What 89 owners told NHTSA about the 2024 Ford Bronco Sport Later Release

Nothing has happened but I want to file a complaint because it has been almost a year since this recall was issued and nothing has been done. Manufacturer Recall Number25S76 NHTSA Recall Number25V467

NHTSA ODI 11726909

The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11725622

The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11723582

Recall is taking way to long to fix!

NHTSA ODI 11721287

The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11720957

The contact's wife owns a 2024 Ford Bronco Sport. The owner received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the final remedy was not yet available. The contact stated that the owner occasionally noticed a fuel odor coming from the vehicle. The vehicle was taken to the dealer, where the engine control software was updated as an interim repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the final recall repair. The manufacturer was made aware of the issue. The contact's wife had not experienced a failure.

NHTSA ODI 11720101

The battery has failed three times. Took it to a dealer in El Paso, Texas and they told us they put in a new battery which they lied. They did not. They charge the battery. Then we’ve took the car again to a dealer in San Antonio and they told us that there were some type of short in the battery, so they recharged the battery and fixed it, they lied again. Today the car will not start, the car is only a year and a half old and the dealer does not want to replace the battery, they want to recharge it again. This battery keeps leaving us stranded everywhere. It’s happening every two weeks.

NHTSA ODI 11719776

I purchased my vehicle 6 months ago. I had no prior issues outside of a rough drive or a very slight burning smell from time to time. 12/2025 I found out through my auto insurance that my vehicle had a active safety recall (25S76) so I scheduled with my local Ford to get the temp software PCM update done until the remedy becomes available. Immediately after the software update I started getting a lot of system error codes; keys not detected, airbag fault, Tailgate open (when it wasnt), auto hold system fault, auto start/stop system fault, etc.. During this time I had issues with my break system "softening" like the breaks wanted to go out OR the break peddle locking up on me and being unable to move/drive. Delays in acceleration or spurts of acceleration which was uncommanded. This happened in active school zones making it even more unsafe and dangerous to drive. I took it back to my nearest dealership, and they could not replicate the issues but kept my case open and said to inform them if things changed. Things gradually got worse. I have video recording of my car accelerating without my foot on the peddle and my breaking peddle softening to the point of not working properly as well as hardening and locking up. I have photos of the errors when I was able to safely due so. I have full documentation that is not listed here (due to the amount of words allowed). I took my vehicle back and has been with Frontier Ford in Anacortes WA for 5 days. I have contacted Ford as well. I am unable to get a rental due to both Ford and the dealership both telling me to go to each other for help. I have no update as my vehicle is still in testing. They were able to replicate some of the issues but have no update outside of that. I have no way to work or take my children back and forth to their classes. My Ford dealership said this software has caused similar issues with other vehicles but my issue was a more severe case. I am unsure on how to move forward with this.

NHTSA ODI 11711867

The contact owns a 2024 Ford Bronco Sport. The contact stated that while starting the vehicle, there was a ticking sound coming from the engine compartment. There was no warning light illuminated. Additionally, while driving at an undisclosed speed, the contact smelled a fuel odor. The Mobile App indicated that the VIN was associated with NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, parts were not yet available for the recall repair. The vehicle was taken to a dealer, and a software update was performed related to the recall, but the dealer confirmed that parts were still not yet available. The dealer also informed the contact that metal shavings were found in the engine and that the engine needed to be replaced. The contact was also informed that the muffler had failed and needed to be replaced. The engine and muffler were repaired. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and the contact was denied a buyback option for the vehicle. The approximate failure mileage was 23,099.

NHTSA ODI 11709937

• What component or system failed or malfunctioned, and is it available for inspection? The brake system on my 2024 Ford Bronco Sport failed to respond for approximately 2–3 seconds after I pressed the brake pedal. This occurred immediately after freeing my foot from underneath the gas pedal while cruise control was active. The vehicle is available for inspection. • How was your safety or the safety of others put at risk? The vehicle did not slow down when the brake pedal was fully pressed, causing me to enter an intersection while other vehicles were turning. I had to swerve to avoid a collision, but another vehicle entered my path and a crash occurred. The braking delay directly increased the risk of a serious accident. • Has the problem been reproduced or confirmed by a dealer or service center? UNKNOWN. I have not yet had a dealership or service center attempt to reproduce or diagnose the issue. • Has the vehicle or component been inspected by the manufacturer, police, insurance, or others? The accident was documented by police and insurance, but the mechanical issue itself has not yet been inspected for cause. • Were there any warning lamps, messages, or symptoms prior to the failure? When did they appear? There were no warning lights, messages, or prior symptoms before the brake failure. The brakes simply did not respond when pressed. • Description of the incident: While traveling northbound on Sterling Ave approaching Truman Rd, the light turned yellow. I attempted to brake, but my foot was caught under the accelerator due to cruise control being engaged. After freeing my foot, I pressed the brake firmly, but the brakes did not respond for approximately 2–3 seconds. I swerved left to avoid turning traffic and sounded my horn. Another vehicle continued its turn and my front passenger quarter panel struck its rear passenger quarter panel at about 15 mph. The brakes only began functioning after the vehicle jerked from evasive steering input.

NHTSA ODI 11701629

The transmission failed to go in gear. The transmission was replaced and fixed by the dealership.

NHTSA ODI 11700929

At least 6 times now my gas guage has plummeted from 60+ miles to 6 then 2 and none in less than a mile. Thus has left me standed after midnight on the side of the highway and other various places. I had to use the road side help ford offered. It happens often and doinng deliveries this is very scary for me. I never know how much gas i have. I feel like im constantly putting in gas. I looked up the symptoms and found on reddit quite a few people experience the same. This could be very dangerous to me and other drivers constantly getting stranded on side of road or in the middle of the road. This is a new car im Paying alot of money for. And should feel as safe as possible while driving

NHTSA ODI 11700593

extreme loud vibrating noise coming from sunroof while driving at or above 35 mph. it may be bad design for rubber seal and body trim for the sunroof. for example: automatic car washing - hard rolling brushes hitting the top of the vehicle during the wash process, then there is the high pressure water rinsing from different directions, followed by a high wind vortex that causes every exterior surface extreme pressure and force. so, a few trips to the car wash, now causes your sunroof seal failure which may lead to a sunroof blow out while driving at 60mph on the high way... please ALERT ALL to this danger. sunroof seal failure. sunroof blowout. sunroof vibrating.

NHTSA ODI 11696609

Powertrain malfunctions have occurred on 12/17/24, 4/11/25 and 10/5/25. Powertrain malfunction and yes. The car would not accelerate and someone could of ran into me, I could of been killed or badly injured and same for any other occupants in the either vehicle. Yes. Yes. The messages appeared on 12/17/24, 4/11/25 and 10/5/25.

NHTSA ODI 11691829

I don’t know the exact name of the system that failed but my Bronco would not accelerate after making complete stops. When I would press on the gas pedals to move from a stopped position the Bronco would move very very slowly which in turn almost caused me to have over 3 car accidents as when I would press the gas to move from a stopping position it would move forward very slowly no matter who much pressure I would put on the gas pedal which in turn the oncoming cars almost hit me. I took the Bronco to the dealership and they said they had to reprogram the acceleration but that it could take up to 500 miles for the issue to be corrected. I believe from my experience this is dangerous and not safe! And should be addressed. This incident has happened several times not one.

NHTSA ODI 11691255

poor engine performance, including rough idling, misfires, engine stalls, sometimes difficult to start or no-start situation.

NHTSA ODI 11686448

I reached out to ford due to my 2024 bronco sport overheating and running hot. During the time of that complaint I was advised that my bronco currently has a recall that the fuel tank needs to be replaced but it is currently being deemed as non safety and will only be addressed if the vehicle is in for service. I was also advised that due to this recall it is currently a part of fords customer satisfaction program. Anything fuel related should be deemed as a safety recall considering fuel is a flammable chemical. I have requested a buy back as I no longer feel safe operating the vehicle or comfortable transporting my daughter in the vehicle as it aligns too closely with the known fuel safety recall currently present on some 2021-2024 bronco sports.

NHTSA ODI 11686469

Recall 25V467 can result in vehicle fire and manufacturer does not have a remedy. This is a lease and I would like to return the vehicle back because it is a safety hazard.

NHTSA ODI 11685825

I reached out to ford due to my 2024 bronco sport overheating and running hot. During the time of that complaint I was advised that my bronco currently has a recall that the fuel tank needs to be replaced but it is currently being deemed as non safety and will only be addressed if the vehicle is in for service. I was also advised that due to this recall it is currently a part of fords customer satisfaction program. Anything fuel related should be deemed as a safety recall considering fuel is a flammable chemical. I have requested a buy back as I no longer feel safe operating the vehicle or comfortable transporting my daughter in the vehicle as it aligns too closely with the known fuel safety recall currently present on some 2021-2024 bronco sports.

NHTSA ODI 11685185

See attached document for complaint.

NHTSA ODI 11685294

I have contacted ford directly and they still have not gotten a remedy for the unrepaired recall. My spouse and I went on a road trip that was 20 hour trip in total. They told us to keep driving it until it catches on fire because they did not have a remedy for it yet. We had just taken it in for an oil change and had them look the vehicle over due to the rpms keep jumping up even when going at low speed. The vehicle keeps loosing power and shakes when at idle or even when it starts up. We told ford about the smell of fuel or something when we walk by the hood of the vehicle and they said there was nothing wrong with it and that they didnt notice or smell anything when they did the oil change. When we talked to ford about our concern with the vehicle and that were were afraid to drive it especially since we have a baby and that we were told to continue driving it until it catches fire. We have a 9 month old who is in the vehicle daily due to having to go daycare. i am afraid for him being in the vehicle and it catching on fire or anything and not having enough time to get him out of the vehicle. Something needs to be done pronto or a law suit will be brought up

NHTSA ODI 11684418

The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle vibrated, and the contact stated that there was an abnormal white noise coming from the rear of the vehicle. No warning lights were illuminated. The contact stated that on another occasion, while driving 60 MPH, there was smoke coming from under the hood. The contact pulled over to the side of the road and shifted in park(P). The contact opened the hood and noticed that the engine had overheated. No warning lights were illuminated. The contact waited for the engine temperature to lower. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. On another occasion, while driving 65 MPH in the rain, the steering wheel pulled to the right. The contact was able to control the steering wheel and continued to drive at a slower speed. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. Most recently, the contact stated that there was an abnormal static sound coming from the electronics inside the vehicle. The contact stated that the abnormal sound was also heard with the engine turned off. The contact stated that the magnetic vibrations and potential unauthorized electronic interference affected her health. The contact used the PHYPHOX App to get the magnetic and electronic interference readings. The contact stated that while the vehicle was being diagnosed, a rental was provided. The rental was a 2024 Ford Bronco Sport, and the contact experienced the same failure. The manufacturer was made aware of the failure. The failure mileage was approximately 1,000.

NHTSA ODI 11681341

Vehicle is having trouble with moving, when press on gas pedal it does not really want to move. When sitting at idle vehicle shakes really bad. can hear a really bad tick when driving vehicle. noticed that when driving the vehicle has been shaking really bad. Rpms have also been shooting up high when barely going up to speed.

NHTSA ODI 11680958

When coming from a stop at a traffic light vehicle losses power for approximately 15-20 seconds. This puts the driver of the vehicle, passengers, and other vehicle drivers operating on the roadway in danger of a major collision, possible bodily harm or even death. We have twice taken the vehicle to our dealership, where we purchased the vehicle; in order to fix the recall and we have had no success in gaining a remedy for the issues. The vehicle was seen twice by the Chandler, Arizona Earnheart Ford service department. There were no warning signs before the incident and they started appearing soon after the purchase of the vehicle. We have notice that the hotter it is outside the more frequent the loss of power occurs.

NHTSA ODI 11679483

The contact owns a 2024 Ford Bronco Sport. The contact received a Carfax notification that the VIN was included in NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the repair was unavailable. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, but was unable to provide an anticipated date for the parts' availability. The contact had not experienced a failure.

NHTSA ODI 11678477