What 41 owners told NHTSA about the 2024 Kia Seltos

While driving, the vehicle suddenly began handling abnormally. In response, we safely pulled over as quickly as possible. Before we could fully stop, the wheel catastrophically failed. The rim cracked around the entire circumference, the tire completely separated from the vehicle, and the vehicle lost stability and struck the guardrail. As a result of this incident, the vehicle sustained substantial damage, including but not limited to: •Complete destruction of the wheel/rim; •Tire separation; •Axle and suspension damage; •Body damage to the driver-side front and rear panels; and •Additional mechanical damage that is still being assessed. Photographs taken immediately after the incident clearly show that the wheel fractured around the rim itself. The damage pattern is consistent with a catastrophic wheel failure, not ordinary cosmetic damage or curb rash. When I initially contacted the Kia dealership, I was told that they had "never seen anything like it." However, after the vehicle was towed to the dealership, the explanation changed, and I was informed that Kia now believes the vehicle must have struck something and that the impact caused the wheel to fail. That explanation is inconsistent with what occurred. At no point prior to the failure did we strike debris, a pothole, a curb, or any other object that would reasonably explain a complete structural fracture of the wheel and the tire separating from the vehicle. The wheel failed first. The collision with the guardrail occurred only after the catastrophic wheel failure and loss of control while attempting to safely pull over.

NHTSA ODI 11744857

Since November 2025, this vehicle has experienced repeated loss of power, severe shaking during acceleration, jerking between gear shifts, abnormal humming/grinding noises, and multiple check engine light events. The condition is most noticeable between approximately 40-70 mph and has repeatedly occurred while driving on highways. On multiple occasions, the vehicle struggled to accelerate properly and would not respond normally to throttle input. During one occurrence, the vehicle had difficulty accelerating beyond approximately 55 mph while on the expressway. The shaking became severe enough that I feared mechanical failure could occur while driving. I was forced to pull off to the shoulder of the highway because I no longer felt it was safe. The inability to maintain speed and accelerate normally created a safety risk for both myself and surrounding traffic. The vehicle has been returned to the dealership six times for the same recurring issue. Repairs have included replacement of the ECU, catalytic converter, ignition components, fuel injectors, and other engine related components. Despite these repairs, the problem continues to return. The condition has been repoduced and documented by the dealership, and a manufacturer field technician was involved in the most recent diagnosis process. Most recently, after the vehicle was inspected and believed to be repaired, the check engine light illuminated again while the service manager was moving my vehicle to be washed inside of their garage, as I waited (today, June 11th 2026). The recurring loss of power, repeated check engine light events, and inability to permanently correct the defect raise significant safety concerns while operating the vehicle. I have all documentation in my notes, as well as the dealership repair documents.

NHTSA ODI 11743542

Under extremely cold temperatures, approx 10° the main display does not work. The MPH & other vehicle information will not display. KIA service requires the vehicle to be brought to the facility while condition exists in order to troubleshoot, however once the vehicle warms up, the non functioning display begins to operate normally and the problem does not exist. Speaking with the service advisor and service manager in charge, they are aware of the problem and know of other vehicles with this display problem.

NHTSA ODI 11735970

Came out of work to a cracked windshield. There was no crack in my windshield prior to this. The crack spans across half of the windshield requiring a full replacement which is going to come completely out of pocket for me because I had a $1000 deductible. Had I known this was such a common issue with this year make and model, I would’ve opted for the $0 glass deductible. As many others have reported and stated, this was never an issue I’ve had with any other vehicle I’ve owned. It is clearly a manufacturing defect and SHOULD be covered by Kia. I’ve had this car for 7 months.

NHTSA ODI 11718087

While driving in traffic, my 2024 Kia Seltos suddenly shut down without warning again. I lost propulsion while the vehicle was in motion with passengers inside, creating an immediate safety hazard. The issue appears electrical or powertrain-related. This occurred during normal operation and could result in a serious crash. My vehicle shutting down in active traffic with passengers is unacceptable, and there is no recall remedy in place to correct this hazard. I am requesting a manufacturer-level resolution under Ohio Lemon Law and the Magnuson–Moss Warranty Act.

NHTSA ODI 11717634

The dashboard goes completely black and will not work when it is really cold outside. This is a dangerous problem because I cannot see my speedometer, how much gas I have in my car, or the engine temperature. I have been to the Kia dealership 3 or 4 times for this problem and have them report it to Kia. They always tell me that they cannot replicate the problem so they cannot fix it. I have video evidence of this happening and have showed it to the dealership. This has happened now for 2 winters. There have been no warning messages or anything before this happens.

NHTSA ODI 11714925

When the temperature is around zero my dashboard will not come on. I have been to the dealership 5 times for this issue. It takes me an hour to get to the dealership and by the time I get there it comes on. Dealership (Ken Ganley) states they can’t find the problem if it’s on. This is total bullshit, they know they have an issue and can fix it. Bought the car brand new. I believe it’s a safety hazard when I have no speedometer, gas guage or indicator lights. This has been going on since I purchased the vehicle in July 2024.

NHTSA ODI 11714763

During the incident in question, the vehicle’s lane‑assist system malfunctioned in a manner I have never previously experienced. As I approached an area with multiple lane markings, the system appeared to become confused—possibly due to low‑light conditions—and abruptly pulled the steering wheel with significant force. This deviation was severe enough that I temporarily lost control, causing the vehicle to drift toward the left-side ditch. When the steering suddenly released and became limp, I attempted to correct the trajectory, but the response window was too narrow to avoid impact. The vehicle struck a wooden signpost, resulting in damage to the right headlight assembly and the complete detachment of the right fog light. No lane‑departure warnings were issued at any point. Under normal circumstances, the vehicle provides audible alerts regardless of whether lane assist is active, and I am familiar with the areas where such alerts typically occur. Additionally, the forward‑collision warning system failed to activate, despite its usual tendency to trigger even in non‑hazard situations. This inconsistency has been present since I acquired the vehicle. Prior to this event, I had also been experiencing intermittent electrical issues. I attempted to seek service at the nearest Kia dealership; however, reaching it requires traveling through a national forest during winter conditions, which is unsafe unless absolutely necessary. I attempted to file an incident report with local law enforcement, but was informed that a report could only be taken if another motor vehicle was involved. I then attempted to file a report with the DMV, but the online system requires an Oregon‑issued driver’s license. I currently hold a valid Oklahoma license and have been unable to update it due to financial constraints and an anticipated move later this year. I have experienced neck pain between my shoulders since the incident.

NHTSA ODI 11713766

When the stop and go feature re-enables the engine to go. Causes all clusters/ infotainment to shut off and reset. It remain black for a 10-15 seconds

NHTSA ODI 11710459

Electrical control unit car just shuts off in drive completely goes black no matter what within seconds even on freeway going 70 mph car tune off loss of control then starts back up very dangerous

NHTSA ODI 11706681

When pressing the horn on the steering wheel of my 2024 Kia Seltos SX Turbo AWD during an emergency no sound was heard. Horn is silent. Fuse is not blown and it appears likely the horn is defective.

NHTSA ODI 11702358

Driver side seat stays warm all the time I tried removing both seat heater fuses and in plugged the seat warmer plugs but the back seat rest still stay warm

NHTSA ODI 11699697

See attached document for complaint.

NHTSA ODI 11696416

I bought this Kia with 25 miles on it and I had all oil changes done and then at 33,000 miles the engine seized and Kia refused to honor my 100,000 mile warranty. The dealership told me that the spark plugs melted causing the issue and that it definitely wasn’t an oil issue. Kia still refused to honor the warranty. I only owned the car from June 2023 to September 2024 I want them to pay the remaining balance since I had to give it back to the bank for them to only be able to sell it for 8000.00 dollars. I will never deal with Kia ever again but they need to do the right thing by paying the remaining balance for something they refused to take accountability for. I contacted the lemon law attorney office for the state of Michigan and they wanted to help me but couldn’t because Kia refused to give me any vehicle repair invoice or anything documentation on the vehicle while it was in their care. I tried hard to find a lawyer to help me with my case but I couldn’t find one that does these particular cases.

NHTSA ODI 11693492

Rear window shattered due to heat

NHTSA ODI 11690242

My car smells like fire since day 1 of purchase. When driving the smell gets so bad I think the car will go on fire. Not sure if it’s faulty electrical or something else. I have read many reviews and too many people have experienced the same thing. What is going on? Other Kia Seltos models have caught fire. Why hasn’t this been addressed. This is a matter of safety. Why do I smell smoke or fire when driving?

NHTSA ODI 11688806

Issue: Defective Seatbelt Sensor - Refused Warranty Repair Vehicle: 2024 Kia Seltos EX Make/Model/Year: Kia Seltos, 2024 Mileage (approx.): 12,033 I am filing a formal safety complaint regarding a malfunctioning seatbelt sensor on my 2024 Kia Seltos EX. The front passenger seatbelt alarm goes off repeatedly even when there is no one sitting in the seat, and this behavior is unpredictable and distracting while driving. When I contacted the Kia dealership (Summit Place Kia, Auburn Hills, MI), they refused to inspect or repair the issue without charging me $180 upfront, even though my vehicle is fully under warranty and this clearly relates to a safety system. They claimed they would only waive the fee if they determine it’s covered, which gives them the option to deny responsibility arbitrarily. Kia Consumer Affairs was contacted and gave the same answer: pay up front or we won’t look at it. This raises major concerns about Kia’s warranty practices and possible violations of federal law requiring free repairs of safety-related defects under warranty. I am reporting this to request investigation and to hold the manufacturer accountable for failing to honor federally mandated coverage.

NHTSA ODI 11676977

On July 9 while waiting at a red light car randomly turned off, had to put car in park and restart On July 19 while driving about 55mph on an extremely busy interstate highway car shut down completely. I could not restart or shut the car off, car was in drive and we had full power, no issue with battery, no warning signs, we were nearly killed by an 18-wheel truck traveling at normal high speed on this highway. We were eventually pushed off to the side where we sat for 2 hours until family members came. In the car were 2 seniors, 1 battling dementia and another anxiety and a young man who suffers from paranoia schizophrenia. Both trying to recover. In addition, Kia roadside assist wanted to tow us 2 hours past our dealership and home and charge us $661 when we were fully covered. Kia dealership said if they could not repeat the stall they could not really determine what is wrong. This is the 3rd serious issue I have had with this vehicle and each occurrence I was made to feel like the issues did not exist. 1 week into ownership I complained about a knocking noise, was told that the struts came from the factory loose, a month ago the differential gear box needed to be changed. I am now told that it could take a very long time to repair, and I would need to rent a car at my expense and if approved will be reimbursed at some point. I am terrified to drive my new car.

NHTSA ODI 11676008

Our vehicle was in an accident with extensive damage to the entire front end. The accident warning senors did not go off and the air bags did not deploy. The insurance adjuster said the entire engine was pushed back towards the driver area so it's surprising the air bags did not deploy. In our Kia Access app, only the "passenger turn signal" has a critical error detected. The car has been deemed totaled.

NHTSA ODI 11670573

The contact owns a 2024 Kia Seltos. The contact stated while driving 25 MPH and attempting to depress the horn there was no sound coming from the horn. The contact turned off and restarted the vehicle; however, the failure persisted. The contact stated that the failure began in 2023. The vehicle was taken to a dealer to be diagnosed; however, the dealer was unable to determine the cause of the failure. The contact stated that the horn was previously replaced, and the vehicle was repaired three times for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 11,000.

NHTSA ODI 11667141

Rear view camera collects rain drops obstructing the rear view while backing up during rainy weather

NHTSA ODI 11665491

My car, over the last few oil changes has had very little to practically no oil. It also has been having the noise when it is low oil. This is already a recall, and when taken to a local dealer, they claimed the piston rings, which is the issue for the oil consumption, were not a problem and within spec. They have performed a test to check oil levels after 1000 miles and am still waiting on the results for the first test. This problem, as written by the recall, can cause an engine fire, or even grenade the motor causing catastrophic damage, potentially to my life.

NHTSA ODI 11665420

The contact owns a 2024 Kia Seltos. The contact stated while driving 30 MPH and attempting to accelerate, the vehicle briefly lost motive power before the engine seized. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the valves. The vehicle was not repaired. The vehicle was towed back to the residence and later to the local dealer where it was diagnosed and determined that the engine had failed and needed to be replaced. The vehicle was not repaired. The contact stated that several months before the failure, the vehicle was serviced, and the fuel injectors and spark plugs were replaced. The manufacturer was not notified of the failure. The contact stated that the failure was related to NHTSA Campaign Number: 23V531000 (POWER TRAIN); however, the VIN was not included. The failure mileage was unknown.

NHTSA ODI 11664693

The vehicle rolled backwards and hit a predestination with no one in the vehicle on level ground. I don't know why it rolled backwards since it has never done this before unless someone had hacked into the computer system and caused it to go backwards. I also don't know if this car has the lvl of technology that can be hacked as in the completely driverless vehicles. I only know the theory of computer science and smart technology, I don't know if my car has advanced enough technology for someone to remotely hacking into the car causing it to move backwards or not.

NHTSA ODI 11660548

Over the last year that I have had my car, I noticed that things as little as gravel, bugs, and small rocks chip my windshield easily. I worry that I have defective glass considering I have over 10 chips on my windshield.

NHTSA ODI 11651615