What 10 owners told NHTSA about the 2011 BMW R 1200 Rt

This vehicle was subject to a recall under bulletin 16 0114. The issue was a fuel pump which cracked at flanges which leaked fuel onto the hot engine, which could cause safety issues with fire. My vehicle listed above, had the fuel pump replaced with 12,505 miles on it under the recall. The replacement fuel pump, which is apparently no better than the original that was replaced under recall, cracked again leaking fuel onto the hot motorcycle engine. This happened with 20,300 miles on the vehicle, which is less than 8000 miles later. BMW is refusing to replace under the recall or a warranty the fuel pump which means I am stuck with the bill. I believe that BMW should be replacing a defective part with a new design and better part not an old design faulty part. I would encourage you to issue another recall on the vehicles in question under bulletin 160114 in the interest of motorist safety.

NHTSA ODI 11681917

The contact owns a 2011 BMW R1200 RT Motorcycle. The contact stated that while starting the motorcycle, fuel was spraying from the fuel line. There were no warning lights illuminated. The contact called the local dealer but the motorcycle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 20V471000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 37,528.

NHTSA ODI 11485901

Development of a major fuel leak after starting motorcycle, leak is coming from the high pressure fitting on the fuel pump. Very dangerous as the fuel is dripping on the hot exhaust and pooling on top of the fuel pump. Risk of fire and possibility of fuel getting on pant leg and burning riders leg. I talked to a couple dealers in the Phoenix area and it’s more common than not.

NHTSA ODI 11483260

The contact owns a 2011 BMW R 1200 RT. The contact received notification of NHTSA Campaign Number: 20V471000 (Fuel System, Gasoline). The dealer was contacted and informed that the parts were not available. The contact called back the same dealer on two separate occasions and was informed that parts were still unavailable. The manufacturer was notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11430640

The contact owns a 2011 BMW R 1200 RT Motorcycle. The contact stated that fuel was leaking from motorcycle. There were no warning lights illuminated. The contact received notification of NHTSA campaign number: 20V471000 (Fuel System. Gasoline) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified however, no further assistance was provided. The failure mileage was approximately 17,000. Parts distribution disconnect.

NHTSA ODI 11428477

The contact owns a 2011 BMW R 1200 RT. The contact received notification of NHTSA campaign number: 20V471000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11427749

THROTTLE CABLE BELL CRANKS/CAMS CRACK DUE TO POOR QUALITY PLASTIC MATERIAL. THIS CAUSES MOTORCYCLE TO SUDDENLY LOSE POWER AS THE HAND THROTTLE NO LONGER WORKS AND ENGINE RETURNS TO IDLE RPM. THIS IS A SERIOUS SAFETY HAZARD AS FAILURE CAN OCCUR WHILE ENTERING TRAFFIC, TURNING THRU TRAFFIC, OR TRAVELING ON A HIGH SPEED ROADWAY WITH NO AREA TO PULL OFF. THESE CRACKS, (AND IMPENDING FAILURE OF THE PARTS), WERE DISCOVERED BY SERVICE PERSONNEL DURING SERVICE WORK.

NHTSA ODI 11408223

TENGO PROBLEMAS CON EL FUEL PUMP LIQUEA MUCHO Y TAMBIEN CON EL ENCENDIDO LOS CALIPERS SE ATORAN

NHTSA ODI 11355042

SPONTANEOUS DEVELOPMENT OF A COPIOUS FUEL LEAK AFTER STARTING BIKE, SUBSEQUENTLY FOUND TO BE ORIGINATING FROM FUEL PUMP AROUND HIGH PRESSURE FITTING. VERY DANGEROUS SCENARIO, AS FUEL DRIPS CLOSE TO HOT ENGINE. I ASKED AROUND AND APPARENTLY IS NOT AN UNCOMMON ISSUE. HARD TO BELIEVE THERE HAS NOT BEEN A RECALL ON THIS. *TR

NHTSA ODI 11329259

FUEL PUMP LEAKS AT HIGH PRESSURE FUEL LINE. THIS FUEL LEAKS OVER EXHAUST PIPE AND IS A POTENTIAL FIRE HAZARD. *TR

NHTSA ODI 11328609