What 119 owners told NHTSA about the 2012 Mini Cooper Countryman

THESE 2012 MINI COOPER CLUBMAN ARE HAVING THE TIMING GUIDES BRAKE AND SOMETIMES RUIN THE ENGINE. IN MY CASE I THINK I CAUGHT IT ON TIME, I CALLED MINI HERE LOCALLY AND MY WARRANTY RUNS OUT THIS SEPTEMBER 2017 OR 100,000. BUT MY CAR JUST HIT 105,000, THIS IS AN ISSUE THAT MINI HAVE HAD FOR QUITE A FEW YEARS AND I SAW A RECALL UP TO 2011 BUT HAVEN'T SEEN ANYTHING FOR 2012 MINI CLUBMAN. IT'S HARD TO BELIEVE THAT BMW/MINI WENT WITH PLASTIC GUIDES INSTEAD OF SOME OTHER MATERIAL THAT COULD WITHSTOOD MORE BEATING, SPECIALLY FOR THIS AREA. THANK YOU FOR ANY HELP, BECAUSE I'M HAVING TO FORK OUT ANY WHERES BETWEEN $1500'TO $3000.00!TO GET THIS FIXED. I WAS DRIVING WHEN I HEARD THE NOISE AND NOW IT SITS IN MY DRIVEWAY.

NHTSA ODI 11021337

CHECK ENGINE LIGHT-- COOLENT THERMOSTAT STICKING PER ALLDATA SHOWS THERMOSTAT HOUSING W/THERMOSTAT, SENSOR ETC, SHOWS RECALL FOR THESE PARTS UPDATED.

NHTSA ODI 10896947

WATER PUMP FAILURE. BEGAN TO NOTICE SMALL AMOUNT OF LIQUID UNDER CAR IN APRIL 2016, THOUGHT IT WAS CONDENSATION FROM A/C. LEAK WORSENED AND CALLED MINI IN JUNE 2016 TO CHECK IT OUT. WATER PUMP FAILURE ON VEHICLE WITH 45,500 MILES. CLASS ACTION LAWSUIT SETTLEMENT AGREED IN CALIFORNIA IN MARCH WAITING ON FINAL APPROVAL OF TERMS DUE IN NOVEMBER 2016. BMW KNOWS THIS IS A DEFECTIVE PART. WATER PUMP FAILURE FROM DEFECTIVE PART COULD HAVE CATASTROPHIC EFFECTS IF AUTOMOBILE IS IN MOTION AT ANY SPEED.

NHTSA ODI 10885861

DRIVING 45 MPH ON BUSY CITY FOUR-LANE ROAD, I BRAKED GRADUALLY IN APPROACH TO RED LIGHT, WHICH IS MY NORMAL BRAKING STYLE. CAR DID NOT COME TO A COMPLETE STOP--BRAKES ONLY WORKED TO A POINT BUT DID NOT COMPLETELY STOP CAR; SIMULTANEOUSLY ENGINE REVVED TO VERY HIGH RPM. I THREW TRANSMISSION INTO PARK AND TURNED OFF IGNITION LEST MY CAR RAM CAR AHEAD OF ME. VERY FRIGHTENING. AT PREVIOUS TWO LIGHTS I HAD NOTICED THAT BRAKES WERE ACTING FUNNY, NOT BRINGING CAR TO A COMPLETE STOP BUT I HAD LEFT PLENTY OF BRAKING DISTANCE AND WAS ABLE TO LET CAR ROLL TO A STOP, IN SPITE OF BRAKES NOT EFFECTING A COMPLETE STOP . AT THOSE TWO LIGHTS THE RUNAWAY ENGINE (HIGH RPM) DID NOT OCCUR OR I WOULD HAVE PULLED OVER RIGHT THEN. HOWEVER, ENGINE REVVING TO HIGH RPM HAS ALSO OCCURRED OCCASIONALLY WHEN PULLING INTO GARAGE BUT I HAD NOT GIVEN THIS A LOT OF THOUGHT BECAUSE I HAVE QUICKLY TURNED OFF IGNITION. NOW I KNOW IT'S VERY DANGEROUS SITUATION. OF COURSE I AM NOT DRIVING IT BUT AM HAVING IT TOWED TO DEALER FOR REPAIR. THE CAR HAS BEEN SERVICED REGULARLY AT DEALER AND HAS 24,239 MILES ON IT. THERE HAS NEVER BEEN A NECESSITY FOR REPAIRS ON THIS MINI COOPER CLUBMAN.

NHTSA ODI 10875740

MY 2012 MINI COOPER COUNTRYMAN WITH 30,000 MILES IS REQUIRING REPLACEMENT OF THE THERMOSTAT AND WATER PUMP - BOTH OF WHICH WERE RECALLED AND REPLACED ON THE 2011 MINI COOPER COUNTRYMAN. THERE ARE NOT ANY PARTS IN THE UNITED STATES CURRENTLY TO FIX THE CAR. WE WILL BE WITHOUT OUR CAR FOR NEARLY 3 TO 4 WEEKS WHILE WE WAIT FOR THESE PARTS AND WE HAVE BEEN TOLD NOT TO DRIVE OUR CAR ON THE HIGHWAY. THE DEALER SAID TOUGH LUCK.

NHTSA ODI 10871243

TL* THE CONTACT OWNS A 2012 MINI COOPER. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE TECHNICIAN DIAGNOSED THAT THERE WAS A LEAKAGE ON THE OIL CONTROL VALVE. AS A RESULT, THE TECHNICIAN STATED THAT THE OIL CONTROL VALVE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 10,800.

NHTSA ODI 10853576

TIMING CHAIN STRETCHED CAUSING TIMING TO BE OFF BY 75MM, THIS RESULTED IN DAMAGE TO THE ECCENTRIC SHAFT AND TIMING CHAIN. ENGINE ENGINE MALFUNCTION LIGHT ILLUMINATED, UPON INSPECTION AT MINI DEALER DETERMINED THE ABOVE CONDITION OF VEHICLE.

NHTSA ODI 10852760

TL* THE CONTACT OWNS A 2012 MINI COOPER COUNTRYMAN. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE ENGINE SPUTTERED AND THERE WAS SMOKE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT OIL WAS LEAKING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE HOSE PIPE AND FREEZE PLUG OVERHEATED AND MELTED WHICH CAUSED THE ENGINE TO REQUIRE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 44,000.

NHTSA ODI 10845785

TL* THE CONTACT OWNS A 2012 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TURBO CHARGER AND THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 10820319

TL* THE CONTACT OWNED A 2012 MINI COOPER. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT CRASHED INTO THE PRECEDING VEHICLE AFTER IT STOPPED WITHOUT WARNING. THE VEHICLE WAS MERGED INTO A PARKING LOT, WHERE THE CONTACT NOTICED SOME MINOR DAMAGE TO THE FRONT OF THE VEHICLE AND SMOKE APPEARED UNDER THE HOOD AS A FIRE STARTED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 10744546

CHECK ENGINE LIGHT CAME ON. CAUSE: HEATING FAULT CODE IN DIAGNOSIS(THERMOSTAT ACTIVATION). THERMOSTAT, HOUSING , AND ADAPTER REPLACED. REMOVED AND REPLACED COOLANT, CHECKED COOLING SYSTEM FOR LEAKS. 06/17/2015 CHECK ENGINE LIGHT HAS COME ON AGAIN, AND AFTER TAKING TO DEALERSHIP IT APPEARS TO BE THE THERMOSTAT AGAIN.

NHTSA ODI 10735421

ENGINE LIGHT CAME ON SO I WENT IN FOR A DIAGNOSTIC. I LIVE 2.5 HOURS FROM A MINI SERVICE CENTER. THE DIAGNOSTIC AT AUTOZONE JUST LISTED A BUNCH OF MISFIRES AND NOTHING ELSE. THAT EXPLAINED THE HARSH SOUNDING START AND SPUTTERING. AS DAYS HAVE GONE BY, CAR WILL LOSE POWER IN THE MIDDLE OF TRAFFIC, STRUGGLE UP HILLS, FAIL TO MAINTAIN SPEED LIMIT, AND STRUGGLE TO START IN THE MORNING. ALL THESE EVENTS HAVE OCCURRED LESS THAN A MONTH AFTER BEING SERVICED AT SEATTLE MINI. I'M SURE I'M UNDER WARRANTY, BUT I'M NOT HAPPY ABOUT HAVING TO DRIVE 2.5 HOURS IF I CAN MAKE IT THERE, FOR SOMETHING THEY SEEM TO HAVE BEEN HAVING COMPLAINTS ABOUT. *TR

NHTSA ODI 10681435

OUR 2012 MINI COOPER COUNTRYMAN WAS PARKED IN PARKING GARAGE. WITHIN MINUTES OF SHUTTING IT OFF THE ENGINE CAUGHT ON FIRE WHICH SPREAD QUICKLY. THE CAR WAS COMPLETELY DESTROYED. OTHER CARS NEXT TO IT WERE AFFECTED AND THE FLOOR OF THE PARKING GARAGE WAS CLOSED DUE TO DAMAGES. THIS IS VERY SERIOUS AND DANGEROUS. *TR

NHTSA ODI 10633032

PURCHASED A CERTIFIED PRE-OWNED MINI NEXT 2012 CLUBMAN 6-SPEED WITH 6,498 MILES ON IT 08/2013. * 10/14/2013 AROUND 9K MILES LOST POWER ON THE HIGHWAY AND WENT INTO LIMP MODE, MANEUVERED TO SIDE OF HIGHWAY AND CALLED ROADSIDE ASSISTANCE. TOWED CAR IN TO DEALER WHO REPLACED 4 SPARK PLUGS SAID ALL WAS OK. * 10/17/2013 I PICK THE CAR UP, GET 3 MILES FROM DEALER ON INTERSTATE AND THE CAR DOES IT AGAIN SO I MANEUVERED OFF THE CLOSEST EXIT AND CALLED ROADSIDE ASSISTANCE. TOWED BACK INTO DEALER AND THEY KEPT CAR UNTIL 26TH. THEY SAID THE DME WAS BAD AND REPLACED IT AND 4 FUEL INJECTORS. * 10/30/2013 CAR DID IT AGAIN AND I DROVE HOME IN LIMP MODE, CAR WAS SHAKING AND SOUNDED LIKE A 1970 VW BEETLE, NEARLY DIED AT EVERY IDLE, ROUGH, ACCELERATION AND I CALLED ROADSIDE ASSISTANCE AND THEY HAD CAR TOWED FROM MY DRIVEWAY BACK TO DEALER. *11/5/2013 DEALER STILL HAS CAR. *TR

NHTSA ODI 10551014

ONLY RUN 12000 MILE LESS THAN YEAR THERE IS RATTLE SOUND ON SPEEDOMETER" SPECIALLY NAVIGATION SCREEN. THEY TRY FIX THE PROBLEM, AND TELL ME , THEY CAN NOT FIX, BECAUSE IT COMING FROM SPEEDOMETER. AND PRINT OUR ONE PIECE PAPER, WHICH IS MINI OFFICIAL PAPER AS BELOW" SUBJECT: BUZZING NOISE FROM SPEEDOMETER SITUATION: WHEN THE VEHICLE IS DECELERATION THE CUSTOMER MIGHT EXPERIENCE A BUZZING NOISE FORM THE SPEEDOMETER, WHEN SPEEDOMETER NEEDLE IS BETWEEN 0 AND 12 MILES PER HOUR. GENERAL INFORMATION: THIS IS NORMAL OPERATION????. WHAT?? NORMAL? THIS SOUND MAKE ME CRAZY, SAME SOUND EVERYTIME I RUN. I WAS TALK TO MINI TEC PERSON, MANY PEOPLE COMPLAIN ABOUT THIS PROBLEM, BUT MINI U.S.A DON;T RECALL ANYTHING. THEY SHOULD RECALL FOR THIS PROBLEM, SINCE THEY AGREE THERE IS NOISE FORM SPEEDOMETER" I HAVE PRINTED PAPER FROM MINI. ALSO THERE IS NOISE INSIDE OF CAR, THEY ALREADY FIX THE DASHBOARD, AND ,SIDE DOOR NOISE. *TR

NHTSA ODI 10502715

THE DRIVER SIDE WINDOW MOTOR DIED AND NEEDED TO BE REPLACED. THE TRANSFER CASE AND DRIVE SHAFT BOTH NEEDED TO BE REPLACED AFTER ONLY 14000 MILES ON A 2012 VEHICLE. THE VEHICLE HAS BEEN MAKING A TERRIBLE GRINDING NOISE AND RUSTING OUT FROM THE AXLES BUT WAS TOLD IT WAS SAFE TO DRIVE UNTIL THEY COULD FIT ME IN FOR AN APPOINTMENT. THE GRINDING CONTINUOUSLY GOT WORSE UNTIL WHEN THEY TOOK IN THE CAR TODAY REALIZED THE PROBLEM WAS MUCH WORSE THAN ANTICIPATED. IT SEEMS I AM NOT THE FIRST INDIVIDUAL TO HAVE SUCH A PROBLEM WITH THE VEHICLE AS WELL. *TR

NHTSA ODI 10491920

ON A 2012 MINI COUNTRYMAN S ALL4 WITH MANUAL TRANSMISSION, STARTING AT 15500 MILES ON THE CAR, BEGAN NOTICING ODD RESPONSE TO THE THROTTLE WHEN ACCELERATING ON THE HIGHWAY. THE CLUTCH WOULD ENGAGE AND ENGINE INCREASE REVS (200-400 RPM) TO ACCELERATE WHILE NOT DEPRESSING THE CLUTCH PEDAL. THIS WORSENED OVER THE NEXT 500 MILES UNTIL THE RPM DIFFERENCE WAS 2000-4000 RPM. FINALLY, THE CLUTCH GAVE COMPLETELY, WITH SMOKE BILLOWING FROM THE HOOD AND OBVIOUS SMELL OF BURNT PLATE, EVEN THOUGH I HAD NOT ENGAGED THE PEDAL WHILE TRAVELING ON THE HIGHWAY IN HIGH GEAR. AFTER ALLOWING THE CAR TO REST DURING THE DAY, I MANAGED TO GET MOVING FOR 1/4 MILE BEFORE STOPPING AT A LIGHT. UPON TAKEOFF, THE CAR SHUDDERED VIOLENTLY, AND THEN DISENGAGED FROM 1ST GEAR AND WOULD NOT RE-ENGAGE. HAD THE VEHICLE TOWED TO DEALER FOR REPLACEMENT. *TR

NHTSA ODI 10485016

ON 3/6/12 (VEHICLE MILEAGE 4,743) MY WIFE AND KIDS WERE DRIVING IN OUR 2012 MINI COUNTRYMAN S AND THE ENGINE SUDDENLY WENT INTO LIMP MODE WITH REDUCED POWER ON THE FREEWAY AND NEEDED TO BE TOWED TO THE DEALER. THE ENGINE COMPUTER WAS RESET AND THE VEHICLE WAS RETURNED TO US. ON 5/15/12 (VEHICLE MILEAGE 9,318) THE SAME ISSUE OCCURRED AND THE CAR AGAIN WAS TOWED TO THE DEALER FOR THE REPLACEMENT OF THE VALVTRONIC ACUTATOR. ON 7/27/12 (VEHICLE MILEAGE 13,140) THE SAME ISSUE HAPPENED AGAIN (ENGINE WENT INTO LIMP MODE WITH LOSS OF POWER AND MY WIFE AND KIDS WERE STRANDED ON THE FREEWAY 100 MILES FROM THE DEALER. THE CAR WAS TOWED TO THE DEALER AND THE VEHICLES COMPUTER WAS RESET. I REPORTED THESE SERIES OF INCIDENTS TO MINI USA CUSTOMER CARE AS I DO NOT BELIEVE THE VEHICLE IS SAFE TO OPERATE FOR FEAR OF HAVING MY WIFE AND KIDS STRANDED AGAIN AND HAVE REQUESTED A REPLACEMENT VEHICLE OR REFUND. *TR

NHTSA ODI 10471676

MY MINI WAS STOPPED AT A TRAFFIC LIGHT BEHIND A TOYOTA 4 RUNNER WHEN I WAS STRUCK FROM THE BACK BY A CARELESS DRIVER IN A MIDSIZE SEDAN WHO HAD FAILED TO SEE THE CARS IN FRONT OF HER STOPPED AT A RED LIGHT. THE DAMAGE DONE TO BOTH THE CAR THAT STRUCK MINE FROM BEHIND AS WELL AS THE DAMAGE DONE TO THE 4 RUNNER WERE MINIMAL BY COMPARISON. THE MINI INCURRED IRREPARABLE DAMAGE TO THE FRONT END OF THE CAR. MY CONCERN IS THAT THE AIRBAGS NEVER DEPLOYED AND THE DRIVER OF THE 4 RUNNER PULLED ME OUT OF THE CAR DUE TO FIRE HE SAW COMING FROM UNDER THE ENGINE OF THE MINI, BEFORE LONG THE WHOLE FRONT END WAS ENGULFED IN FLAMES. THE CAR WAS DECLARED A TOTAL LOSS. SHOULD THE VEHICLE HAVE CAUGHT ON FIRE? SHOULDN'T THE AIRBAGS HAVE DEPLOYED WITH THE GRAVITY OF THE DAMAGE? *TR

NHTSA ODI 10468763