What 36 owners told NHTSA about the 2024 Chevrolet Suburban

The contact owns a 2024 Chevrolet Suburban. The contact stated that while driving at approximately 30 MPH, the steering wheel locked at an angle, and the message "Power Steering Not Active" was displayed, causing the vehicle to strike a curb. The steering column, control arm, radiator, fender, and wheel were significantly damaged due to the incident. The vehicle was then towed to a dealer, where it was diagnosed that the power steering module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and an investigation was completed. The failure mileage was 58,277.

NHTSA ODI 11742905

On May 2, 2026, while the vehicle was in operation, the engine suddenly shut off without warning. At the time of failure, the instrument panel remained illuminated; however, the vehicle would not restart. In an effort to resolve the issue, the battery was replaced, but this did not correct the problem. The vehicle was then towed to a local Chevrolet dealership for further inspection and diagnosis. Following their assessment, I was informed by the dealership’s service department that the engine had seized and that metal debris was present in the engine oil, indicating significant internal engine failure. I was further advised that a replacement engine has been ordered. At no point prior to this incident were there any warning indicators, abnormal noises, or performance issues that would have suggested an impending engine failure. The sudden nature of this incident raises concerns regarding the cause of failure and whether it may be related to a defect or internal mechanical issue.

NHTSA ODI 11737261

1. Sunroof 2. Driving on 81 N slightly past the Middlesex exit at highway speeds. My 4 minor children and I heard what sounded like a large balloon popping inside my car. Upon further inspection, my sunroof spontaneously exploded. Absolutely nothing hit our car. The more research I’m doing, this is a known issue with GM manufactures and they have done nothing to correct this issue. 3. I’m working on getting a repair scheduled, once we figure out if it’s under warranty or we have to pay for it through insurance. 4. No warnings

NHTSA ODI 11736953

Windshield wipers stopped working

NHTSA ODI 11736233

The vehicle would jerk when changing gears and would have a rattle and vibration when accelerating.

NHTSA ODI 11735937

The glass of the front movable sun roof shattered. The glass shattered while driving on hwy 89 in Wyoming with no traffic or no identifiable reason for the event. While some glass was saved most of it blew out when is shattered. The problem has not been reproduced or confirmed by the dealer. The dealer blames a flying rock or other object impacting the glass even though no vehicles or source of incident impact was perceived. No one was interested in taking a report. There was a build up of pressure inside the vehicle prior to the blow out of the glass which caused the drivers ear's to pop when the sun roof blew. The remaining glass was visibly pushed upwards away from the vehicle. A picture is available.

NHTSA ODI 11735323

The contact owns a 2024 Chevrolet Suburban. The contact stated that while towing a trailer, the message "Trailer Brakes Disconnected" was displayed. Due to the failure, the trailer brakes locked up and the trailer came to an abrupt and rough stop. Upon investigation, the contact discovered Technical Service Bulletin: 23-NA-149; which was related to the solar panel battery charger or generator on the trailer. The trailer battery was fully charged and had a higher charge than the battery needed and could back feed into the trailer brake power module and cause it to shut down. The dealer was notified of the failure, and the contact was informed that the vehicle was not under recall. The manufacturer was also notified of the failure, and the contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 5,000.

NHTSA ODI 11728081

Upon stepping on brakes, the car shifts into Neutral and says “press start Button again.” This happened to me 2x now.

NHTSA ODI 11723167

Complete and sudden failure of the L87 V8 engine at 70 mph on the highway. Had to maneuver to the right shoulder and coast to a stop. Engine was seized and would not restart. Waited 4 hours on a dangerous highway for a tow truck which took the Chevy Suburban 200 miles to my home Chevrolet dealership. They have ordered a new engine but it is on backorder so no ETA. Vehicle was built 06-26-2024 and has not been recalled so Chevy says I do not get the extended warranty on the replacement engine.

NHTSA ODI 11721740

The contact owns a 2024 Chevrolet Suburban. The contact stated that while driving at various speeds, there was an abnormal sound coming from the rear of the vehicle. The sound became significantly louder while driving. The contact stated that while driving at highway speeds and depressing the brake pedal, the vehicle felt like the rear wheels would lock up. The contact stated that the rear wheels locked while reversing, causing the vehicle to jerk abnormally. The vehicle was taken to the dealer, where it was diagnosed with rear axle failure. The dealer determined that the rear axle needed to be replaced. The private warranty company declined to cover the repair unless the rear axle had completely failed. The manufacturer was notified of the failure and declined to cover the repair because the vehicle was no longer under warranty. The contact had previously reported the failure to the dealer, who could not duplicate the failure while the vehicle was still covered under warranty. Additionally, the contact stated that upon engaging the air recirculation, the contact smelled fumes. The vehicle was not repaired. The failure mileage was approximately 23,000.

NHTSA ODI 11715289

The contact owns a 2024 Chevrolet Suburban. While driving at an undisclosed speed, the vehicle hesitated while accelerating. The vehicle was previously repaired under NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the failure persisted. The local dealer was contacted; however, the vehicle was not repaired. The manufacture was not notified of the failure. The failure mileage was 27,300.

NHTSA ODI 11714279

The vehicle went into limp mode! Everything associated with it happened so quickly,no brakes,no steering ,it was terrifying. We got safely to a gas station. We were advised to take it to a certified Chevrolet dealer which we did We had it towed to the certified Chevrolet dealer in Charlevoix, Michigan.They hooked it up to the diagnostics and said they found absolutely nothing wrong with the vehicle.Very Frustrating! After experiencing this terrible incident will never feel safe in this vehicle!

NHTSA ODI 11713441

Sudden power loss on highway. Engine would not respond. We were fortunate to have been able to pull over to the side of the road but in an unsafe merging area. Vehicle restarted after multiple attempts, but engine would not exceed 3000 rpm causing unsafe speed on highway. Engine died again causing total power loss. I was able to coast down the hill to safely park out of the way of traffic. Tow truck was needed. Vehicle was towed to dealer where it was purchased. After inspection, the engine was confirmed to have failed. The dealer advised for engine replacement as part of the L87 recall. This engine was previously inspected less than 10,000 miles prior as part of the same recall, and the higher-weight oil had been used since per the manufacturer's recommendation. However the inspected engine appears to have failed regardless. This sudden loss of power happened about two weeks prior, with the driver able to pull to safety and restart. It was dismissed as a fluke since it did not occur for the next two weeks.

NHTSA ODI 11712278

Both front CV axles have had to be replaced multiple times. Less than 70,000 miles on the vehicle.

NHTSA ODI 11706012

I took my 2024 Chevrolet Suburban to get repairs associated with GM safety recall N252494000 - L87 Engine Loss of Propulsion. My vehicle "passed" the test, so the "correction" employed by GM is that "vehicles that pass inspection will be provided a higher viscosity oil, which will also require a new oil fill cap, an oil filer replacement, and an owner's manual insert." All of this was done free of charge. However, the owner's manual insert states that "For future engine oil changes, use SAE OW 40" oil. This updated owner's manual insert, which is provided as a solution to GM's recall of a faulty connecting road and/or crankshaft, causes the future costs of oil changes to increase from $160.00 to $230.00. Assuming quarterly oil changes, this will increase the cost of operating this vehicle to increase by $2,800 over an estimated 10 year lifespan. This increase should be covered by GM. GM sent me a letter that states, "If your dealer fails or is unable to remedy this defect without charge, or within a reasonable amount of time, you may submit a written complaint to the Administrator, NHTSA." By passing on the cost of the increase in oil change for all future oil changes, GM failed to remedy this defect without charge. I submit this claim because GM filed to remedy this defect without charge. Please see highlighted portions of attached documents in support.

NHTSA ODI 11695541

The contact owns a 2024 Chevrolet Suburban. The contact stated that while depressing the accelerator pedal, there was a loud rattling sound coming from the engine. The contact stated that while depressing the brake pedal, the vehicle failed to respond as intended while driving with her grandchildren inside the vehicle. The brake failure warning light was illuminated. The contact stated that the vehicle lost power and coasted and slowed down, and the contact shifted into park(P). The contact stated that the failure had occurred on two separate occasions. A dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 16,600.

NHTSA ODI 11695445

i pulled on to the road and i heard a loud knocking and my vehicle started skipping and wouldn't go. the lights on the dash lit up and said, "brake failure" and "emergency brake failure" and i had no brakes. I managed to coast into a parking lot. The engine light was on. I turned the vehicle off and waited about 5 minutes and turned it back on, The engine light remained. The first time this happened I was going down the road and the vehicle started sputtering, the emergency brake light came on the dash and the car shut off. It has a rough idle when you start it. I am terrified of this car. I have grandbabies in the car with me, Had i been on the highway either time i would have caused a terrible accident. The dealer says they can't get the car to do it so they can't fix anything. It has happened twice so you know it will again.

NHTSA ODI 11695456

The contact owns a 2024 Chevrolet Suburban. The contact was notified of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact requested a work order on the vehicle for the recall repair and the dealer refused. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was also made aware of the issue and refused to create a work order for the recall repair. The contact was provided a case number. The vehicle was not repaired. The contact had not experienced a failure.

NHTSA ODI 11688996

The contact's son owns a 2024 Chevrolet Suburban. The contact stated that his son had received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The contact's son had been calling the local dealer and was informed that parts were not yet available for the recall repair. The contact was informed by his son stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the issue. The contact had not experienced a failure.

NHTSA ODI 11685223

The vehicle only has ~39,000 miles on it and the transmission went out and the car is not drivable. The dealership said it is a faulty valve body and that the part is on national back order and could take 2 to 6 months or even longer to get the part before they can start work.

NHTSA ODI 11683979

The engine light comes on and then the rpm's drop to 35 and a notification comes up that says "reduced acceleration. driving with caution". If I stop and turn of the vehicle and restart the rpm's will be better but the truck still seems to have a difficult time increasing in rpm's and accelerating gears. It's incredibly dangerous as if I'm driving at a substantial speed on the highway or freeway and it drops rmp's rapidly I'm likely to be in an accident which could be detrimental. The dealer has had my vehicle on two separate occassions. The most recent time they've had it for 5 days and still do not know what's wrong with it. The engine light will not turn off.

NHTSA ODI 11681402

See attached document for complaint.

NHTSA ODI 11672405

The contact owns a 2024 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11668753

The contact owns a 2024 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed and depressing the accelerator pedal, the vehicle intermittently failed to accelerate as intended before slamming into gear. The local dealer was contacted. No further information was available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 4,000. VIN tool confirms parts not available.

NHTSA ODI 11666614

Since purchasing the vehicle on September 27, 2024, I have experienced a series of troubling issues that raise serious concerns about its design, manufacturing, and overall safety, including: Airbag system malfunction: My airbags were nonfunctional for over a month. Tire-related issues: Required full replacement of the initial set of tires. Persistent alignment problems Bluetooth audio problems: Poor quality and connectivity with multiple phones, resolved only after a service visit in May 2025. Defective seat frame: Rear passenger-side bucket seat required full replacement. Defective paint: Blisters and bubbles in the rear quarter panel paint. Fuel module failure: Most concerning, the vehicle abruptly stopped on the road last week and required towing. I was later told the cause was a fuel module failure. Each of these issues is concerning on its own. Taken together, they represent a troubling pattern of unreliability and potential risk to my safety and that of others on the road. They’ve also resulted in a significant loss of my time. This vehicle has spent over a month at the dealership for service—astounding for a truck that’s only eight months old. These are the kinds of delays and disruptions I specifically try to avoid by purchasing and maintaining new Chevrolet vehicles.

NHTSA ODI 11666254