What 253 owners told NHTSA about the 2012 Hyundai Tucson Hybrid Hev

The contact owns a 2013 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11567997

Our [XXX] daughter was driving the vehicle from our home to work in Richmond Heights (approx. 19 miles) on [XXX] on {XXX]. At approximately [XXX] and before the [XXX] exit ([XXX] area), the vehicle made a load bang/popping noise, began to lose power, and the interior began to fill with smoke. She was driving in one of the center lanes and luckily made it over to the right shoulder without incident despite traffic and the smoke impairing her view and use of the rear and side mirrors. She immediately got out and called 911. Luckily there was no accident involved and she was not trapped in the vehicle. She was not injured, just very shaken. The vehicle was on fire under the hood and eventually burst into flames. The Kirkwood City Police Officer called the Kirkwood Fire Department and Terry's Towing. The fire was put out, but not before causing the vehicle to be totaled (see photos). Terry's Towing towed the vehicle to its lot, where it is currently stored. The vehicle is a total loss. As we purchased the vehicle from a family member earlier in 2023 as a spare car for our 16yo son and 20yo daughter (when she's home on break from college) for local and short drives, we only carried liability insurance on it with Progressive. We were not aware of Hyundai Recall 251 / NHTSA Recall # 23V651000 until after this happened to our daughter. We have filed a case with Hyundai. The vehicle has not yet been inspected by them or anyone else. The vehicle was running fine. The ABS light had come on sometime prior to this incident. The vehicle was going in for an oil change and system check after the holidays. In the process of obtaining the fire department report. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11568090

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11566111

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11565721

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11564827

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11564598

The contact owns a 2012 Hyundai Tucson. The contact stated that while driving at undisclosed speeds, there was smoke coming from the tailpipe and a gurgling sound was coming from the exhaust. Additionally, the vehicle was experiencing excessive oil consumption. The vehicle was taken to the local service center who diagnosed that the engine oil was present inside the engine cylinder and the engine needed to be replaced. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 137,000.

NHTSA ODI 11564391

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was inoperable. The contact depressed the brake pedal to the floorboard and the vehicle failed to stop. The contact continually depressed the brake pedal and the vehicle eventually stopped. The contact checked the brake fluid reservoir and noticed that the brake reservoir was empty. The contact refilled the brake fluid reservoir. The contact drove the vehicle to the residence. The contact stated that the following morning, the vehicle started, and the contact depressed the brake pedal and the brake pedal depressed down to the floorboard. The contact checked the brake reservoir, and the reservoir was empty without the presence of a leak. The contact stated that the vehicle was scheduled to be Serviced the following week. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 150,375.

NHTSA ODI 11562069

Front passenger door extremely hard to open and front driver exterior handle wont open door.

NHTSA ODI 11561801

The contact owns a 2012 Hyundai Tucson. The contact stated that while having an oil change by an independent mechanic, the contact was informed there was a leak in the engine compartment. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Vallejo Hyundai (3266 Sonoma Blvd., Vallejo, CA 94590). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 180,000. VIN tool confirms parts not available.

NHTSA ODI 11559535

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11558542

The contact owns a 2012 Hyundai Tucson. The contact stated while starting the vehicle, the vehicle made abnormal knocking sounds. There was no warning light illuminated. The vehicle was taken to an independent mechanic, and the contact was referred to the dealer for diagnostic testing. The contact received a notification for Hyundai Campaign Number: 966. Additionally, the contact received an unknown NHTSA Campaign Number however, the part to do the recall repair was not yet available. The local dealer was contacted and informed the contact that the vehicle was eligible for repair. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ODI 11558310

Three months ago, I was driving my car when the engine shut down while I was driving on the highway. I was able to pull over safely, however, I could have been in a fatal accident as my engine could no longer accelerate while I was on the highway. My car has been sitting in the Hyundai dealership since September 9 when the incident occurred, with Hyundai stating it can take 6-8 months. This has since placed my financial situation at a personal difficulty as the dealership has not been able to even diagnose car yet as they’ve stated, many other cars have the same issue that are ahead of mine. I tried reaching out to Hyundai customer support to get a rental car, but they said they cannot provide one until a proper diagnosis has been met so I would have to pay out-of-pocket until then, which I don’t know for sure if the rental will for sure be covered in full, much less I cannot afford to pay out of pocket in the meantime anyhow. If Hyundai could send a certified diagnosis to the customer support, that would then allow them to fund a rental car while the dealership finishes repairing the engine.

NHTSA ODI 11558098

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11557961

I am very concerned that our recall has not yet been rectified. Nobody should have to drive a car that can leak brake fluid internally and cause the engine to catch fire. Most people HAVE TO DRIVE THEIR CURRENT VEHICLE AND CANNOT PARK IT OUTSIDE AND LEAVE IT THERE UNTIL THERE IS A REMEDY. Hyundai should provide loaner cars for owners at Hyundai's expense until they can figure out how to rectify the problem.

NHTSA ODI 11556391

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the contact heard an abnormal squeaking sound. The vehicle was taken to an independent mechanic, but the failure could not be duplicated. The dealer was made aware of the failure but confirmed that parts were not yet available 48,000. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 48,000. VIN tool confirms parts not available.

NHTSA ODI 11555214

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic)) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11555124

The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11554364

Door latches do not open from the exterior, could possibly cause a safety hazard

NHTSA ODI 11542545

There are several issues with the rear doors. It started when the rear doors would not respond to being unlocked by the key fob. Then the rear hatch would not open without the back doors being unlocked first, which required (the rear doors) to be opened manually. Finally, the rear driver-side door will not open manually or otherwise; it is stuck shut. All of these issues are grave safety concerns that Hyundai should address.

NHTSA ODI 11540883

My 2012 hyundai tucson driver dash with the speedometer goes blank and I lose acceleration while driving and also the gears dissappear and I'm not able to reverse.yesterday the engine light turned on when I was driving but after I parked and turned car off and waited 10 minutes it was still on,but another 5 min after I turned it off and on again it turned off.looked on other forums alot of hyundai cars are having this problem.

NHTSA ODI 11528417

The contact owns a 2012 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, he heard a grinding sound under the hood. The contact then stated that he heard a loud clunk sound and the vehicle then swerved across the road almost causing a crash. The contact was able to regain control of the vehicle. The contact stated that the vehicle then stalled. No warning lights were illuminated. The contact was able to navigate the vehicle off the roadway. The contact then stated that he smelled an oil odor and a noticed a trail of oil on the ground and pieces of the piston rods. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The dealer was notified of the failure and an appointment was scheduled. The vehicle was not diagnosed or repaired. Additionally, the contact stated that, the day before the failure, the vehicle was taken to the dealer and repaired under Manufacturer Recall Number: 993,999,966. The manufacturer was notified of the failure and the contact was provided a case number and advised to take the vehicle to the dealer. The failure mileage was approximately 169,374.

NHTSA ODI 11525092

While driving my vehicle I accidentally knocked it out of gear and into neutral when I did the car died I was able to pull off of the interstate onto the shoulder where it was scary there were cars passing me at 70 mph, with very little room the car will not start the engine will crank a half of a crank and then freeze up. It had to be towed home where it remains broken down. I don't know if it's the engine I don't know if it's electrical but it will not start the battery is fine the alternator is fine I reported it to Hyundai's consumer hotline and was told to take it to a dealer and have it looked at but the car is not drivable I cannot afford another tow bill to have it taken to a Hyundai mechanic

NHTSA ODI 11521260

Hola el motor del auto se tranc Hello the engine of the car stalled

NHTSA ODI 11518785

The contact owns a 2012 Hyundai Tucson. The contact stated that while using the key fob, the alarm engaged. The contact was concerned about the vehicle being vulnerable to theft. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 100,000.

NHTSA ODI 11518196