What 586 owners told NHTSA about the 2013 Volkswagen Jetta Hev

I was driving and out of no where l.the sunroof exploded . We didn't hit anything or nothing hit us it was crazy

NHTSA ODI 11563162

Ignition cylinder failure. Key would come out while driving, car would stay on, key would not turn in the ignition. Finally wheel locked and key will not turn at all therefore I can’t put my car in neutral.

NHTSA ODI 11561886

Dsg unit with hairline crack and fluid leakage just like known recall for this vehicle but mine isn’t covered for some reason

NHTSA ODI 11557589

My vehicle has the Mechatronic failure that the recall is open for some 13’ Jetta hybrids but I don’t have an open recall for it. The car would start shutting on and off constantly at stop lights instead of staying off running soley on battery power. The error codes are pointing to a failure to maintain fluid pressure inside the mechatronics unit. The mechatronics unit is included in a VW recall from June 2021. There was a design flaw in the housing that caused transmission fluid to lead out under pressure. My vehicle should be included in the recall but since I don’t have an open recall for this to my vehicle I can’t get it fixed and repairs are to expensive for something VW should own up for this mistake but they won’t repair it.

NHTSA ODI 11556871

The contact owns a 2013 Volkswagen Jetta Hybrid. The contact stated while driving at approximately 40 MPH, the vehicle began to vibrate and hesitate. The contact stated that the transmission and hybrid warning lights and several other warning lights were illuminated. The contact pulled over and turned the vehicle off. The contact turned the vehicle on and was able to place the vehicle into drive (D) and began to move forward however, he observed that the check transmission light was blinking. The contact stopped the vehicle shifted into park (P), then shifted into reverse (R) however, the vehicle failed to respond while shifting through PRNDL. The contact turned the vehicle off and had the vehicle towed to a local dealer. The local dealer diagnosed the vehicle and determined that the mechatronic unit and transmission needed to be replaced. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 19V866000 (Power Train). The failure mileage was approximately 126,000.

NHTSA ODI 11552332

Passenger seat air bag light off light is on

NHTSA ODI 11549199

Passenger air bag light is on saying off

NHTSA ODI 11549201

July 2021, (roughly 80,000 miles) vehicle had sudden loss of drive power to motor while driving approximately 30mph and related warning lights came on, leading to Recall Repair in July 2021. Transmission electronic gearbox (mechatronic unit) and transmission accumulator housing replaced by VW Dealer. Car exhibited some shuddering at low speeds and occasional lurching forward from a stop after recall repair - dealer said this is normal behavior and to ignore. Transmission has total failure on October 4, 2023 (roughly 100,000 miles), only 20,000 miles after recall. Vehicle owner experienced the same sudden loss of drive power while driving in a parking lot with the same indicator lights as in July 2021. Car was towed to same dealer. Dealer states transmission problem is not related to recalled parts, but vehicle owner suspects replaced parts from the recall may have also been faulty, as there is not a permanent fix for the recall issue, just replacement of parts. Dealer estimate is $8,500 for a new transmission and $2,500 for labor, more than the total value of the car.

NHTSA ODI 11548892

Since I have possessed the car, the horn has been slowly going out. Until now it no longer works at all. I've checked fuses and not the problem. So this is a safety concern for me because of the alarm! If my alarm goes off, just the lights flash but NO sound??! The alarm should at least be heard, right? Otherwise I hope I can see the lights flashing if my alarm goes off!!! Because I can't hear anything. My horn does not work even if I push the steering wheel? If I have to use my horn to alert anyone then I can't!

NHTSA ODI 11548350

The Jetta hybrid relies on a control unit, called the "mechatronic unit" to decouple the gasoline engine from the transmission. This, in turn, transfers propulsion to the electric motor, inside the transmission housing. The "mechatronic" is a highly specialized component, the "brains" of the Jetta's hybrid powertrain, and, therefore, can only be found in the Jetta hybrid. -market sales data says that a scant 8,515 Jetta hybrids were manufactured across model years 2013 - 2016. -an open NHTSA safety recall, 34j6, has been applied to a cross section of the total 8,515 Jetta hybrids produced. -per recall 34j6, exactly 2,149 Jetta hybrids have been included by VIN# in this recall. -safety recall 34j6 specifically addresses the "mechatronic accumulator housing". -recall description: hairline cracks may develop in the accumulator housing of the transmission (mechatronic unit), leaking and leading to insufficient transmission oil pressure. If this happens, the transmission warning light will illuminate in the instrument panel. If the warning light is ignored and the vehicle is driven, the clutch may not engage. There could be a sudden loss of power to the wheels, potentially leading to a vehicle crash.

NHTSA ODI 11544915

This vehicle and other vehicles of the same model have a faulty ignition cylinder lock housing causing the key to be unable to turn the car to off and be removed from the ignition. This does not allow the driver to park and leave the car as the key remains stuck and unable to turn. This problem has been reported by a dealer as an issue that is fixed weekly on other vehicles of the same make and model in shop.The vehicle has been inspected by the Volkswagen dealership and determined to be a failure within the vehicle. The key in the ignition has occasionally become stuck but, now remains in the vehicle for consistently after each drive for up to 30 minutes of trying to remove it.

NHTSA ODI 11540805

my steering wheel locked up

NHTSA ODI 11538238

The ABS dash board lights came on while driving at 70 miles an hour. At the time the Car mileage was 105,000 miles estimated.

NHTSA ODI 11537883

The contact owns a 2013 Volkswagen Jetta. The contact stated while starting the vehicle, the passenger’s side air bags indicator warning alarm sounded as if there was a passenger seated in the seat. The passenger’s side air bag warning light was illuminated. The dealer was contacted and stated that the vehicle needed to be diagnosed. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 78,000.

NHTSA ODI 11537775

The contact owns a 2013 Volkswagen Jetta. The contact stated while driving 60 MPH, several unknown warning lights illuminated. The contact pulled over on the side road and was able to continue driving to the residence. The vehicle was taken to an independent mechanic and unknown sensors were replaced, but the failure persisted. On another occasion while driving 50 MPH, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to the dealer who stated that the throttle body needed to be replaced. The vehicle was repaired but the failure reoccurred. The vehicle was taken back to the dealer and the electrical control module was replaced. The manufacturer was not contacted. The failure mileage was 110,000.

NHTSA ODI 11537780

The key gets stuck in the ignition switch and the car is not able to turn off. In order to remove the key you have to jiggle it several times which could be minutes or up to an hour. Could be a safety issue if I’m somewhere and need to turn the car off immediately. Was told this is a costly repair but if this is a known issue (and it is) why is this not a recall when possible damage or injury could occur.

NHTSA ODI 11537164

At 80k, the DSG transmission failed and at my expense paid to get a NEW transmission installed. Today, at 155k, the NEW replaced transmission failed again. So every 75K, the transmission fails with the following: Hairline cracks can develop within the transmission electronic gearbox (mechatronic unit), causing an internal transmission oil leak and a decrease in oil pressure. Transmission can not be fixed and must be replaced. Cost for a new transmission is over $8k.

NHTSA ODI 11536216

The key will either get stuck in the ignition while the car is on, or it will occasionally not turn at all. Both of which have left me or others borrowing my car stranded. Has taken up to 2 hours of jiggling the key and finally turning to the on or off position. Some shops are saying the ignition cylinder, others the switch, and others the steering lock but this seems to be a very common complaint online from Volkswagens in this age range. It could seriously harm someone if they were unable to start their car in an emergency situation due to the key not turning.

NHTSA ODI 11535287

Unknown system failure or component. Ever since I've bought the vehicle in I believe 2017 from EICH VW, it has consistently died while driving or idling. It also was "slamming on the brakes on its own" when the car would die. It jerks consistently as well. The latest out of hundreds of incidents, was yesterday, it stalled at a red light that had turned green, so I was stopped, I turned my hazards on immediately when it had stalled. The vehicle behind me went into the turn lane and the vehicle behind it was coming at me at 60+ mph as that was the speed limit on the road. There is NO warning as to when it will stall, almost never any dash light, maybe only once or twice a year. And it can go weeks or even months without incident and then go crazy for weeks or months straight. It stalling out has almost killed me and my son when trying to cross the highway to get to his dad's house, in that situation me and my at the time when I used to take that way he was 1/2 years old, and we were almost t boned by the oncoming traffic after it had stalled. I have taken it to some many certified dealers and "experts" and no one can tell me what is wrong. It has now gotten to the point where it is happening so often I'm scared to put my three year old in my car. This is a VERY COMMON issue Volkswagen knows about but won't acknowledge or do anything about, I did not know about it until after buying the car. There are no beforehand symptoms, there is no way to tell when it is going to happen, even the car is running perfectly fine before it happens. I know that service providers have been able to experience exactly what happens, but they may not remember as this has been going on for years and I'm not their only customer, and I don't even remember everywhere I've been to try and fix the problem. But it is something I have been publicly asking about and complaining about for years. My ex who works for Toyota, even experienced it when we first met, and we had to have my car towed.

NHTSA ODI 11533830

I purchased vehicle 12/06/2022 and day after purchase check engine light went off. Took it back to dealer ASH Auto and they stated they fixed it. 2 Months later check engine light again. Got a diagnostic test and codes were TBI Base Gasket, P01106 Manifold and 01314-013 Engine control module. Now one week ago dropping off daughter to work down the street and when pulled into garage my vehicle will not go I to park. Only neutral, reverse and drive work. Have to keep car in neutral with emergency brake to keep parked.

NHTSA ODI 11528874

When coming to a stop, a wrench appeared where the gear indicator was, and a service hybrid system message appeared. When attempting to accelerate after stopping, the vehicle did not move. After turning the car off and back on it was able to move again. This has occured on multiple occasions.

NHTSA ODI 11519610

Driving on the interstate, my spouse stated that the car just lost power. Fortunately, he was able to pull off. But once he tried to start the car, it wouldn't do anything. The car was towed to my home. We took the car to the local VW dealer to have the recall completed. Since the car had to be towed there, we were told that we would have to pay $500 for a diagnostic before anything can be completed. I took the car to a local repairman and he stated that the fuel pump was bad. We replaced it and the battery. The car now will not start at all. We are getting an error of "hybrid system failure", "air bag failure", epc light is on and transmission warning. The car tries to start but will not.

NHTSA ODI 11517654

The contact owns a 2013 Volkswagen Jetta Hybrid. The contact stated while driving approximately 70 MPH, the vehicle experienced a loss of motive power after the clutch disengaged. The check engine warning light was illuminated. The contact pulled over and turned off the vehicle. The vehicle was able to restart. The vehicle was taken to an unknown local dealer, where the contact was made aware that the VIN was included in NHTSA Campaign Number: 19V866000 (Power Train); however, the part for the repair was not available. The manufacturer was not made aware of the failure. The approximate failure mileage was 130,000.

NHTSA ODI 11515747

I was driving on a rainy day on the freeway where my breaks went out on me. I pressed down all of the way and the car wouldn’t stop. After I let go of the break I then pressed on the break again and they seemed to have locked on me. I ended up using my emergency breaks and was able to get off the freeway and luckily no one was hurt. Soon after they started working again and I was able to get it safely to a near by shop.

NHTSA ODI 11509328

The car would turn on for 2 seconds and turn off for 2 second in a continuous cycle when stationary. The car is available for inspection upon request. Yes the problem has been confirmed by Heritage Volkswagen and they updated the software recall...but the damage is already beyond repair. $10,000 to repair. There were not any warning lamps, messages, just the above symptoms. This started about 5 days ago. Took it to a local auto shop and they said there was an EV when the performed the diagnostics. Would have to take it to the dealership to get it fixed. That day I made an appointment with the dealership for the following morning at 7:30 a.m.

NHTSA ODI 11506444