What 1,129 owners told NHTSA about the 2012 Ford Edge

As I was driving into a parking lot space, I stepped on the brake pedal, and it sank to the floor. I rapidly pumped the pedal 2 or 3 times, but it continued to sink to the floor. As the car continued moving forward, I tried to avoid colliding with landscape items, drove between 2 parked cars, scraping one or both of them, and injured a pedestrian. My vehicle stopped when I jammed the gear control into the “PARK” position.

NHTSA ODI 11738190

I have replaced my front brakes at least 3 times, something is wrong with the brakes on these cars. Started off fine then after 50,000 miles I've changed them almost once a year. Never have had a Ford that I've had to replace brakes so much. Love the car just the little things are hard to handle. Take my car in again this year for front brakes again. Really??? I have just over 90,000 on the car and every 15,000 to do brakes again is unbelievable.

NHTSA ODI 11726464

My car skids when I try to stop the car(car breaking). This happening a couple of times during the past 2 or 3 days. My car mechanic just did a diagnostic and found out that the ABS Sensor module and electrohydraulic has system failure and needs replacement, but parts aren't available where I live (Puerto Rico). This is surely a matter of security I will appreciate if you can help us to find the parts need to fix this issue.

NHTSA ODI 11721355

2012 Ford Edge brake failure occurred without any warning while I was driving on I85. Brake pedal went to floor with diminished braking ability when a vehicle adjacent changed lanes quickly to in front of my vehicle. Luckily no accident occurred. Vehicle was taken to Ford dealer. A previous issue with brakes happened in 2021/mileage 109k and brake booster was replaced under recall 13N02 at that time. Dealer diagnosed current brake issue and recommended replacing HCU AND MASTER CYLINDER DUE TO VALVES AND SEAL LEAKING INTERNALLY. RELACE OIL SENDING UNIT ALSO DUE TO IT LEAKING OIL. Mileage 146K Vehicle is unsafe to drive as is. Cost of repairs is close to value of car.

NHTSA ODI 11703314

Ford Edge 2012 Limited 2.0L [XXX] The brake pedal went all the way to the floor while my wife was driving a few times. The brakes DID NOT STOP OR SLOW THE CAR AT ALL! She pumped the brake pedal and braking came back. But, after that we could not trust the brake system. We paid AutoNation Ford in Fort Worth, Texas $2,694.45 on 10/11/2023 to replace the ABS system, after their recommendation that this will fix the problem. This did fix the problem until recently this past week on 9/21/2025, when the brake pedal went to the floor without any braking, just continued to move forward in our driveway. The next push on the brake pedal did provide braking but now seems a little soft. My wife’s sister also has a Ford Edge with similar or the same symptoms, a 2013 Edge. My daughter has a 2012 Ford Fusion with similar or the same symptoms. This is a very dangerous SAFETY PROBLEM with these Ford cars! I suspect that this problem is more widespread than just my family, more Ford Edge vehicles with this ABS problem. A Ford Edge ABS RECALL might be required to help Ford customers be safe! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11689308

The first incident occurred in GA on vacation in June. While my spouse was driving, he said the brakes seemed squishy and were not right. When he braked to stop the car to get gas, his foot went almost to the floor. After getting gas, I drove and they did not seem right. The second incident happened the beginning of August and I was coming down a relatively steep hill. I went to brake and my foot went all the way to the floor and did not completely stop. I took the car to my mechanic and he wasn't sure of the problem, and to another mechanic. The 2nd thought it was the brake booster. I then took it to the Ford dealership where I bought it last August and had them look at it. They said it is the ABS module and that I am #829 on the list of 1300 people that need that part, that Ford has no idea when it will be available. The third incident was last Sat, [XXX] and I had No Brakes At All, so I had to take my husband's car to work. In All the incidents, I was at risk, as well as my family and the people driving in front & back of me. I have also had issues of the AC coming in for NO Reason, and after I turn it down, it turns itself back on at full blast. This car is NOT SAFE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11687731

The ABS system is completely shot. I have replaced the entire brake system besides the ABS. There is a recall on the ABS System for other 2012 Ford Edges, but for some reason my vehicle isn’t included. Please consider including my car in the recall as this is a serious safety issue. I cannot even drive the car, because i am not able to brake properly.

NHTSA ODI 11684546

Regarding the three Ford vehicles in my possession, each with approximately 80,000 miles, I've observed consistent issues with the Anti-lock Braking System (ABS) module. Despite my inquiry with a Ford dealership, no recall has been issued for these vehicles, and the ABS module is reportedly unavailable for repair. Given the apparent prevalence of this issue, I am concerned about the potential impact on vehicle performance during critical events. Furthermore, I am seeking clarification from Ford representatives regarding the lack of a resolution for this recurring problem across multiple vehicles. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11681100

BRAKE PEDAL HITTING THE FLOOR : ISSUE COMES AND GOES VERY RARELY . FIRST COMPLAIN REPORTED ON APRIL 2014: BRAKE BOOSTER REPLACED ON WARRANTY. LAST COMPLAIN REPORTED TO ORIGINAL CAR DEALER: COULD NOT IDENTIFY THE ISSUE. IN BETWEEN THESE TWO DATES, BRAKE BOOSTER HAS BEEN REPLACED RECENTLY. ABS HYDRAULIC CONTROL UNIT MAY CAUSE THE BRAKE FAILURE, NO ABS LIGHT YET. FORD HONORED AN EXTENDED WARRANTY ON BRAKE POWER BOOSTER IN 2020. PERFORMING A FEW REPEATED SUDDEN STOPS AT CERTAIN SPEED GETS THE BRAKES TO HOW IT SHOULD BE. NO ACCIDENT EVER INVOLVED.

NHTSA ODI 11680561

On July 31, 2019, I had the brake booster replaced at Midas due to a hissing noise and a loss of brake pressure, costing me $733.39. At that time, I checked for a Ford recall but found none for my VIN. I recently came across Ford Customer Satisfaction Program 13N02: Certain 2010-2014 Model Year Edge and MKX Vehicles Extended Warranty Coverage on Brake Booster. While I never was contacted by Ford about this issue for my 2012 Ford Edge, I feel it should be part of the program as it was clearly a safety issue at the time. Ford Customer Satisfaction Program 13N02 does show as an outstanding field service action for my VIN.

NHTSA ODI 11666331

See attached document for complaint.

NHTSA ODI 11666389

The contact owns a 2012 Ford Edge. The contact stated that while depressing the brake pedal, the brake pedal went to the floorboard. The vehicle was taken to a dealer where a diagnostic was performed, and the contact was informed that the brake booster, hydraulic cylinder, and master cylinder needed to be replaced. The manufacturer was also notified of the failure, and a case was filed. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 124,000.

NHTSA ODI 11658535

The ABS module failed which also impacted the traction control. The ABS module cannot be repaired because Ford cannot get the part needed due to the high volume of failure on this required safety feature. My car is unsafe to drive due to this system failure.

NHTSA ODI 11655748

The contact owns a 2012 Ford Edge. The contact stated that while operating the vehicle, the ABS and traction control warning lights remained illuminated. The contact stated that while depressing the brake pedal, the brake pedal extended to the floorboard, and the vehicle failed to immediately stop, causing the braking distance to be extended. The vehicle was taken to an independent dealer and was diagnosed with ABS module failure. The contact was informed that the ABS module needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 230,000.

NHTSA ODI 11655262

The brakes can’t been repair I totally lost brakes to may times

NHTSA ODI 11648404

The contact owns a 2012 Ford Edge. The contact stated that while depressing the brake pedal, the brake pedal went to the floorboard causing the braking distance to become extended. The vehicle was diagnosed by a certified mechanic who determined that the brake booster had failed and needed to be replaced. The braked booster was replaced. While driving approximately 10 MPH in the snow, the contact depressed the brake pedal, and the brake pedal went to the floorboard before the vehicle came to a stop. There was no warning lights illuminated. The vehicle was returned to the mechanic who diagnosed the vehicle and determined that the ABS module had failed. The vehicle had not been repaired. The contact became aware of Technical Service Bulletin: 13N02. The manufacturer was made aware of the failure and confirmed that the VIN was not covered under warranty, Service Bulletin, or recall. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 140,000.

NHTSA ODI 11630521

The ABS light comes on, Increased braking distance, Brake pedal is very stiff, Fluid leaking from the master cylinder, and Engine stalls when braking.

NHTSA ODI 11625232

Seen on the internet where there was a recall for a brake booster....checking to see if mine can be fixed or has it already been fixed.....

NHTSA ODI 11618391

The contact owns a 2012 Ford Edge. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle did not stop as intended. The contact stated that the brake pedal had to be depressed hard to stop the vehicle. In addition, the contact stated that the brake pedal made a squealing sound while depressed. The vehicle was taken to the dealer where it was diagnosed with brake booster failure. The contact was informed that the brake booster needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed about Customer Satisfaction Program: 13N02; however, the contact was informed that the VIN was not included. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 124,500.

NHTSA ODI 11616344

My 2012 Ford Edge has always had an issue with its brakes. I put new ones on and then the ABS system goes haywire and kicks in making the car feel like the brakes are constantly engaged. The car has also stopped in the middle of the road by it self with no warning. The brake pedal at times is squishy as well. I have it at a Ford dealership now to get it fixed I have to purchase a new ABS unit and modular. These parts are on indefinite back order per the dealership. I cannot be without a car for months on end but I dare not drive it because it is a safety hazard with unpredictable braking. My son drives this car and I do not want him involved in an accident related to this faulty brake system. Ford should recall this issue and correct it before someone dies in an accident. This dealership does not offer a loaner car like other car manufacturers do which is disgraceful when it is their product that is faulty and on back order. Since my son needs this car ASAP I may have to resort to buying the parts off of the internet.

NHTSA ODI 11611567

Brake pedal goes to floor with minimal stopping power

NHTSA ODI 11608434

I experienced spongy pedal that went to the floor, no brake light or abs light came on, no leaks. I was driving my wife's edge and hit the brakes to make a left hand turn. When I did the the brake pedal went straight to the floor! It showed some stopping power but not enough to actually stop the car without having a good amount of distance. I shut off the car, turned it back on and the brakes were fine. It happened again!

NHTSA ODI 11601552

My brakes are going all the way to the floor just every once in a while, but wow, my vehicle is in park and running, my traction control light comes on the only way to get it off. Is to turn the ignition off and back on.

NHTSA ODI 11595283

Wow, vehicle is in park and idling. My traction control light comes on then my brakes go all the way to the floor. It has done about six times so far.

NHTSA ODI 11595279

The contact owns a 2012 Ford Edge. The contact stated while attempting to stop the vehicle, the brake pedal was extremely firm while depressed, and the vehicle failed to stop immediately, causing the braking distance to be extended. The vehicle was eventually taken to the local dealer who diagnosed that the brake booster and master cylinders were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.

NHTSA ODI 11589953