What 56 owners told NHTSA about the 2022 Ram Promaster 2500

The power steering for my 2022 Ram Promaster failed on 3/7/24. The safety issue this caused was that steering the van was nearly impossible. Fortunately, the failure occurred while I was in a parking lot. The van had to be towed to the local dealer. The defective parts were on backorder (part number 6TB16JXWAC Module-steering control) and arrived on 5/21/24. This was covered under warranty and the repair work was done by the local dealer. There weren't any warning lamps that would indicate an issue. I used the van to drive to the jobsite, worked for a few hours, and the issue occurred as I was leaving for the day.

NHTSA ODI 11746282

forward collision warning has never worked, after resetting it in controls it will show not working soon after. this has occurred in many 2022 and 2023 ProMaster units. the company says it is a weather problem. after replacing the camera unit, it still does not function. I purchased this unit new, it has never worked.I purchased this unit especially for this safety feature among others included in the contract.

NHTSA ODI 11743334

Promaster 3500 Forward Collision Warning turning itself off in Uconnect. Uconnect is where you can turn off FCW or set it to warning only, or warning and braking. I want it ON all the time but it keeps setting itself OFF. I turn on the vehicle and I see the warning light indicating it is turned OFF. I have to go into setting and set it manually. I will travel to get gas and when I re start the vehicle it is set OFF again. If I don't happen to notice it, I'm traveling down the road without this safety feature, which to me is dangerous and just not right. My Promaster is a Roadtrek van and the service manager at the dealer where I purchased the van says he sees this light on all the time on other Promaster vehicles and just ignores it. I see many posts on Roadtrek and Promaster forums that reference people having the same issue. Ram dealer finally acknowledged the issue but is unable to get any acknowledgement from the manufacturer that they are working on a fix. I've had this issue from day one and have taken it to the dealer several times with no resolution. This is one thread that documents what I have experienced as well: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11742434

While driving, the power steering stopped and basically locked up the steering wheel almost causing an accident. At the same time, multiple warnings flashed on the dash. After restarting, the vehicle operated as should until the following day when it occurred again and we had to have it towed to the dealership. Water intrusion and corrosion damaged a wiring harness and rack and pinion. The cost to repair was $5200. The dealership we use is Diehl Automotive. 6181 Steubenville Pike, McKees Rocks, PA 15136. They told me this is the 12th van they've had this happen to. They told me to report this incident since it is a safety hazard and the vehicle is only 4 years old.

NHTSA ODI 11742299

VIN: [XXX] Recall data refreshed on Apr 18,2026 1Unrepaired Recalls associated with this VIN Oct 23,2025 Manufacturer Recall Number67C NHTSA Recall Number25V-720 Recall StatusRecall Incomplete, remedy not yet available Summary 4-13-2026 Is someone going to have to die because this vehicle is still on the road with a recall that could start a fire in the engine compartment that no one knows what causes it except that it has something to do with the radiator fans. This is a very serious situation. No one should be able to drive a vehicle with this kind of problem. This recall was issued several months ago, I think from October 2025. This van has a camper made in it by Thor Twist and sold by Camping World in Arkansas. We bought it to travel around the country we retire. What a nightmare. We have a granddaughter who lives with us and goes camping with us most of the time. We also have a handicapped daughter who also travels with us sometimes. She has never been able to walk. What if the van catches on fire while she is with us? My wife and I are in our mid [XXX] . We have been losing sleep thinking about this The people we bought it from said it’s not their responsibility, same as Thor Twist. They say it’s a chassis problem and we need to call Chrysler Corporation. I called the Chrysler Corporation the Dodge dealership near our location. Recall notice states “The remedy for this condition is not currently available. We can’t plan any vacation time due to this recall. We now have nightmares about traveling anywhere in this van. We paid over $100,000 for this van and cannot use it. We are requesting that we return the van and get all our money back. We have had nothing but problems with this van and worry about making any trips in it in the future. We have had it in the shop 4 times for recalls and several other times for malfunctioning issues. We were unable to use the van for weeks at a time. Let us return it please. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11732010

The contact called for the owner of a 2022 Ram Promaster 3500. The vehicle was taken to be serviced due to a power steering failure. While operating the vehicle, the owner experienced a power steering failure, and the steering wheel was difficult to turn to the left or the right. The messages "Service Power Steering", "Service Hill Assist", "Service Collision Warning", "Blind Spot Alert Unavailable", and “Service ESC" were displayed. The contact diagnosed the vehicle and determined that water was inside the main steering connector, causing the power steering failure. The owner was informed that the steering rack needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were not contacted. The contact was informed of NHTSA Action Number: PE26002 (STEERING, ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the investigation. The failure mileage was 68,974.

NHTSA ODI 11725316

The contact owns a 2022 Ram Promaster 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11716815

The contact owns a 2022 Ram Promaster 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11716821

This recall is supposed to be lifted as this is an RV. Please lift this recall

NHTSA ODI 11707490

My vehicle is subject to Safety Recall 67C for an engine-compartment fire risk involving the cooling fan module and inadequate fuse protection. I contacted an authorized Ram dealership and Stellantis corporate. Both confirmed that the recall is open and that no repair remedy is currently available. Stellantis has confirmed in writing (Case #95056397) that there is no interim safety solution available for affected owners while this recall remains unresolved. This vehicle is my primary residence. Stellantis has offered rental reimbursement, but this does not provide a safe or realistic interim solution for a vehicle that functions as both transportation and housing. The manufacturer has acknowledged a fire risk but has provided no interim safety guidance or accommodation for owners who cannot reasonably stop using the vehicle while awaiting a remedy. I am reporting this as a safety concern due to the lack of a remedy and the absence of interim safety guidance for affected owners. Stellantis has issued a stop-sale on affected vehicles, confirming the seriousness of the defect, while existing owners remain without a viable safety alternative.

NHTSA ODI 11706682

Less than a half mile into my work day the van started flashing all warning lights ( Hill assist, power steering, service engine, abs ETC.) I was on a busy road and was attempting to pull off to safety But the van turned off. Was able to jump it after 2 attempts and get it to the dealer 1 mile away, without any other lights coming back on aside from CEL. Dealer informed me I have 2 Corroded wiring harnesses, bad rack & Pinion and alternator is at 7%.... From what I've heard, this is a problem that could have been prevented by the manufacturers.. I also had a Transmission replacement at 30k miles and full Engine replacement at 55k miles. Currently at 80k Miles... This is Unacceptable for a Commercial fleet vehicle.

NHTSA ODI 11705681

Power Steering Failed

NHTSA ODI 11704910

My vehicle started to have an extremely aggressive shaking steering wheel when trying to turn into a parking lot leaving me stuck in the road for 10minutes not being able to turn without it jerking aggressively. Turns out its a common issue and caused by faulty plugs under vehicle going to the power steering motor that let water in and corrode the plugs/wiring. Dealer suggested I replace 2 wiring harnesses and motor.

NHTSA ODI 11699640

Sudden failure of the power steering system. Vehicle became very difficult to steer, lucky no other cars or pedestrians were in the area. Per the dealer water entered the wiring harness and entered the power steering module causing it to fail. When the power steering failed, warning messages began appearing on the dash, which included "hill assist needs service", "ECS needs service", "FWC system needs service" and "Engine needs service".

NHTSA ODI 11691814

Power steering failure. Luckily for us, the failure happened while still in our driveway, so no accident or collision occurred. We had warning messages for ESC, hill start assist, and several other systems, but nothing for EPS (electric power steering). The dealership was able to repair the problem by replacing the steering rack and two associated wiring harnesses. The mechanic noted water and a lot of corrosion in the wiring connector on the steering rack. This vehicle has only had normal water exposure (rain and puddles on the road).

NHTSA ODI 11682952

The electronic power steering has failed on my 2022 Ram Promaster with 38,000 miles. While driving the steering wheel began jerking violently and couldn't be controlled. It seemed like there was a legitimate chance of the vehicle rolling over on the highway. The issue was reproduced and confirmed by a Ram Dealer in my area. The dealer stated "verified customer complaint intermittent lack of power steering assist at times. found I264A inline connection under vehicle full of water / mud with corrosion no connector repair kits available to fix any of this harness replacement with rack is required". There were no warnings lamps or any notification of an issue prior to or even while the issue occurred.

NHTSA ODI 11682200

Seat belt ripped while putting seatbelt on. Nothing in the way of system. Local parts department advised 35 belts nationally are requested weekly. We shouldn’t have to pay $500 for their safety issue.

NHTSA ODI 11677728

I purchased this Ram Promaster 3500 in 2022. In 2023 I was in Canada and went to have a spare key made. The dealer was unable to program a key to the vehicle. When I returned home to the Seattle area I took the vehicle to a Seattle Ram Business link dealer. They were also unable to program a key. May of 2025 I took the vehicle in for work and asked them to continue investigating the key issue. They were still unable to do so and said that I needed a new RFH. This repair did not fix the problem and made it impossible to start the engine. They also replaced the PCM. This did not correct the problem. A tech was called from MOPAR who found a STAR ONLINE PUBLICATION for mopar which states that between Ram vehicles ( I don’t know if it is specific to ProMasters) manufactured between the dates of 11/29/2021 and 12/23/2021 had an “incorrect encryption software being programmed to the immobilizer modules.” If you type the VIN into the Service Library you can verify that S2208000129 is applicable. I was not made aware of this until I picked up the vehicle from the dealer with the old parts reinstalled. My concern is that I don’t know what else this problem in terms of the electrical and safety systems.

NHTSA ODI 11666713

Loosing power steering at 50,000 miles. Dealer states out of warranty. This should not be happening on less than a 3 year old promaster van. Total loss now. was happening randomly. driving 70 mph and hit a bump, steering would pull/jerk to the oppisite direction. also slower speeds as well, including reverse

NHTSA ODI 11660728

steering does not work due to malfunctioning steering rack. it has 21,000 miles & is under 3 years old.

NHTSA ODI 11660409

The fcw/acc stopped working all possible fixes exhausted left turn signal intermittent failure. The fcw/acc started as intermittent but now doesn't function at all seems to be common issue from research. There were warning lights indicating an issue. Van was at a dodge dealer for fuel and other electrical issues

NHTSA ODI 11646936

steering wheel keeps locking up and not able to turn at lower speeds (under 10- 20 miles) I took the car to the dealer ship and they said a part named gear- rack and pinion was replaced after waiting for almost 2 months for them to fix the car, Today I had to take the car back to the dealer after I just pick up the car a few days ago because steering keeps locking up after $2700 dollars of charges the car is not safe to drive I'm not sure if I'm the only person with this problem but I hope that if I'm not the only person with this issue you guys can help, thank you

NHTSA ODI 11637141

The contact's employer leased a 2022 Ram Promaster as a work vehicle. The contact stated that the front driver’s side door striker had become loosened and had started to detach from the frame of the vehicle. The contact stated that the door failed to lock securely while driving due to the failure. Upon further inspection of other work vehicles, the contact stated that there were several vehicles with similar failures. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 40,000.

NHTSA ODI 11635607

The contact owns a 2022 Ram Promaster 3500. The contact stated while driving at approximately 45 MPH, the Forward Collision Avoidance warning illuminated. The contact stated that the vehicle was driven however, the Forward Collision Avoidance safety feature was disabled. The contact had taken the vehicle to a local dealer, where it was diagnosed that the Forward Collision Avoidance system was not functioning properly; however, the dealer was unable to repair the vehicle. The manufacturer was informed of the failure. The failure mileage was 7,363.

NHTSA ODI 11630510

The sliding side door cannot be manually unlocked. It can only be unlocked by the remote key FOB or by pressing an electrical switch in the cab. In the event of an emergency, such as a crash or fire, this may delay or prevent evacuation from the vehicle.

NHTSA ODI 11625557