What 604 owners told NHTSA about the 2013 Hyundai Santa Fe Hybrid Hev

I was driving when it stalled out while driving and people helped me push my car out of turning lane to safety. The hood engulfed in flames. It was out the blue I had just bought the car a few months earlier. I was notified later that there was a recall on the car that caused fires but was unaware at the time

NHTSA ODI 11590271

The contact owns a.2013 Hyundai Santa Fe Sport. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The contact stated that while parked, he observed smoke emanating from the engine compartment. The contact opened the hood and observed flames coming from the center of the motor and extinguished the fire. The fire department was made. A police report was not filed. The vehicle was towed to an independent mechanic where it was diagnosed that the fire started due to fuel rail malfunctioned and melting the hard plastic manifold causing the fire, and the fuel rail and intake manifold needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 190,000.

NHTSA ODI 11584912

I have a Hyundai 2013 Santa Fe Sport 2.0T. I parked the car in the middle of my cement driveway. I went into my home for a moment to get my Stanley water bottle. When I walked back to the car, the engine compartment was on fire. I had 2 fire extinguishers and attempted to put out the fire by to no avail. My daughter immediately called 911 to report the fire. The fire department came and it took about 8-10 fireman to put the fire under control. I have owned all types of cars for the past 40-years. I have never seen a car go up in flames and burn to the ground in about one minute. Had I parked my car in the garage my entire house would have burn down while potentially killing my entire family. I called my insurance company (Geico) to advise them of the fire and asked them to contact Hyundai about the matter. Geico said its not their responsibility. I'm having difficulty contacting Hyundai to report this serious fire before some other family gets killed. I never was notified about any type of dangerous recall with the entire car burning down. I will try to contact Hyundai again tomorrow morning (XXX). Please help me with this matter as Hyundai must be held accountable for this fire almost killing my entire family. More importantly I wish to help prevent a similar situation for another family in the future. Thank You, [XXX] [XXX] or [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11583709

The contact owned a 2013 Hyundai Santa. The contact received notification of NHTSA Campaign Number 23V651000 (Service Brakes, Hydraulics) however, the part to do the recall repair was not yet available. The contact stated while driving at 72 MPH, there was a strong smell coming from the vehicle. The contact pulled over but did not see anything and continued driving. No warning lights illuminated. However, the smell became stronger so the contact drove the vehicle to a soccer field where there were no other vehicles to leave and return with a mechanic. As the contact walked away, while the vehicle was parked, a passerby informed the contact the vehicle was on fire. Per the contact, smoke, and flames were coming from underneath the vehicle. No one was injured during the fire and the vehicle was destroyed. The vehicle was towed to CoPart. The fire department was notified and extinguished the fire. A fire department and police report was filed. The manufacturer was made aware of the failure however stated there was no fix. The approximate failure mileage was 145,000

NHTSA ODI 11567951

The vehicle caught fire while driving due to unknown cause. The vehicle was unable to break as smoke began coming into the vents. Car came to a stop and the flames were present underneath the vehicle before engulfing the entire hood. Vehicle has been deemed total loss by insurance.

NHTSA ODI 11558964

My car engine compartment fire while parked in front of my condo

NHTSA ODI 11551311

The contact owned a 2013 Hyundai Santa FE. The contact stated that while driving at an undisclosed speed, the vehicle lost all motive power, but he was able to safely coast to the shoulder of the roadway. After a visual inspection of the engine compartment, the contact observed that the engine was on fire. The contact was able to extinguish the fire with fire extinguishers provided by bystanders. A fire report was filed, and a police report was not filed. No injuries were reported. No warning lights were illuminated. The vehicle was towed to a tow and deemed a total loss. After investigating the failure, the contact related it to NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulics), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 86,000.

NHTSA ODI 11548472

TL* THE CONTACT OWNS A 2013 HYUNDAI SANTA FE. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE BRAKE PEDAL BECAME DIFFICULT TO DEPRESS. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE AND A BURNING ODOR WAS PRESENT INSIDE THE CABIN. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER (DORAL HYUNDAI LOCATED AT 10285 NW 12 ST DORAL, FL 33172) WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V226000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

NHTSA ODI 10993939

TL* THE CONTACT OWNED A 2013 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKES FAILED TO RESPOND WHEN DEPRESSED AND CAUSED THE VEHICLE TO CRASH INTO THE REAR OF ANOTHER VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE CONTACT WAS UNSURE IF A POLICE REPORT WAS FILED. THE VEHICLE WAS DEEMED DESTROYED AND TOWED TO A JUNK YARD. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

NHTSA ODI 10913736

DRIVING 15-17 MILES AN HOUR, RUSH HOUR, ON STREET TRIED TO STOP, BUMP CAR IN FRONT, DEALER SAID I NEED AN MASTER CYLINDER AND AN BREAK BOOSTER, BROUGHT MY CAR 4/9/16, CERTIFIED USED CAR, NOW I HAVE TO PAY 1200.00 TO GET THE BRAKES FIX PLUS 500.00 DEDUCTIBLE FOR ACCIDENT PLUS 100.00 DEDUCTIBLE FOR EASYCARE, THIS IS NOT FAIR.

NHTSA ODI 10872805

CAR IN FRONT OF ME STOPPED TO AVOID RUNNING RED LIGHT AT INTERSECTION. I TRIED TO BRAKE AND THOUGHT MY ANTI-LOCK BRAKES WOULD STOP ME BUT THEY FAILED TO WORK PROPERLY AND I HIT THE CAR IN FRONT OF ME. THERE WAS VERY LITTLE DAMAGE TO THE CAR IN FRONT OF ME BUT $8,000 DAMAGE TO MY CAR. I TOOK THE CAR TO THE HYUNDAI DEALER AND ASKED THEM TO CHECK OUT MY BRAKES AND THEY PUT THEIR COMPUTER ON MY CAR AND SAID EVERYTHING WAS OK. I HAVE SINCE TESTED THE "ANTI-LOCK" ON MY BRAKES AND THEY PROVIDE TOO MUCH "ANTI-LOCK" AND I KNOW HOW ANTI-LOCK SHOULD WORK LOCKING AND QUICKLY RELEASING REPEATEDLY UNTIL STOPPING, BUT THESE BRAKES DO NOT WORK LIKE THAT WITH A FEELING OF BEING ON ICE UNTIL JUST BEFORE STOPPING TO WORK LIKE MY PREVIOUSLY CARS HAVE WORKED.

NHTSA ODI 10733134