What 526 owners told NHTSA about the 2012 Volkswagen Jetta Hev

KEY STUCK IN IGNITION CAR WILL NOT TURN OFF CANNOT TURN OFF WHEN CAR IS IN PARK EMERGENCE BRAKE IS ENGAGED AND FOOT IS ON BRAKE PEDAL

NHTSA ODI 10881659

THE TURBO ON MY 2012 JETTA SPORTWAGON HAS FAILED AT 89,000 MILES AND VW WOULD NOT FIX IT. IT COST ME $3000 TO FIX. THE PARTICULATE FILTER WAS DIRTIED AS A RESULT OF THE FAILURE AND VW WILL NOT REPLACE IT. IT WILL COST ME $2000 TO FIX IT. I WANT FULL VALUE FOR THE CAR PLUS MY $3000 BACK TO FIX THE TURBO. THE TURBO FAILED FIVE MONTHS AFTER VW COMPLETED THE MANDATORY "SERVICE SOFTWARE UPDATE" REQUIRED TO GET AN APPROVED SMOG CHECK.

NHTSA ODI 10873016

CAR'S FUSE # 6 KEEPS BLOWING WHICH CONTROLS THE BACK LIGHTS THAT TURNS ON AT NIGHT, WHEN FUSE BLOWS LIGHTS ON BACK GO OUT AND CARS BEHIND YOU CAN'T SEE YOU AND MAY CAUSE A COLLISION WHERE SERIOUS INJURY AND DEATH MAY RESULT. I THINK THIS AN ENGINEERING FLAW WHERE THEY CONNECTED THE BACK LIGHTS TO OTHER MODULES IN THE CAR, SO THE SHORT REMAINS AND CAR IS NOT SAFE TO DRIVE AT NIGHT FUSE KEEPS BLOWING EVERY TIME YOU PUT A NEW ONE IN VW IS NOT WILLING TO LOOK AT THE PROBLEM AND GIVE ME A SOLUTION, THE SHORT IS NOT IN ANY OF THE LIGHTS ON THE BACK OF THE CAR, OR INSIDE THE CAR, VW IS REFUSING TO GIVE ME THE SCHEMATIC DIAGRAM FOR THAT CIRCUIT SO WE CAN TRACE THE PROBLEM, THEY INSIST ON TAKING IT TO THE DEALER WHERE IT IS GOING TO BE A VERY EXPENSIVE FIX TO TRACK DOWN THE SHORT WHERE IT IS AN ENGINEERING FLAW. ALSO THE AIR BAGS WARNING LIGHTS COME ON INTERMITTENTLY, AND SEAT BELTS WARNING LIGHTS COME ON AND START CHIMING WHILE YOU HAVE SEAT BELTS ON AND PROPERLY FASTENED, DO NOT KNOW IF SEAT BELT OR AIRBAGS ARE DEFECTIVE WHICH IS VERY UNSAFE IN MY OPINION, AND VW REFUSES TO LOOK AT MY PROBLEM WITHOUT A HEFTY DEALER CHARGE. PLEASE HELP

NHTSA ODI 10863781

HAD CAR IN FOR NEW TIRES AND AFTER I LEFT THE MILEAGE WENT FROM MID 40S TO MID 30S, NO ENGINE SERVICE LIGHT, NO PARTICAL FILTER LIGHT, RETURNED TO DEALER AND DIDN'T OFFER TO CHECK IT. 24,000 MILES. IS THIS SOMETHING TO DO WITH DIESELGATE?

NHTSA ODI 10859978

MY FIRST CONCERN IS THE SEAT BELT WARNING LIGHT WILL NOT STOP MAKING AN ALARM NOISE. MY SEAT BELT IS PLUGGED IN, AND THE ALARM WILL NOT STOP AND THE DASHBOARD VIEWS IT AS UN PLUGGED AS WELL. CLEARLY, IT WAS PLUGGED IN. I TRIED TO TAKE IT OUT, INSERTING IT BACK IN SLOW AND FAST. NEITHER WAS ACKNOWLEDGED BY THE SYSTEM. AM I EVEN SAFE??? SECOND, THERE IS SOME SORT OF DELAY WHILE DRIVING. I JUST PURCHASED THE CAR IN DECEMBER 2015. IN MARCH 2016, THE CAR HAS SOME SORT OF DELAY WHILE I'M DRIVING. NOT DURING DECELERATION OR ACCELERATION. BUT IN THE 40 -50 MPH RANGE. I REALIZE, MAYBE IT HAS SOMETHING TO DO WITH THE TURBO INJECTION. IT HAS STARTED HAPPENING AGAIN SPORADICALLY A MONTH LATER.... ??? PLEASE HELP WITH CLARITY ON THIS ISSUE. IS THERE FUEL INJECTION ISSUES WITH TDI? OKW

NHTSA ODI 10855223

ON AN AFTERNOON IN EARLY FEBRUARY 2016, MY 2012 VW JETTA TDI WENT INTO 'LIMP' MODE AFTER STARTING IT AND DRIVING FOR LESS THAN TWO MINUTES OUT OF MY WORKPLACE PARKING LOT. I WAS BARELY ABLE TO GET IT TO THE SIDE OF THE ROAD AND STOP, WHEN IT DIED COMPLETELY AND WOULD NOT START AGAIN. THE GLOW PLUG DASH LIGHT CAME ON. I HAD IT TOWED TO THE DEALER THE NEXT DAY AND THEY DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP (HPFP) HAD FAILED, BLOWING ,METAL SHARDS THROUGHOUT THE ENTIRE FUEL SYSTEM. THEY PERFORMED A DIESEL FUEL TEST, WHICH 'PASSED', SO ALL REPAIRS WERE COVERED UNDER WARRANTY. THE CAR HAD 53,000 MILES ON IT AT THAT POINT. PARTS ALONE WOULD HAVE COST NEARLY $4000, AND I WAS NOT SHOWN WHAT THE LABOR COSTS WOULD HAVE BEEN! I THEN DISCOVERED THAT THIS IS A 'KNOWN' ISSUE BUT NOT UNDER RECALL, ONLY AN EXTENDED WARRANTY PERIOD. HAVING THE COMPLETE LOSS OF POWER THAT LIMP MODE RESULTED IN, AND BEING STRANDED FOR HOURS WAITING FOR A TOW, MADE ME RECONSIDER MY PURCHASE DECISION FOR THIS VEHICLE. I AM VERY GLAD I WAS NOT ON THE FREEWAY, AS THE FAILURE COULD HAVE BEEN DEADLY IN THAT DRIVING ENVIRONMENT. WITH THE CURRENT DIESEL EMISSIONS SCANDAL ONGOING, I AM 'STUCK' WITH THIS VEHICLE, UNLESS I WANT TO TAKE A DRASTIC HIT ON PRIVATE RESALE VALUE; NO ONE WILL TAKE IT IN TRADE. THIS IS A VERY DANGEROUS PROBLEM THAT NEEDS BETTER RESOLUTION.

NHTSA ODI 10855358

4/5/16 4:30PM, VEHICLE WOULD NOT SHUT OFF. BROUGHT TO VOLKSWAGEN DEALERS WHO DIAGNOSED VEHICLE WITH AN IGNITION LOCK CYLINDER HOUSING ISSUE. THE VEHICLE DID NOT STALL OR FAIL IN THAT SENSE, BUT IT IS STILL DISTRESSING TO HAVE A FAULT ON THE IGNITION SWITCH.

NHTSA ODI 10853881

THE VEHICLES ENGINE WOULD REV BY ITS SELF WITH THE PEDAL STUCK TO THE FLOOR AND THE CLUTCH WOULD NOT DISENGAGE DURING THIS LEAVING THE VEHICLE ACCELERATING ON ITS OWN.

NHTSA ODI 10852866

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA SPORTWAGEN. THE CONTACT STATED THAT WHILE PARKED, THE TRUNK AJAR WARNING LIGHT ILLUMINATED AND THE TRUNK OPENED INDEPENDENTLY. THE CONTACT MENTIONED THAT THE TRUNK FAILED TO CLOSE PROPERLY. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REAR LATCH HAD FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 37,545.

NHTSA ODI 10852071

TL* THE CONTACT OWNED A 2012 VOLKSWAGEN JETTA. WHILE DRIVING 70 MPH, THE VEHICLE FAILED TO REMAIN IN POSITION AND THE REAR OF THE VEHICLE MOVED TO THE OPPOSITE POSITION WHEN THE STEERING WHEEL WAS TURNED. THE CONTACT VEERED TO THE LEFT AND THE STEERING WHEEL SEIZED. AS A RESULT, THE CONTACT CRASHED INTO A CONCRETE DIVIDER. THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED NECK AND SHOULDER INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED FROM THE CRASH SCENE AND WAS DEEMED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V656000 (SUSPENSION). THE FAILURE MILEAGE WAS 53,000.

NHTSA ODI 10850384

DRIVER SIDE BULB KEEPS BURNING OUT. WAS REPLACED BY DEALER WITH OEM PARTS, BUT IT KEEPS BURNING OUT EVERY MONTH. THE DAYLIGHT RUNNING LIGHT ON THE DRIVER SIDE DOES NOT WORK. THEY KEEP REPLACING IT AND IT KEEPS BURNING OUT. I SEE MANY OTHER JETTA'S LIKE MINE WITH THE SAME PROBLEM ON THE ROAD.

NHTSA ODI 10850173

MY HEADLIGHTS KEEP BURNING OUT. I REPLACED THEM 4 TIMES IN THE LAST TWO MONTHS! THERE IS NOTHING WRONG WITH THE BULB HARNESSES. THERE WAS A POINT WHERE BOTH HEADLIGHTS BURNED OUT AT THE SAME TIME AND I HAD NO LIGHTS! I DID RESEARCH ON THIS MATTER TO FIND MANY JETTA OWNERS ARE HAVING THE SAME ISSUE THESE BULBS ARE NOT CHEAP TO KEEP REPLACING THEM EVERY COUPLE OF MONTHS, AND THE SAFETY ISSUE HAS TO BE CONSIDERED HERE. I WAS PARKED THANK GOD O NOTICED NO LIGHTS BEFORE O DROVE. IF WHERE I LIVED WAS LIT UP I NEVER WOULD HAVE NOTICED BOTH MY BULBS WERE BURNT OUT!

NHTSA ODI 10850172

FOR OVER A YEAR, MY CAR WAS HAVING HESITATION ISSUES. I KEPT CALLING MY DEALER AND GOING IN FOR REGULAR SERVICE. AT ONE POINT, MY CAR STARTED BUT THEN TURNED OFF TWO TIMES. I KEPT GETTING DIFFERENT STORIES..."UNABLE TO REPLICATE", "A FAULTY VALVE, CODE P2004." ON MY WAY TO WORK 2/23/16, MY CAR LOST POWER ON ACCELERATION. THE CHECK ENGINE LIGHT AND THE COIL (TDI) LIGHT CAME ON. I PULLED OVER AND TURNED OFF THE CAR AND WAITED. THEN STARTED THE CAR AGAIN, BEGAN DRIVING, AND IT HAPPENED AGAIN. I CALLED THE TOW TRUCK. DEALER SERVICE MANAGER (FITZGERALD - ANDREW) GAVE ME THE RUN AROUND -- TELLING ME THAT I PUT CONTAMINATED FUEL IN MY CAR. I CALLED SUNOCO AND MY, GEICO, IMMEDIATELY. THE MOST UPSETTING PART OF ALL OF THIS WAS HOW ANDREW APPROACHED THE PROBLEM, EXAGGERATED MY INVOLVEMENT IN IT AND ARROGANTLY USED HIS POSITION TO SHOW BLAME TO ME -- NEVER EXPLAINING THIS IS AN EXTENDED RECALL AND WHY! I AM NOW GETTING MY FUEL PUMP FIXED UNDER THE WARRANTY. BUT.... THIS SHOULD BE A RECALL NOW. I KNOW THAT THIS PROBLEM WAS ON-GOING FOR ME FOR A WHOLE YEAR, AND I BELIEVE THAT IT HAS DAMAGED MY CAR, AND I CANNOT PROVE THIS. PLEASE SAVE OTHER OWNERS AND RECALL THIS PART.

NHTSA ODI 10840226

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V656000 (SUSPENSION); HOWEVER, THE DEALER STATED THAT THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI 10839535

WHEN THE WEATHER IS COLD (BELOW FREEZING), WHILE DRIVING, AFTER SITTING OUTSIDE OVERNIGHT, OR IN SNOWY CONDITIONS, THE WINDSHIELD WIPERS FREEZE AND DO NOT WORK UNTIL THE WEATHER WARMS UP, OR THE VEHICLE IS PARKED IN A GARAGE. I LIVE IN THE MOUNTAINS OF COLORADO AND THIS HAS BEEN AN ONGOING ISSUE DURING COLD AND SNOWY WEATHER. THIS IS A SAFETY HAZARD AS THE ROADWAY IS NO LONGER VISIBLE BECAUSE THE WINDSHIELD WIPERS NO LONGER WORK.

NHTSA ODI 10838450

I HAD TWO NO START CONDITIONS DUE TO A FROZEN INTER COOLER. THIS HAPPENED IN JANUARY A WEEK APART. THIS HAPPENED WHILE THE CAR WAS IN THE GARAGE.

NHTSA ODI 10825697

AFTER OPENING THE TRUNK ON DRIVE WAY, THE TRUNK LID FELL FREELY AND HIT MY WIFE'S FOREHEAD (VERY CLOSE TO HER EYES).

NHTSA ODI 10825074

AFTER DRIVING AND ARRIVING AT DESTINATION, CANNOT TURN THE CAR OFF, NOR GET THE KEY OUT OF THE IGNITION. SOMETIMES IT TAKES 15 MINUTES OF TURNING THE STEERING WHEEL AND TRYING TO TURN THE KEY OVER AND OVER WHEN THE KEY WILL FINALLY TURN AND THE CAR WILL TURN OFF. THEY KEY FEELS STUCK IN THE IGNITION AND THE CAR WILL NOT TURN OFF.

NHTSA ODI 10821743

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HORN AND SECURITY SYSTEM DID NOT FUNCTION WHEN ATTEMPTING TO LOCK THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT ATTEMPTED TO REPLACE THE SPARKS PLUGS ON FOUR DIFFERENT OCCASIONS, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 69,868.

NHTSA ODI 10819599

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE FUEL DOOR FAILED TO UNLOCK. THE DEALER ADVISED THE CONTACT TO LOCK AND UNLOCK THE VEHICLE DOORS SEVERAL TIMES AND THEN ACTIVATE THE FUEL DOOR LOCK SYSTEM TO UNLOCK THE FUEL DOOR. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS AWARE OF THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER TO HAVE THE FUEL TANK DOOR LOCK MODIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 43,000.

NHTSA ODI 10818423

PURCHASED CERTIFIED PREOWNED IN MAY. 2ND TIME WHEN IT IS COLD OUT THAT WIPERS WILL NOT TURN ON. THE 1ST TIME THIS HAPPENED IN OCTOBER, IT TOOK OVER 5 MINUTES OF DRIVING THE CAR WITH DEFROSTER ON HIGH FOR THEM TO START WORKING I CALLED DEALER AND WAS TOLD THAT IT HAD BEEN COLD THAT MORNING AND THE WIPERS WERE PROBABLY FROZEN TO THE WINDOW, EVEN AFTER I TOLD THEM I HAD LET THE CAR WARM UP FOR 10 MINUTES. THE 2ND TIME WAS THIS MORNING, I LET THE CAR WARM UP FOR 15 MINUTES SINCE IT WAS ABOUT 5 DEGREES OUT AND EVEN AFTER DRIVING THE CAR FOR 1 HOUR, THE WIPERS STILL WOULD NOT TURN ON. I CALLED THE DEALER, MADE AN APPT TO BRING IN THAT DAY AND THE WIPERS STARTED WORKING AROUND NOONTIME. WHEN I WENT TO THE DEALER, I WAS TOLD THAT THEY WOULD LOOK AT IT, HOWEVER, IF THEY COULDN'T FIND ANYTHING AND THERE WAS A GOOD CHANCE THAT THEY WOULDN'T SINCE IT DID NOT MAKE SENSE THAT THEY WOULD JUST START WORKING THAT THERE WOULD BE A CHARGE OF $105.00 PER HOUR IF IT TURNED OUT TO BE NOT COVERED UNDER THE WARRANTY. I HAVE FOUND SEVERAL COMPLAINTS REGARDING THIS SAME ISSUE ON LINE, I THINK IT IS TIME FOR A RECALL.

NHTSA ODI 10818529

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA. WHILE STARTING THE VEHICLE, THE CONTACT NOTICED A BURNING ODOR EMITTING FROM INSIDE THE VEHICLE. THE ENGINE COMPARTMENT CAUGHT FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN AUTO BODY REPAIR CENTER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.

NHTSA ODI 10816968

THE CAR UNINTENTIONALLY ACCELERATES AND THERE SEEMS TO BE AN ISSUE WITH THE CLUTCH DISENGAGING AT HIGHWAY SPEEDS. THE CAR HAS 42K MILES ON IT AND THE DEALER WANTS A PER-AUTHORIZATION SIGNED OF $1600 BEFORE THEY WILL LOOK AT THE ISSUE. UNSAFE AND INSANE!

NHTSA ODI 10816677

THERE IS A SERIOUS DESIGN FLAW IN THE REAR AXLE OF THIS VEHICLE WHEREBY ROAD DEBRIS CAN STRIKE THE AXLE CAUSING IT TO BEND. I THINK THE DESIGN FLAW IS TWO-FOLD. 1. THE AXLE IS PLACED IN SUCH A MANNER THAT IT IS TOTALLY UNPROTECTED FROM ROAD DEBRIS. 2. THE METAL OF THE AXLE AND TRAILING ARMS IS NOT HARDENED TO A STRONG ENOUGH DEGREE TO WITHSTAND DEBRIS STRIKES AND SUBSEQUENT STRESS. DRIVING AT HIGHWAY SPEEDS, I RAN OVER A 4-6" PIECE OF TWO BY FOUR OR POSSIBLY ANGLE IRON (NOT SURE WHICH). THE OBJECT WAS KICKED UP BY THE FRONT COWLING. THE OBJECT MADE MULTIPLE IMPACT STRIKES UNDER THE CAR FROM FRONT TO BACK AS EVIDENCED BY THE MARKINGS LEFT ON THE ALUMINUM COVERED INSULATION THAT COVERS THE UNDERCARRIAGE, ULTIMATELY STRIKING THE REAR AXLE, CAUSING IT TO BEND. THE BEND IN THE AXLE IS FRONT-TO-BACK. THIS IS NOT FROM BACKING OVER ANY OBJECT (SEE CAMPAIGN 14V656000). THIS IS A SERIOUS DESIGN FLAW AND A SERIOUS SAFETY ISSUE. THE REAR AXLE AND TRAILING ARMS ARE EXPOSED TO ROAD DEBRIS AND NOT OF SUFFICIENT STRENGTH TO WITHSTAND IMPACT AND SUBSEQUENT STRESS ON TRAILING ARMS. A THIN PIECE OF SHEET METAL IS NOT SUFFICIENT TO REMEDY THIS ISSUE AND IS EXPOSING AMERICAN DRIVERS TO SERIOUS CRASH POTENTIAL AND DEATH. YOU CAN ALSO SEE CHINA'S INVESTIGATION OF THIS ISSUE HERE: HTTP://WWW.DPAC.GOV.CN/XWDT/GZDT/201509/W020150911606237827139.PDF AND HERE: HTTP://WWW.DPAC.GOV.CN/VIDEO_XINSUTENG/

NHTSA ODI 10811366

STARTING AS THE WARRANTY EXPIRED AT 40K MILES, MY HORN BECAME INTERMITTENT. IT WOULD WORK FINE FOR A WHILE, THEN COMPLETELY STOP FOR A PERIOD; SOMETIMES A WEEK OR SO. BUT AS TIME PROGRESSED, IT WAS NOT WORKING MORE THAN WORKING. BY 50K MILES IT NOT LONGER WORKED AND NOW AT 60K IT HASN'T WORKED FOR A LONG TIME. VERY DANGEROUS. DEALER SAID TWICE THEY WOULD TRY TO GET IT FIXED BUT NEVER CAME THROUGH. SO WITH MY DIESEL "GOOD WILL" PACKAGE, I WILL USE THE $500 CREDIT TO REPLACE MY HORN THAT THEY SHOULD HAVE REPLACED EARLIER. LOT'S OF PEOPLE ONLINE HAVE THE SAME PROBLEM. I THINK IT'S PART OF THE 2011 RECALL FOR HORN AND ALARM SYSTEM PROBLEMS, DON'T THINK THEY CARRIED THROUGH WITH THE PROBLEM.

NHTSA ODI 10810186