What 370 owners told NHTSA about the 2011 Ford F-250 Super Crew

"TAKATA RECALL" WHILE DRIVING DOWN ROAD, VEHICLE WENT INTO REDUCE SPEED MODE. WHEN SLOWED DOWN, ENGINE SHUT OFF AND WOULD NOT START.

NHTSA ODI 11088442

2011 F250 6.2L ENGINE. TRUCK DIES RANDOMLY AND WILL NOT RESTART FOR SOMETIMES DAYS. SOMETIMES IT STARTS AND SOMETIMES IT DOESN'T. WEATHER IS NOT A FACTOR, SOMETIMES ITS WARM SOMETIMES ITS COLD. VERY RANDOM START AND NO START ISSUE.

NHTSA ODI 11088473

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 60 MPH, THE VEHICLE VIBRATED, EMITTED A KNOCKING NOISE, AND THE ENGINE EMITTED SMOKE. THE CONTACT WAS ABLE TO COAST ONTO THE SHOULDER OF THE ROADWAY. THE VEHICLE WAS TOWED TO AN UNKNOWN DEALER TO BE DIAGNOSED AND A FAILURE CODE FOR THE ENGINE VALVE WAS DETECTED. THE DEALER INFORMED THE CONTACT THAT THE ENGINE NEEDED TO BE REPLACED. THE ENGINE WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 146,000.

NHTSA ODI 11084558

EXHAUST BEING DRAWN INTO CABIN BY VENTILATION SYSTEM WHEN STOPPED.

NHTSA ODI 11083355

STARTED MY F1 50 WITH THE REMOTE CONTROL WHEN I PUT IT IN REVERSE THE BACK GLASS SHATTERED THIS IS THE SECOND TIME THIS IS HAPPENED THAT IT COST ME $500 DEDUCTIBLE EACH TIME

NHTSA ODI 11082369

I WOULD LIKE TO KNOW WHY FORD HAS NOT RECALLED THE PLASTIC OIL PAN DUE TO SEAL FAILURE AND RETURNING BACK TO STEEL PAN ON NEWER MODELS. THIS A CONTINUING PROBLEM NOTED ON NUMEROUS INTERNET POSTS. MY 2011 FORD F-250 LARIAT 4X4 IS LEAKING OIL AND NOW HAS TO BE REPLACED, COSTING A LOT OF MONEY FOR LABOR AND OIL REPLACEMENT WHICH SHOULD NOT BE NECESSARY FOR A VEHICLE WITH ONLY 135,000 MILES DRIVE TIME.

NHTSA ODI 11082330

STEERING BECOMES TIGHT THEN WANDERS WITH NOT ABLE TO REGAIN CONTROL OF STEERING UNTIL VEHICLE IS PARKED FOR SOMETIME. MECHANIC SAID ALL PARTS ARE IN GOOD WORKING ORDER. HAPPENS AFTER A TURN BUT IF YOU STOP AND TURN OFF TRUCK FOR SEVERAL MINUTES IT SEEMS FINE FOR AWHILE. THIS MOSTLY IN TOWN SLOW TO MEDIUM SPEED 15-45 MPH. IT HAS HAPPENED FOR ABOUT THREE MONTHS NOW. 3-29-2018 AND @40-50 DEGREES OUTSIDE.

NHTSA ODI 11082090

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE INTERMITTENTLY LOST POWER AND SHUT DOWN. THE TRACTION CONTROL AND TRACTION SENSOR INDICATORS ILLUMINATED. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. THE DEALER WAS NOT CALLED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 220,000. THE VIN WAS NOT PROVIDED.

NHTSA ODI 11081093

DEATH WOBBLE, WE ALMOST DIED ON 395, HAD TO STOP FAST AND IT HAPPED TWICE. WITH IN 10 MIN OF EACH OTHER, HE GOT NEW TIRES, AND ALIGNMENT A MONTH AGO. TOWING HORSE TRAILER. PLEASE HELP WITH THIS ISSUE. THIS IS OUR SECOND FORD TRUCK, WE HAVE A154,000. MILES. WE ARE NOT GOING TO BUY ANOTHER FORD IF YOU DO NOT HAVE REMEDY TO FIX THIS ISSUE

NHTSA ODI 11076502

FROM DAY 1 I HAVE HAD ISSUES WHERE THE FRONT END WOULD BOUNCE UNCONTROLLABLY AT HIGHWAY SPEEDS AFTER HITTING A POTHOLE OR BRIDGE EXPANSION JOINT. IT'S GETTING WORSE. THE DEALERSHIP CANNNOT FIND ANY PROBLEMS. THEY TOLD ME AT ONE TIME TO REPLACE MY TIRES BUT THAT DID NOT FIX THE ISSUE. I ALMOST RAN OFF THE ROAD 4 TIMES IN ONE TRIP BECAUSE OF THIS AS I COULD NOT MAINTAIN CONTROL. THIS WILL KILL SOMEONE IF NOT RESEARCHED AND CORRECTED BY FORD.

NHTSA ODI 11064272

TL* THE CONTACT OWNS A 2011 FORD F-250. THE CONTACT STATED THAT THE HOLLOW TUBE THAT HELD THE SPARE TIRE WAS RUSTED. THE VEHICLE WAS TAKEN TO FORMULA FORD LINCOLN (4318 MIDDLE RD, RUTLAND, VT 05701) WHERE IT WAS DIAGNOSED THAT THE TUBE NEEDED TO BE REPLACED. THE CONTACT INFORMED THE DEALER THAT A STRONGER TUBE WAS NEEDED DUE TO THE WEIGHT OF THE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.

NHTSA ODI 11062380

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE LOST POWER AND THE INSTRUMENT PANEL INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO LONE STAR FORD (8477 NORTH FWY, HOUSTON, TX 77037) WHERE IT WAS DIAGNOSED THAT THE HIGH INJECTION FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED A CASE. THE FAILURE MILEAGE WAS 84,615. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 11057084

WHILE DRIVING AT A SPEED OF 50 MILES PER HOUR THE TRUCK STARTED LOSING POWER, WAS ABLE TO GET TO SIDE OF THE HIGHWAY AS IT LOST ALL POWER AND SHUT DOWN WAS UNABLE TO RESTART TRUCK. GOT TRUCK TOWED HOME AND WENT CHECKING THE MOTOR AND THE ANTIFREEZE WAS COMPLETELY DRY BUT NO LEAKING UNDER MOTOR AND NO WARNINGS OF LIGHTS FLASHED WHEN TRUCK SHUT DOWN.. TRUCK IS SERVICED EVERY 3 MONTHS AND CHECKED AT HOME REGULARLY. TRUCK WAS LOOKED AT BY A ASE MECHANIC AND THE MOTOR SEIZED

NHTSA ODI 11054132

WENT TO INSPECT THE VEHICLE, UPON DOING A WALK AROUND I CHECKED THE TIRES AND NOTICED THAT ALL FOR TIRES ON THE VEHICLE HAD SPLITS IN THE SIDEWALLS. THE SPLITS ARE ABOUT A 1/4 TO 1/2" FROM THE EDGE OF THE WHEEL NEAR THE BEAD OF THE TIRE. THE SPLITS ARE NOT CONTINUOUS BUT REACH NEARLY ALL THE WAY AROUND THE TIRE FOLLOWING THE LINE OF THE WHEEL/TIRE BEAD. AT INITIAL INSPECTION IT LOOKED AS IF THE TIRES HAD BEEN CUT, AFTER LOOKING AT ALL FOR TIRES AND ALL OF THEM HAVING THE SAME CRACKS/SPLITS YOU COULD TELL THAT IT WAS NOT CUT AND RATHER THE RUBBER SPLITTING. THE TIRES HAVE NO OTHER DAMAGE TO THE TREAD OR SIDEWALL FROM CURBS AND OR ROCKS/ROUGH ROADS. THE TIRES WERE INSTALLED AND USED FOR APPROX. 4 MONTHS WITH 3,363 MILES PUT ON THEM SINCE INSTALLED. SIZE - 245/75/17, LOAD RANGE - E, BRAND/MODEL - HERCULES TERRA TRAC T/G MAX

NHTSA ODI 11031746

VEHICLE HAS A VIOLENT SPEED WOBBLE WHEN CROSSING SMALL BUMP IN ROAD AT HIGHWAY SPEED THIS IS MORE UNNERVING AS THIS OCCURS ON A CURVE VEHICLE WILL MOVE ACROSS LANE

NHTSA ODI 11025340

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT HEARD AN ABNORMAL RATTLING NOISE COMING FROM THE VEHICLE WITHOUT WARNING. THE CONTACT OBSERVED UNDER THE VEHICLE THAT THERE WAS MULTIPLE RUBBER MOUNTING PIECES THAT WERE MISSING OR DETACHED DUE TO DETERIORATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (BOGGUS FORD MCALLEN, 1400 E EXPY 83, MCALLEN, TX) WHERE IT WAS DIAGNOSED AND CONFIRMED THAT THE RUBBER MOUNTS FAILED AND/OR WERE MISSING, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WAS NO RECALL AT THE TIME AND NO ADDITIONAL ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS APPROXIMATELY 133,000. .. .UPDATED 10/04/17 *BF *TT

NHTSA ODI 11021802

SPEED APPROXIMATELY 55 ON CURVE, TRUCK FRONT END BEGAN TO VIOLENTLY SHIMMY AND WOBBLE TO POINT OF LOSS OF CONTROL. DESTROYED FRONT ROTORS, BRAKE SHOES, AND MASTER BRAKE CYLINDER AS PER PEP BOYS REPAIR RECEIPT. REPEATED AFTER REPAIR AT SAME SPEED. TRUCK HAS 50,000 MILES, VERY LITTLE OFF ROAD MILEAGE. INTERNET RESEARCH INDICATES OTHER DRIVERS' INSTANCES WITH THIS MODEL TRUCK AS "DEATH WOBBLE".

NHTSA ODI 11014891

FORD F250 4X4 HAVE A PROBLEM WITH THE FRONT SUSPENSION DESIGN. WHEN YOU ARE DRIVING AND YOU HIT A POTHOLE OF ONE OF THE WHEEL IS JARRED THE VEHICLE WILL SHAKE, THIS CAN BE VERY VIOLENT DEPENDING ON SPEED. THE VEHICLE WITH THIS REPORT HAS HAD SEVERAL INSTANCES IN VARIOUS DEGREES. WE HAVE ALSO TRIED TO CORRECT THE PROBLEM. THE INSTANCES HAVE ALL BEEN AT HIGHWAY SPEEDS.

NHTSA ODI 11014839

7/7/17 - 2011 FORD F250, 6.7L DIESEL ENGINE, MILEAGE 79530. (PURCHASED DECEMBER 2010). I WAS PULLING A SMALL TRAILER UP AN INCLINE (8%) ON I-64 IN WV. ON THIS PORTION OF THE INTERSTATE THERE WAS NO EMERGENCY PULL OFF SHOULDER. THE TRUCK OPERATED NORMALLY FOR THE FIRST 3 MILES ASCENDING THE HILL. DURING THE 4TH MILE, THE TRUCK BEGAN TO GRADUALLY, BUT PROGRESSIVELY LOSE POWER, GOING FROM 70 MPH DOWN TO 0. AT APPROXIMATELY 30 MPH, THE TRUCK BEGAN TO SHUTTER SLIGHTLY, AND CONTINUED TO DO SO UNTIL IT STOPPED IN THE LANE OF TRAFFIC AND STALLED. THERE WERE NO WARNING LAMPS OR CHIMES THAT WENT OFF BEFORE THE ENGINE STALLED. THIS VEHICLE IS EQUIPPED WITH A 'STOP SAFELY NOW' WARNING, ALONG WITH MANY OTHER WARNING INDICATORS ' BUT IT DIDN'T ILLUMINATE. THE TRUCK WOULD NOT RESTART. I IMMEDIATELY CALL 911 TO REPORT THAT MY VEHICLE WAS DISABLED IN THE ROADWAY. AFTER BEING STUCK IN THE LANE OF TRAFFIC FOR ABOUT 10 MINUTES, I WAS ABLE TO DRIFT THE TRUCK AND THE TRAILER BACKWARDS SAFELY, OFF OF THE ROADWAY, INTO THE DRAINAGE DITCH, AFTER A BREAK IN TRAFFIC. UPON HAVING IT TOWED TO A FORD DEALERSHIP, I WAS INFORMED THAT IT WAS GOING TO NEED A MOTOR, AND IT SOUNDED LIKE IT HAD SPUN THE BEARINGS ON ONE OF THE ENGINE RODS. THE ENGINE WOULD RESTART AT THE FORD DEALERSHIP, BUT IDLED VERY ROUGH. I CONFIRMED THAT THERE WERE IN FACT METAL SHAVINGS IN THE OIL. THE FUEL WAS NOT CHECKED FOR CONTAMINATION. THIS VEHICLE HAS BEEN MAINTAINED ACCORDING TO FORD'S RECOMMENDED SERVICE GUIDELINES. BECAUSE OF THE COST TO ME TO REPAIR ($16,000 OR MORE), I'VE ELECTED NOT TO CONTINUE WITH DIAGNOSIS (AT $120 PER HOUR) TO DETERMINE REASON FOR FAILURE. AGAIN, THERE WAS NO WARNING SYSTEMS ACTIVE AT THE TIME THE ENGINE STALLED. THIS WAS AN ORIGINAL OWNER, PERSONAL VEHICLE, AND ONLY TOWED A TRAILER ON OCCASION. I HAVE VIDEO FROM DASH CAM W/AUDIO OF THIS EVENT.

NHTSA ODI 11005821

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 60 MPH OVER A BUMP IN THE ROADWAY, THE VEHICLE SHOOK VIOLENTLY UNTIL SLOWING TO 30 MPH OR COMING TO A FULL STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE LOCAL DEALER (JIM BURKE FORD 2001 OAK ST, BAKERSFIELD, CA 93301 (661) 328-3600), BUT THE FAILURE COULD NOT BE DUPLICATED OR DIAGNOSED. THE CONTACT WAS ADVISED TO REPLACE ALL FOUR TIRES. ALL FOUR TIRES WERE REPLACED, BUT THE ISSUE PERSISTED. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 225,000.

NHTSA ODI 11003164

2011 FORD SUPER [XXX], 6.7L FIRE HAZARD, FUEL INJECTOR HOLD DOWN FAILURE WHILE IDLING IN YARD, SPRAYING FUEL ALL OVER PLACE, TOWED TO DEALER, RECOMMENDS REPLACING ALL HOLD DOWNS DO TO FAULTY PART. TSP ON IT.. 1600.00 NOT COVERED UNDER WARRANTY 86,000 MILES. FIRE HAZARD. GLAD I'M NOT THE ONE THAT'S GOING TO BURN IN THE SUPER [XXX] TRUCK RECOMMEND YOU HAVE FORD RECALL ALL 2011 6.7 LITERS TO REPLACE THE DEFECTIVE PARTS. SELL FORD STOCK. FIRE PROFESSOR AND ENGINEERING STUDENTS. COME ON PEOPLE REALLY!!!!!!!!!!!!!!!!!!!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI 11002411

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 60 MPH, THE VEHICLE WOBBLED AND SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER (MAC HAIK FORD LINCOLN HYUNDAI 4506 N NAVARRO ST, VICTORIA, TX 77904), BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE DEALER REPLACED UNKNOWN PARTS ON THE FRONT END OF THE VEHICLE, BUT THE FAILURE RECURRED SEVERAL MORE TIMES. THE MANUFACTURER STATED THAT THE CONTACT SHOULD TAKE THE VEHICLE TO A DEALER AND HAVE IT DIAGNOSED. THE CONTACT WAS REFERRED TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

NHTSA ODI 11001691

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING OVER 60 MPH, THE VEHICLE SHOOK AND THE STEERING WHEEL LOCKED. WHILE THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE SHOOK UNCONTROLLABLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (KOONS SILVER SPRING FORD, 3111 AUTOMOBILE BLVD, SILVER SPRING, MD 20904 (301) 890-6100) WHERE IT WAS DIAGNOSED THAT THE BALL JOINT, BRAKE PADS, AND STABILIZER BAR NEEDED TO BE REPLACED. ALSO, FLUID WAS LEAKING ON THE SHOCKS AND THE STRUT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURES RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 58,100.

NHTSA ODI 10992335

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 35 MPH, THE VEHICLE SLOWED DOWN AND THE REAR PASSENGER AND DRIVER SIDE WHEELS SEIZED. IN ADDITION, THE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE DEALER DIAGNOSED THAT THE TRANSMISSION WAS LOSING LINE PRESSURE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V248000 (POWER TRAIN). THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE PAST 35-40 MPH. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 133,600. UPDATED 06/29/17*LJ *AS

NHTSA ODI 10986355

WHEN DRIVING THIS TRUCK, IF YOU HIT A POTHOLE OR ANY UNEVEN SURFACE, THE TRUCK WILL SHAKE VIOLENTLY AND IT'S ALL OVER THE ROAD. IT TAKES ALL THE STRENGTH IN MY BODY JUST TO HOLD ONTO THE STEERING WHEEL, AND THE ONLY WAY TO STOP IT IS COME ALMOST TO A COMPLETE STOP. SOMEONE'S GOING TO GET KILLED, BECAUSE WHEN IT START TO SHAKE, YOU HAVE KNOW CONTROL OVER THE DIRECTION IT'S GOING TO GO. FROM WHAT I'VE READ ON THE NET, THIS SHAKE IS CALLED THE DEATH WOBBLE AND FOR GOOD REASONS. I ALSO HEARD THAT FORD HAD KNOWN ABOUT THIS DEFECT FOR YEARS, BUT WANT DO ANYTHING EXCEPT GIVE YOU THE RUN AROUND.

NHTSA ODI 10986078