What 96 owners told NHTSA about the 2024 Ford Maverick Hev Hev

While driving at highway speed on I-275with cruise control engaged on afternoon of June 11 the truck suddenly began slowing down. I couldn't get it to accelerate. I ultimately had to get over two lanes and still had enough momentum to get off an exit ramp. At the end of the ramp, I noticed I was unable to get the truck to accelerate from a stopped position either. Only then did I notice the dial transmission had moved to N from D. I did not initiate this move while I was on the highway, nor was I aware of it, nor do I believe I bumped the dial. This is the second time this has happened. Previously it occurred some time in late 2025 in a store parking lot. At highway speeds, this is extremely dangerous.

NHTSA ODI 11744383

SENCE PURCHACED the truck has a tie rod rattle, I have spoken to dealership and was informed no issue found. But as of late Vehicle wobbles very harshly when execrating or pulling away from stop signs passing another vehicle. Turns out it's a VERY common CV axle issue that the dealership doesn't have any sort of recall on. Feels very very unsafe to drive and its disappointing to see so many other drivers with the exact same issue with the tie rod ends. Now a recall on some of the mavericks suspension AKA tie rod installed wrong/ defective with a DO NOT DRIVE WARNING?

NHTSA ODI 11742520

My 2024 Ford Maverick (VIN [XXX] ) has had three sudden losses of drive power while driving. Each time the accelerator stopped delivering power with NO warning lights, no error messages, and no dashboard indicators before, during, or after. Each time I pulled over, shut off the vehicle, and restarting fully restored normal function. Incident 1 — Aug 2024, two-lane highway, New Mexico. Clear, ~80°F, light traffic, ~60 mph. Accelerator suddenly lost power, no indicators. Pulled to shoulder; restart restored function. Incident 2 — XXX, ~6:10 PM, XXX northbound on-ramp from [XXX] . While accelerating up the ramp to merge, power cut out — same behavior, no warnings. Pulled over; restart restored function. Incident 3 —XXX, ~8:05 AM, [XXX] . Slowed for a turn; no power when I accelerated out. Same signature. These symptoms are identical to NHTSA Recall 24V-267 (Ford 24S24) — loss of motive power from the BCM/PCM failing to detect 12V battery degradation — and the follow-on battery recall 25V-158 (Ford 25S26). My vehicle is a 2024 Maverick and is NOT included in 24V-267, which Ford limited to 2022-2023 Mavericks built Feb 2021–Oct 2022. I am reporting because my 2024 shows the identical failure mode, including the total absence of warning before power loss, matching the owner reports that prompted Recall Query RQ24014 into the adequacy of the 24V-267 remedy. I request NHTSA consider whether the affected population should include model year 2024 Mavericks. These events are recurring and have occurred at highway speed and while merging, creating a serious crash risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11741536

Over the past 1-1/2 years I have experienced my transmission going into neutral and loss of power 4 times. The first time it happened I thought my hand hit the shifter and moved it into neutral. After a few more incidents and seeing the recall, I realized this was the cause of the issue. I noticed the NHTSA website has recall number 25V881000. Today I contacted Ford Motor Company regarding this recall and they do not show it against my 2024 Ford Maverick Hybrid. I have experienced the problem as indicated below and have not received a recall letter on this. Was my VIN left out of this recall? Dates were between November 2024- February 2026 Incidents occurred between 40-75 mph Mileages between 4000-12000 Very scary losing power on the expressway with lots of traffic Recall date 2025-12-17 Recall no. 25V881000 Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick Hybrid and 2020 Escape Hybrid vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power. Hide details Recall consequence A loss of drive power increases the risk of a crash. Recall action Dealers will update the HPCM software, free of charge. Owner notification letters were mailed February 12, 2026. Owners may contact Ford customer service at [XXX] . Ford's number for this recall is 24S33. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on [XXX] beginning January 15, 2026. This is an expansion of Recalls 24V330 (24S33) and 25V133 (25S16). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11731938

The contact owns a 2024 Ford Maverick. The contact stated that on several occasions, while driving at an undisclosed speed, the vehicle unexpectedly shifted into neutral(N). There was no warning light illuminated. The contact stopped the vehicle and shifted the vehicle back into drive. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,000.

NHTSA ODI 11723033

At approximately 42K miles, front wobble upon acceleration. Front axels replaced under 60k power train warranty

NHTSA ODI 11686147

Significant shaking in the front end during acceleration due to CV axle failure

NHTSA ODI 11680942

While driving on onramp to the interstate the engine shut down and warning came on pull over now. All power was lost. The APP showed power train fuel control module could not connect. I tried to restart but had no power. On 6/16/2025 I took the vehicle in for repair (could not get appointment). It was returned (could not duplicate problem). On my way home it happened again engine lost power while driving. The vehicle was brought back to Ford. This time it was returned 6/25/2025.

NHTSA ODI 11674048

At approximately 10 pm driving on the interstate at approximately 65 mph, I was attempting to accelerate to 70 mph and my speedometer was decreasing in speed even though I had my foot on the accelerator. I had to pull off to the side of the interstate that has a very narrow shoulder. My car was not able to accelerate. I had to turn it off and turn it back on and then it appeared to work as usual. This has happened twice now. I took it into the dealership to have it fixed and they said they updated the control module unit and replaced my battery due to other issues I’ve been having with the car. No warning lights came on, and the car still appeared to be on and in drive when the incident occurred. The component has been inspected and the dealership said they repaired the issue, which was not the case, due to the same thing reoccurring approximately 10 days after the “repair” was made.

NHTSA ODI 11673380

Repeated failures of accessory battery resulting in powertrain failures. One incident disabled the response of the accelerator. Acceleration was only achieved by releasing the brake pedal and the vehicle slowly accelerated up to approx 35 mph. Battery has been replaced/repaired by dealer 4 times already, with a 5th pending shortly. Accessing the battery to jump start the vehicle requires lifting the back seat, including detaching car seat installed in the rear of the vehicle.

NHTSA ODI 11666525

On April 5th, 2025 I was driving about 20-30 mph and braking down a slight hill. When I went to accelerate up the other side of the hill the vehicle would not accelerate while pushing on the throttle. There were no check engine lights or errors while the vehicle would not accelerate. I pulled over to the side of the road and turned the vehicle off. Upon restarting the vehicle it appeared to function normally and continued driving for about an hour home. I have not reported the incident to Ford or the dealer.

NHTSA ODI 11652997

Transmission leak that goes undetectable due to the shield underneath the vehicle, catching any leakage. Failure to detect the leak cause case the vehicle to fail to drive or not operate properly. (Vehicle has been repaired now)

NHTSA ODI 11652882

The vehicle is 9 month old with less than 12,000 miles. Factory battery repeatedly entered "deep sleep" mode, disabling vehicle remote features and failed to start the engine. Battery test showed sulfation and can no longer function as designed.

NHTSA ODI 11652249

occasionally shifts into neutral while doing down the interstate at 60-70 miles an hour. does this after hours of driving.

NHTSA ODI 11646906

Concerning 2024 Ford Maverick hybrid pickup. Vehicle has had a sudden loss of power and loss of acceleration at highway speeds on four different dates between December 2024 and late January 2025. Took to local Ford dealer service [XXX] There were no vehicle health alerts or diagnostic trouble alerts. Service advisor searched manufacturer database found no information related to problem, and to call and bring vehicle in again if it reoccurred. Safety of passenger and self endangered due to sudden power and acceleration losses. On 3/4 incidents I was able to pull over to shoulder and engage emergency flashers. On two of these occasions vehicles close behind mine had to quickly engage their brakes to avoid collisions, and one following vehicle also had to make an emergency move to swerve away from my vehicle and avoid collision. On fourth episode there was a very near miss of collision - six following vehicles had to emergency brake to avoid a multi vehicle collision at highway speed. Problem could not be reproduced by dealer service center. The vehicle was inspected by dealer service tech on [XXX] as noted above. There were no warning lamps, messages or other symptoms of problem prior to the failures that I was aware of. However, since my focus was on quickly and safely reacting to get the vehicle off the road and avoiding collisions there may have been warnings or symptoms I was unaware of. The speedometer needle went down and the accelerator was completely unresponsive when I depressed the gas pedal. I called local dealer service again on [XXX] after reading several reports online of the same or very similar incidents that occurred in earlier model years of Ford Maverick and other models sharing same or similar platform or components. Dealer reset or updated PCM and BCM software. [XXX] … INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11641999

Shortly after starting the vehicle and stopping at a stop light after driving approximately 50 yards, the vehicle jerks, feels like engine/drivetrain is shuddering, and attempts to lurch forward. To stop it I have to apply additonal pressure to the brakes. This has occurred 4 times that I detected after driving on a daily basis since 12/20/24 (when vehicle was purchased) and today 01/01/25. I have not contacted the dealership about this issue yet. There have been no warning lamps, messages or other related symptoms that I have detected.

NHTSA ODI 11633508

CV axle joint near engine failed and leaked grease out of joint. Axle is damaged but still drive able until replacement part comes in on 1/31/25. This is a FWD hybrid.

NHTSA ODI 11633438

When stopped in drive with brakes applied, the vehicle will lurch forward without me releasing the brakes. This is not an intermittent issue - it happens constantly. This is obviously a safety issue and many other owners have reported the same issue on several forums.

NHTSA ODI 11632263

lost acceleration function on freeway, no error code or warning sound. I didn't lose power just wasn't able to accelerate had to pull over and restart engine for the problem to go away.

NHTSA ODI 11631306

Car battery died. When jumped, it then started up. However, upon getting onto the street - only the hybrid battery would engage (not the combustion engine). Thus, my speed was limited to ~10 miles per hour and this made the drive very unsafe.

NHTSA ODI 11629566

Front right cv joint failed after only 30,000 miles

NHTSA ODI 11627383

2024 Ford Maverick bought from Sames Ford Mcallen shut itself off completely mid road and wasn't able to shift to neatrul to move from harms way. Several errors show powertrain error detected a fault with the high voltage system

NHTSA ODI 11596183

Driving on Baltimore's 695 outer loop traveling south at apx 65-75 mph in the left lane, the truck flashed a warning"stop safely now" all vehicle powertrain was disabled and I, while decelerating uncontrolled, pulled across 4 lanes to a median and waited roadside 3+ hours before ford's roadside collected the truck.

NHTSA ODI 11592072

The contact owns a 2024 Ford Maverick. The contact stated that while driving at approximately 45 MPH, the vehicle suddenly decelerated to 20 MPH and the check engine warning light illuminated and the vehicle failed to accelerate as needed. The contact took the vehicle to the dealer and the vehicle was diagnosed with battery failure. The battery was replaced. The contact stated shortly after the battery replacement, the failure reoccurred. The vehicle was returned to the dealer and diagnosed with PCM failure. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 13,000.

NHTSA ODI 11584509

[XXX] , at 75 MPH, the engine quit running. Had to pull over into the left shoulder as the construction on the freeway prevented any other movement. After the truck stopped, I turned off the key and then restarted it. No other problem like this have occurred since (3Months). There were no warning signs or warning lamps. Feel free to inspect. Truck has not been inspected. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11575373