What 43 owners told NHTSA about the 2022 Lincoln Aviator

While driving, there is a loss of fuel pressure at random. It has happened when stopped at traffic light and while driving on the freeway, the vehicle does not respond to the gas pedal being pressed. This is unsafe for myself and my passengers, as I cannot confidently change lanes as I never know when it will happen. The problem has been reported to the dealership, but no confirmation on their ability to reproduce this. It was announced as a recall issue 07/2025 but still not resolution. There are never any warning lights before this happens, so its always a surprise when it happens.

NHTSA ODI 11740055

The contact owns a 2022 Lincoln Aviator. The contact received notification of NHTSA Campaign Numbers: 26V123000 (Back Over Prevention) and 25V455000 (Fuel System, Gasoline); however, the parts for the repairs were unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the remedy to be available. The contact stated that the back over camera and alarm system would fail intermittently, and the park aid stopped message would display on the vehicle. The dealer was contacted, and it was confirmed that the remedy for 26V123000 (Back Over Prevention) would not be available till Q2 OF 2026, and they were unsure of when the remedy for 25V455000 (Fuel System, Gasoline) would be available. The manufacturer was not made aware of the issue. The contact had not experienced any failure was approximately 57,000.

NHTSA ODI 11738033

THIS REQUIRES A RECALL ASAP. Dealers are well aware of this problem as is Lincoln CHQ but Lincoln refuses to address it. Rear camera cannot differentiate between steady rain & an object which then causes car to engage the collision avoidance system which then prevents ability to drive in reverse gear. There have been many rearview camera recalls on this car & each has made things worse. The ONLY way I can drive car in reverse (in rain) is to TURN OFF collision avoidance system (insane). Having to turn off this safety feature when it’s needed the most (in rain) is VERY dangerous. I tapped a person backing out of a parking spot. He was walking in blind spot, couldn’t see him on rearview camera, parking sensor alerts failed, collision avoidance was off because I can’t drive in reverse in rain. Thank God he wasn’t injured. BEGGING NHTSA TO FORCE A RECALL BEFORE A HUMAN GETS RUN OVER.

NHTSA ODI 11730549

REF C PILLAR RECALL & NHTSA Complaint # 11713372 by another owner on 11/18/25. NHTSA NEEDS TO ISSUE RECALL FOR A PILLARS. Have had wind noise issue on front passenger side since I bought car. Dealer looked at numerous times in 3 yrs & always stated ‘unable to recreate condition’ (likely due to not testing on Hwy at 65mph which is when this noise can be heard). Took car in for C Pillar recall fall 2025. Dealer said they weren’t loose so didn’t replace them. Left w/car 12/22/25 & immed heard wind noise on Hwy. Returned to service & this time, DEALER INSPECTED A PILLARS & FOUND RIGHT SIDE WAS LOOSE so replaced both. Tried to charge me (was 2 wks out of warranty) but given multiple attempted repairs during warranty & my open case w/CHQ they split repair cost. Thankfully A pillars didn’t break loose & injure human or another driver in past 3 yrs. Dealer told me Ford had A pillar recall but Lincoln’s weren’t included in it. There appears to be a pervasive issue with failure of the adhesive used for many parts by the assembly plant.

NHTSA ODI 11730557

REF RECALL 26V117 (Wiper Motor failure) & MY (2) PRIOR NHTSA COMPLAINTS; 11681607 & 11688314 (Autosense wiper operation failure). Autosense wiping does not clear wIndshield enough for visibility & therefore can’t be relied upon for safe driving. The only way to get MANUAL INTERMITTENT wiper operation is to go to SYNC settings & turn off auto wiper while driving in rain on Hwy at 65+ mph. Seriously?! THIS IS DISTRACTED DRIVING AT ITS WORST. Took dealer 2+ yrs to discover the shipping protective film used on wiper sensor was NOT removed by Chicago assembly plant prior to installing the sensor. Apr 2025, dealer replaced my sensor however it failed again by Aug 2025. Dealer had car 10/28/25-12/22/25 to fix multiple issues incl Autosense wiping. No codes appear & they can’t ID root cause of problem. Took car back for service 12/29/25-2/13/26 (multiple issues incl this) & they still can’t ID root cause. Given there’s now also a recall for wiper motor failure I requested a loaner from Lincoln CHQ but they have refused. I’M REQUESTING NHTSA REQUIRE LINCOLN TO PROVIDE LOANERS UNTIL THEY FIX ALL WIPER OPERATION FAILURES.

NHTSA ODI 11730564

Lincoln Way App team bricked (some) users by deploying an App update early Feb 2026 that was not backwards compatible for use of basic features/function. I last used App Jan 2026 while car was at dealer but when I picked up car 2/13/26 I was BRICKED with no ability to use App since. Checked Lincoln website & compatibility reqmt stated IOS 16.0 is min req’d, updates are optional & not required to continue use for basic features like lock/unlock, remote start, chk tire pressure, etc. (see screenshot attached). Opened case w/Lincoln Way App team 2/17/26. Ops mgr confirmed my iphone was compatible & iOS 16.0 was still min. reqmt. Said he’d escalate. Suddenly, wks later Lincoln updated website & changed compatibility requirements with NO NOTICE TO USERS (before or since) they’ve changed compatibility reqmts (they have users names, email, addr & phone #s since they’re req’d upon setup). In addition, NONE of the App version release notes shown in App Store indicate any change to Min compatibility reqmts. Development team is negligent & Lincoln needs to fix.

NHTSA ODI 11730568

Regarding safety recall notice 25S66/NHTSA recall 25V407 - we took our car to the local Lincoln dealer in Lubbock (Gene Messer Ford/Lincoln) in late November for the repair of the recall "C-Pillar Applique Delamination." There was considerable wind/rattle noise coming from the passenger side, which is a component of the recall. After completing the recall we noticed the wind/rattle noise is still there and even slightly worse. We have contacted the service representative at Gene Messer Ford/Lincoln regarding this and have yet to receive a reply. We are reaching out to you for a solution to the noise problem. Any help is much appreciated! Thanks for your time, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11713372

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at 35 MPH and entering the on-ramp, the vehicle stalled. The vehicle was restarted. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to the local dealer, but the vehicle had not been diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 47,000.

NHTSA ODI 11712909

On July 25, 2025 my 2022 Lincoln Aviator Hybrid Grand Touring Edition stalled while driving on Interstate 25 in Colorado Springs. I lost partial control of the vehicle but was able to guide it onto the shoulder and allow it to coast to a stop. I had this vehicle towed to the dealership (where it was purchased new): Phil Long Lincoln, Motor City in Colorado Springs, Colorado. It has been there ever since (almost 5 months) and has not been repaired. The service department suspects that the current safety recall issued July 8, 2025 (NHTSA Recall number: 25V455) was the root cause. They claim they could find nothing in the logs but they cannot rule out this as a problem. This is a life threatening issue with this vehicle and I have also been without my car for almost 5 months with repair available or capable by the dealer or Lincoln. This a very unreasonable amount of time and has been an undue burden upon me. I have sought to get a vehicle buy back under both the Lemon Law and the duration of this safety recall and they have refused (Lincoln corporate and the dealership). Please help.

NHTSA ODI 11706296

Rear door trim came loose and fell off while driving. Had the service department at the local dealership look at the missing trim on the rear of the car and they noticed multiple of the plastic clips holding the trim on the rear were broken and remained in the area where the trim was attached.

NHTSA ODI 11705135

high voltage alert and vehicle shuts down and unable to drive and car locks up Should be recall# 23s53 and NHTSA campaign # 23v-626 It has not been repaired yet and this is very frustrating has happened 4-5 times Last incident happened on 11/7/2025 inside of a car wash & had to get towed

NHTSA ODI 11698286

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at 30 MPH, the trim pieces on the liftgate partially detached. A dealer was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed; however, the vehicle received an unknown recall repair and was provided an estimate for the repair. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 3,333.

NHTSA ODI 11693917

1- ABS/Braking Issue The ABS system appears to be malfunctioning. On multiple occasions, typically once or twice a week, when I apply the brakes, the tires lock up and cause the vehicle to skid. This happens most often when descending hills or backing up on a sloped driveway. The wheels lock and slide until I release the brake pedal, posing a serious safety concern. 2- Severe Water Leak Interior Roof Area There is a significant water leak from the interior roof, specifically from the top center area near the rearview mirror, every time it rains. I’ve taken the vehicle to the dealer multiple times. They confirmed that all drain tubes are clear, all seals are functioning properly, and no water appears to be entering from the sliding moonroof. However, the issue persists. Water pours down like a waterfall through the vent (as shown in the attached photo), soaking the center console and creating an unsafe driving condition. I have also recorded videos showing the water intrusion. Living in Guam, where it rains frequently, this has become a major problem. 3- Malfunctioning Interior Ceiling Light The ceiling light on the driver's side (center dome light) turns on randomly and often remains on until manually switched off. The dealer has inspected this issue but reported no faults found. Despite this, the problem continues to occur intermittently. 4- Rear Camera Display Issue When shifting into reverse, the monitor occasionally turns completely blue, and the backup camera does not function. The blue screen remains until the vehicle is turned off and restarted. This happens sporadically and disrupts safe maneuvering.

NHTSA ODI 11691739

Emergency escape issue Like many modern cars the aviator was designed with electric opening doors. Of the four doors, only the front driver side door has a manual override in case of emergency. That means if a major accident was to occur on that ONE door and disable the vehicle the other 3 doors do not have a way to exit. Why would the nhtsa allow a vehicle on a road that at a minimum doesn't have a override for left side and right side or more than one door?

NHTSA ODI 11691190

The contact owns a 2022 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 50 MPH, the vehicle stalled. The contact was unable to pull over to the side of the road. It was unknown whether a warning light was illuminated. The vehicle failed to restart and was towed to the residence. The dealer was contacted and confirmed that the part for the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 10,000.

NHTSA ODI 11690950

My Aviator was parked with trunk open to load groceries from shopping cart. Must have stepped under bumper such that it triggered the kick sensor to close the tailgate. The problem is, it did NOT detect spouse’s body, did NOT stop the tailgate from closing & as a result, hit him on the head. He jolted out of the way & the tailgate continued to close all the way. This is serious safety issue!

NHTSA ODI 11688306

Reference my NHTSA complaint # 11681607 dtd 8/19/25 regarding the problem with Autosense wipers that I’ve had since I bought my Aviator 2.5 yrs ago. As I previously reported, problem was finally resolved in April when dealer replaced the Autosense sensor. I have come to learn that the plastic covering dealer found on the sensor (see attached pic) is actually a protective film for part shipment & should have been removed by the assembly plant prior to installing the sensor but was NOT. There are other owners that have this same ‘wipers gone wild’ condition with Autosense wiping in which the windshield does not clear enough for safe driving & you need to switch to manual wiper operation to clear the windshield. This plant assembly error should trigger a recall with all manufacturers that use this part, not just Lincoln.

NHTSA ODI 11688314

Despite multiple backup camera recalls & fixes, the backup camera blurs visibility & engages the backup collision avoidance system when there’s a steady rain thereby preventing me from backing car up my DW & parking in garage. The vehicle repeatedly stops & engages the rear collision avoidance system so much so that I had to turn it off in settings to back my car in. Cleaning the backup camera lense did not improve this condition. It appears the system cannot differentiate between rain & an object.

NHTSA ODI 11681596

The AUTOSENSE wiper function has been erratic & not working properly since my Aviator was a yr old (2022). None of the Autosense wiper stalk positions worked correctly to clear the windshield enough for safe visability. I had dealer check this problem 3 times in 2023 & 2024 & they indicated no problem was found & no codes appeared. After experiencing dangerous visability issues on a 4 hr trip in which I needed to keep the regular wiper on to see (because Autosense didn’t clear windshield enough to see on Hwy), I left vehicle at dealer & refused to pick it up until problem was corrected once & for all. Since car is under warranty they decided to replace the sensor & found it to be defective (yellowed). Since replacing the sensor Autosense now works. This leads me to believe these sensors are failing prematurely. I’m posting this in case others are experiencing a similar problem with Autosense wipe.

NHTSA ODI 11681607

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the contact received notifications of NHTSA Campaign Numbers: 25V407000 (Structure), 25V393000 (Seats), and 25V455000 (Fuel System, Gasoline). The dealer was notified of the recalls and the contact was informed that parts to do the recall repairs were not yet available. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

NHTSA ODI 11678160

Lincoln Aviators 2020-2024 using the Sync 3 Radio screen. Have a issue not switching to dimmed/night mode during night time driving. This is a major safety issue because when driving a night you have a super bright display inches from your eyes creating a blinding issue at night. This issue has been reported by many folks, a simple Google search will reveal this. Unless NHTSA steps if to doing something 10s of thousands Lincoln Aviators 2020-2024 are on the road with blinded drivers. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11676669

Please see the attached email conversations and service records with Lincoln Motor Company (manufacturer) and Kayser Lincoln (service center and dealer) regarding the issues with the display in this vehicle. I have had this vehicle into the service center 50 times in the past 2 years trying to get this display issue fixed - they have not fixed it. I have asked for a vehicle buy back - Lincoln has denied this request. I have filed or a Lemon Law Complaint - Lincoln has denied this request. This is only the first 10 attachments of the 33 attachments I have in evidence - but I can only upload 10.

NHTSA ODI 11660674

What component or system failed or malfunctioned, and is it available for inspection upon request? The 2nd row seats have an electrical switch to slide and slightly fold the seat for entry to the 3rd row. This switch seems to get stuck and will randomly slide and tilt the seat forward while driving as well as while stationary. while driving, the seat can hit the back of the driver seat very hard and cause disorientation. The vehicle has not yet been reproduced or inspected by a dealer or other service center. the vehicle has not been inspected by manufacturer, police, insurance rep, or any other organization. There were no warnings or messages prior to failure, this car I purchased used and the symptom was presenter as soon as I drove off the lot.

NHTSA ODI 11651190

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving approximately 75 MPH, there was a loud banging sound above the contact’s heads. The contact became aware that the sunroof had fractured into several pieces, leaving a large hole in the sunroof. The vehicle was not taken to the dealer to be inspected or repaired. The manufacturer was not informed of the failure. The failure mileage was 51,000. The VIN was not available.

NHTSA ODI 11650747

Driving and slowing down accident brakes and frontal collision and airbags didn't go off

NHTSA ODI 11647320