What 65 owners told NHTSA about the 2023 Ram Promaster (passenger Double Seat)

The contact owns a 2023 Ram ProMaster 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA ODI 11729902

On December 23, 2025, a 2023 RAM ProMaster 2500 Van used as a commercial fleet delivery vehicle in [XXX] suffered an engine compartment fire. The vehicle was declared a total loss by the insurance carrier. At the time of the fire, the vehicle was subject to open Safety Recall 25V-720 / Manufacturer Recall 67C, issued by FCA US LLC for a defective cooling fan module with premature bearing wear and inadequate fuse protection on the 400W fan circuit — the exact defect identified as a known fire risk. No remedy was available at the time of the incident. The interim recall notification letter had been received but the vehicle could not be repaired as FCA had not yet developed or made available a fix. The vehicle was inspected by insurance representatives and declared a total loss. No warning lamps or prior symptoms were observed before the fire occurred, consistent with NHTSA's own warning that affected vehicles may fail suddenly with no prior dashboard alert. The component believed to have failed is the cooling fan module. It is unknown whether the component remains available for inspection as the vehicle has been transferred to the insurance carrier as part of the total loss settlement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11728539

The contact owns a 2023 Ram Promaster 2500. The contact stated that while driving at an undisclosed speed, the steering wheel was shaking abnormally. The Forward Collision Avoidance warning light was illuminated. Additionally, the contact stated that the failure had occurred while driving over a speed bump or while turning the steering wheel. The vehicle was taken to an independent mechanic, where it was diagnosed with EPS control module connector failure. The contact was informed that the EPS control module connector needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but provided no assistance. The contact stated that the failure was a known failure with the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,000.

NHTSA ODI 11727266

The electronic power steering system randomly cuts out. While turning on the on ramp, speeding up to get up to highway speeds the power steering randomly cuts out when hitting small bumps. This caused the van to almost drive into the wall going 40+ mph. I had to use 2 hands an a lot of force to correct the steering. This is especially scary because I regularly drive on snowy roads on i70 in the winter. On a slick surface this would cause me to loose control of the van with no way to correct it. The problem has not been confirmed by a dealer. The vehicle has not been inspected by the manufacturer/police/insurance. There were no warning signs.

NHTSA ODI 11725819

EcoFlow unit wires crimped, may be inadequate on size of wire from alternator to EcoFlow unit . Leading to overheating and potential fire danger .

NHTSA ODI 11725329

On 3/13/26 we were driving to a location to make a delivery when the steering locked up causing loss of control, the driver was able to correct the van and was able to limp it back to our location, we contacted our dealer Bob Johnson Chrysler in Avon NY where we just dropped it off today 3/17/26 , He stated that he hadn't heard of any issues with that vehicle, but I looked up the cause and saw that there has been a ongoing problem, luckily our driver was going slow enough to be able to gain control before he crashed. this van was purchased new from this dealer in November of 2022 and only has 13500 miles on it. The dealer hasn't looked at it yet but said its out of warranty and probably wont be covered

NHTSA ODI 11724943

The contact owns a 2023 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11724146

Steering wheel hard to turn. Not able to react quickly. Confirmed by independent service center that the rack and pinion is faulty. Not inspected by anyone else, and no warning lamps illuminated. Independent repair shop is going to replace rack and pinion.

NHTSA ODI 11723885

12v DC outlet caught fire

NHTSA ODI 11722552

Emergency call system has never worked. Dealership and Chrysler have done nothing to resolve the issue

NHTSA ODI 11722555

Moisture in the air has corroded the wiring harness and connections to the Rack and Pinion causing the power steering to freak out and jerk the sheen all over the place and then cut out while driving.

NHTSA ODI 11722004

The contact owns a 2023 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 25V720000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11720745

The contact owns a 2023 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling). The contact was concerned about a potential fire. The local dealer was not notified. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that parts were not yet available for the recall repair. The contact had not experienced a failure.

NHTSA ODI 11719456

Nothing has occurred, yet. I was told by Dodge representative, Riazen on 12/6/2025 “DO NOT DRIVE” as a result of the safety recall. As it is reported that 300,000 vehicle are affected by this recall I am terrified of driving my RV! I have initiated a vehicle buyback letter with John Elkann, and complaints with the CT Attorney General, CT Consumer Protection, CT Lemon Law, and BBB.

NHTSA ODI 11717826

The contact owns a 2023 Ram ProMaster 3500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11710874

Without any warning my steering wheel locked up and started jerking resulting in lack of steering and drivability. I was backing out of my driveway and started to turn onto the street when this happened. This could have been very dangerous if I had been driving on regular roads. The van is currently parked on the street and available for inspection as I was able to gently maneuver it to a safe spot. This has been looked at by a mobile mechanic who put an OBD2 scanner on it and couldn't bring up any codes. It has not been taken to a shop at this point. The dealer said over the phone that this is not a powertrain warranty because it is not engine or transmission. It has not been inspected by the manufacturer, police, insurance. There were warning lights on the panel when this happened but they didn't stay on. Checking the internet for answers I discovered that a power connection to the rack for power steering was getting corroded from not being sealed properly and water was entering the connection. Today I removed the black battery cable and checked on the connector to the rack myself and discovered the same issue many people are having. below is a photo from today January 9, 2026. The connector looks corroded and burnt. Why is this not a recall? This is not safe.

NHTSA ODI 11709820

Unsafe to operate Commercial use Financial harm Manufacturer unresponsive Safety issue Recall with no remedy Loss of use

NHTSA ODI 11707984

The contact owns a 2023 Ram ProMaster 3500. The contact stated that while the vehicle was idling, there was an abnormal sound coming from the engine compartment. The contact checked under the hood and saw that the cooling fan was making a whirring" sound. The contact stated there was no warning light illuminated. The contact stated that the fan was revolving very slowly, and when the fan was touched, there was resistance while revolving. The contact had received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling). The contact called a local dealer and the manufacturer and was advised that the parts for the recall repair were not available. The contact added that the dealer and the manufacturer advised not to drive the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 5,275.

NHTSA ODI 11705657

Power steering failure and tech said it was corrosion of wire harness and not considered a mechanical failure. Water had entered the power steering rack and harness. Pump and rack need to be replaced as well. Driving on highway and power steering gave out without warning. Had to pull to the side of the road. Safety at risk.

NHTSA ODI 11704215

The contact owns a 2023 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11704013

The emergency call / SOS system in my van has never worked. I have taken it in multiple times over the last 3 years to have this repaired to no avail. This is an advertised safety feature of the vehicle and has never worked properly and the dealership has avoided permanently fixing the problem for over 2 years now. I believe the problem is caused by an electrical shortage from bad factory seams on the roof leaking into the Emergency call unit.

NHTSA ODI 11702713

The contact owns a 2023 Ram Promaster 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted and informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet available. The contact had not experienced a failure.

NHTSA ODI 11696773

The contact owned a 2023 Ram Promaster 2500. The contact stated that the employee had reported that the front end of the vehicle had caught on fire immediately after parking the vehicle. The vehicle was unoccupied at the time of the incident. The fire was extinguished by the fire department, which reported that the fire originated from the front end of the vehicle. There was no injury sustained. The contact stated that the front end of the vehicle had completely burned. The contact stated that the fire seemed to have originated near the engine compartment. The vehicle was towed to the residence and was totaled. No police report was filed. The dealer and the manufacturer were notified of the failure. The manufacturer informed the contact that they were not liable for the failure. The failure mileage was approximately 30,000.

NHTSA ODI 11696578

The contact owns a 2023 Ram Promaster 3500. The contact stated that while the vehicle was parked, while attempting to start the vehicle, the power steering and several other unknown warning lights illuminated. In addition, the contact stated that the steering wheel failed to turn in the intended direction. The contact stated that the day prior, the contact was aware of some unusual steering issues; however, the power steering feature was operational. The vehicle was taken to the dealer, where it was diagnosed with water intrusion in the wiring harness. The contact was informed that the two wiring harnesses needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

NHTSA ODI 11696367

Intermitent loss of electronic power steering. Dealer Service Tech says it is water intrusion into the steering rack. Part needs replacement. Dash warning at time of failure only once. I have heard from other owners this is a common problem.

NHTSA ODI 11693680