What 1,671 owners told NHTSA about the 2014 Ford Explorer Police Intercept

THE "DRIVER DOOR AJAR' WARNING LIGHT STAYS ON WHEN ENTERING OR EXITING THE VEHICLE EVEN WHEN THE DOOR IS CLOSED. I HAVE TO SLAM IT SEVERAL TIME TO GET THE LIGHT TO GO OFF.

NHTSA ODI 11111415

STEERING GEAR AND TIE ROD ISSUE. TIE RODS HAVE FAILED AND STEERING GEAR IS GOING OUT. DEALER RECOMMENDS COMPLETE REPLACEMENT. DIAGNOSIS IS THAT STEERING WILL LOCK UP WILL DRIVING ONCE STEERING GEAR COMPLETELY FAILS.

NHTSA ODI 11111194

THE FIRST TIME, THE VEHICLE WAS IN THE GARAGE AND AS I WAS BACKING OUT, THE TRACTION CONTROL AND POWER STEERING ASSIST FAILURE WARNINGS CAME. I TURNED OFF THE CAR AND EVERYTHING SEEMED TO REBOOT. THE NEXT TIME I WAS JUST PULLING OUT OF A PARKING LOT, BUT THIS TIME, THE CAR TOOK NUMEROUS ATTEMPTS TO FINALLY REBOOT. THEN I WAS ON A HIGHWAY AND WAS BARELY ABLE TO MAKE IT TO THE BREAKDOWN LANE TO STOP AND TRY TO REGAIN POWER STEERING. THAT WAS VERY DANGEROUS! SHORTLY THEREAFTER, I TURNED ON THE CAR IN THE GARAGE, AND THE LIGHT CAME ON AND NEVER WENT OUT ALONG WITH THE POWER STEERING. MY QUESTION IS; WHY IS THIS EXACT PROBLEM A RECALL FOR 2011 2012 2013 EXPLORERS BUT NOT 2014? MY ACQUAINTANCE ALSO HAS AN EXPLORER AND IS EXPERIENCING THE SAME ISSUE. CLEARLY FORD IS AWARE OF THIS DANGEROUS MALFUNCTION.

NHTSA ODI 11110976

WHILE DRIVING AT 70 MPH THE LEFT WHEEL FELT LIKE IT WAS GOING LEFT AND THE RIGHT FELT LIKE IT WAS GOING RIGHT WHILE HOLDING WHEEL STRAIGHT. VERY DIFFICULT TO CONTROL. THEN STEERING ASSIST FAULT MESSAGE AND TRACTION CONTROL LIGHT CAME ON.

NHTSA ODI 11109608

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE THE DRIVER, A POLICE OFFICER, WAS TRAVELING VARIOUS SPEEDS, THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. IN ADDITION, THE BRAKE WARNING INDICATOR ILLUMINATED. THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE BRAKE HOSE CONNECTED TO THE CALIPER HAD FRACTURED. THE DRIVER WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A POLICE FACILITY WHERE AN INDEPENDENT MECHANIC DIAGNOSED THAT THE FRONT PASSENGER SIDE BRAKE HOSE CONNECTED TO THE CALIPER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED CASE NUMBER: CA3-15196031R3N7Z5. THE APPROXIMATE FAILURE MILEAGE WAS 70,429.

NHTSA ODI 11109638

EXHAUST FUMES COMING IN THROUGH A/C VENT UPON RAPID ACCELERATION. HAD ALWAYS BEEN A PROBLEM SINCE FIRST PURCHASING THE VEHICLE IN 2014. FORD HAS TRIED TO REPAIR PROBLEM FOUR TIMES AND IT IS STILL NOT FIXED. IT IS A DESIGN FLAW THAT FORD HAS NOT ADDRESS SINCE 2011 WHEN THIS MODEL FIRST CAME OUT AND STILL ARE PRODUCING THE VEHICLE WITH SAME DESIGN. THE REASON WHY THE FORD EXPLORER POLICE CARS HAVE MORE ISSUES IS NOT BECAUSE OF ALTERATION WITH THE VEHICLES IT IS BECAUSE THEY DRIVE THE VEHICLES FASTER AND THE HARDER YOU PUSH THE VEHICLE THE MORE YOU WILL NOTICE THE EXHAUST FUMES. THAT'S WHY THERE HAVE BEEN MORE ISSUE'S WITH FORD EXPLORER OLICE VEHICLES. THE ISSUE HAPPENS ALL THE TIME. THE VEHICLES NEED TO BE RECALLED BEFORE MORE PEOPLE GET HURT.

NHTSA ODI 11109538

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE EMITTED AN ABNORMAL ODOR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO RAY SCHULTENS FORD (2400 W 6TH ST, THE DALLES, OR) WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO CRACKS IN THE HEADLAMP ASSEMBLIES. THE DEALER STATED THAT THE VEHICLE NEEDED ADHESIVE ADDED TO THE OPENING OF THE HEADLAMP ASSEMBLIES. THE VEHICLE WAS REPAIRED. THE CONTACT'S HUSBAND SUSTAINED HIGH HEMOGLOBIN LEVELS AND REQUIRED MEDICAL ATTENTION. ONE YEAR PRIOR TO THE FAILURE, THE CONTACT'S HUSBAND WAS HOSPITALIZED BECAUSE HIS BLOOD HEMOGLOBIN LEVELS WERE HIGH DUE TO CARBON MONOXIDE POISONING. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. THE VIN WAS NOT PROVIDED.

NHTSA ODI 11105168

EXHIBITS AN AIR BAG WARNING LIGHT DUE TO HIGH RESISTANCE BETWEEN RCM AND SECOND ROW INFLATABLE SEAT BELT CIRCUIT

NHTSA ODI 11105153

UPON ACCELERATION IN PASSING GEAR THERE'S A FOUL ODOR COMING THRU THE AIR VENTS. IT SMELLS LIKE AN OVER HEATED HAIR DRYER. IT'S BAD ENOUGH THAT THE WINDOWS NEED TO BE OPENED TO LET THE ODOR OUT. MY SUV IS IN THE SHOP FOR THE 2ND TIME IN A YEAR WITH THE SAME PROBLEM. TODAY'S DATE IS 07/02/2018

NHTSA ODI 11105187

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 55 MPH, THE STEERING WHEEL FAILED TO MOVE. THE FOLLOWING DAY, THE VEHICLE FAILED TO START AND THE OIL PRESSURE, STARTING SYSTEM FAILURE, TRACTION CONTROL, AND ENGINE COOLANT WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED A LOCAL DEALER (EXPRESSWAY FORD, 3800 HIGHWAY 62 W, MT VERNON, IN 47620, (812) 838-4366) AND WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER A WARRANTY OR RECALL. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT TO HAVE THE VEHICLE TOWED TO THE LOCAL DEALER. ADDITIONALLY, THE CONTACT WAS REFERRED TO NHTSA. THE FAILURE MILEAGE WAS 120,336.

NHTSA ODI 11104139

I DISCOVERED THAT ON EACH SIDE 1 OF THE 2 BOLTS SECURING THE SUB-FRAME STABILIZER BRACKET TO THE BODY WAS MISSING AND THE OTHER ONE WAS ALMOST OUT. IN THE ATTACHED PARTS DIAGRAM THE BOLTS ARE HS1. THE CAR HAS 104,000 MILES AND IT IS CLEAR THAT HAD I NOT NOTICED THE REMAINING 2 BOLTS WOULD HAVE FALLEN OUT LEAVING THE REAR OF THE SUB-FRAME ABLE TO MOVE AROUND. THE MAIN SUB-FRAME BOLTS WOULD THEN HAVE COME UNDER INCREASED STRAIN AND THE SUSPENSION WOULD HAVE BEEN SUBJECT TO INCREASED MOVEMENT IN UNINTENDED DIRECTIONS.

NHTSA ODI 11103601

2014 EXPLORER SPORT - ISSUE STARTED AS SMALL CLICK/POP WHEN TURNING WHEEL LEFT OR RIGHT AT LOW SPEED AROUND 48K MILES. ISSUE HAS ESCALATED AT 51K MILES TO STEERING LOCKING UP MID-TURN, IN-MOTION STILL AT LOW SPEED FOR 3-5 SECONDS UNTIL IT RELEASES ON ITS OWN.

NHTSA ODI 11103450

MY WIFE AND KIDS COMPLAIN OF HEADACHE'S AND NAUSEA AFTER PROLONGED TIME TRAVELING IN SAID VEHICLE. SMELL OF EXHAUST TYPE FUMES WITHIN THE CABIN AREA.

NHTSA ODI 11102332

THE POWER CONTROL LOCKS HAVE QUIT FUNCTIONING. IT STARTED WITH THE FRONT DRIVER SIDE DOOR, AND 2 MONTHS LATER IT STARTED HAPPENING ON THE BACK DRIVER SIDE DOOR AS WELL. THE KEY FOB DOES NOT WORK FOR UNLOCKING THE DOORS. THE DOOR LOCK ON THE DOOR PANEL DOES THAT LOCK/UNLOCK THE DOORS EITHER. YOU HAVE TO MANUALLY LOCK/UNLOCK THE DOORS BY HAND. THE ISSUE WITH THE FRONT DRIVER SIDE DOOR STARTED ABOUT 6 MONTHS AGO. THE ISSUE WITH THE BACK DRIVER SIDE DOOR STARTED ABOUT A MONTH AGO. BOTH ISSUES ARE STILL HAPPENING.

NHTSA ODI 11101803

TAKATA RECALL) I WAS DRIVING MY KIDS TO SCHOOL WHEN MY TRUCK MADE A CRAZY SOUND AND FELT LIKE CAR CAME TO A STOP WHILE GOING APPROX 40 MILES PER HOUR, IT THREW OUR BODIES IN A JERKING MOTION. I IMMEDIATELY GOT CAUTIOUS DRIVING NOW NO MORE THEN APPROX 5 MILES PER HOUR TO PREVENT US FROM JERKING US AS IT KEPT MAKING THE TRUCK JERK. AFTER CAUTIOUSLY DRIVING IT HOME AND HAVING TO KEEP MY KIDS OUT OF SCHOOL I PARKED IT AND GOT A EVALUATION ON TRUCK ISSUE WHICH I WAS TOLD SEEM TO BE TRANSMISSION I THEN AFTER GOT ON THE PHONE WITH FORD MOTOR COMPANY WHO REFUSED TO ASSIST ME WITH ANY HELP OR EVEN TAKE MY COMPLAINT UNTIL I TOOK IT TO ONE OF THEIR DEALERS.I EXPLAINED TO HER THE REPRESENTATIVE I WAS LOOKING FOR THE BEST ADVICE AND SEE IF THEY BE WILLING TO WORK WITH ME BECAUSE AFTER LOOKING UP THIS MAKE AND MODELS TRANSMISSION I FOUND OUT THERE'S SEVERAL DEFECTS ALSO THE SAME STYLE OF TRANSMISSION BEING PUT INTO OTHER FORD VEHICLES . WHILE RESEARCHING I CAME ACROSS SEVERAL OWNERS WHO HAVE HAD NIGHTMARES ALSO WITH THEIR TRANSMISSIONS OR PARTS WITHIN THE TRANSMISSION . I AM REACHING OUT BECAUSE THE COST OF THIS IS GOING TO BE ABOUT $2000 FOR THE LABOR AND PART REPLACEMENT NOT INCLUDING MISSED TIME AT WORK LOST WAGES RENTAL VEHICLES.IT IS VERY FRUSTRATING AND COULD BE VERY DANGEROUS THAT THESE TRANSMISSIONS CAN JUST FAIL WITH NOTICE WHILE DRIVING AT HIGH SPEEDS .I HAVE TRIED TO GO THROUGH FORD MOTOR COMPANY AND GET SOME TYPE OF SOLUTION I'VE SEEN MANY CONSUMERS WITH THE SAME ISSUE AND FEEL FORD SHOULD TAKE MORE RESPONSIBILITY AND BE HELD ACCOUNTABLE FOR THIS WHAT'S IT GOING TO TAKE A LOST LIFE!? THE SAME VEHICLE HAS AN CARBONMINOXCIDE LEAK THAT IS KNOWN THROUGHOUT THEIR VEHICLE AND SUSPENSION ISSUES IN THE REAR THIS PARTICULAR VEHICLE HAS MANY FAULTS TO IT AND I BELIEVE THEY ARE TRYING TO COVER IT TO SAVE THEM FROM PAYING THE COST BACK TO CONSUMERS . PLEASE HELP!!

NHTSA ODI 11100765

EXHIBITS AN AIR BAG WARNING LIGHT INTERMITTENTLY DUE TO HIGH RESISTANCE BETWEEN RCM AND SECOND ROW INFLATABLE SEAT BELT CIRCUIT

NHTSA ODI 11100025

40,000 MILES INTO A NEW CAR, REAR BRAKES ARE COMPLETELY WORN DOWN. THE PASSENGER SIDE NEEDED A NEW TEMPERATURE DOOR ACTUATOR TO ALLOW THE CLIMATE CONTROL TO WORK PROPERLY.

NHTSA ODI 11099213

STEERING ASSIST FAULT MESSAGE CAME UP WHEN MY WIFE STARTED DRIVING OFF TO PICK UP OUR KID FROM SCHOOL AND STEERING WAS EXCESSIVELY DIFFICULT FOR HER TO SAFELY MANAGE. VEHICLE CURRENTLY HAS 92,350 MILES.

NHTSA ODI 11099071

MY HUSBAND, SON AND MYSELF WERE DRIVING FROM HIGH POINT NC TO WINSTON SALEM NC ABOUT 30 MINUTES DRIVE, BEFORE ARRIVE TO OUR DESTINATION WE HAVE TO STOP ALMOS IN THE MIDDLE OF A ROAD BECAUSE WE WERE FEELING SHORT OF AIR ALMOST UNABLE TO BREATH AND FEELING CHEST SUPPRESSION AND NAUSEA OUR SON GIVE COMPLAIN ABOUT THE SMELL IN THE BACK SEAT BUT I WAS UNABLE TO FEEL IT DUE TO STUFF NOSE. MY HUSBAND HAD TO DRINK TWO BOTTLES OF WATER AND WE GOT OFF THE VEHICLE LIVING ALL DOORS OPEN, THE ODOR WAS VERY STRONG. IN MAY 15 2018 WE TOOK THE VEHICLE TO THE DEALER WHEN WE LEARNED ABOUT THE CARBON MONOXIDE RECALL THEY SAY THEY MADE THE REPAIR AND TODAY MAY 23 WE ALMOST CRASH. I THANKS GOD WE STOPPED AND GOT OFF THE CAR.

NHTSA ODI 11097703

WHILE DRIVING THE TRACTION CONTROL TURNED OFF, WHICH CAUSED THE ELECTRONIC STEERING TO TURN OFF. THE CAR JERKED TO THE LEFT SIDE (ALMOST HITTING A BOX TRUCK). I HAD TO PULL THE STEERING WHEEL WITH ALL MY STRENGTH TO GET THE CAR TO STEER CORRECTLY. TOOK THE CAR TO DEALERSHIP AND WAS TOLD THE ELECTRONIC STEERING GEAR NEEDED TO BE REPLACED.

NHTSA ODI 11096353

I PURCHASED AN USED 2014 EXPLORER AND BEEN HAVING ISSUES WITH A GAS ODOR. I WAS NEVER INFORMED ABOUT THIS PROBLEM WHEN I PURCHASED THE VEHICLE. UPON RECEIVING A RECALL I THEN BECAME AWARE OF THE PROBLEM. I BROUGHT IT IN AND THEY SUPPOSEDLY CORRECTED IT. NOW IT IS WORST. I WILL BRING IN AGAIN TO FIX THE SMELL. MY 11 YEAR OLD DAUGHTER SUFFERS FROM MIGRAINES AND WAS PLACED ON ADULT MIGRAINE PREVENTATIVE. MY FIANCE HAS BREATHING ISSUES AND NOW USES INHALERS. I BELIEVE THE EXHAUST FUMES IS THE CAUSE OF THE MEDICAL ISSUES.

NHTSA ODI 11093616

STOPPED FOR FUEL ON 5/13/18. WHEN I RESTARTED THE VEHICLE I RECEIVED A WARNING STATING SERVICE POWER STEERING ASSIST FAILURE. NO LONGER HAVE POWER STEERING, TRACTION CONTROL, OR TURN SIGNALS. BRINGING IT TO THE DEALERSHIP TODAY. VEHICLE WAS MANUFACTURED 10/2013.

NHTSA ODI 11093666

LOST POWER STEERING WHILE DRIVING ON A LOCAL STREET. POWER STEERING CAME BACK THE NEXT DAY AND LASTED 3 DAYS BEFORE GOING OUT AGAIN.

NHTSA ODI 11091601

THE A-PILLAR EXTERIOR MOLDING FELL OFF. THIS WAS THE SECOND TIME SUCH A PART FALLING OFF. THIS TIME IT WAS THE DRIVER SIDE. THE FIRST TIME WAS A YEAR AGO ON THE PASSENGER SIDE. THE A-PILLAR EXTERIOR MOLDING FELL OF ON THE FREEWAY AT HIGH SPEED. THE CAR WAS ESSENTIALLY A HIGH-SPEED ROAD HAZARD TO PUBLIC SAFETY, BECAUSE THE POINTED HARD PLASTIC MOLDING BECAME A PROJECTILE THAT CAN SERIOUSLY HURT SOME CAR OR PEOPLE BEHIND.

NHTSA ODI 11091284

THE ELECTRONIC STEERING GEAR ABRUPTLY FAILED. PULLING OUT OF MY DRIVEWAY. STEERING STOPPED AND RECEIVED LIGHT WARNING. ' STEERING LOSS STOP SAFELY' LOST ALL FUNCTION OF STEERING AND TRACTION. DEALERSHIP SAYS 2234.00 TO REPAIR. THIS WAS A RECALL ON THE 2013 VEHICLES AND OLDER. I COULD HAVE EASILY BEEN ON HIGHWAY THE DAY BEFORE WITH MY KIDS. IT WOULD HAVE CAUSED SEVERE ACCIDENT, TO LOSE STEERING AT 65 MPH.

NHTSA ODI 11089774