What 1,347 owners told NHTSA about the 2014 Ford Fusion Energi

The transmission is idle high and hard and yes it is available for inspection My safety and the safety of other is the car jerks and it accelerate unvoluntary Yes it was confirmed by a certified mechanic No it have not been inspected my manufacturer or others No there is no warning lights or messages that prior to failure

NHTSA ODI 11650750

Vehicle flexplate broke causing loss of power in rush hour traffic. Luckily was able to get to the side of the road without major incident or causing an accident. Broken flexplate also caused damage to transmission and ptu. Was informed this is a common issue wiith this yeat make and model but ford refuses to do anything about it. They would rather wait for some peopke to lose their life befor takiing responsibility. But who cares about peoples lives when you have stockholders to pay and ceo bonuses to hand out. Feel its worth mentioning i had the car at the dealership a couple times for other issues and had asked them about problems i suspected were precursors to this happening. They denied there was even an issue. They they told me the noises were normal and refused to even document my concerns let alone actually physically check the vehicle. I believe they were intentionally trying to hide the fact they knew exactly what was going on. Ford needs to take responsibility but since they wont you guys need to make them.

NHTSA ODI 11644336

The contact owns a 2014 Ford Fusion. The contact stated while her son was driving 30 MPH, while depressing on the accelerator pedal the vehicle failed to respond as needed. The contact merged to the side of the road. The dealer was contacted. The vehicle was towed by an insurance vendor to the Sam's Auto Repair. The vehicle was then towed to the dealership where it was diagnosed that the transmission needed to be replaced.  The vehicle was not repaired. The manufacturer was notified of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 221,478.

NHTSA ODI 11639453

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was taken to an independent mechanic and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 39,112.

NHTSA ODI 11633876

6 speed transmission has major manufacturers flaws.

NHTSA ODI 11623107

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle was hesitating. Additionally, the contact stated that the vehicle was not driving properly. The contact stated that later that day, while the vehicle was parked, the contact saw fluid on the ground underneath the front driver’s side of the vehicle. The vehicle was taken to the dealer where it was diagnosed with transmission fluid leak and half shaft seal failure. The contact was informed that either the half-shaft seal or the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed of an unknown recall repair; however, the VIN was not associated with the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 113,098.

NHTSA ODI 11622821

The contact owns a 2014 Ford Fusion Hybrid. The contact stated while driving 20 MPH, there was an abnormal sound coming from the front of the vehicle. The vehicle was driven to the dealer to be diagnosed. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 76,000.

NHTSA ODI 11619359

Slowing driving out of store parking lot, sudden heavy steering, loss of power steering, 'service advancetrac' & 'hill start assist unavailable ' traction control warning lights on

NHTSA ODI 11619221

The contact owns a 2014 Ford Fusion. The contact stated while attempting to drive, the gear shifter was moved to drive(D), but the vehicle failed to respond after several attempts. There was no warning light illuminated. The vehicle was towed to the residence. The dealer was notified of the failure and advised the contact to take the vehicle in for diagnostic testing. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Numbers: 19V362000 (Power Train) and 22V413000 (Power Train). The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The failure mileage was approximately 114,000.

NHTSA ODI 11617825

The contact owns a 2014 Ford Fusion. The contact stated while driving 45 MPH, the vehicle stalled. There was no warning light illuminated. The contact stated that he was able to slightly pull to the side of the road after 5-10 seconds. The vehicle failed to restart. The dealer was notified of the failure and advised the contact that the earliest availability for diagnostic testing was in 5 months. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 94,000.

NHTSA ODI 11612339

My car when it is parked it will randomly pop the trunk. A lot of issues I’m seeing is ford fusions 2014 and up! Few of my friends are having the same issues especially with keyless entry pad it’s causing issues from water damage or heat causing the car to to this! Their needs to be recall on that cause kids doors aren’t locking properly I have kids I had someone almost steal my car cause my trunk was popped open by itself! This is my second time reporting this I have [XXX] [XXX] and [XXX] I need my car! Can yall please fix this issue INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11603925

Took the car in for a forced recall it was the bushing on the transmission and now our transmission failed when it had showed no problems. The service department is claiming no fault.

NHTSA ODI 11600168

The flex plate on my vehicle was cracked. Which damaged the transmission pump. We heard what sounded like a box of rocks which quickly got louder and louder we took the car to the dealer the next day. We had no other warnings something was wrong no engine light or anything. Had this plate broken completely we likely would have crashed and our small children could have been hurt. We took it to our local Ford dealer who diagnosed the issue, but would want over $6000 to fix the issue, on top of the $225 we paid to get the issue diagnosed. So for the forseable future we have no safe vehicle.

NHTSA ODI 11588803

I bought Ford Fusion Hybrid 2014 from Marine County Ford [XXX] (@51,000+ miles) The car was inspected & in “good condition”. In 5 months, 6/2022 (@61,000+ miles) I noticed a barely distinguishable noise. My mechanic discovered a tiny leak in transmission. There were NO leaks under car. This “tiny” leak took 2.0L of transmission fluid to fill, so the car was ALMOST OUT of transmission fluid. There was NO warning on the dashboard. Mechanic said the leak had to be 6-12 months old since the hole was small it had to take long time for all fluid to leak out. Same day while driving on FREEWAY, the vehicle suddenly started shaking and became almost uncontrollable, then Dashboard displayed “stop immediately”. I barely managed to steer it to the closest exit. It turned out the bearing (VERY small part) was completely destroyed & because of it the WHOLE unit needed to be replaced. It’s a huge unit 1/3 size of the car. Both dealer and FORD said the car was out of warranties (warranty issued only for 8 years/100,000 miles) not applicable @61,000 miles. They also denied coverage with extended 90 days warranty, even tho mechanic stated the leak was old. Ford has this transmission issue listed in their TSB which means it’s a KNOWN DEFECT to the dealer. The repair cost was 1/2 of car value. But Ford dealers do NOT disclose this. I did replace transmission in 8/2022, with my mechanic with the unit from used car with 54,000 miles on it, “tested and certified by the “SWEngines”, a national parts dealer. BUT that unit ALSO broke, also after 5 months, due to SAME defect of same bearing. The unit had apps. 65,000 miles. But I was watching it. I had to pay twice, for both units. This model represents DANGER on the road due to faulty transmissions that can break any time, without warning. Leaks in them are not easily detectable and even concealed by the cover absorbing oil. Warranties issued INCORRECTLY for this defect. There are other 1500 cases on internet like this. Thank u INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11585318

The contact's wife owns a 2014 Ford Fusion. The contact stated while his wife was driving on the freeway at an undisclosed speed, the vehicle failed to go over the speed of 25 MPH. The contact stated that the check engine and an unknown yellow gear icon warning lights illuminated. The contact merged to the side of the road and restarted the vehicle after 10 minutes. The contact was able to drive the vehicle home but the continued not being able to drive over 25 MPH. The contact's wife also mentioned that the vehicle was restarted on multiple occasions. The contact's wife mentioned while starting up, there was a clanking noise coming from the engine. The contact received notification of NHTSA Campaign Number 18V471000: (Power Train). The vehicle was taken to an independent transmission mechanic where it was diagnosed with a coolant leak causing the engine to need to be replaced. A dealer was not contacted. The vehicle was not repaired. The manufacturer was made aware of the failure, however, the contact was informed that the vehicle was not included in a recall. The failure mileage was approximately 103,010.

NHTSA ODI 11581214

The contact's partner owns a 2014 Ford Fusion. The contact stated that while driving at slower speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The contact stated that on one occasion while driving 70 MPH, the vehicle stalled while depressing the accelerator pedal to the floorboard. The contact stated that the transmission eventually re-engaged, and the contact drove the vehicle to the dealer. The dealer performed a diagnostic test and informed the contact that the transmission had failed. The manufacturer was notified of the failure and informed the contact that there were no recalls or warranties on the vehicle. The vehicle was not repaired and remained with the dealer. The failure mileage was unknown.

NHTSA ODI 11580858

The contact owns a 2014 Ford Fusion. The contact stated that when his friend placed the vehicle in the park position on an inclined parking lot, the vehicle rolled back 30 seconds after the driver exited the vehicle. The vehicle collided with another vehicle. A police report was not taken. The vehicle was not diagnosed or repaired. The contact believed the failure was associated with NHTSA Campaign Number: 22V413000 (Power Train). The manufacturer was not notified of the failure. The failure mileage was approximately 116,000.

NHTSA ODI 11578295

recall 19V632000 does not show up as a valid recall for my specific vehicle; however, it is at a Ford dealership now. the issue is bolts corroded, the steering gear motor is detached from the gear housing - just as described in the recall. My bolts disinigrated, corroded, and broke away. Can you please issue the recall to my specific vehicle

NHTSA ODI 11574264

The Car seems to always have a strange issue with power. I have taken it for all services and recall but nothing has every fixed that issue. From talking to other Ford fusion 2013-2014 owners the transmission is bad on these cars from the start. It would be bad to loose or have the transmission go out on any major road people could get hurt. I am now getting p0744,p0741. I believe it is related to other issue suck as car clutch assembly malfunction causing high rev because car pop into wrong gears while driving. This should be a ford issue and google search and you will find everyone who own a ford fusion having this problem.

NHTSA ODI 11570070

My torque converter is going out in my 2014 FORD FUSION SE and it caused me to almost get t-boned twice and hit in the rear once. I pull out of the driveway and it cuts off and won't move. No engine light was on and that's a safety hazard. The dealer is telling me to continue to drive it and if it does it again take a video. The vehicle is getting looked at tomorrow as I will show the video I took too the dealership and they will actually take me seriously. I was told it was low on transmission fluid which is why I began driving it again and it happened two more times while getting it to the dealership. This could cause a hazard to others on the road and myself, it could cause injury or even death. I was so scared getting stuck in the middle of the road of oncoming traffic.

NHTSA ODI 11567883

The contact owns a 2014 Ford Fusion. The contact stated while pulling out of a parking space and driving, the vehicle jerked and stalled. There was no warning light illuminated. The contact was able to pull to the side of the road. The contact turned off and restarted the vehicle, and the vehicle responded as needed. The contact stated that the failure recurred while driving on another occasion. The vehicle was taken to the dealer however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 88,000.

NHTSA ODI 11566102

The cable to the transmission has messed up came off. There’s a recall for the 2014 ford fusion for this problem but it’s not showing one for our vin number and it is the exact problem the recall says

NHTSA ODI 11547956

My transmission has failed multiple times. Luckily my car is under warranty, because I have been able to have it replaced twice, but both times, these malfunctions have put my life and countless others in danger, because the failure is sudden and not preceded by any warnings. This problem has reproduced twice and been confirmed and fixed both times by Sun’s Auto in Spring Texas. The vehicle has been inspected recently by the manufacturer as my shifter bushings also disconnected as part of a separate recall, resulting in a similar situation as the transmission failure. There have been no warnings prior to any of these issues occurring, and at this point recalling individual parts is not sufficient. The transmission and shifter bushing issues alone cost more to repair than the car is worth at this point, and they are extremely dangerous, especially when combined with the other active safety recalls for this same car such as the brakes, door latches, and steering. Almost every aspect of this car is unsafe as manufactured .

NHTSA ODI 11545286

The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle failed to function in fifth and sixth gear. There was an abnormal clicking and grinding sound while in fourth gear. There were no warning lights illuminated. The driver was able to pull over to the side of the road. The vehicle was towed to the residence. The vehicle was taken to several independent mechanics, and the contact was informed the vehicle could not be serviced at their location. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 146,000.

NHTSA ODI 11542586

The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed and while shifting in reverse, she heard a grinding sound at the hood of the vehicle. No warning lights were illuminated. The vehicle was towed to a Midas where it was diagnosed that the transmission failed and needed to be replaced. The vehicle was then towed to Atlantic Transmission Specialist where the vehicle was diagnosed, and it was determined that the transmission had failed and needed to be replaced. The dealer was notified of the failure and the contact was informed that the VIN was previously repaired under the NHTSA Campaign Number: 22V413000 (Power Train). The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 97,000.

NHTSA ODI 11536019