What 181 owners told NHTSA about the 2022 Kia Sorento Plug-in Hybrid

2022 Kia Sorento failed to increase speed when accelerator was depressed , engine RPMs increased, but no subsequent speed increase. The Amber ISG light was flashing, with no other warning lights. The car was driven to a safe pull out, placed in park, turned off and restarted, no flashing light. The car accelerated satisfactorily afterwards. This has happened several times in the last two years. Both fuel pumps were replaced as well as the battery and computer systems were reset and the problem still intermittently persists. This is a significant safety issue if the car cannot properly accelerate when required to merge into traffic and properly maintain designated speed. Was told that Kia engineering said this maybe a heat related issue, the car is operated mainly the the southwestern US, Phoenix, Az metropolitan area.

NHTSA ODI 11743350

Idle stop and go system randomly auto disabled on start, unable to enable. Causes vehicle to be unable to accelerate faster than 25mph.

NHTSA ODI 11743009

At stop lights trying to excel it stales for a couple of seconds then resumes. Does this on and off all day because I drive for a living. Finally the check engine light is on and now have to replace the whole turbo because it’s failing. I just got the car mid march of 2026. I have kids and scared to drive around and the car fail on me.

NHTSA ODI 11742570

I am writing to report a recurring issue with the center navigation and infotainment screen in my 2022 Kia Sorento. The screen periodically goes completely black while I am driving. Occasionally, the display glitches before failing, while at other times, it goes dark without any warning. This is particularly concerning when I am relying on the navigation system for directions. I have previously taken the vehicle to the dealer, but they were unable to replicate the issue and therefore have not yet performed a repair.

NHTSA ODI 11742498

The Auto Start-Stop System light came on flashing while driving. Vehicle wouldn’t accelerate while in heavy traffic. Pulled over to the shoulder and turned vehicle off. Attempted to start vehicle again and would not start. Had to get the vehicle towed. Positive battery post is loose and screw is tightened as much as possible.

NHTSA ODI 11741207

I own a 2022 Kia Sorento that was manufactured on January 13, 2022. My vehicle experienced a failure involving the electronic oil pump within the transmission system. While driving, a transmission error message appeared prior to the failure. Shortly after, the vehicle unexpectedly entered a limited-mobility condition and significantly slowed down, operating only at a reduced speed. This created a hazardous situation, as I was unable to maintain normal traffic flow, increasing the risk to myself and other drivers. The issue has been diagnosed and confirmed by a service center as a malfunction of the electronic transmission oil pump. I am aware that Kia Motors has issued a recall for certain 2021–2022 Sorento and 2021–2023 K5 vehicles related to a defect where the fail-safe limited-mobility drive mode may be impaired due to a transmission oil pump malfunction, potentially resulting in a complete loss of drive power. Although my vehicle appears to have been manufactured during the same timeframe as the affected vehicles, it has not been included in the recall. The failure I experienced is consistent with the conditions described in that recall. The vehicle has not been inspected by the manufacturer, police, or insurance representatives, but the issue has been confirmed by a service center and the component should be available for inspection upon request. Given the safety risk and similarity to the recalled defect, I believe this issue warrants further investigation and potential inclusion of my vehicle in the recall population.

NHTSA ODI 11737579

The vehicle began making a clicking/popping sound when turning the steering wheel left or right, especially at lower speeds and while turning into parking spaces or driveways. The exact component causing the issue has not yet been fully identified, but it may involve the steering or suspension system (such as the CV axle, tie rods, or steering components). The vehicle is available for inspection upon request. The problem puts my safety and the safety of others at risk because the clicking noise may indicate a failing steering or suspension component, which could potentially affect steering control or vehicle handling while driving. The problem has not yet been officially confirmed by a dealer/manufacturer, but the issue is consistently reproducible whenever the steering wheel is turned left or right. The vehicle/component has not yet been inspected by the manufacturer, police, or insurance representatives. There were no warning lights or dashboard messages prior to the issue. The clicking noise first appeared while turning the steering wheel during normal driving and has continued since then.

NHTSA ODI 11736463

I am submitting a formal safety complaint regarding my 2022 Kia Sorento, which is experiencing a dangerous and recurring loss of engine power during acceleration. This issue presents a significant safety hazard, particularly during situations requiring immediate acceleration such as highway merging, crossing intersections, and passing traffic.

NHTSA ODI 11736537

Rear passenger taillight assembly, specifically the turn signal light failed. Currently unable to utilize the right signal light when turning causing a safety issue for others. This taillight assembly is a sealed unit with LED lights that cannot be replaced. To fix you must purchase a new taillight assembly. These are very costly $790 from the dealer. This is an exorbitant expense for most people and will delay the consumer from replacing this assembly. Due to this exorbitant expense this is a safety hazard that I believe the manufacturer, KIA, should implement a recall and make this taillight assembly with easy to replace inexpensive light components so customers can easily afford and replace bulbs quickly and limit safety issues and prevent accidents

NHTSA ODI 11735234

on my way home Friday evening from work. After exiting the expressway , I made a right turn on the street going towards my house. My steering wheel locked to the right and almost caused me to run into another car. If I had not be driving slow than the speed limit or still on the expressway, this would have been a very bad accident, if not fatal! This is after the dealership made repairs on my vehicle and deemed it safe to drive.

NHTSA ODI 11734731

The vehicle’s transmission failed. While driving on the highway, the transmission began slipping and then would not allow the vehicle to accelerate beyond approximately 10 mph. The vehicle also lost the ability to reverse. My family’s safety was put at significant risk. The incident occurred on a highway with a speed limit of 70 mph and low visibility. Due to the sudden loss of acceleration, our vehicle was unable to keep up with traffic, creating a dangerous situation with a high risk of being struck by other vehicles. The dealer reproduced and confirmed the issue. They documented very hard shifting, lack of reverse, and stated the transmission fluid smelled burnt. No diagnostic codes were present. The dealer advised replacement of the transmission. No warning lights or messages appeared on the dashboard prior to the failure.

NHTSA ODI 11732426

The fuel door actuator failed. The gas door would not open due to the actuator being seized shut, preventing access to the fuel tank. This vehicle does not have a manual release mechanism, so there was no alternative way to open the fuel door. The dealership confirmed the actuator malfunction. My family’s safety was put at risk because we were unable to refuel the vehicle. The incident occurred during extremely cold weather, with a windchill of approximately -8°F. Due to the inability to add fuel, we were at risk of running out of gas and losing heat in the vehicle, which could have resulted in a dangerous exposure situation. There were no warning lights or messages indicating a problem prior to the failure. The issue was first noticed when attempting to refuel and the fuel door would not open.

NHTSA ODI 11732430

The transmission and related drivetrain components malfunctioned. While driving, the vehicle’s RPMs would surge into the 5,000–6,000 range without corresponding acceleration, and the vehicle would not shift properly into the next gear. The issue caused poor acceleration and inconsistent performance. The dealership later replaced the transmission and updated the ECM after identifying a fault code. My family’s safety and the safety of others were put at risk due to the vehicle’s inability to properly accelerate. The engine would rev excessively without increasing speed, making it difficult to merge, cross traffic, or respond to driving conditions. This created a dangerous situation where the vehicle could not reliably keep up with traffic flow. The issue was initially reported to the dealership, but they were unable to duplicate the concern at that time and noted no active or stored diagnostic codes. However, the problem persisted after the vehicle was returned. During a subsequent visit, a check engine light was present, and the dealership identified a fault code and ultimately replaced the transmission and updated the ECM, confirming a drivetrain-related failure. Initially, there were no warning lights when the issue first occurred. At a later point, the check engine light began intermittently turning on and off when the problem occurred. The primary symptoms were sudden RPM surges, failure to shift properly, and lack of acceleration during normal driving.

NHTSA ODI 11732432

The driver’s seat frame and adjustment mechanism failed. The seat broke off from the frame, resulting in the seat only being able to move left and right, with no ability to adjust forward/backward or recline. The dealership confirmed a seat frame malfunction and addressed the issue. My safety was put at risk because I was unable to properly adjust the driver’s seat to a safe driving position. Without proper positioning, I could not safely reach the pedals or maintain appropriate control of the vehicle, increasing the risk of losing control or being unable to react quickly in traffic. The dealership confirmed the seat frame malfunction and performed repairs to address the issue. No warning lights, messages, or prior symptoms were present before the failure. The issue occurred suddenly without warning.

NHTSA ODI 11732433

2022 Kia Sorento. Dec 2024(previous owner incident) to new owner purchase May 2025- April 2026 vehicle keeps displaying all lights and warnings, loses acceleration & loss of throttle power while driving. High voltage code P0653 code displays. RPM’s will go up and down while vehicle is in park. Have had an active case open with Kia America Escalated case specialist since Nov 2025. Vehicle has been taken to two different Kia dealerships and has had this incident 7 times since May 2025 used purchase. A few different parts have been changed while working with a Kia America tech over a computer, yet it doesn’t fix the problem. It was reported in 2024 by the previous owner and the dealership could not find the source. It was never disclosed from the dealership prior to reselling. My problems started 3 weeks after owning the car. Less than 200 miles. I got in contact with previous owner, the vehicle kept going into limp mode while driving & the code would clear before she could get it to the shop & they couldn’t resolve it, so she traded it back in. 1st Incident: Dec 2, 2024 (previous owner) 2nd: June 6, 2025 3rd: July 19, 2025 4th: August 14, 205 5th: September 19,2025 Contacted Kia after and finally assigned a case officer Nov 10, 2025. Taken to shop Nov 11, 2025. 6th: Feb 22, 2026 7th: April 4, 2026 - going 75Mph on a highway and having to cross 4 lanes of traffic with no throttle power.

NHTSA ODI 11729873

The contact owns a 2022 Kia Sorento. The contact stated that while driving at an undisclosed speed, the instrument panel displayed a blank screen. In addition, the check engine warning light illuminated. The contact stated that the failure had occurred several times. The vehicle was taken to the dealer where it was diagnosed with battery sensor failure. The contact was informed that the battery sensor needed to be replaced. The vehicle was not repaired. The contact stated that the diagnostic test was not performed on the instrument panel. The contact was informed that an additional diagnostic test was required to determine the cause of the failure with the instrument panel. The contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 39,000.

NHTSA ODI 11727036

My AC system has failed due to leak in the evaporator core. It has been inspected by 2 mechanics (one including the Kia dealership) the extreme Texas heat puts myself and small children at risk. I’ve been told the evaporator core has been made with cheap thin metal and has small pinholes in it. I will allow my car to be inspected and there were no warning lights before or after this happened.

NHTSA ODI 11726505

1. Panoramic sunroof 2. Sunroof exploded while parked sounding like a gun shot. 3. Dealer/Kia Customer Care has informed me this is a known issue. 4. Dealer said they looked at my car but never looked at it. I confirmed this with the service manager at University Kia in Waco Tx. He admitted to falsifying the paperwork, I had him redo the paperwork showing nothing was inspected. Now Kia won't look at it again. 5. No warnings, just spontaneous exploding glass.

NHTSA ODI 11725991

When I turned my car on and started to drive, an orange a popped up and started blinking. It looked like the automatic stop and start light. My car would not shift and I could not go above 60 mph. I had to turn my car off and turn it back on for it to stop doing what it was doing.

NHTSA ODI 11725737

All sensors and alarms glitching.

NHTSA ODI 11724512

The contact owns a 2022 Kia Sorento. The contact stated that while driving at an undisclosed speed, the sunroof exploded without impact. There was no injury sustained. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 86,296.

NHTSA ODI 11719848

The vehicle has less than 75k miles, and I am the second owner. I was driving, and the vehicle lost power. Creating a traumatic experience that could have been fatal. After Kia had inspected the vehicle, I was informed that I needed a new engine and it would cost 8k or more, and my extended warranty would not cover it. Kia has current recalls for similar issues.

NHTSA ODI 11719170

Vehicle purchased August 2022. July 13, 2023: Vehicle experienced sudden loss of acceleration while driving. The vehicle would not properly accelerate with traffic flow and another vehicle nearly struck me due to the unexpected loss of propulsion. Vehicle was towed to Kia dealership in Duluth, GA. I was told the issue was repaired and an electrical recall was completed. December 8, 2025: Acceleration failure reoccurred while driving. Vehicle drifted and would not accelerate. A vehicle behind me nearly collided with my car because I could not accelerate normally. After restarting the vehicle multiple times, I was able to reach home. December 11, 2025: Vehicle again failed to accelerate while stopped on an incline. The vehicle would not move forward properly and created a rollback hazard. A vehicle approached from behind and I was placed in a dangerous position due to inability to accelerate. Vehicle was towed by insurance. Dealership diagnostics reportedly cannot detect an issue. I have been instructed to operate the vehicle with a monitoring device installed to capture driving data. Repeated loss of acceleration and multiple near-collision events present a significant safety hazard and risk of serious accident. The issue remains unresolved.

NHTSA ODI 11717389

There is a safety recall concerning fire hazard during normal operation. Kia is refusing to buyback the inoperable vehicle

NHTSA ODI 11716773

The contact owns a 2022 Kia Sorento. The contact stated that while driving approximately 70 MPH, the contact experienced the death wobble. There was no warning light illuminated. Additionally, the vehicle unexpectedly accelerated. There was no warning light illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The dealer informed the contact that the failure could not be duplicated. The manufacturer was made aware of the failure. The approximate failure mileage was 78,000.

NHTSA ODI 11716781