What 40 owners told NHTSA about the 2025 Kia K4

The contact owns a 2025 Kia K4. The contact stated while driving at 40 MPH on several occasions, the vehicle stalled. The vehicle was able to restart but would immediately stall again, requiring the driver to wait approximately 10 minutes before the vehicle could be successfully restarted and driven. The vehicle was towed on one occasion and taken to the same dealer twice, but the dealer was unable to replicate the failure. The manufacturer was notified of the failure. The failure mileage was approximately 69,085.

NHTSA ODI 11748745

The car completely cut off while driving on the highway going 65 mph. This isn’t the first time it has turned off while driving. I had to pull over and put the car in park before it would turn back on. The error says Accessory Mode. I have taken the vehicle to Kia Dealership in Winston Salem but they told me they are unable to recreate the issue so they are unable to assist with the problem. The car turning off while driving has happened at least 20 times. I have repeatedly called Kia and they are unwilling to diagnose an issue with the vehicle unless it happens while they have it. I am putting myself and others at danger driving this vehicle. I contacted Hertz Auto sales where I purchased it and they directed me to contact Kia since I have a warranty. I plan on taking the car again but I can only hope the issue happens while they have it because this vehicle is VERY dangerous to be on the road and I have no other option than to be at the dealerships mercy.

NHTSA ODI 11748312

This car is a rental to [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11748151

Transmission slippage, rpms rev higher then mph, hesitates at red lights and stop signs

NHTSA ODI 11746968

“The engine undercover (belly pan) detached and is dragging/scraping on the ground on a 2025 Kia K4 with approximately one year of normal use. The radiator support is also affected. Dealer (Selma Kia, Selma CA) denied warranty coverage and stated damage was caused by driver hitting a speed bump. These are factory-installed components on a one-year-old vehicle and should not detach under normal driving conditions. This appears to be a fitment or installation defect.”

NHTSA ODI 11745734

The contact owns a 2025 Kia K4. The contact stated that while driving at 75 MPH, the vehicle downshifted upon depression of the accelerator pedal, with heavy white smoke coming out of the exhaust pipe. The contact stated that the low oil pressure warning light was illuminated prior to the failure. The contact pulled off the highway and drove into a store parking lot as the engine made an abnormal knocking sound. The contact requested assistance from a bystander, who advised the contact that the head gasket appeared to have blown. The contact checked and noticed that the coolant and oil levels were low. The contact added both oil and water to the vehicle and drove to the residence. The contact made a diagnosis appointment with a local dealer. Upon starting the vehicle, the check engine warning light illuminated, and the contact decided to tow the vehicle to the dealer. The dealer determined that the engine needed to be replaced due to sludge. Additionally, the contact stated that the vehicle had experienced various electrical failures, as the trunk, power door, and power windows buttons were inoperable. The contact also stated that the rearview camera image remained displayed while in drive(D) for an extended period. The contact was provided an estimate for the repair, and the vehicle remained in the dealer's possession. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 58,000.

NHTSA ODI 11743732

The warnings on the car all failed and I was lead off the road while going on a roundabout. This has trigged my car to completely lose all control and even though I was attentive to my steering wheel I still didn’t stop the car from leading me to that curb and off road onto grass etc.

NHTSA ODI 11739853

Vehicle's forward collision warnings did not sound. Airbags did not deploy. Vehicle in front end collision at 40mph

NHTSA ODI 11738950

To whom this may concern, I was using my cruise control on my way to work. I usually set it to 80 because police are okay with that speed on I-75. I braked before my automatic brakes hit after I got cut off. I pressed resume in the cruise control and it accelerated pretty quick. I’ve experienced that quite a bit, but there’s been a few times that the car exceeded the set cruising speed while trying to resume. I forget it happens because it’s happened about 4 times since purchasing the vehicle. I noticed an officer on the shoulder leaving the shoulder as I got closer, and he got right behind me and cut his lights on, I look down and the cruise control shows 80 above the speedometer (photo attached taken while pulled over), BUT the arm was past the tick for 90. The officer clocked me at 92 apparently. This is the only time this issue has occurred, and I informed the officer that this happens. I have a court date set for July 9th now. I Googled to see if other owners have this problem. There are others who expressed experiencing this in their K4s and K5s. The AI tool explained the following • "Resume" Behavior: When you press the resume button, the car attempts to get back to 80 mph as quickly as possible. This aggressive acceleration can cause it to temporarily overshoot the target speed before settling down. • Settings Sensitivity: The acceleration strength and reaction speed can be set to "Fast" in your infotainment system, causing more aggressive throttle input.

NHTSA ODI 11737989

I was hit on the driver side of the car infront of the driver door side of the hood and it took out my wheel and the car is totaled with how hard the hit was made my car bounce but the air bags never deployed and the fireman and the police officer said with as hard as I was hit it should have deployed

NHTSA ODI 11733814

As I entered onto i4 reaching the speed of 60 miles an hour my vehicle began to make a high pitched whining noise that got louder as I pressed on the gas pedal, noise dissipated when I let off the gas pedal. Vehicle began to slow down on its own , even when applying pressure to the gas pedal, I had no choice but to pull over on i4, error message displayed “RED CAUTION EMBLEM” error message “Transmission Control Unit” Kia k4 app displayed Diagnostic Alert AT PO72200

NHTSA ODI 11729395

While driving my 2025 Kia K4, the steering system failed and became unresponsive. I was unable to steer the vehicle as intended. The exact cause of the steering failure is UNKNOWN at this time. The vehicle and steering components are available for inspection upon request. The loss of steering control put my safety and passengers riding at serious risk because I could not properly control the direction of the vehicle. Steering is essential for avoiding hazards, staying in the lane, and maintaining control. The failure resulted in a single‑vehicle accident and could have caused serious injury or involved other motorists if traffic conditions had been different. The problem has not yet been confirmed by a Kia dealership or an independent service center. At the time of this report, the vehicle has not been inspected by Kia or another repair facility. Police and/or insurance involvement may have occurred due to the accident, but no mechanical inspection of the steering system has been completed yet. There were no warning lights, messages, or alerts prior to the steering failure. The problem occurred suddenly and without warning while the vehicle was being driven. I did not notice any clear symptoms before losing steering control. The exact cause of the steering failure is UNKNOWN. Based on my personal experience, the failure was sudden and unexpected and occurred during normal driving conditions. I had no prior indication that there was a problem with the steering system before the accident occurred.

NHTSA ODI 11729402

After having my information panel replaced apx. a month later the airbag for passenger seat illuminated and has not gone off.

NHTSA ODI 11721339

Engine Failure, Engine cooling and lost power

NHTSA ODI 11719127

When parked and cutting the car on check driver assistance system come on, check and, and esc comes on. The parking brake does not go off and malfunction. When trying to move the car sometimes it still drives and sometimes the parking brake will not allow you to move until the system resets its self. There are 6 codes that appear. Started in December 2025 have taken car to the dealership 3 times and they report back because the codes are no longer present they can not fix it.

NHTSA ODI 11718311

The insurance claim agent called on behalf of their insured driver, who rented a 2025 Kia K4. The contact stated that while their insured driver was attempting to reverse, the reverse sensor became inoperable with no warning lights illuminated. The contact stated that the reverse sensor failed to function properly. The contact stated that due to the failure, the rear of the vehicle crashed into a barrier. The driver did not suffer any injuries, and no medical attention was required. A police report was not filed. The contact stated that the air bags did not deploy during the incident. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The rental company was made aware of the failure, and a case was opened. The failure mileage was not available.

NHTSA ODI 11717827

The 2025 Kia K4 sensors failed to go off resulting in the rear bumper to hit a barrell. The operator of the Kia K4 was reversing at 1mph

NHTSA ODI 11716251

The digital instrument panel (including infotainment screen) has occasionally turned off and back on. An article showed Kia and Hyundai were going to have a recall at the end of March for this problem, but noted only 2025 K4 vehicles built after Aug 4, 2025 were involved, while the door frame shows my vehicle built 7/2025. Please include my vehicle VIN in the planned software update for the problem to correct the instrument panel screen occasionally turning off and back on. (vehicle recently bought Jan. 2026)

NHTSA ODI 11715310

When I drive over 65 mph, I feel the car lose stability, and sometimes I feel those movements in the steering wheel. Also, it doesn't show the actual tire tread depth. In addition. And there is a burning smell.

NHTSA ODI 11714428

There are times my vehicle keeps accelerating even though I’m hitting the brakes. Once stopped, it then doesn’t want to accelerate. I’ve reported to the dealership and they try to tell me it’s the type of transmission it has and that it’s normal. Continuing to accelerate while braking is extremely unsafe. My engine is also making a ticking noise that it never used to make. I bought my car brand new in October of 2025. I left the dealership with 9 miles on it, I now have 25k miles on it and I don’t feel safe driving it. The lane assist and emergency braking system is also extremely inaccurate and over corrects when it shouldn’t especially in bad weather. Emergency braking is detecting stuff in front of me that isn’t actually there, same with in reverse it sees things extremely far away and prevents you from moving, although it’s safe to do so.

NHTSA ODI 11711366

I am reporting a serious safety defect involving the brake pedal area of my newly leased Kia K4 GT-Line. There is a metal bracket/component located directly above the brake pedal that interferes with foot placement. My foot becomes caught on this bracket when attempting to apply the brake, which delays or prevents proper brake application. On [XXX], while exiting the roadway and attempting to stop at a stop sign, my foot became stuck on this bracket as I applied the brake. This caused a delay in braking and nearly resulted in an accident. I was shocked and frightened, as this situation could have resulted in a life-threatening collision. I took the vehicle to the dealership, Kia Beavercreek in Dayton, Ohio, for inspection. The dealership reviewed the vehicle and stated that they were unable to fix the issue. I was told there was “nothing wrong” with the vehicle and that I simply did not know how to drive it. Despite this, the obstruction remains and continues to interfere with safe braking. Because this defect directly affects my ability to safely apply the brakes, I do not feel safe operating this vehicle. This is a critical safety issue involving brake operation that poses a risk of serious injury or death. The vehicle has extremely low mileage, and the dealership has acknowledged the concern but stated it cannot be corrected. Photos of the brake pedal area are available and clearly show the metal bracket near the brake pedal that causes the obstruction I can not put life and others life in danger driving this car. Please assist INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11711102

Location: Intersection of [XXX] and [XXX] Lakeville, MN Date/Time: [XXX], at approximately [XXX] Vehicle: 2025 Kia K4 (911 call placed at 10:08 am) On [XXX], while traveling toward the roundabout at [XXX] and [XXX], my vehicle experienced a sudden and violent unintended acceleration. Despite having my foot completely off the gas pedal, the engine began to accelerate the vehicle rapidly on its own. I immediately attempted to regain control by pumping the brake pedal repeatedly with significant force. These efforts had no effect; the vehicle continued to accelerate faster and faster. As the speed increased, the vehicle began to swerve, and I realized I was losing control while rapidly closing the distance between myself, the roundabout, and the vehicles ahead of me. Fortunately, the right lane was clear. Because the vehicle was already veering in that direction and the brakes were failing to slow the car, I made a split-second decision to steer into a large snowbank to avoid a high-speed rear-end collision. The force of the impact with the snowbank was substantial, resulting in the front body panel and a lower front component being torn off the vehicle. The Lakeville Police and Fire Departments responded to the scene and were required to dig the vehicle out of the snow pile. I have attached the official police report to this statement. Had I not maintained a safe following distance or made the decision to steer off the road, the result would have been a catastrophic multi-vehicle collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11708024

I am reporting ongoing safety issues with my Kia K4 LXS involving driver assistance systems and steering control. While driving in heavy rain with reduced visibility, the vehicle disabled multiple sensors and displayed a “camera obscured” message along with inattentive driving warnings, despite both of my hands being on the steering wheel and my full attention on the road. The loss of driver assistance features during hazardous weather conditions created a distracting and dangerous situation. This issue occurs frequently. I regularly receive false inattentive driving and hands-on-wheel warnings even when I am driving properly. These alerts are distracting and interfere with safe vehicle operation. I am also experiencing lane control and steering interference. The steering wheel will sometimes pull the vehicle in a direction that does not match the road, even when lane assist is turned off. This is especially dangerous in construction zones with temporary lanes marked by reflectors, including when driving next to large trucks. I have experienced multiple near-miss incidents and have had to physically override the steering wheel to remain in my lane. These problems now occur almost every time I drive and have caused me to feel unsafe operating the vehicle. I believe this represents a serious safety defect.

NHTSA ODI 11707033

High mounted rare brake (pulse)

NHTSA ODI 11706751

Bought car in Nov 24. Noticed a popping sound as if a rock was hitting windshield. Nothing hit windshield. The popping sound was intermittent but went on for months. Finally in August 2025, I noticed a crack in upper side of drivers windshield. Next day crack got bigger. Called safelite to replace. Had to park car with cover over windshield since I couldn’t get an appointment right away. Had to rent a car. Windshield replaced. Popping continues, less frequently but it still pops. Took it to Burlington Kia and explained my issue. They could not replicate the popping sound.

NHTSA ODI 11706672