What 1,312 owners told NHTSA about the 2011 Ford Escape Gas

Airbag light on/ flashing. Shop says "passenger side seat belt retractor assembly" needs replaced. I switched it with a known working part, didn't fix the issue. Upon further research I found that it is a known issue. Source: [XXX] April 1, 2011 MANUFACTURER COMMUNICATION NUMBER: SIS-21841 Components: AIR BAGS, ELECTRICAL SYSTEM NHTSA ID Number: 10038965 Manufacturer Communication Number: SIS-21841 Summary: COMM-TRANS LUND: SOME 2009-2011 MODELS MAY HAVE THE AIR BAG INICATOR FLASHING WITH A STORED TROUBLE CODE. THIS IS A SOFTWARE PROBLEM. *RM I have contacted both local dealerships, as well as Ford corporate. The remedy they all 3 offered: Take it in for diagnostics (I'm already fully aware of the issue) which will cost me around $300, then they will tell me if there's even a possibly solution. They were completely unwilling to tell me if they could fix the software issue without first paying for their diagnostic service, even though it's a known and recorded issue, with the NHTSA ID Number: 10038965 as well as the Manufacturer Communication Number: SIS-21841. Upon researching complaints, I have found that I am by far not the only person who has this exact issue. Note: "date of incident" is when I purchased the vehicle, mileage is the mileage at the time of purchase, it has had the light on since before that date and mileage. I tried to resolve this issue then, and recently have been trying again, in hopes that there has been a fix found finally, to no avail. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11631440

While driving the vehicle, the power steering suddenly went out without warning.

NHTSA ODI 11630762

Intermittent loss of power steering.

NHTSA ODI 11628478

The front subframe on the passenger side is rusted through. I have also heard this part referred to as the engine cradle. I noticed while changing the serpentine belt and had it looked at by a mechanic. Took it to Midas and mechanic said front subframe should to be replaced but couldn't get the part. I researched this online and found it to be a common problem. People say it may be from AC water discharge due to occurring mostly on passenger side only. The uploaded images are of my own vehicle. Apparently people say these snap and the car takes a hard right turn when the wheel comes loose. I guess all the people that die don't post anything so the government isn't taking this issue seriously... Uploaded images are of my own vehicle. I'm also including youtube links of other people's similar year/make, same model issue as 2011 Ford Escape with the same issue. The first one is apparently by a Ford mechanic, fixing his mom's vehicle because he doesn't want her to die. I'm a [XXX], discovered this on Veterans Day 2024. Survived combat, but will this faulty vehicle kill me? Needs manufacturer recall, myself and many others have no choice but to drive it. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11627912

The contact owns a 2011 Ford Escape. The contact stated while driving approximately 35 MPH, the contact attempted to make a right turn however, the power steering failed, and the steering wheel became difficult to steer in either direction. No warning light was illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. Upon further investigation, the contact related the failure to an unknown recall however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 152,000.

NHTSA ODI 11625992

The contact owns a 2011 Ford Escape. The contact stated while driving 20 MPH around a roundabout, the steering wheel became difficult to maneuver. The contact stated that the steering assist warning light was illuminated. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA Campaign Number: 14V284000 (STEERING). The manufacturer was not notified of the failure. The failure mileage was 188,000.

NHTSA ODI 11623421

I lose my power steering. First time it happened I had turned the steering wheel to its’ fullest extent, then lost the power steering.when I turn off the engine and restart it, the power returns. This has happened 4-5 times in the past 4-5 years… until today. Today it happened 4 times, just with normal turns (no hard banked turns) - again, I had to turn off the engine, then start it, with hopes that it reset itself. I’m 71, I CAN drive it without power steering, but I believe it’s dangerous and a safety hazard. Is my 2011 Ford Escape on a list for a replacement part? Thank you.

NHTSA ODI 11622168

The contact owns a 2011 Ford Escape. The contact stated while driving 45-50 MPH, the vehicle lost electrical power steering functionality and was nearly rear-ended. The contact stated that the steering wheel was significantly difficult to turn. There was no warning light illuminated. The contact was able to veer into a parking lot. A mobile mechanic determined that the electric power steering had failed. The mechanic turned off and restarted the vehicle, and the electrical power steering became functional. The vehicle was taken to the dealer, where it was diagnosed that the steering torque sensor had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 14V284000 (Steering) because the VIN was not included. A case was opened. The failure mileage was approximately 204,043.

NHTSA ODI 11621296

Power steering is inoperable and was verified by Crossroads Ford Wake Forest. Same issue as other 2011 Escapes that are covered under TSB 14-0016. My VIN was not included in the TSB but is the same issue per Ford Dealership. Vehicle is available for inspection if needed. May cause a crash since vehicle is difficult to control without power steering. Power steering has been intermittently not working for approximately 2 months.

NHTSA ODI 11619633

The contact's father owns a 2011 Ford Escape. The contact stated that while her father was driving at an undisclosed speed, the suspension of the vehicle collapsed, and the vehicle came to an abrupt stop. The vehicle was towed to an independent mechanic, who determined that the front passenger's side axle had fractured and had bent the front passenger's side wheel. The independent mechanic advised that the vehicle be replaced rather than repaired. The vehicle was not repaired. No further information was provided. The manufacturer was made aware of the failure. The failure mileage was approximately 170,000.

NHTSA ODI 11618040

The electric steering is not letting you turn the steering wheel while driving you have to turn the car off and let it sit before it will work again. I see there is a recall for the same year as my car but it is not included? I don’t understand why as I see that there are others with the same issues.

NHTSA ODI 11610240

The brakes completely failed and I was unable to stop the car except by turning up hill and applying the emergency brake. I had it repaired by Ford in Bangor and it turned out that the ABS module had failed. It seems unreasonable that there was no mechanical backup to a failure of an electronic part.

NHTSA ODI 11607855

Had my Escape in for an oil change and was informed that the engine cradle (Front Sub Frame) was rusting out. Took it to a second shop and was instructed that is need to be fixed in the month or it is going to drop when I am driving sometime. The estimated cast is from $1,500 to over $2,000. That is a huge cost for me and I am not sure how I am going to afford that. I look up and it seems to be happens to a lot of 2011 escape owners and need to be looked into. It could cost someone there life.

NHTSA ODI 11606497

Sub frame rotted out on passenger side, causing passenger side control arm to become dislodged which resulted in lost control of car! Could have resulted in major accident and or death at higher speed! Entire family in car.

NHTSA ODI 11604174

The contact owns a 2011 Ford Escape. The contact stated while operating the vehicle, the electronic power steering assist malfunctioned, and the steering wheel was very difficult to turn in either direction. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 14V284000 (Steering). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was unavailable.

NHTSA ODI 11602755

The contact owns a 2011 Ford Escape. The contact stated while driving 40 MPH, the electronic power steering stopped functioning properly, requiring increased effort to maneuver the vehicle. The power steering assist fault warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V284000 (Steering); the VIN was included, but the vehicle had already been repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 102,000.

NHTSA ODI 11601601

The contact owns a 2011 Ford Escape. The contact stated while driving approximately 45 MPH, the steering wheel was very difficult to turn. The contact was not aware if there were any warning lights illuminated. The contact pulled over and called a friend for assistance. The contact was able to drive the vehicle to the residence and then the vehicle was taken to an independent mechanic. The mechanic diagnosed the vehicle and determined that the electric power steering sensor had failed and needed to be replaced. The mechanic informed the contact that the failure was related to NHTSA Campaign Number: 14V284000 (Steering). The mechanic referred the contact to a dealer to complete the repair. The vehicle was taken to a dealer; however, a diagnostic test was not performed and the vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 170,000.

NHTSA ODI 11600451

The contact owns a 2011 Ford Escape. The contact stated while driving at an undisclosed speed, the vehicle shuddered and jerked, with the check engine warning light illuminated. The contact also stated that while attempting to accelerate, the vehicle lost motive power. The vehicle was diagnosed by Roadside Assistance as a failure with the alternator. The vehicle was towed to an independent mechanic to be diagnosed as it was confirmed that the alternator had failed and needed to be replaced. The vehicle was repaired but the failure persisted. The dealer was not contacted; however, the vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 134,499.

NHTSA ODI 11598015

The contact owns a 2011 Ford Escape. The contact stated while the vehicle was parked, the contact attempted to drive from the parking lot; however, the steering wheel became very stiff, making it difficult to maneuver the vehicle. The contact was not able to turn the steering wheel to the right nor the left. The contact stated that the failure reoccurred. There were no warning lights illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or local dealer. The contact related the failure to an unknown recall; however, the vehicle was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

NHTSA ODI 11596989

The contact owns a 2011 Ford Escape. The contact stated while driving 30 MPH, the steering wheel was pulling to the right. There was no warning light illuminated. The contact used excessive force to regain control of the vehicle. The contact arrived to the destination and had the vehicle towed to an independent mechanic. The mechanic diagnosed the vehicle with a defective steering column. Upon investigation, the mechanic discovered NHTSA Campaign Number: 14V284000 (Steering) which was linked to the failure. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 175,000.

NHTSA ODI 11595504

The contact owns a 2011 Ford Escape. The contact stated that while driving at an undisclosed speed, the steering wheel was firm and difficult to maneuver. No warning lights were illuminated. The vehicle was diagnosed by an independent mechanic and the contact was informed that the steering column needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 14V284000 (Steering). The dealer was made aware of the failure but confirmed that the vehicle was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000.

NHTSA ODI 11595027

Power steering went out on wife's 2011 ford escape, checked for recall and found none for her vehicle however there was for 2008 to 2011 escapes which involved the torque sensor. I don't know why I never received a recall notice and have noticed many other people have had the same problem and Ford is unwilling to do anything about it. This is a defect that could cost someone or someone's their life or serious injury and Ford should be required to fix the problem. Hope that pressure will be put on Ford to fix the problem as they should.

NHTSA ODI 11594801

The contact owns a 2011 Ford Escape. The contact stated while driving 10 MPH, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to maneuver the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering column assembly. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V284000 (Steering) however, the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was unknown.

NHTSA ODI 11592712

The contact owns a 2011 Ford Escape. The contact stated that while his granddaughter was driving 30-35 MPH, the steering wheel was difficult to turn. The air bag warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 14V284000 (Steering). The manufacturer was not contacted. The failure mileage was approximately 206,550.

NHTSA ODI 11589229

You turn on the car and the steering wheel is locked and this is happening every day, every time you turn on the car.

NHTSA ODI 11588310