What 40 owners told NHTSA about the 2023 Mitsubishi Outlander Mhev

The contact owns a 2023 Mitsubishi Outlander. The contact stated that while driving at an undisclosed speed, the rear of the vehicle would move independently. The contact stated that it felt as if the vehicle were going to slide and eventually would lose control. No warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that an unknown rear chip had failed. The shock absorbers had water, the rear brake pads were worn down to zero, and the rear differential needed to be replaced. The vehicle was repaired. The contact stated that the failure persisted and was worsening. In addition, the contact stated an abnormal grinding sound could be heard coming from the rear differential. The vehicle was taken back to the dealer, where it was diagnosed that the differential gauge had failed to function as intended. The warning light for the 4-wheel drive was illuminated. The brakes and calipers were replaced. The rear differential was not repaired. The dealer informed the contact that the pole where the breather pipe is inserted on the rear differential carrier is off spec, allowing water intrusion. And that the new rear tires were badly worn on the inside and had high spots on the center. The manufacturer was not made aware of the failure. The failure mileage was approximately 46,000.

NHTSA ODI 11735926

Clunking/Rattling noise coming from passenger rear of vehicle when hitting bumps and rear of vehicle swaying/swerving. Can hear noise while shaking the car side to side while parked. Only 35000 miles. Rear suspension of vehicle seems soft. Took to the dealer rear was misaligned didn't find any other problems. Continue to have the problem swaying/swerving is still there but not as bad. This could possibly cause driver to loose control.

NHTSA ODI 11684655

At 15,000 miles the car began to exhibit a loud “knocking” and / or “clunking” sounds upon turning the steering wheel. Three dealerships later I’ve learned it is called a “strut bearing”, and that it’s covered under a “special coverage”. Which special coverage means that this is a widely known issue after the cars have be sold. This should be a total recall. They dealer a fixing it. Had to order parts. Of course no loaner car. Won’t be using the selling dealer any longer.

NHTSA ODI 11599323

The contact owns a 2023 Mitsubishi Outlander. The contact stated that on several occasions while driving at various speeds, the vehicle drove over a rock or a manhole cover, the rear end of the vehicle was fishtailed, and the contact lost control of the vehicle. Additionally, during rainy weather, the vehicle would hydroplane. The vehicle was taken to a dealer several times however, the failure was not duplicated. The manufacturer was not notified of the failure. The failure mileage was approximately 10,000.

NHTSA ODI 11588082