What 94 owners told NHTSA about the 2023 Ford Escape

My 2023 Ford Escape (with fewer than 50,000 miles) began experiencing significant mechanical issues. I noticed exhaust fumes entering the cabin that passengers and I would inhale, loud noises from under the hood, and lose power during acceleration. After inspecting the vehicle, the dealership determined that the turbocharger wastegate/flapper valve had failed mechanically, causing the turbocharger to overboost and sustain internal damage. This failure led to numerous drivability issues, including hesitation, rough shifting, delayed upshifts, loud whining noises during cold starts, slipping during acceleration, and, at times, the inability to shift beyond second gear. Ultimately, the dealership concluded that the transmission needed to be rebuilt or replaced. My vehicle remained at the dealership from January 28, 2026, through May 14, 2026, over three and a half months. The vehicle still has transmission issues and loses power at times when driving on the highway commuting to work. At this moment of time, I scheduled it to go back to the dealership on July 9th.

NHTSA ODI 11748002

The contact owns a 2023 Ford Escape. The contact stated that while driving approximately 65 MPH the "WRENCH Icon" was illuminated and the message "Service Gear Shifter" and the vehicle began to rapidly reduce speed. The contact was able to drive the vehicle to the shoulder of the highway road and the vehicle stalled. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that the transmission had failed and needed to be rebuilt. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 33,000.

NHTSA ODI 11747401

The car started and when I went to put it in gear, turns off. Park brake limited function appeared on the dash . The car would not let me put it in gear without turning off. A month prior my dash with the speedometer was blank while driving not allowing me to see my speed . I turned the car off and on three different times. Only after sitting for several hours would the dash info reappear.

NHTSA ODI 11746394

The contact owns a 2023 Ford Escape. The contact stated that while the vehicle was parked, the engine unexpectedly stated revving at a high rate. No warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with turbo charger assembly failure. The turbo charger assembly was replaced; however, the failure persisted. The oxygen sensor was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 42,616.

NHTSA ODI 11745710

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V789000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the unrepaired recall repair was an inconvenience because the battery could only be charged to 80-percent. The dealer was not contacted. The manufacturer was not contacted. The contact had not experienced a failure.

NHTSA ODI 11745757

My 2023 Ford Escape is equipped with a factory-installed rearview backup camera system and SYNC infotainment system. Beginning on or around February 2026. I began experiencing a series of recurring, intermittent, and worsening failures with the rearview camera and the Accessory Protocol Interface Module (APIM) that controls it. These failures render the backup camera system unreliable or completely non-functional during vehicle operation. Specific Symptoms Observed •BLUE / BLANK SCREEN: When the vehicle is placed in reverse, the rearview camera display shows a solid blue screen or goes completely blank rather than displaying the rear camera image. This failure occurs with no warning and leaves me unable to see what is behind the vehicle while backing up. •INVERTED / UPSIDE-DOWN IMAGE: The rearview camera image displays upside-down and/or mirrored, rendering the image confusing and unsafe. Guidelines, directional aids, and proximity warnings displayed on screen are also inverted, making them unusable. •DISTORTED / CORRUPTED IMAGE: The camera feed displays visual distortion, artifacts, freezing, flickering, or corruption that makes it impossible to accurately interpret what is behind the vehicle. •APIM FAILURE: The Accessory Protocol Interface Module (APIM) — the core software module controlling the SYNC 3 display and camera feed — has failed or malfunctioned. Dealership diagnosis has identified the APIM as requiring repair or replacement. This module failure is the root cause of the camera display issues described above. The failures occur intermittently and unpredictably. The camera may function correctly for a period, then fail on the next use. In some cases, the failure is persistent across multiple ignition cycles. There is no consistent triggering condition — the defect occurs in varied weather conditions, temperatures, and after varying periods of use. Turning the vehicle off and back on sometimes temporarily restores the camera, but the defect returns.

NHTSA ODI 11741427

2023 Ford Escape with approximately 80,000 miles. While traveling home, vehicle started shifting violently making loud bang. Lost acceleration while traveling on a two-way roadway with no shoulder. Vehicle would shift violently and allow acceleration momentarily and then would again lose acceleration. Just prior to reaching a pull off area in a safe place, the vehicle shifted violently one last time and would no longer accelerate. The service engine now warning light then came on advising of a powertrain malfunction. Vehicle was towed to Ford dealership and the technition reported that the planetary gears were locked up and a full transmission replacement would need to be done. This posed a serious safety issue on the road way due to the initial sudden speed changes becuase of the loss of acceleration and then the complete loss of ability to accelerate causing the vehilce to have to drift slowely to the shoulder while impeding traffic.

NHTSA ODI 11740355

Stopped at a Light and took off thru the intersection and car made a loud bang noise then no power and kept bogging out, pulled into parking lot and stopped then car wouldn’t move. Shut car off then restarted it and put into reverse and car drive forward, put in neutral and car still drove forward, couldn’t get it to go into reverse, now the motor is tilting back to fire wall like motor mounts are broke and it’s make a grinding noise when idling.

NHTSA ODI 11739386

[Recurring No-Start Issue with Multiple Warning Alerts – Safety Concern] I am reporting a recurring vehicle issue involving failure to start, which I believe may pose a safety risk. The issue has occurred five times: August 11, 2023 April 12, 2025 June 13, 2025 December 12, 2025 April 1, 2026 During these incidents, the vehicle failed to start and displayed multiple warning messages on the dashboard. On some occasions, the vehicle only started after several hours. The vehicle becomes completely inoperable when this issue occurs. After the third occurrence, I brought the vehicle to an authorized service center. However, the issue was not resolved and has continued to occur. This repeated failure raises serious concerns about vehicle reliability and safety, as the vehicle may become inoperable without warning. I have attached documentation, including repair records and photos of the dashboard warnings. I am submitting this report so that this issue can be properly investigated.

NHTSA ODI 11739002

1.engine failed and my infotainment system turned off 2.i feel like I was scared because I didnt know if I was going to come back on 3. No 4. No

NHTSA ODI 11738223

The contact owns a 2023 Ford Escape. The contact stated that while driving at an undisclosed speed, the message "Battery Issue, Pull Over" displayed, and the battery, check engine, and master warning lights illuminated. The contact pulled over and contacted the dealer, who instructed him to turn off and restart the vehicle. After following the dealer's instructions, the failure was resolved. The contact later received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the recall but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,000.

NHTSA ODI 11735883

While pulling into a residential parking space at low speed, the vehicle (2023 Ford Escape) suddenly accelerated unexpectedly without additional throttle input. The acceleration was abrupt and forceful, and I was unable to stop the vehicle before it struck the structure in front of the parking space. The incident occurred at very low speed and under normal driving conditions. The driver was applying the brake at the time of the unintended acceleration. Airbags deployed upon impact. There were no prior warning lights or indications of a mechanical issue before the incident. The vehicle sustained significant front-end damage.

NHTSA ODI 11735200

The contact owns a 2023 Ford Escape. The contact stated that while attempting to start the vehicle, the radio displayed a blank screen. A dealer was contacted. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The contact stated that the failure had occurred on several occasions. The manufacturer was not notified of the failure. The approximate failure mileage was 34,756.

NHTSA ODI 11733971

The left rear liftgate hinge cover flew off in the car wash during the drying cycle. The same thing has happened to my 2020 Escape and that vehicle is covered under a recall but this 2023 Escape is not. I feel it should be because it has the same issue for the same part.

NHTSA ODI 11727734

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V789000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11727257

I am reporting a recurring safety issue involving sudden loss of power while driving in my 2023 Ford Escape. The vehicle has experienced multiple incidents where, while accelerating or pulling into traffic, it suddenly loses power, hesitates, or fails to respond to the accelerator. In some cases, the RPM drops unexpectedly, and the vehicle will not move or respond for several seconds. After this delay, the vehicle may jerk or surge forward suddenly. This creates a dangerous situation, especially when entering busy roads or intersections, as it puts me at risk of being struck by oncoming traffic. This issue has occurred multiple times and has been brought to the dealership on several occasions. The vehicle has undergone multiple repair attempts, including major engine-related repairs such as cylinder head and cooling system work, as well as a fuel system component replacement. Despite these efforts, the problem persists. On multiple visits, the dealership has stated they were unable to duplicate the issue, even though the condition continues to occur during normal driving. The vehicle has been out of service for an extended number of days due to these ongoing issues. This defect is intermittent but poses a serious safety hazard due to the unpredictable loss of power and delayed acceleration. I am concerned about the risk of an accident or injury if this issue is not properly identified and corrected. I am requesting that this issue be investigated, as it appears to be a recurring defect that may affect other vehicles of the same make and model

NHTSA ODI 11727319

Vehicles coolant emptied out causing vehicle to overheat and smoke from under engine.

NHTSA ODI 11726171

Reporting Long term safety defect and manufacturer behavior. There was no single incident. This is an ongoing safety defect related to multiple battery recalls that now limit my vehicle to 80% charging (in the past, no plug in charging), now going on nearly three years. My Ford Escape PHEV has been subject to limited charging due to these multiple recalls, and I am concerned Ford may close the recall with a software‑only fix that cannot truly validate battery safety, especially if modeled on limited and not real world charging. I have complied with all of Ford's requests which came at my expense and caused increased fuel usage and a diminished efficiency of my car. Now I need assurance that when a "fix" is determined that it will indeed be a permanent fix that is safe at 100% charge. This is a potentially crucial safety issue and thermal consequences with my grand daughters sitting above the battery is of the greatest concern.

NHTSA ODI 11726178

My vehicle has stalled several times in the last couple of months. I go to accelerate and the vehicle suddenly stops out of no where. This has almost caused me to get into an accident. I see there have been several recalls on ford escapes and this issue should be looked into for my 2023 escape.

NHTSA ODI 11724490

My 2023 Ford Escape acts like it is about to stall out once I hit the gas from a stop. It has happened multiple times. After idling for 10 minutes when I go to take off it will shift so hard that it pushes you forward in your seat. It has not been taken to a dealership yet since no light comes on and it doesn’t happen all the time. It has put my safety at risk since I was turning on the highway and it took 10-15 seconds to get up to speed.

NHTSA ODI 11722362

The engine shut off and immediately turned on

NHTSA ODI 11721791

Symptoms appeared in January 2026. Check engine light is on-HAD P0301 & P0316. Ran misfire monitor & Relative compression and cylinder 1 is the issue with 70 PSI. Performed cylinder head leak down test- exhaust valve leaking replace cylinder head assembly. Problem confirmed and diagnosed by Ford dealership. The safety issue associated with the car are: sudden jerking or hesitation, loss of acceleration when merging or crossing traffic, unpredictable throttle response, sudden loss of power. Symptoms appeared in September 2025. In October 2025, the car required a turbo repair, which cost a total of $1,600. The safety issue associated with the car are: air-fuel balance, engine misfires, complete stall, loss of power. This was diagnosed by certified repair show. Similar recalls have been made to other Ford Escape cars and I believe my VIN number should be included.

NHTSA ODI 11720710

I have had many issues with this vehicle. Most concerning is that the other night while driving down the road at night, my car blacked out and I had no lights inside or headlights outside while driving in the dark. My back hatch button only works when it wants to. My screen freezes every once in awhile and also makes horrible noises very frequently. I’ve had one case of my screen freezing on a longer drive with my seat warmer on and the seats getting too hot and burning me. My safety features shut off all the time. My cruise control wouldn’t work at all on a 4 hour drive last month. When I get my oil changed they tell me under my hood is way louder than it should be for a vehicle this old. The dealership did a factory reset hoping it would help but I’ve already had issues with the hatch door not working appropriately, the sound coming from my screen, and notifications that my safety features have been shut off.

NHTSA ODI 11720435

My ford escape has an ongoing safety issue where the instrument cluster shuts off while driving and the dealership has not been able to fix it.

NHTSA ODI 11719410

I drive a 2023 Ford escape active, 8F35 transmission, with 111,114 miles on it. I purchased my car in July 2025 from truauto of Ladson SC with 93,000 miles on it. Had a transmission complete failure in December 2025 (5 months after buying). Ford dealership in Valdosta Georgia (where I lived) was no help in trying to get it fixed and it sat on there lot for a months or so, because it was undriveable. I got it towed back to SC to get it fixed by a local transmission shop and it is being halted due to a current planetary lawsuit with these cars for parts. I have now been without a car for 2-3 months and have forked over $6,000+ to get this car fixed. I was not told about any known transmission issues when I bought this car (verbally or written) from Truauto, nor was I contacted about any recall from Ford and I was denied a Remanufactured transmission at the dealership that I went to to get the car fixed. I am out of warranty but that still doesn’t explain a transmission failure in a close to brand new car regardless of miles. I have already paid the $5400 or so for the repair at the local shop and it has yet to be fixed due to lack of availability of parts.

NHTSA ODI 11718102