What 1,312 owners told NHTSA about the 2011 Ford Escape Gas

While driving down road, vehicle suddenly pulled right and started shaking the steering wheel and started making grinding noises. The steering wheel was now off by several degrees in order to drive straight. Luckily this occurred at a low speed and not at highway speed. If this was at 70 miles per hour it probably would have resulted in accident. Pulled to side of road and noticed right wheel out of alignment. After getting vehicle home looked under vehicle and discovered the end of the subframe where lower A arm mounts has rusted thru and cracked. This had the potential to be a really bad accident. Hard to believe a 2011 Ford Escape with only 93000 miles has cracked subframe.

NHTSA ODI 11654991

I have been having problems with a coolant leak that’s been fixed but then leaks again. Got it fixed 2 different times now since I purchased the car.

NHTSA ODI 11654558

The contact owns a 2011 Ford Escape. The contact stated that while driving at an undisclosed speed, the steering wheel failed to steer in the intended direction, nearly causing a head-on collision. No warning light was illuminated. The vehicle was taken to an unknown dealer, but was not diagnosed or repaired. The contact was informed of an unknown recall related to the failure and was advised that the VIN was not included in the unknown recall. The contact stated that the dealer declined to inspect the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 151,000.

NHTSA ODI 11654062

The contact owns a 2011 Ford Escape. The contact stated that while his wife was driving 15-20 MPH and taking the grandchildren to school, the driver heard an abnormal popping sound coming from under the steering wheel and the vehicle lost power steering functionality. The driver was able to pull over to the side of the road. The vehicle was turned off and restarted; however, the failure persisted. The contact met his wife and assisted in driving the vehicle to the residence. The contact stated that upon starting the vehicle the following morning, the power steering was functional. The contact stated that the failure had been recurring intermittently. There was no warning light illuminated. The contact stated that he was a retired independent master mechanic, but the vehicle was not diagnosed or repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that the repair could not be covered because the VIN was not under recall. The failure mileage was approximately 210,000.

NHTSA ODI 11653836

The contact owns a 2011 Ford Escape. The contact stated that while driving 35 MPH, the steering wheel seized intermittently. There were no warning lights illuminated. The contact stated that on another occasion, while the vehicle was parked, the sensor failure caused the steering wheel to move back and forth with a loss of power steering assist. The vehicle was taken to an independent mechanic who diagnosed the vehicle with torque sensor failure. The vehicle was not repaired. The dealer was made aware of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 250,000.

NHTSA ODI 11649283

While driving my steering wheel locks up and it is hard to turn. If I turn my car off then back on it start working right then locks right back up

NHTSA ODI 11649130

The contact owns a 2011 Ford Escape. The contact stated while driving approximately 15 MPH and descending a steep grade, the contact attempted to turn the steering wheel to the right however, the steering wheel failed to turn or respond as needed. The contact stated there was no warning light illuminated. The contact stopped and turned off and restarted the vehicle and was able to regain power steering functionality. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The contact had researched online and related the failure to NHTSA Campaign Number: 14V284000 (Steering). The contact had called the manufacturer and was advised that the VIN was not included in the recall. The failure mileage was approximately 69,000.

NHTSA ODI 11646687

Yesterday, When coming to a stop at a Hwy intersection, the steering wheel suddenly would not turn. I was able to get the car to a parking lot. Turned the vehicle off. Approximately 15 minutes later I started the car to move it to a safer location and the steering wheel moved freely. This same steering problem happened today when backing out of my driveway. I pulled back in and turned the vehicle off. I have not tried to drive it again. Haven’t taken it to the dealership yet. You have to make an appointment. One is not available within the next few days. It is Thursday, I’ll call them back on Monday. So the reason for the loss of steering is unknown at this time.

NHTSA ODI 11645295

The contact owned a 2011 Ford Escape. The contact stated that while driving at 25 MPH, as the contact was approaching a traffic light, the brake pedal was depressed; however, it failed to stop as intended. The contact moved to the other lane when the vehicle came to a stop. There was no warning light illuminated. The vehicle was taken to AutoZone and the contact was informed that three sensors needed to be replaced. Two sensors were replaced; however, the ABS sensor was not replaced due to cost. The contact stated that on the drive home, an abnormal odor was coming from the vehicle. While the vehicle was parked, the vehicle was consumed by fire and destroyed. The Fire and Police departments were called. A fire report was filed; the Fire Department stated the cause of the fire was due to faulty wiring. The contact notified her insurance company and the vehicle was towed to an unknown location. The manufacturer was not notified of the failure. The failure mileage was approximately 170,000.

NHTSA ODI 11645090

The contact's friend owns a 2011 Ford Escape. The contact stated that upon starting the vehicle, the power steering assist failed to operate as needed. There was no warning light illuminated. Despite the failure, the contact drove the vehicle to an independent mechanic who informed the contact that the steering column, including the rack and pinion, needed to be replaced. The manufacturer was notified of the failure and informed the contact that the vehicle was not under recall. The contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was unknown.

NHTSA ODI 11644871

The contact owns a 2011 Ford Escape. The contact stated that while driving at various speeds, the power steering assist function failed to operate as needed with the "Power Steering Assist Fault" message displayed on the instrument panel. The contact also stated that the steering wheel was shaking abnormally while in park(P). The contact stated that the vehicle had previously been repaired under NHTSA Campaign Number: 14V284000 (Steering); however, the failure recurred. The vehicle was not repaired. The contact attempted to reach out to the dealer that had performed the recall repair; however, all the calls went to voicemail. The manufacturer was notified of the failure and referred the contact back to the dealer for assistance. The failure mileage was approximately 200,000.

NHTSA ODI 11644470

The contact owns a 2011 Ford Escape. The contact stated that while his daughter was driving 10 MPH and pulling into a parking lot, the vehicle lost power steering functionality. The contact was able to continue driving. There were no warning lights illuminated. The local dealer was contacted, and the contact was informed there were no open recalls on the VIN for the failure. The dealer informed the contact that the rack and pinion were replaced, and a software update was performed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the local dealer. The failure mileage was approximately 93,000.

NHTSA ODI 11641972

The fuel pump was replaced and a new one was installed and now the engine is misfiring really hard and when the vehicle is placed in drive or reverse the engine tries to stall. The mechanic is saying that I will have to purchase a fuel rail pressure sensor that controls the fuel to each fuel injector. If this item or the whole fuel system is on a Recall List. Then I shouldn't have to pay anything to have it repaired and replaced by the Dealership. I do need to be notified about this issue immediately. This is a 2011 Ford Escape XLT AWD 4dr SUV with 3.0 V6 Flex Fuel system.

NHTSA ODI 11641697

The contact owns a 2011 Ford Escape. The contact stated that while his daughter was driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The vehicle was taken to an independent mechanic, who determined that the crankshaft position sensor signal experienced a loss of power, resulting in a loss of power steering assist. The contact was informed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 173,000.

NHTSA ODI 11641799

I was merging onto I-91 when the steering went out in my Escape. The ramp was at a right angle and this is when I felt the tightness. There was no alert activated on the dashboard and I was not sure what happened. I drove for about 2 miles toward work and exited the highway. It was scary because I was afraid I would not be able to make the turn off to avoid the left side barrier of the bridge on my exit turn. I was unable to park at work and simply drove to a nearby mechanic. I used my flashers to make wide turns. I left the vehicle at Rick’s Automotive. They called a few hours later and confirmed a bad torque sensor in the vehicle.

NHTSA ODI 11641118

There was a recall (#14S05 from Ford) that covered Electric Power Steering Failure in Escapes and Mariners from 2008 - September of 2011 made in the Kansas City Assembly plant. This vehicle mentioned is having the same issue, but is not included on the recall list? We diagnosed the problem with a Snap-On computer here at M&D Auto & Trailer Sales & Service, LLC. The customer complained that the steering wheel and column would shake and then feel like there was no power steering making it almost impossible to drive. No inspection other than at M&D Auto. No lights came on but our Snap-On scanner produced DTC B2278 and told us about the afore mentioned recall.

NHTSA ODI 11641175

Top of wheel well around shock absorber broke off due to rust as well a frame disintegrating due to rust. When shock broke free part of wheel well lodged behind the tire and destroyed the brand new tire.

NHTSA ODI 11639804

The contact owns a 2011 Ford Escape. The contact stated that while driving at approximately 20 MPH, the steering wheel became stiff, and difficult to turn to the left or the right. The contact was able to veer into a parking lot for an errand and upon restarting the vehicle the vehicle resumed normal function. No warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 14V284000 (Steering); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 200,000.

NHTSA ODI 11639148

The contact owns a 2011 Ford Escape. The contact stated that while his wife was driving 10 MPH, the vehicle lost power steering functionality. The contact stated that after restarting the vehicle, the vehicle regained power steering functionality. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 14V284000 (Steering); however, the VIN was not included. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall. The failure mileage was approximately 144,454.

NHTSA ODI 11637556

Leaking gas from gas tank where the fuel delivery pipe enters the tank

NHTSA ODI 11635414

The contact owns a 2011 Ford Escape. The contact stated while her husband was driving approximately 20-25 MPH and making a right turn with the contact occupying the front passenger's seat, the vehicle lost power steering functionality, nearly causing the driver to lose control of the vehicle. There was no warning light illuminated. The driver was able to drive to the nearby residence of the contact's brother. The contact stated upon restarting the vehicle approximately two hours later, the power steering functionality had returned. The vehicle was taken to the dealer the following day and was diagnosed with steering shaft torque sensor malfunction. The dealer replaced and calibrated the steering shaft torque sensor twice. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 14V284000 (Steering). The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 138,260.

NHTSA ODI 11634271

The contact owns a 2011 Ford Escape. The contact stated while driving at an undisclosed speed, the steering wheel failed to function as intended. The contact stated that the steering wheel was seized, and the vehicle became difficult to steer. The vehicle was taken to an independent mechanic where it was diagnosed with a failed torque sensor. The contact was informed that the steering column needed to be replaced. The vehicle was next taken to the dealer where it was diagnosed with a failed torque sensor and the contact was informed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.

NHTSA ODI 11633983

We were sitting in a parking lot and the car was started, the steering wheel was very difficult to turn. Yes, the vehicle is available for inspection. No one’s safety was at risk. This is the first time this has happened, we have had the car since July 2024, we have not taken it to a mechanic yet. The vehicle has not been inspected yet. There was no warning light or other symptoms prior to this event.

NHTSA ODI 11633003

The contact owns a 2011 Ford Escape. The contact stated that upon approaching the vehicle, the contact observed gasoline leaking underneath the fuel tank. The contact became aware of a crack in the gasoline tank seal. The contact stated that there was a constant odor of gasoline on the interior of the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 240,000.

NHTSA ODI 11631781

The contact owns a 2011 Ford Escape. The contact stated while driving at approximately 35 MPH and making a right turn, the steering wheel was difficult to turn. The contact stated that the failure was self-corrected, and proper functionality returned. The contact stated there was no warning light illuminated. The contact stated that the failure had reoccurred. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the electric power steering gears needed to be replaced. The vehicle was not repaired. The independent mechanic made the contact aware of NHTSA Campaign Number: 14V284000 (Steering); and referred the contact to a dealer for assistance. The VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.

NHTSA ODI 11631395