What 100 owners told NHTSA about the 2025 Ford F-150 Supercab

issues with my 2025 f150 tremor when I applied my brakes firmly, really not that hard ( not hard enough to skid) my truck locked into park and I wasn’t even able to put it back into a gear with a flashing message! Couldn’t get it back into gear for about 30 sec to 60 sec until a message stopped flashing. Had this happened in traffic or on a freeway this could have been really bad especially in traffic. Very dangerous!

NHTSA ODI 11747019

THIS CONCERN HAS A TRACKING NUMBER FROM NHTSA #XXX. THIS 2025 FORD F 150 [VIN [XXX] ] HAD NO ISSUSES WITH A MESSAGE THAT STATES REVERSE BRAKE ASSIST NOT AVAILABLE SEE MANUAL SHOWING ON THE DASH DISPLAY UNTIL AFTER THE REQUIRED UPDATE FOR THE DASH AND THE BOSCH BRAKE MODULE WAS INSTALLED. IT HAS BEEN TO 2 DEALERS FOR THIS ISSUE MULTIPLE TIMES FROM OCT 25 - APRIL 26. THE SECOND DEALER FOUND THE SAME THING, MESSAGE APPEARS WITH NO CODES SET, THEY HAVE ALIGNED CAMERAS AND THE MESSAGE STILL COMES BACK ON. THIS BEING A BIG SAFETY ITEM TO SAVE BACKING INCEDENTS YOU WOULD THINK THEY WOULD FIND OUT WAT IS CAUSING THE ISSUE, BUT NO FORD TELLS THE DEALER TO TELL THE OWNER IT'S NORMAL. I DON'T BELIEVE IT IS, IT'S INSTALLED AND ADVERTISED AS A SAFETY FEATURE AND IF YOU READ UP ABOUT THIS PROBLEM THERE ARE A LOT OF THESE TRUCKS WITH THIS ISSUE AND FORD DON'T WANT TO ACKNOLEDGE THAT THERE IS A PROBLEM AND FIX IT. I WOULD HOPE YOU WOULD ENTICE FORD MOTOR COMPANY TO GET OFF THERE XXX AND TAKE CARE OF THIS. FORD CUSTOMER COMPLAINT TOLD ME THAT THEY SHOWED 1 RO ON FILE FROME THE PREVIOUS DEALER AND I HAD FOUR AS THEY HAD BILLED 4 UNDER SERVICE CONTRACT FOR MAINTAINCE NOT THE CONCERN, I DON'T KNOW ABOUT THE SECOND DEALER BUT THEY HAVE TRIED UNTILL FORD SAID IT'S NORMAL. I HOPE HEAR SOMETHING BACK ON THIS. THANK YOU INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11740802

My wife was parking our F150 in a parking lot with landscaped dividers I was a passenger. The vehicle was in one foot driving mode. As she approached the curb going 1 to 3 mph, she moved her foot from the accelerator to the brake. As soon as she left the accelerator the vehicle rocketed off. She put her foot down on the brake, but the power of the vehicle was so great and so fast the vehicle went over the curb and a 4 inch landscaping tree. Luckily we were facing a drive on the other side and not a car. The vehicle stopped in the drive. The surge possibly lasted 1-2 seconds, but that was enough to lose complete control. If we were facing another car we would have landed on top of it. We were not injured and no pedestrians were in the vicinity. The body shop and the Ford dealership were unable to tell us what occurred. Ford needs to access the EDR module. Online research shows this event has happened to other owners.

NHTSA ODI 11738717

Forward collision assist was activated without warning and for no reason. Brakes were applied abruptly causing the vehicle to slow down dramatically causing passengers to lurch forward which caused temporary discomfort in head, neck and shoulder area. Driving at approximately 50MPH in a straight direction on a two-lane road, one lane for each direction. There were no vehicles in front or rear in same lane of travel. Had just passed another vehicle traveling in the opposite direction. Road conditions were normal. Roadway was dry with no obstacles. Vehicle is scheduled for inspection.

NHTSA ODI 11732347

While driving slowly in a traffic queue, the driver applied the brakes to stop behind the vehicle ahead. The ABS activated unexpectedly, causing the truck to lurch/jump forward instead of stopping smoothly. The driver was forced to steer left to avoid a collision, but the vehicle ultimately struck the car in front, damaging the left front of the truck. No injuries occurred. This is not the first time this behavior has been observed in this vehicle, and the vehicle had previously been inspected by an authorized Ford dealership for similar braking behavior without resolution. The incident occurred at low speed in stop-and-go traffic conditions. The vehicle is currently at a Ford dealership for repair related to this incident.

NHTSA ODI 11730060

While backing at low speed in a residential driveway, the vehicle struck a parked car causing significant damage. No ADAS safety systems activated: reverse automatic braking did not engage, no parking sensor warnings sounded, no audible or visual alerts occurred. The vehicle made no attempt to slow or stop despite approaching a large stationary obstacle. The vehicle has two open unrepaired recalls at the time of incident: Recall 25V488 (Electronic Brake Booster): EBB module may shut off unexpectedly during ADAS use. The EBB is integral to the electronic braking system ADAS relies on to autonomously apply brakes. If faulted, reverse automatic braking cannot engage regardless of sensor detection. Software fix was available but never applied. Ford documented 37 warranty claims and one crash before issuing this recall. Recall 25V863 (Integrated Park Module): May fail to lock into park. Remedy not yet available. The vehicle provided zero warning of degraded safety capability. No dashboard indicators or alerts that ADAS was unavailable. Multiple overlapping systems failed simultaneously suggesting cascading failure from the EBB fault or multiple independent defects. Ford SSMs 52161, 49767, and 50360 document known Lightning issues with inoperative park aid and reverse brake assist unavailability. The recall notice emphasizes brake pedal feel but does not clearly communicate that the defect can disable automatic emergency braking. Consumers may delay repair not realizing ADAS is compromised. Vehicle is available for inspection.

NHTSA ODI 11720513

The truck has approximately 5,000 miles. When adaptive cruise control is engaged, the vehicle accelerates on its own to 85 mph whenever the posted speed limit changes, and there are no available settings to prevent this. For example, if the speed limit is 55 mph and adaptive cruise control is set to 55 mph, when the limit changes to 65 mph the truck automatically increases speed to 85 mph without driver input. Additionally, Apple CarPlay does not connect or function in the vehicle. The truck was taken to the dealership for this issue on 11/21/25 and has since been in and out of service multiple times, often remaining there for weeks at a time, for the same unresolved problems.

NHTSA ODI 11717772

The automatic forward collision warning slammed on the breaks whe. There were no other vehicles or obstacles in the road

NHTSA ODI 11717889

The contact owns a 2025 Ford F-150. The contact stated while driving approximately 80 MPH with the Adaptive Cruise Control activated, the vehicle unexpectedly veered toward an 18-wheeler while passing. The driver’s hands were not on the steering wheel during the failure, and the driver was attentive and was not distracted, and was actively monitoring the roadway. The Adaptive Cruise Control system independently disengaged. The driver was able to regain control of the vehicle and later reactivated the Adaptive Cruise Control and the vehicle operated normally. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 19,000.

NHTSA ODI 11717211

Wednesday [XXX]/Phantom Braking Proceeding northbound on [XXX] at estimated speed of 35 mph. Road was clear with no oncoming traffic. Suddenly the brakes locked up and a collision notice appeared on dash. Brakes released and continued northbound with no further issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11715724

While using the vehicle’s BlueCruise driver assistance system, the driver monitoring system generates frequent false driver-attention alerts despite normal posture and active attention to the roadway. The system often fails to recognize attentive driving unless the driver deliberately exaggerates head position or facial expression. Routine and unavoidable behaviors—including briefly touching the face, wiping the nose, or checking side-view mirrors for traffic—frequently trigger alerts, even though these actions are part of safe driving. These false positives create alert fatigue and increased cognitive load, forcing the driver to divert attention from driving to manage the monitoring system itself. The intrusiveness of the alerts becomes distracting and undermines the intended safety benefit of the system. Due to the frequency of false alerts, the driver is often compelled to disengage BlueCruise entirely. I am concerned the current driver-monitoring calibration may inadvertently increase distraction for attentive drivers and warrants review. This issue has been reported to the manufacturer and logged under Ford Product case number [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11712028

This truck has had numerous messages on the dashboard stating Reverse Brake Assist Not Available See Manual. Have taken to the Dealership and was told that there was no code and the couldn’t fix as the message wasn’t displayed. They said when it came on to bring it in. Long story short when message is displayed by the time you arrive it is gone. I have done the simple things like make sure sensors are clean, doors and hood is closed and the soft clear by unhooking the battery cable for 15 minutes. This whole mess started after a dash recall in the fall of 2025.What good is this for a safety feature to prevent reverse incidents if not working properly.

NHTSA ODI 11709670

The contact owns a 2025 Ford F-150. The contact stated that while idle at a red light, while using the brake hold feature, the vehicle's brakes suddenly released, causing them to rear-end the vehicle in front. No air bags deployed. There were no injuries or medical attention needed. A police report was filed. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The vehicle's cruise control was set to 15 mph when entering and passing through a school zone, and once out of the school zone, the speed limit increased to 30 MPH at which time the vehicle accelerated to the higher speed with the cruise control still set to 15 MPH and activated. The manufacturer was informed of the failure. The failure mileage was approximately 3,000.

NHTSA ODI 11707547

In November, shortly after engaging adaptive cruise control on [XXX] the truck indicated an incorrect speed limit of 45 mph and immediately started braking HARD causing a hazard on a busy roadway. I stomped on the gas trying to override the automation until I could disable the feature. This is a commonly reported issue on forums and local news reports ( [XXX] ) and does not appear to have a fix so I have not bothered to take it to the dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11706810

I was turning right, out of a store parking lot onto the street, at very low speed. Suddenly the truck accelerated on its own. I had to quickly hit the brake to prevent striking a vehicle in front of me that had stopped for a red traffic signal. I believe there is a possibility that Ford's new method of activating cruise control (which now only requires a single button press after which the truck will set current speed OR 15 MPH, whichever is greater) could be to blame. If a driver turning the steering wheel makes contact with a single button on the steering wheel with his/her hand or palm by accident, this seems to cause the unexpected acceleration. It is a quite dangerous situation that in my opinion Ford should correct by requiring TWO steps to activate cruise control as opposed to one.

NHTSA ODI 11704439

The following components have failed multiple times over the course of 3 months to include the above referenced recalls and additional components. The recalls have been completed per ford . The instrument panel was not going blank until the software update was completed now it malfunctions multiple times a day . The brake warning will appear randomly and without warning depicting "Brake System Fault" service required . "Parking Brake Fault " service required immediately. In addition to the above issues the entire lighting/lamp system will turn off unwarranted at night while on auto . Reported multiple issues as described to AutoNation Ford and Ford Credit. No resolution has been provided.

NHTSA ODI 11699811

On November 2nd, 2025 at approximately 6pm, in Houston, Texas, my 2025 Ford F‑150 with Ford BlueCruise engaged in Hands‑Free mode was traveling with traffic at about 70 mph on a major thoroughfare. Without driver input, the system rapidly reduced speed to about 50 mph after it appeared to misinterpret an unknown speed‑limit change. This sudden, uncommanded deceleration created a hazardous speed differential with surrounding traffic. I swiftly took over manual control to maintain traffic flow and prevent a potential rear‑end collision. No crash or injury occurred, but the behavior constitutes phantom braking and false speed‑limit recognition in an Advanced Driver Assistance System feature.

NHTSA ODI 11697240

Ford BlueCruise steering oscillation •Date/Time: October 17, 8:00 PM •Location: Hempstead, Texas •System: Ford BlueCruise (hands‑free lane‑centering/driver‑assist) BlueCruise was engaged in hands‑free mode when, without driver input, the system became confused and initiated repeated left/right steering corrections. The vehicle weaved within the lane several times in quick succession, requiring immediate intervention to maintain control and prevent a collision. After I took over, the vehicle tracked normally with manual steering. This behavior represents a serious safety hazard.

NHTSA ODI 11696012

On October 12 at approximately 6:25 PM in Texas City, TX, while Ford BlueCruise (hands‑free) was active, the vehicle abruptly steered left, crossing into the left lane toward the left‑side barrier. I immediately took control and counter‑steered to keep the vehicle in its lane and avoid a collision. No contact occurred, but the maneuver created an imminent risk of loss of control and impact with the barrier or another vehicle. This appears to be unsafe/erratic lane‑centering behavior by BlueCruise.

NHTSA ODI 11696014

On October 8, 2025, my wife and I purchased a 2025 Ford F-150 Lariat, 3.5L Full Hybrid, with Ford's BlueCruise hands-free driving feature. As first-time users, I reviewed the owner's manual and Ford’s videos to understand BlueCruise. After several uses, I noted unpredictable behavior and now report a serious safety issue warranting federal investigation. On October 15, 2025, while driving north on I-95 near Boston with BlueCruise engaged in hands-free mode on an approved route, I pressed the Memory 1 recall button to adjust my seat. A chime sounded, and the instrument panel stated that Memory Recall is not active while the vehicle is moving. Unexpectedly, pressing the button deactivated BlueCruise, causing immediate deceleration and returning steering control to me. During a shallow left turn, the vehicle proceeded straight, almost deviating from the lane. I quickly regained control, preventing a lane departure. The owner’s manual and Ford’s resources do not mention that Memory Recall can deactivate BlueCruise. This undocumented behavior is highly concerning. On October 20, I contacted Ford (Reference Number [XXX] ), but their response was inadequate, offering only a generic process without technical team access or follow-up commitment. BlueCruise’s lane-centering struggles with unclear or conflicting lane markings. On I-95 sections under resurfacing, temporary markings are placed 1-2 feet from fainter original lines. BlueCruise inconsistently tracks either set, causing unpredictable lateral movements, including sudden lane-edge excursions or rapid shifts over bridges where markings misalign. When another vehicle overtakes closely, crossing into our lane, BlueCruise momentarily loses lane-keeping ability due to obstructed markings, resulting in rapid steering movements. While such overtaking reflects poor driving by others, an automated system must handle these common scenarios reliably. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11694608

Ford BlueCruise cut-in non-response Incident date/time: September 29, 2025, ~6:15 PM Location: US-290 East, near Waller, Texas Vehicle: 2025 Ford F-150 Lightning System: Ford BlueCruise (hands-free driver assistance) While traveling eastbound on US-290 with BlueCruise engaged (hands-free with lane centering and adaptive cruise), an 18-wheeler flatbed changed into my lane directly ahead. The system did not decelerate or otherwise respond to the cut-in and continued closing speed on the truck. After a couple of seconds, I manually and rapidly disengaged and braked to prevent a rear-end collision. No contact occurred, but the lack of deceleration created an immediate crash risk.

NHTSA ODI 11692043

The Ford BlueCruise system almost got my family and myself rear ended with possibly a major injury to death. On our way to San Antonio, Texas from Houston, Texas we were driving across [XXX] withe the BlueCruise engaged. Then out of no where it started giving me the message to place my hands on the steering wheel. My hands were on the steering wheel. It gave me the message 3 times. Then it shook the steering wheel at the same time flashing Resume control. Then it slammed on the brakes. Luckily the truck behind us was paying attention and slammed on their brakes slowing their vehicle down. They drove around us. My wife asked if I did that and I said No, it was the truck. It also did it on the way back to Houston, Texas. After several times of the BlueCruise acting up, I took the truck back to the dealership. It was also turned in for the Brake system recall. iT has been at the dealership for just over a week now p w. The dealership; Tomball Ford, contacted me saying their technician and QC tech couldn't replicate the issue. So, i went up there and had; Ray, the QC tech ride with myself in the truck. Within a mile or 2 the truck's BlueCruise did exactly the same thing. We turned around to head back to the dealership and the truck did it again, but worse. This time the brakes engaged 3 to 4 times slowing the truck down from 60 mph to 30 mph and turning on the Hazard flashers before I turned it off. This time numerous vehicles slowed down and swerved to avoid rereading my truck with both myself and the Tomball Ford QC technician. All the QC technician said, was, "Oh, that's not supposed to do that." I was like [XXX] But your technician couldn't replicate that? The truck is in the shop, but I do have the messages from the service advisor; Ashly, from Tomball Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11683658