What 157 owners told NHTSA about the 2024 Chevrolet Trax

The display system on serval occasions has been blinking on and off. I can not touch the entertainment display system and the speedometer display also malfunctions not displaying correct speed and malfunctioning the blinker light, back up camera, etc. I have videos of occurrences which I can not upload. This has happened in multiple occasions. The dates of occupancies are 6/7/26,6/17/26,7/7/26, and 7/8/26. The display even flickers when the car is turned off.

NHTSA ODI 11748975

I have a 2024 Chevy Trax Activ that was originally purchased in British Columbia, CA and subsequently purchased through a private dealer in New Mexico. It has just gone over the 36,000 mile warranty. The infotainment system including the speedometer will occasionally flicker and go black. Additionally the metric to US conversion of mileage will revert back to metric once the vehicle is shut off and restarted. This happens intermittently. There are also USB and Bluetooth connection issues. The vehicle does not show up under any bulletins or recalls as the origin was initially purchased in Canada. This problem has been reported to GM and Chevy customer service. How do I add this to the recall and NHTSA bulletin so I can get this repaired?

NHTSA ODI 11747222

Carplay turning off during heavy travel (getting lost), going 5 minutes down the road, anytime. but phone is still connected so gps will not work properly. Screen Glitches. Heavy/thick random speaker bass noise while on phone calls and even no music. Phone trying to connect to previous forgotten phones while driving.

NHTSA ODI 11746438

The contact owns a 2024 Chevrolet Trax. The contact stated that while at a complete stop at the stop light, the instrument panel and the infotainment screen went blank momentarily. The vehicle was taken to the dealer, where the codes were reset. The contact stated that while driving approximately 35-40 MPH on two occasions, the instrument panel and the infotainment screen turned blank, and the vehicle failed to accelerate as intended. The contact stated that the failure lasted for few seconds. The contact related the failure to NHTSA Campaign Number: 23V744000 (ELECTRICAL SYSTEM). The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and advised the dealer of the issue. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 20,000.

NHTSA ODI 11745572

On XXX, [XXX] was applying her brakes to prepare to turn left into the fire station. Her vehicle suddenly steered to the left causing her vehicle to enter oncoming traffic. This action caused the Chevrolet Trax to collide head on with a passing vehicle. The collision resulted in 2 totaled vehicles and multiple injuries in both vehicles. It has since been brought to our attention that there is a potential class action lawsuit for similar incidents. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11742910

our vehicle is doing the same identical thing as other 2024 Trax that are under a recall. The dealer is wanting to charge a diagnostic fee to even look at it. This is crazy when other 2024 Trax are under the recall and get it fixed for free. INSTRUMENT PANEL BLACKOUT RECALL The issue is the Virtual Cockpit Unit intermittently goes black.

NHTSA ODI 11742941

The contact owns a 2024 Chevrolet Trax. The contact stated that while driving at 70 MPH with cruise control engaged. The low-pressure oil light illuminated. The driver was able to pull over. The vehicle was taken to the local dealer, who determined that it was 4 quarts low and replenished it. An oil compensation test was performed. The dealer found no issue. While driving, there was an abnormal banging sound. The "Pull over and turn off the engine" message was displayed. The driver noticed that there was smoke emerging from the engine. There was oil leaking from the vehicle. The vehicle was towed to the local dealer, where it was diagnosed as having a blown engine. A hole was located in the block due to low oil. The vehicle was not repaired due to the parts being backordered. The manufacturer was not contacted. The approximate failure mileage was 41,000.

NHTSA ODI 11737511

Traveling up I-XXX in [XXX] with my [XXX] daughter, heard a loud bang, pulled over to the side of the road and vehicle caught on fire. Connecting rod broke and blew out the side of the engine block. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11735690

I am submitting this complaint to report serious, recurring, and potentially dangerous safety defects involving my 2024 Chevrolet Trax. Timeline of Safety-Related Mechanical Failures: March 12, 2026 – First Highway Safety Incident While driving to work on [XXX] [XXX] ight activated, and the vehicle began to hesitate during highway operation. This occurred during my daily commute at highway speeds, creating an unsafe driving condition and serious concern for vehicle reliability and safety. [XXX] is extremely [XXX] ring this incident, I was afraid for my life due to the vehicle’s behavior in heavy traffic. I depend on this highway daily for work, and my family depends on my safe return home. My wife, daughter, son, and parents deserve peace of mind knowing I operate a safe vehicle. March 15, 2026 – Diagnostic Codes- P0521 – Engine Oil Pressure Sensor/Switch Range or Performance- P06DE – Engine Oil Pressure Control Circuit Stuck On Concerns include oil pressure, lubrication issues, and potential engine damage. April 27, 2026 – Second Highway Incident While driving on Route 78 after work, the vehicle experienced another failure:- Severe shaking- Check engine light- Unsafe operation Code:- P0300 – Random/Multiple Cylinder Misfire Detected GM Case Numbers:- XXX- XXX Manufacturer and Dealership Awareness: General Motors and the dealership are fully aware of these repeated issues. Vehicle is currently at: [XXX] Ongoing Safety Concerns:- Engine misfires- Highway hesitation- Severe shaking- Oil pressure faults - Possible engine failure- Risk of power loss while driving I am still making monthly payments on this vehicle despite these ongoing failures. Personal Impact: I depend on this vehicle for work and family safety. These repeated failures have caused fear, financial burden, and stress. I was also forced to rent a vehicle due to delays in loaner availability. VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO [XXX] S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11735005

To Whom It May Concern, I am submitting this formal complaint regarding a malfunction in the air conditioning system of my 2024 Chevrolet Trax. Specifically, the evaporator and/or condenser has failed, resulting in inadequate cooling performance and potential system leakage. This issue is more than a matter of comfort—it presents a significant safety concern. Operating the vehicle in high temperatures, particularly in Texas, creates hazardous conditions inside the cabin. Excessive heat can lead to driver fatigue, dehydration, and reduced concentration. Additionally, the malfunctioning A/C system affects humidity control, which may cause windshield fogging and reduced visibility while driving. The problem has been consistently reproducible during normal vehicle operation. Symptoms include poor cooling performance, inconsistent air temperature, and possible unusual odors or sounds when the A/C system is in use. Notably, no warning lights or dashboard messages appeared prior to the failure, making it difficult to detect the issue early. At this time, the vehicle is available for inspection and can be evaluated by a dealership, certified technician, or manufacturer representative upon request. I request a thorough inspection to confirm the failure and determine whether this is due to a manufacturing or design defect. If necessary, I am also willing to have the vehicle reviewed by independent service professionals or relevant authorities. Given that this issue has occurred in a nearly new vehicle, it raises concerns about reliability, quality control, and potential widespread defects affecting other vehicles of the same model. I urge prompt investigation and corrective action to ensure driver safety and product integrity. Please advise on the next steps for inspection, repair, and resolution of this matter. I appreciate your prompt attention to this serious issue. Sincerely, [XXX] [XXX] [XXX] 35300 Began@ 35,000 and progressed INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11733714

On 4 seperate occasions, my vehicle has completely shut off in the middle of the road. 3 times this has happened while traveling on the interstate. Every time with my 6 year old son in the car. The steering wheel locks up when it happens and you have to use all of your strength to get out of the road as soon as possible to avoid being smashed by oncoming traffic. On 8 seperate occasions, my vehicle randomly loses the majority of it's power, and takes over 6,000 rpms just to continue at 50mph. The issue fixes itself by the time I try to take it to the dealership and they tell me there is nothing they can do about any of these issues because it "isn't doing it now" - refusing to even look at it. If I don't take no for an answer, they said just a diagnostic will take 48 hours and they do not offer any sort of loaner vehicle. Both of these events happen without warning, at completely random times. Chevrolet service members each give me different advice and non of it is helpful. My car is a death trap. I bought it brand new with 5 miles on it. I had to order it and wait for it to be shipped to me. This has happened throughout the entire life of the vehicle.

NHTSA ODI 11731862

The instrument cluster is blacking out again. There was a recall for this issue previously. While driving the instrument cluster along with the radio will go out for a period of time. It happening frequently

NHTSA ODI 11731361

The contact owns a 2024 Chevrolet Trax. The contact stated that the vehicle was taken to the dealer after the check engine warning light illuminated. The dealer diagnosed the vehicle with an EVAP purge valve failure. The contact was informed that the EVAP purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000. The VIN was not available.

NHTSA ODI 11731429

On December 28, 2025, while driving normally with my children, my 2024 Chevrolet Trax displayed multiple warnings including Engine Power Reduced, Service ESC, Service Stability, and Steering Assist Reduced. The engine began sputtering and knocking. The next morning the vehicle would not start and was towed to Malcolm Cunningham Chevrolet. The dealership found the engine free-wheeling with no compression and denied my warranty claim alleging spark plug tampering. I never touched the engine. It went directly from my driveway to the dealership via tow. An active recall — A242435780, Engine Spark Timing Following Auto Stop Event — was noted on the repair order upon arrival but was not completed until February 17, 2026, seven weeks after the engine failed. GM’s own recall states engine knock and engine damage are the known risks of this unrepaired fault. The dealership told me verbally it was just a console update, directly contradicting GM’s published description. A second dealership performed a compression test showing Cylinder 1 at 10 PSI, Cylinder 2 at 90 PSI, and Cylinder 3 at 0 PSI. Normal compression is 150 to 200 PSI. No diagnostic codes were retrievable. This dealership initially found something different but reversed their position after speaking with the first dealership and receiving direction from GM. GM denied my warranty claim and offered only a 2,000 incentive toward a new vehicle. The vehicle remains completely unrepaired. I continue making monthly payments on a car I cannot drive. This aligns with class action Cook v. General Motors LLC, Case 1:26-cv-00229-RGA, filed March 4, 2026.

NHTSA ODI 11731014

I was driving home I got a message on my dash about engine pressure and then heard a loud boom, pulled off on the shoulder called a tow and the guy used to be a mechanic, he stated there was a hole in my engine and that it looked like a rod broke off and shot through the engine, I did take it to a dealership to get a diagnostic and they called and said something happened internally not sure what at this point and time.

NHTSA ODI 11730871

My engine failed with no warning on my 2024 Chevy Trax , at night in the express lanes of a very busy expressway in Chicago. I was able to get on an off ramp, but the car then stalled again and I was almost hit by other vehicles trying to exit the ramp. I did call 911 and was told to stay in my car because I would have a "better chance of survival". I had just had the car at the dealership for an oil change and check-up a few weeks before. The dealer explanation was the engine is defective and they replaced the engine, but I have no confidence in this car. I told the dealer and they did not seem to care. I have had nothing but problems with this car, it is a danger to myself and others driving this car.

NHTSA ODI 11730200

17k miles, head a loud pop sound, engine light came and all the oil and coolant was on the ground, engine was smoking. Had the vehicle towed and was told by the service department the connecting Rod failed which caused the catastrophic engine failure. According to the service department and GM there is not Estimated time of arrival for an engine replacement and it’s already been a month.

NHTSA ODI 11728313

The contact owns a 2024 Chevrolet Trax. The contact stated that the vehicle was taken to an independent mechanic for the windshield wiper blades to be replaced. The contact stated that the mechanic was unable to find aftermarket wiper blades to fit the wiper blade arms due to the design of the wiper blade arm attachment point. The design made it impossible to use an aftermarket wiper parts. The local dealer and the manufacturer were contacted and the contact was informed that the wiper blades were on a national back order. The vehicle was not repaired. The failure mileage was approximately 12,000.

NHTSA ODI 11728053

Digital Dash went Black when I started my vehicle, remained black even when I turned off the vehicle and restarted.

NHTSA ODI 11727192

My 2024 Chevy Trax’s engine (1.2L turbocharged I3 engine) went out while driving on the expressway (about 70mph) in the middle to left lane. I had to come to a complete stop and safely and immediately get my car on the left shoulder without injuring myself or others around me. My own safety was severely at risk as I was as close to the dividing wall on the left side as I possibly could be but cars are racing through right next to me. Another safety risk to be added is I was dropped off in the most sketchiest plaza and stranded from 12/1am-3am. I was left to lock myself in my non operating vehicle in a country I do not reside in. Issue was confirmed the following day or two at a dealership I got the car towed to, they found a hole in my engine block due to a rod. And all documents can be provided. Police and blocker trucks were unable to arrive to the scene for 40+ min and the car was fully investigated by GM. There were no engine lights or warnings on the Chevrolet app or car dash. The only thing I can mention is on my last documented oil change, the oil was low due to high consumption, no leaks were located. Dealership also found the fuse box blown, I assume hot oil gushed all over my wire harnesses or the oil switch flipped the sensor which caused further issues, or simply a power surge. Current cause is unknown.

NHTSA ODI 11727205

On March 22, 2026, I was driving at approximately 45 mph, and my daughter was in the passenger seat, trying to connect her music to the car radio and the instrument panel (dashboard) screens went completely blank. For several seconds, I had not readings from the dashboard lighting. It went completely black. It then reset itself, much like a computer when you restart it. Within a short time (less than a minute) the instrument panel began working again. This was the third time this has happened to this vehicle. The first time was in July 2024 and the second time in November 2025. Both of those incidents were reported to NHTSA. There had been a software recall for NHTSA 23V744000 for this very problem in 2024 Chevrolet Trax, but my VIN was not included in the safety recall for increased risk of crash. I brought the Trax to the dealership after the third incident. They did a software update on 25-NA-071. I hope this remedies the problem.

NHTSA ODI 11727118

I was driving on the highway going around a ramp when I went to press on the brakes to slow down the pedal just went to the floor and the car would not slow down, causing me to go off the road. My insurance company did an inspection and said the accident was caused by engine failure and won’t cover damage. GM did inspection said it wasn’t their fault but won’t release their inspection report

NHTSA ODI 11725606

I was driving down the highway going with the flow of traffic and my car caught fire. I was told by the mechanic that “the turbo line combusted and put a hole in the engine” I’ve also been told “oil got on the turbo belt and caught fire” I’ve also been told “the software recall actually had nothing to do with the software and it was an issue with turbos and something was mechanically wrong with this car. I was in the car with my 9 month old daughter. In the middle lane in the highway. The car instantly stopped accelerating leaving us going very slow compared to others. We could’ve been killed! I had to figure out how to get over and then get my daughter out of the car safely and wait on the side of the highway with a baby for fire and police to come put the fire out. When I was driving it sounded like pressure popped under the car and then I could almost hear pieces flying out. And then the dash lights came on telling me to turn the engine off. It was extremely unsafe and now I’m afraid to even drive with my baby in any car.

NHTSA ODI 11725012

My wife was driving her car in Maine on a narrow mountain road, it had been snowing and the roads had been plowed and treated but they were slushy and wet this is also a two lane road. She was driving and all of a sudden the warning lights came on and there was an immediate loss of power, she said that a logging truck was behind her and luckily he was paying attention or else he would have ran her over she could not accelerate and she could only go about 15 mph.There are no shoulders to pull off the road so she put on her flashers and drove it barely to a little gas station to pull off the road to call me. We had it towed to the closet Chevy dealership who had it for 39 days replacing the motor that had blown up, the dealership said that the #1 piston or rod broke and destroyed the engine. The car had only 28k miles on it and there were no motors to be found, they did after 39 days replace the motor and turbo in the car. Mine and her concern is with this immediate loss of power on these types of roads she could've been in an accident or even worse, there has to be answers as to why this happened and what is the long term solution to r his issue. We have seen on the GM forums of this happening to other Chevy Traxs vehicles. I do have the repair paperwork from the dealership.

NHTSA ODI 11724380

Automatic headlight sensor flashes lights on and off even during sunny days

NHTSA ODI 11724015