUSE THE PARTS WERE NOT AVAILABLE AND BEING BACKORDERED NATIONALLY. THEY HAD THEIR PARENT COMPANY PAY FOR A RENTAL VEHICLE BUT THERE WERE ISSUES WITH A COUPLE OF THOSE CARS TOO. IT IS NOW MAY 5, 2016 AND I HADN'T HEARD ANYTHING MORE SO I CALLED THEM AND THEY SAID THEY MAY HAVE PARTS TOMORROW AND BECAUSE MY CAR HAS BEEN THERE SO LONG THEY WOULD TRY AND PUT MINE FIRST TO BE SERVICED. IT'S BEEN VERY DISAPPOINTING AND AN INCONVENIENCE SINCE THEY HAVE PUT ME IN 4 DIFFERENT CARS IN THE LAST MONTH. NOW I AM UNEASY ABOUT HOW SAFE MY VEHICLE ACTUALLY IS. IT IS A 2014 AND HAS LOW MILES AND IS IN GOOD SHAPE AND I'VE HAD IT LESS THAN A YEAR AND QUESTIONING MY DECISION TO PURCHASE THIS VEHICLE AT ALL.

NHTSA ODI 10863472

DRIVER'S DOOR HANDLE LOCK COVER (PLASTIC) FELT UNEXPECTEDLY WHILE DRIVING.

NHTSA ODI 10838742

EXPERIENCED A LOUD RATTLE IN THE CAR, TOOK IT TO THE DEALER, THEY REPLACED THE REAR SHOCKS, BUT THE RATTLE STILL HAS NOT BEEN ILLUMINATED. I EMAILED THE DEALER AND TOLD HIM THAT REPLACING THE SHOCKS DID NOT ILLUMINATE THE PROBLEM, HE SAID THAT MINI ENGINEERING IS GOING TO WORK ON THIS PROBLEM, THAT EVIDENTLY IS OCCURRING IN THIS YEAR AND MODEL.

NHTSA ODI 10822384

TWO TIRES THAT CAME WITH MY MINI COOPER 2014 WENT FLAT IN LESS THAN 7,500 MILES, ONE ON NOV 7, 2015 AND THE OTHER ON JAN 3, 2016. THE TIRES ARE VERY EXPENSIVE (ABOUT $200 PER TIRE) AND OF VERY LOW QUALITY. AS A CUSTOMER I FEEL BEING CHEATED ON.

NHTSA ODI 10821813

I HAVE A 2014 MINI COOPER HARDTOP. I HAVE HAD THIS CAR SERVICED AT LEAST 4 SEPARATE TIMES FOR A RECURRING ISSUE. TODAY WAS VERY DIFFERENT AND UNEXPLAINABLE. I WAS DRIVING TO WORK ON THE FREEWAY, MY CAR REACHES SPEEDS OF 80 AT LEAST, BUT I HAD SLOWED TO A CRAWL BEFORE THE TOLL PLAZA. TRAFFIC WAS THE USUAL HEAVY TRAFFIC. I MUST HAVE BEEN GOING 5-10 MPH IN STOP AND GO TRAFFIC. SUDDENLY, TH CAR STARTED BUCKING , LIKE IT WAS HAVING TROUBLE DOWNSHIFTING . THIS IS THE TYPICAL BUCKING IT MAKES RIGHT BEFORE THE "DRIVE TRAIN MALFUNCTION: DRIVE MODERATELY." WARNING COMES ON. THE ENGINE STARTED TICKING (TO ME THAT IS INDICATING LACK OR NO OIL). "DRIVE TRAIN MALFUNCTION: DRIVE MODERATELY." AND "DROP IN OIL PRESSURE. SLOW TO A STOP " WARNINGS BOTH CAME ON. I PULLED OVER 3 LANES QUICKLY TO THE SIDE OF THE FREEWAY , SHUT THE CAR OFF AND HOPED I WAS IN A SAFE SPOT. WHEN THE TOW TRUCK OPERATOR CAME, HE TOLD ME OIL WAS UNDERNEATH MY CAR. WHY WOULD A CAR JUST SPILL OIL OUT WHILE DRIVING ? IM PRETTY SCARED OF WHAT HAS HAPPENED TO MY ENGINE. CAR IS AT THE DEALER, AND I'M REALLY NOT CONFIDENT IN THIS CAR. I HAVE NOT BEEN CONFIDENT SINCE ALL OF THE PROBLEMS I HAVE HAD SINCE PURCHASE.

NHTSA ODI 10783527

YOUTUBE LINK: HTTPS://WWW.YOUTUBE.COM/WATCH?V=QWXHFEKSZ0W MINI COOPER S ROADSTER 6 SPEED MANUAL WHILE DRIVING SMELLED ODOR OF RUBBER BURNING, THEN ABOUT 10 SECONDS LATER SAW SMOKE COMING FROM THE DEFROSTER VENTS AND THEN SOME SORT OF WARNING LIGHT CAME ON AND I IMMEDIATELY TURNED OFF THE ENGINE AND COASTED TO A STOP BELIEVING THE ENGINE HAD OVERHEATED. I GOT OUT OF THE CAR AND THE SMOKE GOT WORSE AND WHEN THE PLASTIC IN THE DASHBOARD HAD MELTED AWAY I SAW FLAMES AND CALLED 911. THIS ALL HAPPENED IN LESS THAN 2 MINUTES FROM THE START TO CALLING 911. THE ENGINE WAS NOT DAMAGED AND THIS WAS FROM THE WIRING I BELIEVE. I PURCHASED THE CAR NEW ON MAY 28, 2014. THE CAR WAS TOTALED.

NHTSA ODI 10758960

TL* THE CONTACT OWNS A 2014 MINI COOPER. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V815000 (STRUCTURE) WAS RECEIVED IN FEBRUARY OF 2015. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI 10733953