What 266 owners told NHTSA about the 2025 Hyundai Tucson Fuel Cell

On XXX, my vehicle unexpectedly activated its automatic braking system while driving, resulting in a rear-end collision. My infant daughter was in the vehicle at the time. While we were fortunate to avoid catastrophic injuries, the incident placed both of us in significant danger and could easily have resulted in a much more serious outcome. The other driver may also have sustained injuries as a result of the collision. The vehicle sustained approximately $20,000 in damage. Since the accident, I have learned of Hyundai’s recall involving this braking system. Given the circumstances, I am deeply concerned that the condition addressed by the recall contributed to the collision. What is particularly troubling is that this was not the first time I raised concerns regarding the vehicle’s braking behavior. On February 23, 2026, at approximately 11:00 a.m., I spoke with my dealership, North Bay Hyundai in [XXX] regarding unexpected braking behavior that I was experiencing with the vehicle. My concerns were not escalated, and I was not advised that a potential safety issue might exist. Several months later, I was involved in a collision involving the same system that is now subject to recall. I am also deeply concerned by the manner in which this recall was communicated. I received only a text message regarding a defect involving a critical vehicle safety system. Given the potential consequences of unexpected braking events, I do not believe the seriousness of this issue was adequately conveyed to affected customers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11740955

Doesn't slow down properly when I step off from gas pedal and try to stop at traffic light/stop signs and before making turns. It barely reduces average 2 mph for whole block. Lets say when I step off from the gas pedal at 25 mph, the car reduce the speed to about 23 mph when it's so close to light/stop signs and right before making turns. It seems like there is no 1st gear, just 2nd gear is the lowest. Always I have to brake harsh before light/stop sign/ making turns. I've been driving for 45 years in NYC but I can't get used to this dangerously weird driving situation while driving the 2025 Hyundai Tucson. I have driven the 2023 Hyundai Tuscon before as well but I have not had this issue until now with the 2025 model.

NHTSA ODI 11740310

Component or system that failed or malfunctioned: The electronic throttle control system and/or the powertrain control system malfunctioned, causing the vehicle to accelerate automatically and involuntarily. How safety was put at risk: The malfunction caused a collision with another vehicle and a structure. The failure placed the safety and physical integrity of two individuals at serious risk. Problem reproduction or confirmation: To my understanding, the issue has not yet been reproduced or confirmed by a dealer or an independent service center. Inspection of the vehicle or component: The vehicle and/or the affected component have not yet been inspected by the manufacturer (Hyundai), law enforcement, or insurance representatives, as an insurance claim is currently in progress. Warning lamps or prior symptoms: There were no warning lights, messages, or other symptoms prior to the failure. The incident occurred suddenly without any prior indication. During the event, the brake pedal did not respond.

NHTSA ODI 11716552

The contact rented a 2025 Hyundai Tucson. The contact stated that the vehicle would stop and would restart independently while driving. The contact stated that while attempting to reverse, the vehicle failed to respond on several occasions while the gear shifter was in reverse(R). The contact stated that the failure occurred while there was a vehicle parked behind the vehicle or further away. There was no warning light illuminated. The rental company was informed of the failure. Additionally, the contact stated that upon shifting to reverse on one occasion, the vehicle responded, but unintendedly accelerated. The contact stated that upon depressing the brake pedal, the brake pedal was stiff and failed to respond, causing the vehicle to crash into an unoccupied parked vehicle. The contact stated that the distance between the two vehicles could fit two parked vehicles. The contact stated that her teenager was occupying the front passenger's side seat during the incident. The contact stated that the front passenger's side and driver's side seat belts failed to restrain the passengers as needed, causing both passengers to use their arms to protect themselves. The police officers arrived at the scene but did not file a report. Both passengers sustained arm, neck, and head pain but declined to be transported to the hospital by ambulance. The contact stated that the gear shifter was locked after the crash and required two hands to move to park(P). The rental company was informed of the failure. The contact was able to drive the vehicle back to the residence. The vehicle was driven to the Rental Company the following day. No further information was available. The dealer and the manufacturer were not notified of the failure. The failure mileage was 24,292.

NHTSA ODI 11714439

The Forward Attention Warning system performs erratically, frequently disabling the adaptive cruise control without warning. Even when it does emit a warning, which again, is erractic, the warning is barely audible. When conditions, such as grooved pavement or loud cabin noises, such as when a window or moonroof is open, the warning is completely in-audible. Similarly, the warning message displayed is not readable within the 0.5 - 1.0 sec (best estimate) that it is shown, as it is several lines of text - a distraction in itself. The disabling occurred during times when this ADAS feature is most value, cruising at highway speeds in heavier traffic - a time when automatic speed control and braking, along with maintaining a clear distance, are all invaluable to driver safety.

NHTSA ODI 11702350

In October 2025, the center display screen in my 2025 Hyundai Tucson Hybrid began shutting off repeatedly while the vehicle was in motion. The screen controls essential functions including speed information, navigation, backup camera, safety alerts, and hybrid system data. When it shuts off, all of these features become unavailable without warning. The failure is intermittent and continues to reoccur. The component involved is the center display/infotainment system and may affect related radar and safety-system warnings. The dealer stated they duplicated the issue and reported that it was repaired, but the same display failure occurred again afterward while I was driving. The vehicle is currently with the dealer and is available for inspection upon request. My safety and the safety of others is put at risk because when the screen shuts off, I lose access to critical vehicle information. This has happened at highway speeds, including one instance where the display shut off approximately eight times within 20 minutes. In addition, the radar warning system has activated when no nearby vehicles were present, creating distraction and uncertainty. The problem has been reproduced by the dealership, documented by me on video, and reported to the manufacturer. The vehicle has been inspected multiple times by an authorized Hyundai service center and reviewed by the manufacturer’s customer service department. There have been no police or insurance inspections because the defect has not resulted in a crash, though the safety risk is significant. Warning symptoms include intermittent radar system alerts appearing without surrounding traffic. These symptoms began in October 2025 and have continued even after dealer repairs. The display failure persists and the vehicle remains unsafe to operate. P.S. I cannot upload video evidence as the website would not allow me and I have to start over.

NHTSA ODI 11702037

Concern: DAW Driver Monitoring System False alerts shuts down cruise control. Safety issue when passing on interstate and suddenly the cruise shuts off and has to be reset. This warning sometimes goes off randomly and not due to driver attentiveness. If my arm is in top of steering wheel it blocks camera and wearing certain types of sunglasses. This system is asking the driver to not put his arm on top of wheel which is ridiculous.

NHTSA ODI 11698087

Vehiclr has been doing this since 4 montbs after purchase, then a recall came out we were told it would fix the problem. 3 times now since the recall the odometer screen and media screen will go blank while your driving. The car wont accelerate, turn signals, and steering colum becomes hard to operate properly. We have had to near accidents 1 being less than 2 hours in August of 2025 after Hyundai just claimed to repair the issue. We were driving on [XXX], screen went out, we lost full control of steering, had to wrestle with the wheel to keep car in its lane, we were almost hit by semi truck and ran off road. We immediately took car back to dealership, and shop assistant mgr was able to see for himself, it wasnt working after theu just made repair. They kept car a few days we were very reluctant to take vehicle back, out of these safety concerns, and my family having to ride in this vehicle. We took ot back as the dealership assured us the matter had been taken care. Then last week on [XXX], in the evening was driving down street and the screens started to flicker and the car wouldnt stay centeryed in the lane, then it happened both went blank, the car slowed down and the fight began on operating vehicle. In regards to no turn signal would go off, it wouldnt accelerate, the steering wouldnt operate correctly, if O wanted to center the car in the lane, it would pull the car another direction. A 7 minute ride home took over 20 minutes. We took car back to World Hyundai Matteson, the next morning and called Hyundai Corporate office to inform them we didnt want the vehicle back. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11693090

In my 2024 Tuscon, Hyundai has connected their cruise control to their driver assistance function. This system includes a camera on the steering column that watches the drivers eyes. If for any reason, they cannot see your eyes they will shutdown cruise control without warning. This can be caused by simply wearing sun glasses. So this forces the customer to choose between two safety features. Cruise control which we all know has signifcant safety implications reducing stress fatique, etc. and bypass all the driver assistance systems. There are people who are putting black tape over the camera and disabling DAS so they can use their cruise control due to the inability to wear sun glasses when heading west (obviously even within a curve, so it shuts down unexectedly in the curve). Surely that is not an acceptable solution. Hyundai should add an option to ignore the eye checks while using the cruise control but so far they have totally ignored it. You can google for "Hyundai cruise control sunglasses" and will see a lot of complaints and people disabling safety features. Obviously there is no specific event, this is happening all the time in the US.

NHTSA ODI 11692400

First incident was July 2025 . Car had 1300 miles. Would not accelerate over 25 miles an hour. Made an appointment with Route 60 Hyundai in Vero Bch, Fl. They could not find anything wrong. (invoice # [XXX]) Second time [XXX]. 3009 miles on the speedometer. The car would not accelerate over 4mph. After several minutes acceleration was possible. We will once again return to Route 60 Hyundai. Car could not get thru a busy intersection. Very dangerous. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11691399

The message “Consider taking a coffee break” will pop up just 15 minutes into a trip. This message beeps prior to flashing on the screen which causes us to take our eyes off the road to determine what is beeping and continues to “alert” us often during our travels. Hyundai has not provided a way for this warning to be deactivated. Hyundai has way too many messages beeping and appearing on the screen that causes distractions and has not provided a way to turn them off. As for the speed control, my ophthalmologist suggested I wear dark sunglasses due to issues I have in bright sunlight. The speed control will actually turn off if I wear dark sunglasses because the onboard camera cannot see my eyes. Also, the speed control will turn off if I’m making a turn and my arm gets in the way of the camera. This is extremely dangerous that the speed control just stops. We also will get beeps and a message on the screen if the camera cannot see our eyes, even when we are looking straight ahead. Again, this causes us to see what is beeping and what the message says. This is a distraction that causes us to take our eyes off the road. Terrible design.

NHTSA ODI 11680745

There is a sensor on the steering column that turns off the cruise control if it can’t see your eyes. This happens abruptly and slows the car down. It will cause a rear end collision if not taken care of! Has been to the dealer 5 times.is available for more inspection. There is a sensor on the steering column that turns off the cruise control if it can’t see your eyes. This happens abruptly and slows the car down. It will cause a rear end collision if not taken care of! I have more documentation from the dealers but I don’t have room to upload. Yes dealers have reproduce the issue. Manufacture has been notified and had us take to dealers. Warning message on dash but no time to react.

NHTSA ODI 11643566

-auto start/stop "feature" Since there is no way to permanently disable this feature i forgot that it was on. while stopped a stop light i was unable to move when the car behind me could not stop due to the wet roads. If the car behind me was unable to swerve in time i would have been rear-ended. by the time the engine started the car behind me was in line with my back seat. no amount of gas saving is worth being immobilized essentially in a emergency situation. - forward collision avoidance is way too sensitive, in the same trip as above a car hit their brakes approximately 6 car lengths in front of me to turn into a parking lot. the car in front of me did slam on their brakes to make the turn. As i took my foot off the gas to slow down the "safety feature" activated, applied my brakes and almost caused the car behind me to rear end me. i was going roughly 45 mph and the car behind me was roughly 2 car lengths behind me when the "safety feature" activated. the sensitivity of this system is way too high and will wind up causing more accidents then it prevents

NHTSA ODI 11642579